← New search

2006 Saturn Ion

Owner reports · Recalls · Investigations

Similar to other model years

Owner complaints for the 2006 Saturn Ion do not stand out strongly from the model-year median of 816.5.

About this comparison →

When problems were reported

Mileage at the reported incident

1,073 reports with mileage · 162 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Steering. Review the 544 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 392 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel System, Gasoline. Review the 127 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

44 crash reports7 fire reports23 injury reports

Electrical System complaints

392 reports
Clear category filter
30,000 miles · Feb 4, 2013
Electrical System

TL* THE CONTACT OWNS A 2006 SATURN ION. THE CONTACT STATED THAT THE KEY WAS UNABLE TO BE REMOVED FROM THE IGNITION AND THE CONTACT WAS UNABLE TO POWER OFF THE VEHICLE. ALSO, THE CONTACT MENTIONED HE WAS ABLE TO SWITCH GEARS WITHOUT DEPRESSING THE BRAKE. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC FOR DIAGNOSTIC TESTING. THE MECH…

Read full complaint

TL* THE CONTACT OWNS A 2006 SATURN ION. THE CONTACT STATED THAT THE KEY WAS UNABLE TO BE REMOVED FROM THE IGNITION AND THE CONTACT WAS UNABLE TO POWER OFF THE VEHICLE. ALSO, THE CONTACT MENTIONED HE WAS ABLE TO SWITCH GEARS WITHOUT DEPRESSING THE BRAKE. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC FOR DIAGNOSTIC TESTING. THE MECHANIC STATED THAT THE IGNITION KEY CYLINDER NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THE VEHICLE WAS NOT INCLUDED IN ANY RECALLS. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 30,000 AND THE CURRENT MILEAGE WAS 78,000.

NHTSA ODI #10496309

69,000 miles · Jan 16, 2013
Electrical System

TL* THE CONTACT OWNS A 2006 SATURN ION. THE CONTACT STATED THAT THE KEY BECAME STUCK IN THE IGNITION AND THE CONTACT WAS UNABLE TO POWER OFF THE VEHICLE. THE CONTACT TOOK THE VEHICLE TO THE DEALER FOR DIAGNOSTIC TESTING AND WAS ADVISED THAT A FOREIGN OBJECT HAD BECOME FRACTURED INSIDE OF THE IGNITION SWITCH. THE DEALER REPLACED …

Read full complaint

TL* THE CONTACT OWNS A 2006 SATURN ION. THE CONTACT STATED THAT THE KEY BECAME STUCK IN THE IGNITION AND THE CONTACT WAS UNABLE TO POWER OFF THE VEHICLE. THE CONTACT TOOK THE VEHICLE TO THE DEALER FOR DIAGNOSTIC TESTING AND WAS ADVISED THAT A FOREIGN OBJECT HAD BECOME FRACTURED INSIDE OF THE IGNITION SWITCH. THE DEALER REPLACED THE IGNITION SWITCH. THE FAILURE MILEAGE WAS 69,000.

NHTSA ODI #10493188

65,000 miles · Jan 3, 2013
Electrical System

KEY LOCKS UP IN IGNITION AND WILL NOT TURN TO OFF POSITION. KEY IS STUCK AND WILL NOT RELEASE FROM IGNITION. TO GET KEY OUT CAR MUST BE TURNED TO ON POSITION AND BACK OFF AGAIN. FRIENDS OF OURS ALSO HAD A SATURN ION FROM 2005 AND THEY HAD THE SAME ISSUE. THE KEY WOULD BECOME STUCK IN THE IGNITION AND THEY WOULD HAVE TO START…

Read full complaint

KEY LOCKS UP IN IGNITION AND WILL NOT TURN TO OFF POSITION. KEY IS STUCK AND WILL NOT RELEASE FROM IGNITION. TO GET KEY OUT CAR MUST BE TURNED TO ON POSITION AND BACK OFF AGAIN. FRIENDS OF OURS ALSO HAD A SATURN ION FROM 2005 AND THEY HAD THE SAME ISSUE. THE KEY WOULD BECOME STUCK IN THE IGNITION AND THEY WOULD HAVE TO START THE CAR AND TURN IT OFF (SOMETIMES SEVERAL TIMES) TO GET THE KEY OUT. OUR WORRY IS THAT THE PROBLEM WILL BECOME MORE EXTREME AND DANGEROUS WHERE WE CANNOT TURN THE CAR OFF (AS I HAVE READ IN OTHER COMPLAINTS) AS WELL AS NOT BEING ABLE TO EVENTUALLY FREE THE KEY. THIS IS A DEFECT THAT NEEDS TO BE RECALLED AND FIXED! *TR

NHTSA ODI #10490953

35,000 miles · Dec 10, 2012
Electrical System

PUT THE KEY IN AND NOW IT WILL NOT SHUT OFF....HAD TO PULL FUSE...KEY WILL NOT TURN BACK AND CAN NOT GET IT OUT. *TR

NHTSA ODI #10487835

70,000 miles · Dec 9, 2012
Electrical System

WHEN I TRY TO TAKE OUT MY KEY I CAN NOT REMOVE IT. I AM ABLE TO TURN OFF THE MOTOR, BUT THEN THE KEY IS STUCK IN THAT POSITION AND I CAN NOT REMOVE IT. I AM CONCERN THAT THEY KEY COULD STICK IN THE POSITION WHERE THE CAR IS STILL RUNNING OR THAT IT WON'T COME OUT AT ALL.. I SOMETIMES HAVE TO STAY IN MY CAR FOR 2-3 MINUTES, SO…

Read full complaint

WHEN I TRY TO TAKE OUT MY KEY I CAN NOT REMOVE IT. I AM ABLE TO TURN OFF THE MOTOR, BUT THEN THE KEY IS STUCK IN THAT POSITION AND I CAN NOT REMOVE IT. I AM CONCERN THAT THEY KEY COULD STICK IN THE POSITION WHERE THE CAR IS STILL RUNNING OR THAT IT WON'T COME OUT AT ALL.. I SOMETIMES HAVE TO STAY IN MY CAR FOR 2-3 MINUTES, SO THAT I CAN REMOVE THE KEY. I KNOW I CAN REMOVE THE KEY WHEN THE CAR MAKES A CERTAIN SOUND. IT IS A SOFT CLICK, AS IF SOMETHING IS RELEASED. IT SOUNDS SIMILAR TO THE WHEN YOU UNLOCK YOUR CAR DOORS WITH THE AUTOMATIC SWITCH, BUT QUIETER. THE KEY STICKS 1-2 TIMES/WEEK AT LEAST. (I USE MY CAR TWICE A DAY, TO AND FROM WORK, THIS HAS BEEN GOING ON SINCE I PURCHASED THE CAR SEVERAL YEARS AGO. AT THE TIME IT HAD MAYBE 40,000 MILES. NOW IT HAS 82000 MILES. *TR

NHTSA ODI #10487783

16,607 miles · Nov 30, 2012
Electrical SystemSteering

THIS VEHICLE WAS PURCHASED BRAND NEW AND DRIVEN VERY LITTLE. PROTECTED IN CLOSED IN GARAGE. DROVE TO COLORADO SPRINGS FOR VACATION AND WENT TO VISIT RELATIVES. PARKED VEHICLE IN FRONT OF RELATIVE HOME AND THE KEY COULDN'T BE TURNED TO SHUT OFF THE CAR. FORTUNATELY THERE WAS A NEIGHBOR OF MY RELATIVES THAT NEW HOW TO SHUT IT OFF …

Read full complaint

THIS VEHICLE WAS PURCHASED BRAND NEW AND DRIVEN VERY LITTLE. PROTECTED IN CLOSED IN GARAGE. DROVE TO COLORADO SPRINGS FOR VACATION AND WENT TO VISIT RELATIVES. PARKED VEHICLE IN FRONT OF RELATIVE HOME AND THE KEY COULDN'T BE TURNED TO SHUT OFF THE CAR. FORTUNATELY THERE WAS A NEIGHBOR OF MY RELATIVES THAT NEW HOW TO SHUT IT OFF BY DISCONNECTING THE BATTERY CABLES. TO START THE CAR THE CABLES HAD TO BE HOOKED BACK UP. DROVE TO FERGUSON BUICK GMC IN COLORADO SPRINGS AND THEY CHECKED IT. THE TUMBLER CAME APART, WON'T TURN OFF , REPLACED IGNITION LOCK. WAS CHARGED FOR HOUSING KIT (15857948), CODE CYL, CYLINDER KIT (20869121), LABOR AND COST OF PARTS TOTALLED $614.22. WITH ONLY 16, 607 MILES FROM 2006 TO 2012 THIS SHOULD NOT HAVE HAPPENED. TODAY, NOVEMBER 30, 2012, I WENT TO DRIVE MY VEHICLE AND WHEN I STARTED THE ENGINE ALL THE LIGHTS ON THE DASH AND MESSAGE ABOUT STEERING OFF TRAC KEEPS FLASHING AND IT SAID SOMETHING ABOUT STEERING FLUID, BRAKES AND THE LIGHTS WERE GOING CRAZY. I AM AFRAID TO DRIVE IT SO I DROVE IT BACK INTO MY GARAGE. COULDN'T DRIVE IT LIKE THAT. NOW WHAT IS WRONG. THIS VEHILCE HAS BEEN PAID FOR SINCE 2008 AND ONLY HAS 19, 000 MILES ON IT. MY HUSBAND BOUGHT ME THIS VEHICLE AS A SURPRISE AND LITTLE DID HE KNOW HE WOULD GET PANCREATIC CANCER THE FOLLOWING YEAR. HE WANTED ME TO HAVE A DEPENDABLE EXTRA VEHICLE. I CANNOT KEEP PAYING MONEY TO FIX A VEHICLE THAT I AM AFRAID TO DRIVE. MAY GET STRANDED SOMEWHERE. I WOULDN'T FEEL IN GOOD CONSCIOUS TO EVEN SELL IT TO ANYONE. NOT WORTH WHAT HE PAID FOR IT. *TR

NHTSA ODI #10486510

Mileage unknown · Oct 31, 2012
Electrical System

TL* THE CONTACT OWNS A 2006 SATURN ION 2. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 25 MPH, THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE WAS MERGED TO THE SIDE OF THE ROAD AND AFTER WAITING TEN MINUTES THE VEHICLE RESTARTED. THE FAILURE OCCURRED SPORADICALLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO STATED …

Read full complaint

TL* THE CONTACT OWNS A 2006 SATURN ION 2. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 25 MPH, THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE WAS MERGED TO THE SIDE OF THE ROAD AND AFTER WAITING TEN MINUTES THE VEHICLE RESTARTED. THE FAILURE OCCURRED SPORADICALLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO STATED THE FAULTY ANTI THEFT PASS LOCK WOULD NEED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS UNAVAILABLE.

NHTSA ODI #10482716

45,000 miles · Oct 25, 2012
Electrical System

TL* THE CONTACT OWNS A 2006 SATURN ION. THE CONTACT STATED THAT THE KEY BECAME LODGED IN THE IGNITION AND SHE WAS UNABLE TO GET IT OUT. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE CYLINDER NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTAN…

Read full complaint

TL* THE CONTACT OWNS A 2006 SATURN ION. THE CONTACT STATED THAT THE KEY BECAME LODGED IN THE IGNITION AND SHE WAS UNABLE TO GET IT OUT. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE CYLINDER NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NOT INCLUDED ON ANY RECALLS. THE FAILURE MILEAGE WAS 45,000. THE VIN WAS UNAVAILABLE.

NHTSA ODI #10482243

80,000 miles · Oct 22, 2012
Electrical System

THE KEY IS STUCK IN THE ON POSITION IN THE IGNITION SWITCH AND WILL NOT COME OUT. THIS HAS HAPPENED TWICE. HAD IT REPAIRED ON 08/28/2012 AND HAPPENED AGAIN ON 10/20/2012. *TR

NHTSA ODI #10481475

102,000 miles · Oct 20, 2012
Electrical System

I HAVE HAD A SLIGHT PROBLEM WITH MY SATURN ION SINCE I HAVE PURCHASED IT FROM MY DEALERSHIP. THE KEY WILL GET STUCK EVERY OTHER TIME I HAVE TRIED TO SHUT IT OFF. IT WAS A MINOR INCONVENIENCE AT THE MOST. BUT YESTERDAY I HAD MY KEY GET STUCK WHILE THE VEHICLE WAS RUNNING! I HAD TO HAVE THE BATTERY DISCONNECTED AND PULL A FUSE JUS…

Read full complaint

I HAVE HAD A SLIGHT PROBLEM WITH MY SATURN ION SINCE I HAVE PURCHASED IT FROM MY DEALERSHIP. THE KEY WILL GET STUCK EVERY OTHER TIME I HAVE TRIED TO SHUT IT OFF. IT WAS A MINOR INCONVENIENCE AT THE MOST. BUT YESTERDAY I HAD MY KEY GET STUCK WHILE THE VEHICLE WAS RUNNING! I HAD TO HAVE THE BATTERY DISCONNECTED AND PULL A FUSE JUST TO GET IT TO SHUT OFF. I LOOKED ONLINE FOR HOURS AND HOURS AND FOUND OUT IT IS MOST LIKELY THE IGNITION LOCK CYLINDER. THERE WERE SO MANY COMPLAINTS ON THE SATURN IONS DOING THIS I WAS SHOCKED THAT A RECALL HAS NOT BEEN ISSUED. I AM FRUSTRATED AT THE DEALERSHIP SAYING IT WILL BE $90 JUST TO LOOK AT IT, AND THEN THEY WILL GIVE ME AN ESTIMATE. ONLINE I HAVE SEEN THAT THE AVERAGE COST PAID TO HAVE THIS FIXED IS $300-$500. WHY SHOULD I HAVE TO SPEND MORE OF MY HARD EARNED MONEY IF THIS IS CLEARLY THE MANUFACTURERS FAULT? IF NOTHING IS DONE ABOUT THIS I WILL HAVE LOST ALL FAITH IN PEOPLE. *TR

NHTSA ODI #10481253

Official recalls

4

14V171000 · Electrical System:ignition

Apr 10, 2014

General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.

Consequence & remedy

Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.

Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.

14V153000 · Steering:electric Power Assist System

Mar 31, 2014

General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.

Consequence & remedy

Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.

Remedy: GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.

14V047000 · Air Bags; Electrical System:ignition:switch

Feb 10, 2014

This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.

Consequence & remedy

Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.

Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GM’s recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.

Additional source detail variants (2)

Air Bags

This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.

Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.

Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GM’s recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.

Electrical System:ignition:switch

This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.

Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.

Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GM’s recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.

09V419000 · Fuel System, Gasoline:delivery:fuel Pump

Oct 29, 2009

GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2006 CHEVROLET COBALT AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA; AND MODEL YEAR 2007 CHEVROLET COBALT, PONTIAC G5 AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA, CALIFORNIA, FLORIDA, NEVADA AND TEXAS. THE PLASTIC SUPPLY OR RETURN PORT ON THE MODULAR RESERVOIR ASSEMBLY MAY CRACK. IF EITHER OF THESE PORTS DEVELOPS A CRACK, FUEL WILL LEAK FROM THE AREA. IF THE CRACK BECOMES LARGE ENOUGH, FUEL MAY BE OBSERVED DRIPPING ONTO THE GROUND AND VEHICLE PERFORMANCE MAY BE AFFECTED.

Consequence & remedy

Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Remedy: DEALERS WILL REPLACE THE FUEL PUMP MODULE FREE OF CHARGE. A SPECIAL COVERAGE WILL BE IMPLEMENTED IN THE SAME TIME FRAME FOR MODEL YEAR 2006 VEHICLES REGISTERED IN ALABAMA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA, TENNESSEE AND TEXAS AND MODEL YEAR 2007 VEHICLES REGISTERED IN: ALABAMA, ARKANSAS, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA AND TENNESSEE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 4, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

2

EA11014 · Electric Power Steering Failure

Opened Sep 29, 2011 · Closed Apr 15, 2014

Status: closed (inferred from source dates) · Steering:electric Power Assist System

On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.

Additional source detail variants (2)

Steering:electric Power Assist System

On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.

Steering:electric Power Assist System

On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.

RQ10004 · Electric Power Steering Failure

Opened Dec 15, 2010 · Closed Oct 5, 2011

Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System

ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.

Additional source detail variants (2)

Steering:electric Power Assist System

ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.

Steering

ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.