IllustrationTHE IGNITION CASSETTE NEEDED TO BE REPLACED. *TR
2005 Saab 9-5
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all 9-5 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 11 of 11 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Equipment. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
2 crash reports0 fire reports1 injury reports
Equipment complaints
2 reportsTHE FACTORY FLOOR MAT SLIPPED FORWARD AND WAS WEDGED TO THE ACCELERATOR PEDAL SO THAT THE PEDAL STUCK AT ALMOST FULL THROTTLE. AVOIDED A COLLISION BY SHIFTING INTO NEUTRAL, STOPPING, AND REALIZING THE MAT WAS JAMMED INTO THE ACCELERATOR PEDAL. I EXTRICATED THE MAT FROM THE PEDAL AND RESTORED THE FUNCTION TO NORMAL. THE CAR HAS R…
Read full complaint
THE FACTORY FLOOR MAT SLIPPED FORWARD AND WAS WEDGED TO THE ACCELERATOR PEDAL SO THAT THE PEDAL STUCK AT ALMOST FULL THROTTLE. AVOIDED A COLLISION BY SHIFTING INTO NEUTRAL, STOPPING, AND REALIZING THE MAT WAS JAMMED INTO THE ACCELERATOR PEDAL. I EXTRICATED THE MAT FROM THE PEDAL AND RESTORED THE FUNCTION TO NORMAL. THE CAR HAS RESTRAINING PINS DESIGNED TO HOLD THE MAT IN PLACE BUT THE DESIGN IS FLAWED, ESPECIALLY IF THE MAT CURLS IN THAT AREA. *TR
Official recalls
208V160000 · Seats:front Assembly:head Restraint
Apr 9, 2008
SAAB IS RECALLING 57,389 MY 2002-2008 9-5 SERIES VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." DURING COMPLIANCE TESTING, ONE OF THE UPPER INTERIOR OCCUPANT PROTECTION TEST POINTS EXCEEDED THE STANDARD'S REQUIREMENTS.
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, PERSONAL INJURY TO OCCUPANTS MAY OCCUR.
Remedy: DEALERS WILL INSTALL A-PILLAR TRIM WITH IMPROVED ENERGY-ABSORBING CAPABILITY FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 25, 2008. OWNERS MAY CONTACT SAAB AT 1-800-955-9007.
07V087000 · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
Mar 7, 2007
ON CERTAIN PASSENGER VEHICLES, THE FUEL PUMP RETAINING TABS HOLDING THE FUEL LINES WERE DAMAGED DURING PRODUCTION.
Consequence & remedy
Consequence: OVER TIME, THIS COULD CAUSE THE FUEL LINES TO LOOSEN FROM THE PUMP RESULTING IN FUEL LEAKAGE. IF AN IGNITION SOURCE WERE PRESENT, THE FUEL MAY IGNITE RESULTING IN A VEHICLE FIRE.
Remedy: DEALERS WILL DEVELOP A SECURING BRACKET THAT WILL SECURE THE FUEL LINES TO THE FUEL PUMP EVEN IF THE PLASTIC RETAINING TABS SHOULD BREAK. THE RECALL BEGAN ON JUNE 13, 2007. THIS IS AN EXPANSION OF PREVIOUS RECALL CAMPAIGNS - SEE 04V557 AND 06V126. OWNERS MAY CONTACT SAAB AT 1-800-955-9007.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.