Vehicle experienced severe, premature component failures posing direct safety hazards while operating a commercial work van: 1. Parking Brake Seizure (01/25/2025 @ 49,197 miles): The parking brake pivot assembly completely seized, causing the rear brake assembly to lock up and rendering the vehicle unsafe to operate on public r…
Read full complaint
Vehicle experienced severe, premature component failures posing direct safety hazards while operating a commercial work van: 1. Parking Brake Seizure (01/25/2025 @ 49,197 miles): The parking brake pivot assembly completely seized, causing the rear brake assembly to lock up and rendering the vehicle unsafe to operate on public roads. Replaced under Invoice #CHCS490962. 2. Catastrophic Transmission & Drivetrain Failure (05/15/2026 @ 66,082 miles): The transmission suffered recurring fluid leaks beginning at 49,197 miles (pan leak reseal) and 51,648 miles (complete front pump replacement). At 66,082 miles, the transmission suffered complete internal failure (burnt fluid, clutch metal material), resulting in total loss of reverse power and gear slipping while operating. Both front strut mounts failed on the same visit. Experiencing brake lockup and sudden total loss of transmission control under 66,000 miles on a commercial vehicle presents significant safety risks to vehicle operators and traffic.
NHTSA ODI #11753014
Mileage unknown · Nov 15, 2024
Service Brakes
My van began making a loud squeaky sound, louder at low speeds and less at higher speeds. It sounded like it was coming from the wheels or undercarriage. There were no dash warning lights, alarms, or any other indicator of a serious issue. I drove the van around town for a few days approximately 30 miles. The van is heavy and I …
Read full complaint
My van began making a loud squeaky sound, louder at low speeds and less at higher speeds. It sounded like it was coming from the wheels or undercarriage. There were no dash warning lights, alarms, or any other indicator of a serious issue. I drove the van around town for a few days approximately 30 miles. The van is heavy and I live in a hilly area, so I use the parking brake fairly often. I applied the parking brake within that week on an incline, and when I released the parking brake and drove forward, the squeak was louder then ever, so much so, people stared. There were no error or warning message on the dash or elsewhere. The parking brake indicator had come on normally while engaged and went off when it was released. I drove it directly to the local Ram dealer, as it seemed worse, hoping it was just in need of minor lubrication. It had just been serviced at the same dealer a few months earlier and I was told "it was like new with its low 12,500 miles". I explained the new noise and that I didn't want to cause damage by driving it, although there were no warning lights on. My van is still under the original warranty for a few more months. Even though they were booked, an employee went out and felt by the rear driver's side wheel and said it was really hot and likely a frozen brake caliper. They were able to fit me in and discovered the parking brake was frozen, which was causing the noise. They ordered the parts to repair, disengaged the parking brake, and said it was safe to drive as the main brakes were a separate system. They said not to apply the parking brake again as it would hang up as before. -The dealer ordered the parts over a month ago, but said the brake parts are not only on back order, but with no estimated shipping date, meaning they aren't even manufacturing them. -I am driving without a parking brake in a heavy vehicle in a hilly area with no pending solution and heading into winter weather. This is a safety issue! Please help ASAP.
NHTSA ODI #11625522
Mileage unknown · Jan 10, 2024
Service Brakes
Every time the vehicle is driven downhill for an extended period, such as over a mountain pass, the brake system light comes on and can only be turned off by stopping the vehicle and turning the car off. This has happened every time I go over a mountain pass for the last 1-1/2 years. I have reported this to the Ram dealer and h…
Read full complaint
Every time the vehicle is driven downhill for an extended period, such as over a mountain pass, the brake system light comes on and can only be turned off by stopping the vehicle and turning the car off. This has happened every time I go over a mountain pass for the last 1-1/2 years. I have reported this to the Ram dealer and have been told that this is a known issue on Ram Promasters and that there is no resolution by multiple technicians. It is disconcerting every time it comes on, but I worry that when I really have a brake issue I will not know it since the brake light comes on all the time already.
NHTSA ODI #11564652
Mileage unknown · Aug 9, 2023
Service Brakes
The back brakes are locked up. The identical issue on the same 2021 promaster 3500 we have. I'll submit a separate request
NHTSA ODI #11537348
Mileage unknown · Aug 9, 2023
Service Brakes
Back brakes are locked up. Identical issue on the same 2021 promaster 2500 we have. I'll submit a seperate request
NHTSA ODI #11537346
Mileage unknown · May 31, 2022
Service Brakes
Most times when going down long grade over 6 + percent a dash warning comes on about service brake system. Once we get to flat area and turn ignition off the message goes away. We haven't had an issue braking. We are on Facebook group with other promaster 3500 and over 80 other similar vehicle owners stated this happens to t…
Read full complaint
Most times when going down long grade over 6 + percent a dash warning comes on about service brake system. Once we get to flat area and turn ignition off the message goes away. We haven't had an issue braking. We are on Facebook group with other promaster 3500 and over 80 other similar vehicle owners stated this happens to them. Everyone says it's a "known problem" and not an issue and just ignore. We are worried what happens if it really is a problem. It happens every time we do mountain driving. I'd say over 10 times this year.
NHTSA ODI #11466828
Mileage unknown · Nov 3, 2021
Service Brakes
After van was put in reverse, when put in forward, the left rear caliper seized up and wheel would not turn. Was able to free wheel after putting in forward and reverse a few times. Seized again later that day. Was able to free up again and drive to dealer. Dealer stated rear and front driver-side calipers were not functioning c…
Read full complaint
After van was put in reverse, when put in forward, the left rear caliper seized up and wheel would not turn. Was able to free wheel after putting in forward and reverse a few times. Seized again later that day. Was able to free up again and drive to dealer. Dealer stated rear and front driver-side calipers were not functioning correctly and will need replaced. Currently, van is at dealer awaiting repair. There was no accident. I don't recall any warning lights.
NHTSA ODI #11439264
Mileage unknown · Aug 24, 2021
Service Brakes
On August 5, I descended on California Highway 88 East from the Carson Pass; less than 1 mile down a warning appeared to “Service Brake System”. The warning disappeared but the “brake” light on the instrument cluster remained on. I took the vehicle to Carson Dodge on August 6. The dealer performed diagnostics and made two rep…
Read full complaint
On August 5, I descended on California Highway 88 East from the Carson Pass; less than 1 mile down a warning appeared to “Service Brake System”. The warning disappeared but the “brake” light on the instrument cluster remained on. I took the vehicle to Carson Dodge on August 6. The dealer performed diagnostics and made two repairs based on generated codes (C1223-68 & P0556). I picked it up on August 13 and drove about 200 miles; the warning re-appeared each time I drove it. I returned the vehicle to Carson Dodge on August 16. The “brake” warning was visible both times it was in for service. The 8/16 work order shows the same problem codes as the August 6 work order. The 8/16 order states that the technician was told by Star (Dodge technical support) that the warning was “normal operations caused by extended braking from a high altitude” so no repairs were required (and ignoring the two codes). I contacted Dodge Customer Service on 8/16. Jagen, a Promaster Case Manager called on 8/17 and told me that he investigated the issue and the “Service Brake System” safety warning was normal when going downhill. I asked if it was normal then where this was published; he said it was proprietary information and not published. I asked if he would provide confirmation in writing; he refused. “Jim”, a supervisor, called on 8/24; he repeated that going downhill would result in the warning light coming on and this was normal operations. That a safety warning consistently appears in normal driving on ordinary roads (e.g. from South Lake Tahoe to Carson City on Highway 50) and is “normal operations” is absurd. If I ignore this warning as “normal operations”, then how do I know when there is an actual problem? If normal, why isn’t it published anywhere? I am unable to confidently use the vehicle as I can’t know if the brakes will function. Brake reliability is a life-threatening safety issue, yet Dodge is telling me to ignore the vehicle’s safety warnings.
Rollx Vans (Rollx) is recalling certain GMC Yukon, Sierra, Chevrolet Express 2500, Ford Transit, E-250, Toyota Sienna, Sienna Hybrid, Honda Odyssey, Chrysler Town and Country, Voyager, Pacifica, Dodge Grand Caravan, and Ram Promaster vehicles equipped with QRT-Deluxe and QRT-Max wheelchair restraints. Please refer to Rollx's recall report for specific model year information. The retractors may not lock, preventing the wheelchair from being properly secured.
Consequence & remedy
Consequence: An unsecured wheelchair can move during transit, increasing the risk of injury.
Remedy: Rollx will work with Q'Straint to inspect and replace the retractors as necessary, free of charge. Owner notification letters were mailed February 5, 2026. Owners may contact Rollx's customer service at 1-800-956-6668.
Chrysler (FCA US, LLC) is recalling certain 2018-2026 Ram ProMaster vehicles. The electrical circuit for the radiator fan may overheat.
Consequence & remedy
Consequence: Electrical circuits that overheat increase the risk of a fire.
Remedy: Dealers will replace the cooling fan module and fuse. In addition dealers will provide an addendum for the manual and label for the power distribution center. Some interim notification letters, notifying owners of the safety risk, were mailed December 11, 2025. Some owner notification letters were mailed beginning December 11, 2025. Additional owner notification letters were mailed in January, March, and June 2026. Remaining owner notification letters are expected to be mailed July 2026. Owners may contact Chrysler customer service at 800-853-1403. Chrysler's numbers for this recall are 67C, B3C, and C9C. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov beginning October 30, 2025.
Chrysler (FCA US, LLC) is recalling certain 2019-2021 Ram ProMaster and 2019-2020 Dodge Journey vehicles. Cracks in the microprocessor may cause the vehicle's rearview camera image not to display properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility.
Consequence & remedy
Consequence: A rearview image that does not display properly reduces the driver's view behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will replace the rearview camera, free of charge. Interim notification letters, notifying owners of the safety risk, were mailed beginning September 30, 2025. A second notice will be sent once the final remedy is available, anticipated July 2026. Owners may contact Chrysler customer service at 800-853-1403. Chrysler's number for this recall is 59C.
Chrysler (FCA US, LLC) is recalling certain 2021-2024 Ram Promaster vehicles. The vehicles are missing a side door beam, and the tire placard contains incorrect seating capacity information. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 214, "Side Impact Protection" and 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: A missing side door beam may not provide adequate occupant protection in a crash, increasing the risk of injury. Incorrect seating capacity information can result in an improperly loaded vehicle, increasing the risk of injury in a crash.
Remedy: Dealers will install a door beam and apply an overlay label, free of charge. Owner notification letters were mailed August 1, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 53B.
Additional source detail variants (3)
Structure:body:door
Chrysler (FCA US, LLC) is recalling certain 2021-2024 Ram Promaster vehicles. The vehicles are missing a side door beam, and the tire placard contains incorrect seating capacity information. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 214, "Side Impact Protection" and 110, "Tire Selection and Rims."
Consequence: A missing side door beam may not provide adequate occupant protection in a crash, increasing the risk of injury. Incorrect seating capacity information can result in an improperly loaded vehicle, increasing the risk of injury in a crash.
Remedy: Dealers will install a door beam and apply an overlay label, free of charge. Owner notification letters were mailed August 1, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 53B.
Seats:mid/rear Assembly
Chrysler (FCA US, LLC) is recalling certain 2021-2024 Ram Promaster vehicles. The vehicles are missing a side door beam, and the tire placard contains incorrect seating capacity information. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 214, "Side Impact Protection" and 110, "Tire Selection and Rims."
Consequence: A missing side door beam may not provide adequate occupant protection in a crash, increasing the risk of injury. Incorrect seating capacity information can result in an improperly loaded vehicle, increasing the risk of injury in a crash.
Remedy: Dealers will install a door beam and apply an overlay label, free of charge. Owner notification letters were mailed August 1, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 53B.
Equipment:other:labels
Chrysler (FCA US, LLC) is recalling certain 2021-2024 Ram Promaster vehicles. The vehicles are missing a side door beam, and the tire placard contains incorrect seating capacity information. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 214, "Side Impact Protection" and 110, "Tire Selection and Rims."
Consequence: A missing side door beam may not provide adequate occupant protection in a crash, increasing the risk of injury. Incorrect seating capacity information can result in an improperly loaded vehicle, increasing the risk of injury in a crash.
Remedy: Dealers will install a door beam and apply an overlay label, free of charge. Owner notification letters were mailed August 1, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 53B.
Chrysler (FCA US, LLC) is recalling certain 2021 Ram Promaster vehicles. An insecure ground connection may cause the electronic stability control (ESC) to be inoperative. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 126, "Electronic Stability Control Systems."
Consequence & remedy
Consequence: Driving with an inoperative electronic stability control system can increase the risk of a crash.
Remedy: Dealers will tighten the ground nut assembly, free of charge. All affected vehicles have been remedied. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 43B.
Chrysler (FCA US, LLC) (Stellantis) is recalling certain 2021-2022 Ram ProMaster vehicles. The wiring harness may have a poor connection, which can cause the left taillight and left turn signal to become inoperative. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: An inoperative left turn signal may not notify other drivers of a turning vehicle, and an inoperative left taillight can reduce the vehicle's visibility to other drivers. Both scenarios can increase the risk of a crash.
Remedy: Dealers will inspect and replace the harness, as necessary free of charge. Owner notification letters were mailed February 20, 2025. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 21B.
Additional source detail variants (2)
Exterior Lighting
Chrysler (FCA US, LLC) (Stellantis) is recalling certain 2021-2022 Ram ProMaster vehicles. The wiring harness may have a poor connection, which can cause the left taillight and left turn signal to become inoperative. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence: An inoperative left turn signal may not notify other drivers of a turning vehicle, and an inoperative left taillight can reduce the vehicle's visibility to other drivers. Both scenarios can increase the risk of a crash.
Remedy: Dealers will inspect and replace the harness, as necessary free of charge. Owner notification letters were mailed February 20, 2025. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 21B.
Electrical System:wiring
Chrysler (FCA US, LLC) (Stellantis) is recalling certain 2021-2022 Ram ProMaster vehicles. The wiring harness may have a poor connection, which can cause the left taillight and left turn signal to become inoperative. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence: An inoperative left turn signal may not notify other drivers of a turning vehicle, and an inoperative left taillight can reduce the vehicle's visibility to other drivers. Both scenarios can increase the risk of a crash.
Remedy: Dealers will inspect and replace the harness, as necessary free of charge. Owner notification letters were mailed February 20, 2025. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 21B.
Chrysler (FCA US, LLC) is recalling certain 2019-2021 Ram ProMaster vehicles equipped with a 62TE transmission. The park pawl may not fully engage the park gear due to debris inside the transmission.
Consequence & remedy
Consequence: A partially engaged park pawl can result in a vehicle rollaway, increasing the risk of a crash or injury.
Remedy: Dealers will update the powertrain control module software, and inspect and replace, as necessary, the transmission or components within the transmission, free of charge. Owner notification letters were mailed June 22, 2023. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 44A.
Chrysler (FCA US, LLC) is recalling certain 2021 Ram ProMaster City and Ram ProMaster vehicles. The seat belt automatic locking retractors may deactivate early, which can prevent the child restraint system from securing properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: An unsecured child restraint system can increase the risk of injury during a crash.
Remedy: Dealers will inspect and replace the seat belt retractors as necessary, free of charge. Owner notification letters were mailed October 28, 2021. Owners may contact FCA US LLC customer service at 1-800-853- 1403. FCA US LLC's number for this recall is Y61.
Additional source detail variants (3)
Seat Belts:rear/other:retractor
Chrysler (FCA US, LLC) is recalling certain 2021 Ram ProMaster City and Ram ProMaster vehicles. The seat belt automatic locking retractors may deactivate early, which can prevent the child restraint system from securing properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence: An unsecured child restraint system can increase the risk of injury during a crash.
Remedy: Dealers will inspect and replace the seat belt retractors as necessary, free of charge. Owner notification letters were mailed October 28, 2021. Owners may contact FCA US LLC customer service at 1-800-853- 1403. FCA US LLC's number for this recall is Y61.
Seat Belts:front:retractor
Chrysler (FCA US, LLC) is recalling certain 2021 Ram ProMaster City and Ram ProMaster vehicles. The seat belt automatic locking retractors may deactivate early, which can prevent the child restraint system from securing properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence: An unsecured child restraint system can increase the risk of injury during a crash.
Remedy: Dealers will inspect and replace the seat belt retractors as necessary, free of charge. Owner notification letters were mailed October 28, 2021. Owners may contact FCA US LLC customer service at 1-800-853- 1403. FCA US LLC's number for this recall is Y61.
Seat Belts
Chrysler (FCA US, LLC) is recalling certain 2021 Ram ProMaster City and Ram ProMaster vehicles. The seat belt automatic locking retractors may deactivate early, which can prevent the child restraint system from securing properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence: An unsecured child restraint system can increase the risk of injury during a crash.
Remedy: Dealers will inspect and replace the seat belt retractors as necessary, free of charge. Owner notification letters were mailed October 28, 2021. Owners may contact FCA US LLC customer service at 1-800-853- 1403. FCA US LLC's number for this recall is Y61.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2021 RAM Promaster Problems, Complaints & Recalls | Skip That Year
Illustration