Illustration2006 SATURN ION IGNITION KEY LOCKED AND WILL NOT TURN. *TR
2006 Saturn Ion
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2006 Saturn Ion do not stand out strongly from the model-year median of 816.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Ion years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
570–25K
23825–50K
34050–75K
19275–100K
190100–150K
56150K+
1,073 reports with mileage · 162 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 544 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 392 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 127 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
44 crash reports7 fire reports23 injury reports
Electrical System complaints
392 reports2006 SATURN ION, MILEAGE 50,000. IGNITION KEY WILL NOT TURN OFF. DEALERS NOR SATURN ACCEPTING RESPONSIBILITY. PERVASIVE PROBLEM, COMPLAINTS AND NO ACTION. COSTLY REPAIR BILLS, LOSS OF INCOME FROM LOST TIME AT WORK. IMMINENT SAFETY HAZARD. RECALL ACTION SHOULD NEVER BE INITIATED ONLY AFTER A DISASTER OCCURS. *TR
STEERING WHEEL WILL NOT LOCK. WHEN TAKING KEY OUT OF IGNITION, AND OPENING DRIVER DOOR, IT CHIMES VERY FAST, AS IF KEY WAS STILL IN IGNITION OR LIGHTS HAVE BEEN LEFT ON. IT'S AS IF THE KEY WAS NEVER REMOVED AT ALL, WHICH MEANS THE ANTI-THEFT DEVICE PROBABLY DOES NOT ENGAGE AND THE IGNITION COULD EASILY BE MANIPULATED AND STARTE…
Read full complaint
STEERING WHEEL WILL NOT LOCK. WHEN TAKING KEY OUT OF IGNITION, AND OPENING DRIVER DOOR, IT CHIMES VERY FAST, AS IF KEY WAS STILL IN IGNITION OR LIGHTS HAVE BEEN LEFT ON. IT'S AS IF THE KEY WAS NEVER REMOVED AT ALL, WHICH MEANS THE ANTI-THEFT DEVICE PROBABLY DOES NOT ENGAGE AND THE IGNITION COULD EASILY BE MANIPULATED AND STARTED WITHOUT THE KEY. I HAVE NOT CONTACTED MY DEALER BECAUSE THE CAR IS NO LONGER UNDER WARRANTY AND I DO NOT HAVE THE MONEY TO PAY FOR SUCH A REPAIR. HOWEVER, I WILL BE TURNING THE CAR OVER TO GMAC ONCE THE SMARTBUY PERIOD IS UP. I ALSO HAD A PROBLEM WITH THE WINDOW FALLING OFF THE TRACK; I HAD THIS FIXED WHILE UNDER WARRANTY, BUT AT 35,500 MILES AND I DON'T DRIVE IT THAT MUCH. *TR
TL*THE CONTACT OWNS A 2006 SATURN ION. THE IGNITION SWITCH FAILED AND THE CONTACT HAS BEEN UNABLE TO REMOVE THE KEYS FOR SIX MONTHS. THE DEALER STATED THAT IT WOULD COST $800 TO REPLACE THE SWITCH AND TO DISCONNECT ANOTHER SWITCH UNDER THE STEERING WHEEL WHEN EVER SHE DROVE THE VEHICLE. THE VEHICLE BEGAN TO STALL WHILE DRIVING; …
Read full complaint
TL*THE CONTACT OWNS A 2006 SATURN ION. THE IGNITION SWITCH FAILED AND THE CONTACT HAS BEEN UNABLE TO REMOVE THE KEYS FOR SIX MONTHS. THE DEALER STATED THAT IT WOULD COST $800 TO REPLACE THE SWITCH AND TO DISCONNECT ANOTHER SWITCH UNDER THE STEERING WHEEL WHEN EVER SHE DROVE THE VEHICLE. THE VEHICLE BEGAN TO STALL WHILE DRIVING; HOWEVER, THE DEALER STATED THAT THEY ARE UNABLE TO DUPLICATE THE FAILURE UNLESS THE CHECK ENGINE LIGHT IS ILLUMINATED. THE CHECK ENGINE LIGHT WAS NOT ILLUMINATED PRIOR TO THE ENGINE STALLING. THE FAILURE MILEAGE WAS 68,000.
THE POWER STEERING KEEPS GOING OUT IN THE CAR. WHEN THIS HAPPENS IT BECOMES VERY DANGEROUS TO DRIVE. IT FIRST STARTED ONCE EVERY COUPLE OF DAYS. NOW IT HAPPENS EVERY TIME I TURN IT ON AND DRIVE MORE THEN 100 YARDS. L HAVE CONTACT THE DEALERSHIP AND THEY HAVE TOLD ME THAT THERE IS NO RECALL FOR IT. BUT I HAVE LOOKED ONLINE AND NU…
Read full complaint
THE POWER STEERING KEEPS GOING OUT IN THE CAR. WHEN THIS HAPPENS IT BECOMES VERY DANGEROUS TO DRIVE. IT FIRST STARTED ONCE EVERY COUPLE OF DAYS. NOW IT HAPPENS EVERY TIME I TURN IT ON AND DRIVE MORE THEN 100 YARDS. L HAVE CONTACT THE DEALERSHIP AND THEY HAVE TOLD ME THAT THERE IS NO RECALL FOR IT. BUT I HAVE LOOKED ONLINE AND NUMEROUS PEOPLE HAVE COMPLAINED ABOUT THIS ISSUE. THE CAR IS A LEASE AND THEY SAID I AM OVER MY WARRANTY EVEN THOUGH I ONLY HAVE 36,000 MILES IN 5 YEARS. *TR
VEHICLE STALLS FROM UNWANTED KEY CYLINDER ROTATION. KEY CYLINDER ROTATES DUE TO TILT STEERING WHEEL ADJUSTMENT. HAS OCCURRED WHILE VEHICLE IS IN MOTION. CAN REPRODUCE EASILY WHILE VEHICLE IS IN PARK. NOTHING DONE TO CORRECT. DEALER INDICATED A BULLETIN EXISTS TELLING CUSTOMERS TO NOT ADD OTHER ITEMS TO KEYRING SINCE EXTRA M…
Read full complaint
VEHICLE STALLS FROM UNWANTED KEY CYLINDER ROTATION. KEY CYLINDER ROTATES DUE TO TILT STEERING WHEEL ADJUSTMENT. HAS OCCURRED WHILE VEHICLE IS IN MOTION. CAN REPRODUCE EASILY WHILE VEHICLE IS IN PARK. NOTHING DONE TO CORRECT. DEALER INDICATED A BULLETIN EXISTS TELLING CUSTOMERS TO NOT ADD OTHER ITEMS TO KEYRING SINCE EXTRA MASS ON KEYRING MAKES THE FAILURE MORE LIKELY. *TR
1. FOR ABOUT A YEAR BEFORE THE INCIDENT, MY KEY ON MY VEHICLE WOULD GET STUCK IN THE IGNITION SOMETIMES (JUST A STICKING FEELING, NOTHING MAJOR). A COUPLE WEEKS AGO, I PUT THE KEY IN THE IGNITION AND IT WOULD NOT COME OUT. THE CAR WOULDN'T TURN OFF B/C THE KEY WAS COMPLETELY STUCK. WHEN I RESEARCHED THE PROBLEM, I FOUND OUT MANY…
Read full complaint
1. FOR ABOUT A YEAR BEFORE THE INCIDENT, MY KEY ON MY VEHICLE WOULD GET STUCK IN THE IGNITION SOMETIMES (JUST A STICKING FEELING, NOTHING MAJOR). A COUPLE WEEKS AGO, I PUT THE KEY IN THE IGNITION AND IT WOULD NOT COME OUT. THE CAR WOULDN'T TURN OFF B/C THE KEY WAS COMPLETELY STUCK. WHEN I RESEARCHED THE PROBLEM, I FOUND OUT MANY PEOPLE HAVE HAD THIS SAME PROBLEM WITH THEIR NEWER SATURN IONS. I WAS UPSET B/C I BOUGHT THIS CAR NEW IN 2006 AND MY WARRANTY HAD JUST EXPIRED. SATURN WOULD NOT PAY FOR THE REPAIR, EVEN THOUGH THEY COULD NOT EXPLAIN WHY THE IGNITION CYLINDER BROKE AND SEVERAL EMPLOYEES ADMITTED THIS WAS A VERY COMMON PROBLEM. 2. THE FAILURE WAS THE IGNITION CYLINDER, WHICH BROKE AFTER ONLY HAVING THE CAR FOR 3 YEARS-I TOOK AUTO SHOP, SO I KNOW NOT TO PUT TOO MANY KEYS ON MY KEY RING. A PART SHOULD NOT BREAK THAT SOON ON A 3-YEAR OLD CAR. I NOTICED THE KEY GETTING SLIGHTLY STUCK EVERY FEW WEEKS OR SO. THE DAY MY KEY GOT STUCK, THE CONSEQUENCE WAS THAT I WAS BASICALLY HOSTAGE TO MY CAR-I COULD NOT TURN OFF MY CAR, & COULD NOT GO TO WORK AND LEAVE MY CAR ON THE STREET. IT WAS UNSAFE FOR ME TO DRIVE AROUND UNTIL I RAN OUT OF GAS ON THE SIDE OF THE ROAD. SO, I HAD TO AGREE TO THE REPAIR, EVEN THOUGH SATURN REFUSED TO PAY FOR IT. 3. THE IGNITION CYLINDER WAS REPLACED AND IT COST ME $250. (ANOTHER $100 FOR A DAY'S MISSED WORK) *I GREATLY HOPE YOU RECALL THIS DEFECTIVE ITEM. I CALLED THE SATURN NATIONAL HOTLINE AND THEY WOULD NOT HELP IN ANY WAY AND SAID THE RECALL PROCESS TAKES "A LONG TIME" AND UNTIL THEN, CUSTOMERS WOULD HAVE TO PAY FOR THE REPAIRS TO THIS PART. I ONLY HAD TO "GOOGLE" THIS ISSUE AND FOUND COUNTLESS PEOPLE WITH 1-3 YEAR OLD SATURNS WHO WERE STUCK WITH THIS SAME PROBLEM. I AM A 33-YEAR OLD STUDENT WHO CARES FOR MY BROTHER WHO'S DISABLED. I DO NOT HAVE THIS KIND OF MONEY. IT SCARES ME TO THINK ABOUT WHAT I WOULD HAVE DONE HAD I BEEN OUT IN AN UNFAMILIAR ROAD/AREA AND BEEN UNABLE TO TURN OFF MY CAR. :/ THANKS VERY MUCH FOR YOUR TIME. *TR
TL*THE CONTACT OWNS A 2006 SATURN ION. THE CONTACT ATTEMPTED TO TURN THE IGNITION SWITCH TO THE OFF POSITION, BUT THE IGNITION FAILED TO TURN OFF. THE ENGINE CONTINUED TO OPERATE. ROADSIDE ASSISTANCE WAS CALLED TO HER RESIDENCE AND THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE TECHNICIAN STATED…
Read full complaint
TL*THE CONTACT OWNS A 2006 SATURN ION. THE CONTACT ATTEMPTED TO TURN THE IGNITION SWITCH TO THE OFF POSITION, BUT THE IGNITION FAILED TO TURN OFF. THE ENGINE CONTINUED TO OPERATE. ROADSIDE ASSISTANCE WAS CALLED TO HER RESIDENCE AND THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE TECHNICIAN STATED THAT THE IGNITION KEPT FREEZING UP AND CAUSED THE FAILURE. THE REPAIR CONSISTED OF REPROGRAMMING THE COMPUTERIZED SYSTEM AND REPLACING THE IGNITION. THE FAILURE MILEAGE WAS 37,000 AND CURRENT MILEAGE WAS 37,800.
2006 SATURN ION HAD LESS THAN 100K MILES ON IT. POWER STEERING WENT OUT WHILE DRIVING. SOON AFTER, THE KEY BECAME STUCK IN THE ON POSITION AND I COULD NOT REMOVE. IGNITION NEEDS TO BE REPLACED. *TR
TL*THE CONTACT OWNS A 2006 SATURN ION. THE CONTACT STATED THAT THE COMPONENT INSIDE OF THE IGNITION LOCK CYLINDER FAILED WHILE DRIVING 25 MPH. AS A RESULT, THE VEHICLE COULD NOT BE TURNED OFF AND THE KEY COULD NOT BE REMOVED FROM THE IGNITION. SHE EXPLAINED THE ISSUE TO THE DEALER, BUT THEY WOULD NOT ASSUME RESPONSIBILITY FOR…
Read full complaint
TL*THE CONTACT OWNS A 2006 SATURN ION. THE CONTACT STATED THAT THE COMPONENT INSIDE OF THE IGNITION LOCK CYLINDER FAILED WHILE DRIVING 25 MPH. AS A RESULT, THE VEHICLE COULD NOT BE TURNED OFF AND THE KEY COULD NOT BE REMOVED FROM THE IGNITION. SHE EXPLAINED THE ISSUE TO THE DEALER, BUT THEY WOULD NOT ASSUME RESPONSIBILITY FOR THE REPAIRS. SOME MECHANICS STATED THAT THE DEFECTIVE ITEM WAS MADE OF PLASTIC, RATHER THAN METAL. THE CONTACT BELIEVED THAT THIS FAILURE SHOULD NOT OCCUR TO A NEWER VEHICLE. THE ONLY WAY TO SHUT OFF THE VEHICLE WAS BY REMOVING A FUSE OR DISCONNECTING THE BATTERY. THE VIN WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 30,000.
Official recalls
414V171000 · Electrical System:ignition
Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
14V153000 · Steering:electric Power Assist System
Mar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
14V047000 · Air Bags; Electrical System:ignition:switch
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
09V419000 · Fuel System, Gasoline:delivery:fuel Pump
Oct 29, 2009
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2006 CHEVROLET COBALT AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA; AND MODEL YEAR 2007 CHEVROLET COBALT, PONTIAC G5 AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA, CALIFORNIA, FLORIDA, NEVADA AND TEXAS. THE PLASTIC SUPPLY OR RETURN PORT ON THE MODULAR RESERVOIR ASSEMBLY MAY CRACK. IF EITHER OF THESE PORTS DEVELOPS A CRACK, FUEL WILL LEAK FROM THE AREA. IF THE CRACK BECOMES LARGE ENOUGH, FUEL MAY BE OBSERVED DRIPPING ONTO THE GROUND AND VEHICLE PERFORMANCE MAY BE AFFECTED.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL PUMP MODULE FREE OF CHARGE. A SPECIAL COVERAGE WILL BE IMPLEMENTED IN THE SAME TIME FRAME FOR MODEL YEAR 2006 VEHICLES REGISTERED IN ALABAMA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA, TENNESSEE AND TEXAS AND MODEL YEAR 2007 VEHICLES REGISTERED IN: ALABAMA, ARKANSAS, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA AND TENNESSEE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 4, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA11014 · Electric Power Steering Failure
Opened Sep 29, 2011 · Closed Apr 15, 2014
Status: closed (inferred from source dates) · Steering:electric Power Assist System
On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.
Additional source detail variants (2)
Steering:electric Power Assist System
On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.
Steering:electric Power Assist System
On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.
RQ10004 · Electric Power Steering Failure
Opened Dec 15, 2010 · Closed Oct 5, 2011
Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System
ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.
Additional source detail variants (2)
Steering:electric Power Assist System
ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.
Steering
ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.