← New search

2006 Saturn Ion

Owner reports · Recalls · Investigations

Similar to other model years

Owner complaints for the 2006 Saturn Ion do not stand out strongly from the model-year median of 816.5.

About this comparison →

When problems were reported

Mileage at the reported incident

1,073 reports with mileage · 162 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Steering. Review the 544 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 392 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel System, Gasoline. Review the 127 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

44 crash reports7 fire reports23 injury reports

Steering complaints

544 reports
Clear category filter
66,900 miles · Jul 22, 2010
Steering

ON JUNE 22ND WHILE PULLING INTO A PARKING LOT THE PWR STEERING WARNING CAME ON MY DASH CLUSTER AFTER THIS CAME ON I LOST POWER STEERING AND IT TOOK GREAT EFFORT TO TURN THE STEERING WHEEL. I CK FOR A BROKEN BELT OR FLUID LEAK BUT FOUND NEITHER. AFTER RETURNING TO MY CAR AND RESTARTING MY CAR THE WARNING LIGHT WENT OFF AND THE PO…

Read full complaint

ON JUNE 22ND WHILE PULLING INTO A PARKING LOT THE PWR STEERING WARNING CAME ON MY DASH CLUSTER AFTER THIS CAME ON I LOST POWER STEERING AND IT TOOK GREAT EFFORT TO TURN THE STEERING WHEEL. I CK FOR A BROKEN BELT OR FLUID LEAK BUT FOUND NEITHER. AFTER RETURNING TO MY CAR AND RESTARTING MY CAR THE WARNING LIGHT WENT OFF AND THE POWER STEERING WENT BACK TO NORMAL. THE PROBLEM DIDN'T OCCUR FOR ABOUT 1 WEEK SO I THOUGHT IT WAS A ONE TIME THING. THEN MY WIFE WAS DRIVING THE CAR AND THE LIGHT CAME ON AGAIN AND THE POWER STEERING FAILED, SHE WAS BARELY ABLE TO GET THE CAR OFF THE ROAD. SHE CALLED ME AND I HAD HER SHUT OFF THE CAR AND RESTART IT. AGAIN THE PROBLEM WENT AWAY AND SHE WAS ABLE TO DRIVE HOME. SINCE THIS TIME THE PROBLEM HAS OCCURRED OVER AND OVER. AT HIGH SPEEDS LOW SPEEDS, AND WHILE TURNING. I CALLED SATURN COMPLAINT LINE 1-800-972-8876 AND TALKED TO TARCARIA AND WAS TOLD THERE WAS NO RECALLS ON THIS PROBLEM AND WAS GIVEN THE ADDRESS AND NUMBER TO A LOCAL DEALER WHO COULD ASSIST ME WITH THE PROBLEM. I WENT TO THE DEALERSHIP AND TALKED TO THE SERVICE MANAGER AND PARTS DEPARTMENT AND WAS TOLD THERE WAS TOLD THAT THE ELECTRIC STEERING MOTOR WOULD HAVE TO BE REPLACED AT AN ESTIMATED COST OF $400.00 PARTS AND LABOR. I WAS ALSO TOLD THAT THERE WERE RECALLS ON THIS PROBLEM ON OTHER GM PRODUCTS (CHEVY COBALT) THAT USED THE SAME TYPE OF STEERING AS MY SATURN ION BUT MY 2006 SATURN ION WAS NOT ON THIS LIST, BUT IT COULD BE ADDED LATER. IF THIS PROBLEM OCCURS WITH SOMEONE WHO DOES NOT HAVE UPPER BODY STRENGTH IT COULD LEAD TO ACCIDENT. *TR

NHTSA ODI #10344675

47,000 miles · Jul 19, 2010
Steering

HAVE A 2006 SATURN ION, IT HAS LESS THAN 50,000 MILES AND I'VE HAD 2 DIFFERENT PROBLEMS WITH THE STEERING COLUMN. THE FIRST PROBLEM WAS 2 YEARS AGO AND I COULD NOT GET THE IGNITION TO TURN OFF, TOOK IT TO THE SATURN DEALERSHIP AND WAS FIXED UNDER WARRANTY. NOW THE PROBLEM IS THE POWER STEERING IS GOING OUT AND I HAVE TO REPLACE …

Read full complaint

HAVE A 2006 SATURN ION, IT HAS LESS THAN 50,000 MILES AND I'VE HAD 2 DIFFERENT PROBLEMS WITH THE STEERING COLUMN. THE FIRST PROBLEM WAS 2 YEARS AGO AND I COULD NOT GET THE IGNITION TO TURN OFF, TOOK IT TO THE SATURN DEALERSHIP AND WAS FIXED UNDER WARRANTY. NOW THE PROBLEM IS THE POWER STEERING IS GOING OUT AND I HAVE TO REPLACE THE WHOLE STEERING COLUMN TO GET THIS FIXED. I HAVE READ THAT THERE ARE MULTIPLE PEOPLE WITH THE SAME PROBLEM. CALLED THE SATURN DEALERSHIP AND THERE ARE OTHER RECALLS CONCERNING THIS CAR, BUT NOT FOR THIS PROBLEM. *TR

NHTSA ODI #10344105

77,000 miles · Jul 19, 2010
Steering

WHILE DRIVING, MY 2006 SATURN ION2'S POWER STEERING SHUTS OFF. THIS CAR HAS AN ELECTRIC ASSIST STEERING MOTOR VS. A POWER STEERING PUMP. DURING NORMAL DRIVING CONDITIONS, THE POWER STEERING WILL SHUT DOWN MAKING IT VERY HARD TO STEER. IF YOU TURN THE CAR OFF, THEN BACK ON, THE MOTOR WILL RESET ITSELF FOR A WHILE BEFORE SHUTTING …

Read full complaint

WHILE DRIVING, MY 2006 SATURN ION2'S POWER STEERING SHUTS OFF. THIS CAR HAS AN ELECTRIC ASSIST STEERING MOTOR VS. A POWER STEERING PUMP. DURING NORMAL DRIVING CONDITIONS, THE POWER STEERING WILL SHUT DOWN MAKING IT VERY HARD TO STEER. IF YOU TURN THE CAR OFF, THEN BACK ON, THE MOTOR WILL RESET ITSELF FOR A WHILE BEFORE SHUTTING DOWN AGAIN. THIS SAME MOTOR HAS BEEN RECALLED BY GM ON DIFFERENT GM CARS, BUT NOT THE SATURNS AS OF YET. I HAVE AN APPOINTMENT THIS WEEK TO LOOK AT IT. I HAVE BEEN DEALING WITH THIS PROBLEM FOR THREE WEEKS NOW. MOSTLY DRIVING STRAIGHT HAS POSED LIMITED DANGER, HOWEVER, THE OTHER DAY I WAS ON THE HIGHWAY ON A CURVE WHEN IT SHUT DOWN ON ME WHICH CAUSED ME TO DRIFT INTO ONCOMING TRAFFIC. IT'S VERY SCARY AND I HAVE LITTLE CONFIDENCE IN MY CAR AT THE MOMENT, BUT I HAVE TO GET TO WORK. *TR

NHTSA ODI #10344045

32,368 miles · Jul 17, 2010
Steering

STEERING ASSIST SHUT DOWN WHILE IN A TURN CAUSING CAR TO MOMENTARILY ENTER LANE WITH ONCOMING TRAFFIC. *TR

NHTSA ODI #10343761

53,445 miles · Jul 16, 2010
Steering

TL* THE CONTACT OWNS A 2006 SATURN ION. WHILE DRIVING AT 55 MPH, THE POWER STEERING LIGHT ILLUMINATED AND THE POWER STEERING WHEEL BECAME VERY DIFFICULT TO STEER. THE CONTACT WAS ABLE TO PULL OVER AND SHUT OFF THE VEHICLE. WHEN RESTARTING, THE VEHICLE RESUMED NORMAL OPERATION AND THE WARNING LIGHT WAS NO LONGER ILLUMINATED. THE…

Read full complaint

TL* THE CONTACT OWNS A 2006 SATURN ION. WHILE DRIVING AT 55 MPH, THE POWER STEERING LIGHT ILLUMINATED AND THE POWER STEERING WHEEL BECAME VERY DIFFICULT TO STEER. THE CONTACT WAS ABLE TO PULL OVER AND SHUT OFF THE VEHICLE. WHEN RESTARTING, THE VEHICLE RESUMED NORMAL OPERATION AND THE WARNING LIGHT WAS NO LONGER ILLUMINATED. THE DEALER ADVISED THE POWER STEERING MOTOR POTENTIALLY WOULD NEED TO BE REPLACED BUT ADVISED HAVING A DIAGNOSTIC PERFORMED ON THE VEHICLE TO DETERMINE THE EXACT CAUSE OF THE FAILURE. THE VEHICLE WAS NEITHER DIAGNOSED NOR REPAIRED. THE CONTACT STATED THE FAILURE OCCURRED THREE ADDITIONAL TIMES. THE FAILURE MILEAGE WAS 53,445 AND THE CURRENT MILEAGE WAS 53,465.

NHTSA ODI #10343688

68,000 miles · Jul 16, 2010
Electrical SystemSteering

POWER STEERING WENT OUT IN MY 2006 SATURN ION TODAY WHILE DRIVING ON THE INTERSTATE. NO RECALL HAS BEEN MADE ON THIS AS OF NOW, BUT AFTER RESEARCHING THIS IS A MAJOR PROBLEM HAPPENING TO MANY PEOPLE BESIDES MYSELF. I HOPE THIS GETS TAKEN CARE OF BEFORE SOMEONE GETS HURT IF THAT HAS NOT ALREADY HAPPENED. THE POWER STEERING RES…

Read full complaint

POWER STEERING WENT OUT IN MY 2006 SATURN ION TODAY WHILE DRIVING ON THE INTERSTATE. NO RECALL HAS BEEN MADE ON THIS AS OF NOW, BUT AFTER RESEARCHING THIS IS A MAJOR PROBLEM HAPPENING TO MANY PEOPLE BESIDES MYSELF. I HOPE THIS GETS TAKEN CARE OF BEFORE SOMEONE GETS HURT IF THAT HAS NOT ALREADY HAPPENED. THE POWER STEERING RESETS WHEN THE CAR GETS TURNED OFF. *TR

NHTSA ODI #10343682

45,000 miles · Jul 14, 2010
Steering

TL* THE CONTACT OWNS A 2006 SATURN ION. THE CONTACT STATED THE VEHICLE HAS NO POWER STEERING ASSIST CAPABILITY. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING OR REPAIRS. THE CONTACT BELIEVED THE FAILURE TO BE A MAJOR SAFETY ISSUE AND THAT THE MANUFACTURER SHOULD TAKE THE LIABILITY FOR THE FAILURE. THE FAILURE A…

Read full complaint

TL* THE CONTACT OWNS A 2006 SATURN ION. THE CONTACT STATED THE VEHICLE HAS NO POWER STEERING ASSIST CAPABILITY. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING OR REPAIRS. THE CONTACT BELIEVED THE FAILURE TO BE A MAJOR SAFETY ISSUE AND THAT THE MANUFACTURER SHOULD TAKE THE LIABILITY FOR THE FAILURE. THE FAILURE AND CURRENT MILEAGES WERE 45,000.

NHTSA ODI #10343271

101,103 miles · Jul 14, 2010
Steering

TL* THE CONTACT OWNS A 2006 SATURN ION. WHILE DRIVING AT 10 MPH, THE POWER STEERING LIGHT ILLUMINATED AS THE STEERING WHEEL LOCKED AND BECAME EXTREMELY DIFFICULT TO STEER. THE CONTACT SHUT OFF THE VEHICLE AND WHEN RESTARTING, THE VEHICLE RESUMED NORMAL OPERATION. THE DEALER WAS UNABLE TO DUPLICATE THE FAILURE. THE VEHICLE WAS N…

Read full complaint

TL* THE CONTACT OWNS A 2006 SATURN ION. WHILE DRIVING AT 10 MPH, THE POWER STEERING LIGHT ILLUMINATED AS THE STEERING WHEEL LOCKED AND BECAME EXTREMELY DIFFICULT TO STEER. THE CONTACT SHUT OFF THE VEHICLE AND WHEN RESTARTING, THE VEHICLE RESUMED NORMAL OPERATION. THE DEALER WAS UNABLE TO DUPLICATE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 101,103 AND THE CURRENT MILEAGE WAS 101,216.

NHTSA ODI #10343176

56,570 miles · Jul 12, 2010
Steering

I WAS DRIVING HOME FROM SCHOOL IN MY 2006 SATURN ION WHEN THE POWER STEERING WENT OUT. I HAVE A LOT OF CURVES ON MY WAY HOME AND TAKE A U TURN TO GET HOME. IT TOOK A LOT OF STRENGTH TO DO BUT I MANAGED TO GET HOME. WHEN I WAS HOME I ASKED A FRIEND TO GO OUT AND TAKE A LOOK AT THE CAR. THEY FIGURED THAT IT JUST NEEDED SOME PO…

Read full complaint

I WAS DRIVING HOME FROM SCHOOL IN MY 2006 SATURN ION WHEN THE POWER STEERING WENT OUT. I HAVE A LOT OF CURVES ON MY WAY HOME AND TAKE A U TURN TO GET HOME. IT TOOK A LOT OF STRENGTH TO DO BUT I MANAGED TO GET HOME. WHEN I WAS HOME I ASKED A FRIEND TO GO OUT AND TAKE A LOOK AT THE CAR. THEY FIGURED THAT IT JUST NEEDED SOME POWER STEERING FLUID. WHEN WE WENT OUT AND LOOKED UNDER THE HOOD OF THE CAR WE COULDN'T FIND ANY PLACE TO PUT IN SOME POWER STEERING FLUID. THEN HE TURNED ON THE CAR AND THE DASH BOARD DIDN'T SAY THAT THERE WAS ANY PROBLEM WITH THE POWER STEERING. WE WENT ON LINE TO FIND OUT THAT THERE IS NO PLACE TO PUT IN POWER STEERING FLUID. IT IS CONTROLLED BY A MOTOR IN THE STEERING COLUMN. THIS WAS UPSETTING TO LEARN BECAUSE I HAVE ALREADY HAD PROBLEMS WITH THE STEERING COLUMN BEFORE WHEN MY KEY WAS STUCK IN THE IGNITION AND MY CAR WOULDN'T TURN OFF. I'M PRETTY SURE THAT THEY HAD TO REPLACE THE STEERING COLUMN THEN, BUT THAT WAS UNDER A RECALL. NOW MY POWER STEERING GOES OUT ABOUT EVERY DAY TO EVERY OTHER DAY. I HAVE TO STOP AND TURN MY CAR OFF AND THEN START IT UP AGAIN SO THAT I CAN HAVE POWER STEERING. *TR

NHTSA ODI #10342751

68,000 miles · Jul 8, 2010
Steering

TL*THE CONTACT OWNS A 2006 SATURN ION. THE CONTACT WAS DRIVING APPROXIMATELY 25 MPH, ATTEMPTING TO MAKE A TURN INTO A PARKING LOT WHEN SUDDENLY, THERE WAS A LOSS OF POWER STEERING. THE POWER STEERING WARNING LIGHT ILLUMINATED AFTER THE POWER STEERING FAILED. THE CONTACT IMMEDIATELY SHUT THE ENGINE OFF AND PARKED THE VEHICLE. T…

Read full complaint

TL*THE CONTACT OWNS A 2006 SATURN ION. THE CONTACT WAS DRIVING APPROXIMATELY 25 MPH, ATTEMPTING TO MAKE A TURN INTO A PARKING LOT WHEN SUDDENLY, THERE WAS A LOSS OF POWER STEERING. THE POWER STEERING WARNING LIGHT ILLUMINATED AFTER THE POWER STEERING FAILED. THE CONTACT IMMEDIATELY SHUT THE ENGINE OFF AND PARKED THE VEHICLE. THE CONTACT STATED THAT THERE WAS A RELATED RECALL FOR THE 2007 MODEL YEAR SATURN ION. THE CONTACT WAS CONCERNED ABOUT THE SAFETY RISK INVOLVED. THE FAILURE MILEAGE WAS APPROXIMATELY 68,000.

NHTSA ODI #10341957

Official recalls

4

14V171000 · Electrical System:ignition

Apr 10, 2014

General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.

Consequence & remedy

Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.

Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.

14V153000 · Steering:electric Power Assist System

Mar 31, 2014

General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.

Consequence & remedy

Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.

Remedy: GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.

14V047000 · Air Bags; Electrical System:ignition:switch

Feb 10, 2014

This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.

Consequence & remedy

Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.

Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GM’s recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.

Additional source detail variants (2)

Air Bags

This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.

Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.

Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GM’s recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.

Electrical System:ignition:switch

This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.

Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.

Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GM’s recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.

09V419000 · Fuel System, Gasoline:delivery:fuel Pump

Oct 29, 2009

GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2006 CHEVROLET COBALT AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA; AND MODEL YEAR 2007 CHEVROLET COBALT, PONTIAC G5 AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA, CALIFORNIA, FLORIDA, NEVADA AND TEXAS. THE PLASTIC SUPPLY OR RETURN PORT ON THE MODULAR RESERVOIR ASSEMBLY MAY CRACK. IF EITHER OF THESE PORTS DEVELOPS A CRACK, FUEL WILL LEAK FROM THE AREA. IF THE CRACK BECOMES LARGE ENOUGH, FUEL MAY BE OBSERVED DRIPPING ONTO THE GROUND AND VEHICLE PERFORMANCE MAY BE AFFECTED.

Consequence & remedy

Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Remedy: DEALERS WILL REPLACE THE FUEL PUMP MODULE FREE OF CHARGE. A SPECIAL COVERAGE WILL BE IMPLEMENTED IN THE SAME TIME FRAME FOR MODEL YEAR 2006 VEHICLES REGISTERED IN ALABAMA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA, TENNESSEE AND TEXAS AND MODEL YEAR 2007 VEHICLES REGISTERED IN: ALABAMA, ARKANSAS, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA AND TENNESSEE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 4, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

2

EA11014 · Electric Power Steering Failure

Opened Sep 29, 2011 · Closed Apr 15, 2014

Status: closed (inferred from source dates) · Steering:electric Power Assist System

On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.

Additional source detail variants (2)

Steering:electric Power Assist System

On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.

Steering:electric Power Assist System

On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.

RQ10004 · Electric Power Steering Failure

Opened Dec 15, 2010 · Closed Oct 5, 2011

Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System

ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.

Additional source detail variants (2)

Steering:electric Power Assist System

ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.

Steering

ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.