NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
392 reportsClear category filter41,000 miles · Jun 12, 2009
Electrical System
TL*THE CONTACT OWNS A 2006 SATURN ION. THE CONTACT STATED THAT THE COMPONENT INSIDE OF THE IGNITION LOCK CYLINDER FAILED. AS A RESULT, THE VEHICLE CANNOT BE TURNED OFF AND THE KEY CANNOT BE REMOVED FROM THE IGNITION. SHE EXPLAINED THE ISSUE TO THE DEALER, BUT THEY ARE NOT ASSUMING RESPONSIBILITY FOR THE REPAIRS. SOME MECHANI…
Read full complaint
TL*THE CONTACT OWNS A 2006 SATURN ION. THE CONTACT STATED THAT THE COMPONENT INSIDE OF THE IGNITION LOCK CYLINDER FAILED. AS A RESULT, THE VEHICLE CANNOT BE TURNED OFF AND THE KEY CANNOT BE REMOVED FROM THE IGNITION. SHE EXPLAINED THE ISSUE TO THE DEALER, BUT THEY ARE NOT ASSUMING RESPONSIBILITY FOR THE REPAIRS. SOME MECHANICS STATED THAT THE DEFECTIVE ITEM WAS MADE OF PLASTIC, RATHER THAN METAL. THE CONTACT BELIEVED THAT THIS FAILURE SHOULD NOT OCCUR TO A NEWER VEHICLE. THE ONLY WAY TO SHUT OFF THE VEHICLE IS BY REMOVING A FUSE OR DISCONNECTING THE BATTERY. THE VIN WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 41,000.
NHTSA ODI #10273614
Mileage unknown · May 24, 2009
Electrical System
WE BOUGHT OUR SATURN ION 2 FROM MY HUSBANDS SISTER WHEN IT HAD 10,000 MILES ON IT. THAT WINTER ('06) THE CAR BEGAN A PATTERN OF NOT STARTING WHEN THE WEATHER WAS COLD, 20 DEGREES OR LESS. ALL THE LIGHTS,RADIO, ECT. WORKED FINE BUT THE THEFT LOCK SYSTEM LOCKS THE IGNITION FOR 10 MINUTES, AND THIS CAN HAPPEN SEVERAL TIMES IN A RO…
Read full complaint
WE BOUGHT OUR SATURN ION 2 FROM MY HUSBANDS SISTER WHEN IT HAD 10,000 MILES ON IT. THAT WINTER ('06) THE CAR BEGAN A PATTERN OF NOT STARTING WHEN THE WEATHER WAS COLD, 20 DEGREES OR LESS. ALL THE LIGHTS,RADIO, ECT. WORKED FINE BUT THE THEFT LOCK SYSTEM LOCKS THE IGNITION FOR 10 MINUTES, AND THIS CAN HAPPEN SEVERAL TIMES IN A ROW! IT WAS FINE COME SPRING, BUT THEN CAME WINTER '07 AND THE PROBLEM ONLY GOT WORSE. SATURN REFUSES TO HELP. THEY THINK YOU DON'T KNOW HOW TO START YOUR CAR AND TELL YOU THAT THEY CAN'T "REPLICATE" THE PROBLEM OR FIND ANY RECORD OF IT IN THE CARS COMPUTER. NOW, AFTER ENDURING A HORRIBLE WINTER OF TRYING TO GET THE CAR TO START ALMOST EVERY DAY NO MATTER WHAT TEMPERATURE, THE CAR IS DOING IT IN THE LATE SPRING! WE HAVE HAD 50'S TO 70'S EVERY MORNING, YET HALF THE TIME IT STILL WILL NOT START! HOW CAN WE RELY ON THIS CAR WHEN GM SAYS NOTHINGS WRONG? *TR
NHTSA ODI #10269831
Mileage unknown · May 23, 2009
Electrical System
WHEN THE WEATHER IS REALLY HOT MY CAR DOESN'T START UNTIL IT COOLS DOWN IN THE EVENING. *TR
NHTSA ODI #10269770
63,000 miles · May 5, 2009
Electrical SystemSteering
I HAVE A 2006 ION SATURN AND I WAS DRIVING ON A HIGHWAY (NY) 684 WHEN A BEEPING SOUND CAME ON AND THE "POWER STEERING" LIGHT CAME ON AND MY CAR LOCKED UP. I WAS DOING 65 IN THE LEFT HAND LANE AND NO SHOULDER TO GO ONTO. THANK GOODNESS I WAS ABLE TO SOMEHOW GET TO A SAFE SPOT ON THE HIGHWAY AND CALL FOR HELP. THIS IS A VERY SE…
Read full complaint
I HAVE A 2006 ION SATURN AND I WAS DRIVING ON A HIGHWAY (NY) 684 WHEN A BEEPING SOUND CAME ON AND THE "POWER STEERING" LIGHT CAME ON AND MY CAR LOCKED UP. I WAS DOING 65 IN THE LEFT HAND LANE AND NO SHOULDER TO GO ONTO. THANK GOODNESS I WAS ABLE TO SOMEHOW GET TO A SAFE SPOT ON THE HIGHWAY AND CALL FOR HELP. THIS IS A VERY SERIOUS PROBLEM AND NEEDS TO BE ADDRESSED BY SATURN. I AM NOT THE ONLY ONE. *TR
NHTSA ODI #10267762
56,257 miles · May 1, 2009
Electrical System
I HAVE 2006 SATURN ION 3 AND THERE IS SOMETHING GOING ON WITH THE PASSLOCK WHICH DELAY THE TIME OF MY CAR STARTING I HAVE TO WAIT 10 MINUTES BEFORE I COULD GET MY CAR TO START. *TR
NHTSA ODI #10267466
40,000 miles · Apr 13, 2009
Electrical SystemPower Train
VEHICLE INITIALLY HAD TROUBLE STARTING, MADE STRANGE SOUNDS,CHECK ENGINE LIGHT ON,WOULD NOT GO OVER 25-30MPH., FOLLOWED TOWTRUCK TO SATURN DEALER, WAS TOLD THIS WAS A COMMON PROBLEM WITH THIS MAKE & MODEL, THERE WERE THOUSANDS OF COMPLAINTS KNOWN AND THAT GM WAS AWARE OF IT BUT HAD NOT RECALLED. TURNED OUT THAT IT WAS THE IGNITI…
Read full complaint
VEHICLE INITIALLY HAD TROUBLE STARTING, MADE STRANGE SOUNDS,CHECK ENGINE LIGHT ON,WOULD NOT GO OVER 25-30MPH., FOLLOWED TOWTRUCK TO SATURN DEALER, WAS TOLD THIS WAS A COMMON PROBLEM WITH THIS MAKE & MODEL, THERE WERE THOUSANDS OF COMPLAINTS KNOWN AND THAT GM WAS AWARE OF IT BUT HAD NOT RECALLED. TURNED OUT THAT IT WAS THE IGNITION MODULE, SWITCH,COIL, HARNESS ETC., JUST UNDER $800 TO REPAIR. IT'S STILL SITTING IN THE GARAGE. THING IS...I PURCHASED THIS CAR ALMOST NEW B/C I HAD AN OLDER CAR & WANTED A NEW CAR IN CASE THE OTHER QUIT! WOW. WHO NEW? POWER STEERING ALSO GROANS AND ITS FULL OF FLUID. BECAUSE OF THIS,(IGNITION), THE KEY HAD TO BE MANUALLY PULLED OUT, TO GET THE ENGINE TO STOP RUNNING,ALL THE ELECTRICAL SYSTEM REMAINED ON, HAD TO DISCONNECT THE BATTERY, WAS TOLD DO NOT KNOW WHAT ELSE MAY HAVE BEEN DAMAGED AS A RESULT, THE DEALER SAID THE TRANSMISSION MAY HAVE BEEN DAMAGED AS A RESULT. YET THEY DON'T WANT TO RECALL BECAUSE OF THE RE-ORGANIZATION? WHAT ABOUT MY SAFETY? GOD KNOWS WHAT COULD HAVE HAPPENED IF I WAS ON THE HIGHWAY WHEN THIS HAPPENED! *TR
NHTSA ODI #10265167
60,012 miles · Apr 11, 2009
Electrical System
ON FOUR OCCASIONS, THE CAR FAILED TO START. THE LIGHTS, HORN WORK, BUT THERE IS NO IGNITION NOISE. AFTER WAITING AT LEAST 15-25 MINUTES EACH TIME, THE CAR EVENTUALLY STARTED. ON APRIL 6TH, 2009 AS I WAS COMING HOME ON THE FREEWAY, THE CAR SUDDENLY LOST POWER, WITHOUT ANY TYPE OF WARNING. I WAS ABLE TO CROSS A LANE TO GET INTO TH…
Read full complaint
ON FOUR OCCASIONS, THE CAR FAILED TO START. THE LIGHTS, HORN WORK, BUT THERE IS NO IGNITION NOISE. AFTER WAITING AT LEAST 15-25 MINUTES EACH TIME, THE CAR EVENTUALLY STARTED. ON APRIL 6TH, 2009 AS I WAS COMING HOME ON THE FREEWAY, THE CAR SUDDENLY LOST POWER, WITHOUT ANY TYPE OF WARNING. I WAS ABLE TO CROSS A LANE TO GET INTO THE SLOW LANE AND PULL OFF THE ROAD. THIS HAPPENED ON A BUSY STRETCH OF HIGHWAY AT APPROXIMATELY 12 :48PM. THE CONSEQUENCES COULD'VE BEEN VERY TRAGIC. I LATER TOOK THE CAR TO A REPAIR SHOP FOR A DIAGNOSTIC TEST, AND THE ENGINE FAILURE WASN'T RECORDED IN MY VEHICLE'S COMPUTER SYSTEM. OUTRAGEOUS. I DON'T FEEL SAFE! *TR
NHTSA ODI #10264974
Mileage unknown · Mar 29, 2009
Electrical System
IGNITION PROBLEM. CAR WILL NOT START. PASSLOCK ENGAGED. TURN KEY UNTIL PASSLOCK LIGHT STOPS FLASHING. WAIT 10MINS AND CAR WILL START. SERVICE BULLETIN IS OUT FOR PROBLEM. THE BULLETIN NUMBER IS 04-08-45-005D AND IT'S TITLED IGNITION SYSTEM - NO CRANK / NO START / DTC'S B2960/B3033. IT'S DATED MARCH 15, 2006. COVERING MODELS: 200…
Read full complaint
IGNITION PROBLEM. CAR WILL NOT START. PASSLOCK ENGAGED. TURN KEY UNTIL PASSLOCK LIGHT STOPS FLASHING. WAIT 10MINS AND CAR WILL START. SERVICE BULLETIN IS OUT FOR PROBLEM. THE BULLETIN NUMBER IS 04-08-45-005D AND IT'S TITLED IGNITION SYSTEM - NO CRANK / NO START / DTC'S B2960/B3033. IT'S DATED MARCH 15, 2006. COVERING MODELS: 2003-2006 SATURN ION. THIS ISSUE IS WIDE SPREAD AND IS KNOW BY GM. THIS IS A KNOWN DEFECT. NHTSA SHOULD DO THE CORRECT THING AND MAKE GM ISSUE A RECALL. *TR
NHTSA ODI #10263570
38,261 miles · Mar 11, 2009
Electrical System
VEHICLE INTERMITTENTLY FAILS TO START. PASSLOCK ANTI-THEFT SYSTEM PREVENTS STARTER FROM CRANKING. THIS IS A KNOWN PROBLEM WITH SATURNS, YET THEY REFUSE TO REMEDY THE DEFECT WITHOUT CHARGING FOR PARTS AND LABOR. *TR
NHTSA ODI #10261555
68,700 miles · Feb 23, 2009
Electrical System
FAILURE OF 2006 SATURN ION TO START IN COLD WEATHER, USUALLY +10 FAHRENHEIT OR BELOW. THIS PROBLEM OCCURS WITHOUT EXCEPTION WHEN TEMPERATURE IS IN THAT RANGE UNLESS WARM ARE IS SUFFICIENTLY BLOWN INTO IGNITION LOCK TO WARM IT UP TO THE POINT WERE IT WILL RECOGNIZE THE KEY. OTHERWISE THE PASS LOCK SYSTEM ENGAGES AND MUST WAIT A…
Read full complaint
FAILURE OF 2006 SATURN ION TO START IN COLD WEATHER, USUALLY +10 FAHRENHEIT OR BELOW. THIS PROBLEM OCCURS WITHOUT EXCEPTION WHEN TEMPERATURE IS IN THAT RANGE UNLESS WARM ARE IS SUFFICIENTLY BLOWN INTO IGNITION LOCK TO WARM IT UP TO THE POINT WERE IT WILL RECOGNIZE THE KEY. OTHERWISE THE PASS LOCK SYSTEM ENGAGES AND MUST WAIT ABOUT 10 MIN. TO ATTEMPT TO START THE CAR AGAIN. TOOK TO DEALERSHIP AND AN UNRELATED PROBLEM WAS FIXED(COMPUTER REPROGRAMMING). BOTH BEFORE AND AFTER REPAIR I WAS TREATED LIKE AN IDIOT BY SERVICE WOMAN AND TOLD IN A VERY DISCOURTEOUS MANNER THAT THE REPAIR WOULD CERTAINLY CORRECT THE COLD START PROBLEM. AND IF NOT THEN IT WAS BECAUSE MICE (OR OTHER SUCH CREATURES) WERE "NESTING" IN MY ENGINE COMPARTMENT AND EATING THE WIRING. MY WIFE DRIVE THIS CAR TO HER JOB IN JOLIET, IL WHICH IS BY NO MEANS A 24/7 BASTION OF SAFETY. I AM VERY CONCERNED FOR HER SAFETY, ESPECIALLY WHEN SHE MUST WORK LATER INTO THE EVENINGS. I HAVE SEEN HUNDREDS OF COMPLAINTS REGARDING THIS VERY ISSUE AND WONDER WHY THERE STILL IS NO RECALL OF THIS DEFECTIVE IGNITION SYSTEM. *TR
NHTSA ODI #10259689
Official recalls
4Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
Mar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Oct 29, 2009
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2006 CHEVROLET COBALT AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA; AND MODEL YEAR 2007 CHEVROLET COBALT, PONTIAC G5 AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA, CALIFORNIA, FLORIDA, NEVADA AND TEXAS. THE PLASTIC SUPPLY OR RETURN PORT ON THE MODULAR RESERVOIR ASSEMBLY MAY CRACK. IF EITHER OF THESE PORTS DEVELOPS A CRACK, FUEL WILL LEAK FROM THE AREA. IF THE CRACK BECOMES LARGE ENOUGH, FUEL MAY BE OBSERVED DRIPPING ONTO THE GROUND AND VEHICLE PERFORMANCE MAY BE AFFECTED.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL PUMP MODULE FREE OF CHARGE. A SPECIAL COVERAGE WILL BE IMPLEMENTED IN THE SAME TIME FRAME FOR MODEL YEAR 2006 VEHICLES REGISTERED IN ALABAMA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA, TENNESSEE AND TEXAS AND MODEL YEAR 2007 VEHICLES REGISTERED IN: ALABAMA, ARKANSAS, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA AND TENNESSEE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 4, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA11014 · Electric Power Steering Failure
Opened Sep 29, 2011 · Closed Apr 15, 2014
Status: closed (inferred from source dates) · Steering:electric Power Assist System
On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.
Additional source detail variants (2)
Steering:electric Power Assist System
On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.
Steering:electric Power Assist System
On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.
RQ10004 · Electric Power Steering Failure
Opened Dec 15, 2010 · Closed Oct 5, 2011
Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System
ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.
Additional source detail variants (2)
Steering:electric Power Assist System
ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.
Steering
ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.
Illustration