NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
236 reports92,000 miles · Apr 24, 2004
Engine And Engine Cooling
DEXCOOL IN 1997 PONTIAC TRANSPORT CORRODED INTAKE MANIFOLD GASKET ENABLING OIL AND DEXCOOL TO MIX IN OIL AND GUMMING UP, CAUSING ENGINE TO OVERHEAT AND SELF DESTRUCT. NO WARNING WHATSOEVER. NO WARNING LIGHTS. NO LOST OIL OR COOLANT. MAINTAINED AT MANUFACTURER INTERVALS. REQUIRES $6,000 ENGINE REPLACEMENT. OLD OIL AND DEXCO…
Read full complaint
DEXCOOL IN 1997 PONTIAC TRANSPORT CORRODED INTAKE MANIFOLD GASKET ENABLING OIL AND DEXCOOL TO MIX IN OIL AND GUMMING UP, CAUSING ENGINE TO OVERHEAT AND SELF DESTRUCT. NO WARNING WHATSOEVER. NO WARNING LIGHTS. NO LOST OIL OR COOLANT. MAINTAINED AT MANUFACTURER INTERVALS. REQUIRES $6,000 ENGINE REPLACEMENT. OLD OIL AND DEXCOOL SAMPLES ARE AVAILABLE AS ARE ALL PARTS (MANIFOLD INTAKE GASKET). OVER 1100 PEOPLE HAVE THIS REGISTERED COMPLAINT -- SEE WWW.GM-V6LEMONS.COM FOR OTHERS.*AK
NHTSA ODI #10067754
Mileage unknown · Apr 20, 2004
Latches/locks/linkages
REAR PASSENGER POWER SLIDING DOOR WILL NOT CLOSE PROPERLY DUE TO A FAULTY LATCH. DEALER WILL REPLACE THE LATCH ONLY AT CONSUMER'S EXPENSE. *AK CONSUMER HAS TO PHYSICALLY LEAN ON THE DOOR TO CLOSE. *LA
NHTSA ODI #10063326
55,000 miles · Mar 24, 2004
Engine And Engine Cooling
GENERAL MOTORS 1997 PONTIAC TRANSPORT MINIVAN- INTAKE MANIFOLD REPLACED AT 55,000 MILES AND 72,000. *NM
NHTSA ODI #10063779
Mileage unknown · Mar 22, 2004
Engine And Engine Cooling
LOWER INTAKE MANIFOLD GASKET IS LEAKING DUE TO FAULTY PLASTIC MATERIALS. DEALER ADVISES IMMEDIATE REPAIR TO AVOID ENGINE FAILURE. DEALER INDICATES THIS IS A COMMON PROBLEM WITH NO RELIEF FROM GENERAL MOTORS. GM HAS ISSUED A TECHNICAL BULLETIN TO ITS DEALERS REGARDING THE PROBLEM. BULLETIN #: 03-06-01-010 MARCH 2003. *AK
NHTSA ODI #10062788
86,000 miles · Mar 22, 2004
Exterior Lighting
HEADLIGHT ASSEMBLY PLASTIC FALLS OFF EXPOSING BULB TO MOISTURE/RAIN WHICH CAUSES THE BULB TO BURN OUT. THEREFORE, LOSING THE ILLUMINATION OF ONE LAMP AND LIMITING VISABILITY WHILE DRIVING AT NIGHT.*AK
NHTSA ODI #10062784
84,000 miles · Mar 14, 2004
Engine And Engine Cooling
FAULTY HEAD GASKEY CAUSES MAJOR ENGINE FAILURE IN GM BEHICLES. *AK
NHTSA ODI #10062155
109,000 miles · Jan 23, 2004
1997 PONTIAC TRANSPORT. FAILED INTAKE MANIFOLD GASKET CAUSED DEXCOOL TO LEAK INTO THE ENGINE. THIS HAPPENED WHILE MY WIFE WAS RETURNING TO ST. LOUIS FROM FLORIDA. VEHICLE STARTED MAKING STRANGE NOISES ON THE TRIP BACK. SHE BARELY MADE IT HOME. ALTERNATOR BURNED OUT THE NEXT DAY. HAD IT REPAIRED. NEXT DAY, THE ENGINE JUST DIED. W…
Read full complaint
1997 PONTIAC TRANSPORT. FAILED INTAKE MANIFOLD GASKET CAUSED DEXCOOL TO LEAK INTO THE ENGINE. THIS HAPPENED WHILE MY WIFE WAS RETURNING TO ST. LOUIS FROM FLORIDA. VEHICLE STARTED MAKING STRANGE NOISES ON THE TRIP BACK. SHE BARELY MADE IT HOME. ALTERNATOR BURNED OUT THE NEXT DAY. HAD IT REPAIRED. NEXT DAY, THE ENGINE JUST DIED. WE WERE TOLD IT WAS A BLOWN HEADGASKET. HAVE SINCE FOUND OUT IT IS ACTUALLY THE INTAKE MANIFOLD GASKET THAT FAILED. GM KNOWS OF THIS PROBLEM YET REFUSES TO TAKE RESPONSIBILITY FOR AN OBVIOUS DESIGN FLAW. THEY HAVE REDESIGNED THE GASKET. THEY ARE EVEN PREMPTIVELY HAVING PEOPLE FIX THESE PARTS BEFORE THEY FAIL WITHOUT TELLING PEOPLE WHAT IS REALLY WRONG. GM SHOULD BE FIXING THIS FOR FREE! YOU PEOPLE NEED TO DO YOUR JOB AND MAKE THESE CROOKS OWN UP TO THE PROBLEM. THIS DOES NOT EVEN APPROACH THE PROBLEM WITH THE DEX-COOL ANTIFREEZE RUSTING OUT THE COOLING SYSTEM.
NHTSA ODI #10054746
200,000 miles · Jan 15, 2004
Unknown Or Other
SPARE TIRE IS STORED UNDERNEATH THE VEHICLE AND IS RAISED AND LOWERED BY A CRANK. DUE TO ITS LOCATION, IT IS SUBJECT TO THE ELEMENTS, AND OVER TIME, THE WIRE USED TO RAISE AND LOWER THE TIRE CORRODES CAUSING THE TIRE TO FALL. IF YOU ARE LUCKY IT HAPPENS WHILE CLOSING THE TAILGATE IN A PARKING LOT. IF YOU ARE UNLUCKY, IT HAPPEN…
Read full complaint
SPARE TIRE IS STORED UNDERNEATH THE VEHICLE AND IS RAISED AND LOWERED BY A CRANK. DUE TO ITS LOCATION, IT IS SUBJECT TO THE ELEMENTS, AND OVER TIME, THE WIRE USED TO RAISE AND LOWER THE TIRE CORRODES CAUSING THE TIRE TO FALL. IF YOU ARE LUCKY IT HAPPENS WHILE CLOSING THE TAILGATE IN A PARKING LOT. IF YOU ARE UNLUCKY, IT HAPPENS WHILE TRAVELLING DOWN THE ROAD. GM CANADA APPARENTLY HAD AN 'EXTENDED WARRANTY' IN PLACE BUT IT WAS DISCONTINUED IN DEC 2002.
NHTSA ODI #10071373
113,000 miles · Jan 15, 2004
Engine And Engine CoolingFuel System, GasolineSteering
OUR CYL HEAD GASKETS HAD TO BE REPLACED AND OUR CYL HEADS HAD TO BE MACHINED, WE ALSO HAD TO REPLACE OUR FUEL PUMP AT THE SAME TIME
NHTSA ODI #10071293
39,000 miles · Jan 15, 2004
Engine And Engine CoolingService Brakes, HydraulicSteering
AT 51000 MILES THE 3.4L ENGINE HAD LOWER INTAKE GASKET FAILURE IN WHICH THE DEX-COOL ANTI FREEZE DUMPED INTO THE CRANKCASE MIXING WITH THE OIL. THIS ONLY HAD ONE WARNING A COUPLE MONTHS EARLIER AS THE LOW COOLANT LIGHT CAME ON AND I ADDED 1/2 GALLON DEX-COOL WITH NO SIGNS OF LEAKAGE. NEXT TIME IT HAPPENED WAS WHEN MY WIFE WAS TA…
Read full complaint
AT 51000 MILES THE 3.4L ENGINE HAD LOWER INTAKE GASKET FAILURE IN WHICH THE DEX-COOL ANTI FREEZE DUMPED INTO THE CRANKCASE MIXING WITH THE OIL. THIS ONLY HAD ONE WARNING A COUPLE MONTHS EARLIER AS THE LOW COOLANT LIGHT CAME ON AND I ADDED 1/2 GALLON DEX-COOL WITH NO SIGNS OF LEAKAGE. NEXT TIME IT HAPPENED WAS WHEN MY WIFE WAS TAKING DAUGHTER TO SCHOOL AND TEMP. LIGHT CAME ON. VAN WAS NOT DRIVEN OVER 2 MILES TO DEALER, AS LIGHT WENT OUT. DEALER SAID EXTREME MIXTURE IN BOTH CRANKCASE AND RADIATOR. RECOMMENDED REPLACE RADIATOR, WATERPUMP, INTAKE GASKETS, FLUSH BOTH SYSTEMS AT A COST OF 1500 NOT TO BE APPLIED TOWARD ENGINE REPLACEMENT IF FAILURE ON START UP. DEALER HAD JUST HAD VAN IN WEEK BEFORE FOR CHECK ENGINE LIGHT AND STEERING RECALL AND FOUND NOTHING WRONG !!!! WE TRADED IT IN AT A LOSS AS I CHECKED INTO THE PROBLEM AND LEARNED ABOUT THOUSANDS OF OTHER OWNERS WITH SAME PROBLEMS WITH TOTAL ENGINE FAILURES AFTER REPAIRS MADE. WE LOST OVER $3000 EQUITY BETWEEN WHAT TRADE VALUE WOULD HAVE BEEN IF NO PROBLEM WITH ENGINE AND LETTING DEALER FIX PROBLEM AFTER TRADE. VAN HAD MANY PROBLEMS SINCE WE BOUGHT IT NEW BUT WE ALWAYS HAD THEM FIXED AND WAS WELL MAINTAINED. LOOKED NEW WHEN WE TRADED WITH ONLY 50,000 MILES. PAINT ON HOOD BLISTERED TWICE, STEERING / BRAKES WOBBLED SINCE NEW AT VARYNG SPEEDS, ALWAYS HAD TICKING SOUND IN ENGINE DEALER SAID WAS "NORMAL", REAR SEATS WOULD JAMB UP IF YOU TRIED TO REMOVE, WIPER ARMS FAILED TWICE, SERPENTINE BELT TENSIONER BROKE OFF ON ENGINE START UP IN DEC. 2002. COST $375 WITH TOWING, POWER WINDOW SWITCH FAILED IN DOWN POSITION AT REPLACEMENT COST OF ABOUT $175. ENGINE UNDER WARRANTY WHEN IT HAD A SEVERE GAS SMELL THAT NEARLY CAUSED A FIRE IN ABOUT 1999. THEY KEPT IT A WEEK AND NEVER SAID WHAT THE PROBLEM WAS. THEY HAD JUST WORKED ON IT FOR TICKING SOUND. (PROBABLY INTAKE GASKETS THEN ALSO). GM WAS NO HELP AFTER WARRANTY WAS UP.
NHTSA ODI #10070686
Official recalls
5Dec 22, 2004
ON CERTAIN MINIVANS EQUIPPED WITH SECOND-ROW BUCKET SEATS OR CAPTAIN'S CHAIRS AND A POWER SLIDING DOOR ON THE PASSENGER SIDE OF THE VEHICLE, A PASSENGER USING THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR COULD BE INJURED.
Consequence & remedy
Consequence: IF A PASSENGER USES THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR AND HOLDS ONTO THE HANDLE WHILE IT IS BEING OPENED BY THE MOTOR, THE PASSENGER'S ARM MAY BE PUSHED INTO THE SEAT BACK OR ARMREST AND A WRIST OR LOWER ARM INJURY MAY RESULT.
Remedy: DEALERS WILL REPLACE THE POWER SLIDING DOOR INTERIOR HANDLE ON THE PASSENGER-SIDE. IF THE VEHICLE IS EQUIPPED WITH A POWER OR MANUAL SLIDING DOOR ON THE DRIVER-SIDE, THE INTERIOR HANDLE WILL ALSO BE REPLACED FOR APPEARANCE REASONS. NOTE: BEFORE THE VEHICLE IS SERVICED, GM ADVISES OWNERS TO NOT USE THE INTERIOR DOOR HANDLE TO OPEN THE DOOR. THE DRIVER CAN OPEN AND CLOSE THE DOOR FROM SWITCHES AT THE DRIVER'S POSITION OR BY USING THE REMOTE KEY FOB. THE DRIVER SHOULD TELL PASSENGERS TO USE THE SWITCH LOCATED IN FRONT OF THE DOOR TO OPEN OR CLOSE IT. THE DRIVER SHOULD USE THE OVERRIDE SWITCH TO PREVENT OPERATION OF THE POWER DOOR BY CHILDREN OR BY OTHERS WHO ARE NOT FAMILIAR WITH ITS USE. THE OWNER NOTIFICATION LETTER MAILING WILL BE CONDUCTED IN PHASES WITH THE FIRST PHASE BEGINNING ON MAY 31, 2005. THE SECOND PHASE MAILING BEGAN ON JULY 18, 2005. THE RECALL BEGAN ON MAY 31, 2005. PHASE 2 BEGAN ON JULY 18, 2005. PHASE 3 (FINAL PHASE) BEGAN ON AUGUST 24, 2005, TO ALL REMAINING CUSTOMERS. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438; PONTIAC AT 1-800-620-7668; OR OLDSMOBILE AT 1-800-630-6537.
Nov 4, 2002
CERTAIN PASSENGER VEHICLES AND MINI VANS HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE AND SOME OTHER RETAINERS USED IN VEHICLES ASSEMBLED BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997, COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN JANUARY 24, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
Aug 21, 2001
VEHICLE DESCRIPTION: 1997-2001 CHEVROLET VENTURE, PONTIAC MONTANA/TRANSPORT, AND OLDSMOBILE SILHOUETTE MINI VANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS THAT WERE SERVICED IN CAMPAIGN 01013 (01V-067) FROM APRIL TO AUGUST 2001. ALSO 2001 CHEVROLET VENTURE, PONTIAC MONTANA, AND OLDSMOBILE SILHOUETTE MINI VANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS ASSEMBLED IN JANUARY THROUGH APRIL 2001. THESE VEHICLES HAVE INADEQUATE FRONT WELDS. IF A FRONT WELD FAILS, THE ACTUATOR CAN JAM IN THE UNLATCHED POSITION AND, WHEN THE SLIDING DOOR CLOSES, IT WILL NOT BE LATCHED.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE POWER SLIDING DOOR CAN OPEN WHILE THE VEHICLE IS IN MOTION, PARTICULARLY WHEN THE VEHICLE ASCENDS A HILL, MAKES A TURN, OR TRAVELS OVER A ROUGH ROAD SURFACE. AN UNRESTRAINED OCCUPANT COULD FALL OUT OF THE VAN AND BE INJURED.
Remedy: DEALERS WILL INSPECT AND, IF REQUIRED, INSTALL A NEW POWER SLIDING DOOR UNLATCH ACTUATOR ASSEMBLY. OWNER NOTIFICATION BEGAN ON OCTOBER 22, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
Mar 8, 2001
VEHICLE DESCRIPTION: MINIVANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS. THE DOOR CLOSES BUT MAY NOT BE LATCHED. IF THIS HAPPENS, THE POWER SLIDING DOOR CAN OPEN WHILE THE VEHICLE IS IN MOTION, PARTICULARLY WHEN THE VEHICLE ASCENDS A HILL, MAKES A TURN, OR TRAVELS OVER A ROUGH ROAD SURFACE.
Consequence & remedy
Consequence: AN UNRESTRAINED OCCUPANT COULD FALL OUT OF THE VAN AND BE INJURED.
Remedy: DEALERS WILL INSTALL A NEW UN-LATCH ACTUATOR ASSEMBLY TO THE POWER SLIDING DOOR. THIS RECALL HAS BEEN CONTINUED UNDER SAFETY RECALL 01V-264. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
Apr 7, 1998
VEHICLE DESCRIPTION: PASSENGER MINI VANS EQUIPPED WITH TRACTION CONTROL SYSTEMS. THE WINDSHIELD WIPER LINKAGE ARM CAN CONTACT A BRAKE LINE WHICH IS CONNECTED TO THE TRACTION CONTROL SYSTEM MODULATOR VALVE. THIS CONTACT CAN CHAFE THE BRAKE LINE RESULTING IN A BRAKE FLUID LEAK.
Consequence & remedy
Consequence: BRAKE FLUID LEAKAGE CAN CAUSE REDUCED BRAKE EFFECTIVENESS AND INCREASED STOPPING DISTANCES.
Remedy: DEALERS WILL INSTALL A BRAKE LINE CLIP TO ENSURE PROPER CLEARANCE. ALSO THE BRAKE LINES WILL BE INSPECTED TO ANY DAMAGE CAUSED BY THIS CONDITION AND WILL REPLACE ANY DAMAGED LINES.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6EA03005 · Rear Axle Trailing Arm Failure
Opened Apr 23, 2003 · Closed Jan 12, 2004
Status: closed (inferred from source dates) · Suspension; Suspension:rear
ON NOVEMBER 18, 2002, ODI OPENED A PRELIMINARY EVALUATION (PE02-086) TO EVALUATE ALLEGATIONS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES (U-VAN) WHICH INCLUDED TWO REPORTING CRASHES.ON APRIL 9, 2003, ODI UPGRADED PE02-086 TO AN ENGINEERING ANALYSIS (EA03-005) TO CONTINUE ITS EXAMINATION OF THE ISSUE. THE TRAILING ARM DESIGN IN THESE VEHICLES HAS BEEN USED IN THE U-VAN FROM MY 1997 THROUGH THE PRESENT.THE GM ANALYSIS CONCLUDED THAT THE SUBJECT TRAILING ARMS COULD CRACK OR BUCKLE IF THEY WERE DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR SUBJECTED TO CERTAIN SERVICE RELATED ABUSE CONDITIONS SUCH AS IMPROPER TOWING OR JACKING.ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 19 INCIDENTS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES.THERE HAVE BEEN NO NEW REPORTS TO ODI OR GM IN THE LAST 12 MONTHS AND ONLY ONE NEW COMPLAINT IN THE LAST 21 MONTHS. DUE TO THE LOW COMPLAINT RATE AND THE ABSENCE OF A CONTINUING TREND IN REPORTED FAILURES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (2)
Suspension
ON NOVEMBER 18, 2002, ODI OPENED A PRELIMINARY EVALUATION (PE02-086) TO EVALUATE ALLEGATIONS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES (U-VAN) WHICH INCLUDED TWO REPORTING CRASHES.ON APRIL 9, 2003, ODI UPGRADED PE02-086 TO AN ENGINEERING ANALYSIS (EA03-005) TO CONTINUE ITS EXAMINATION OF THE ISSUE. THE TRAILING ARM DESIGN IN THESE VEHICLES HAS BEEN USED IN THE U-VAN FROM MY 1997 THROUGH THE PRESENT.THE GM ANALYSIS CONCLUDED THAT THE SUBJECT TRAILING ARMS COULD CRACK OR BUCKLE IF THEY WERE DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR SUBJECTED TO CERTAIN SERVICE RELATED ABUSE CONDITIONS SUCH AS IMPROPER TOWING OR JACKING.ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 19 INCIDENTS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES.THERE HAVE BEEN NO NEW REPORTS TO ODI OR GM IN THE LAST 12 MONTHS AND ONLY ONE NEW COMPLAINT IN THE LAST 21 MONTHS. DUE TO THE LOW COMPLAINT RATE AND THE ABSENCE OF A CONTINUING TREND IN REPORTED FAILURES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:rear
ON NOVEMBER 18, 2002, ODI OPENED A PRELIMINARY EVALUATION (PE02-086) TO EVALUATE ALLEGATIONS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES (U-VAN) WHICH INCLUDED TWO REPORTING CRASHES.ON APRIL 9, 2003, ODI UPGRADED PE02-086 TO AN ENGINEERING ANALYSIS (EA03-005) TO CONTINUE ITS EXAMINATION OF THE ISSUE. THE TRAILING ARM DESIGN IN THESE VEHICLES HAS BEEN USED IN THE U-VAN FROM MY 1997 THROUGH THE PRESENT.THE GM ANALYSIS CONCLUDED THAT THE SUBJECT TRAILING ARMS COULD CRACK OR BUCKLE IF THEY WERE DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR SUBJECTED TO CERTAIN SERVICE RELATED ABUSE CONDITIONS SUCH AS IMPROPER TOWING OR JACKING.ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 19 INCIDENTS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES.THERE HAVE BEEN NO NEW REPORTS TO ODI OR GM IN THE LAST 12 MONTHS AND ONLY ONE NEW COMPLAINT IN THE LAST 21 MONTHS. DUE TO THE LOW COMPLAINT RATE AND THE ABSENCE OF A CONTINUING TREND IN REPORTED FAILURES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
EA02032 · Safety Belt Assembly Failure
Opened Nov 18, 2002 · Closed Nov 21, 2003
Status: closed (inferred from source dates) · Seat Belts
ODI IDENTIFIED 59 REPORTS WITH THE ALLEGED DEFECT.ODI WAS ABLE TO CONTACT 44 OF THE 59 CONSUMERS IN ORDER TO DETERMINE THE SPECIFIC CAUSE OF THE LATCH PROBLEMS.OF THE 44 OWNERS CONTACTED, ODI DETERMINED THAT FOUR FAILURES WERE DUE TO AN OUT-OF-TOLERANCE LATCH PLATE, AND THAT 23 FAILURES WERE DUE TO A DISPLACED BUCKLE HOUSING COVER.THE REMAINING 17 FAILURES HAD INDETERMINABLE CAUSES.OF THE 59 REPORTS, THERE WERE THREE ALLEGED MINOR INJURIES.NO LEGAL CLAIMS OR LAWSUITS HAVE BEEN FILED WITH REGARD TO THIS ALLEGED DEFECT.BASED ON THE LIMITED NUMBER OF REPORTS, AND A DECLINING REPORT TREND, THIS INVESTIGATION IS CLOSED.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEARED TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE ADDITIONAL SUMMARY REPORT.
EA02003 · Power Rack And Pinion Steering Failure
Opened Apr 4, 2002 · Closed Dec 10, 2002
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
THE LOWER PINION BEARING IN THE RACK AND PINION STEERING ASSEMBLY MAY FAIL.GM WILL RECALL 1997-98 GRAND PRIX BUILT BETWEEN 1-MAR-96 AND 31-OCT-97; AND 1996-98 U-VANS/J-CARS BUILT BETWEEN 1-JAN-96 AND 31-OCT-97.SEE ATTACHED SUMMARY.
Additional source detail variants (2)
Steering
THE LOWER PINION BEARING IN THE RACK AND PINION STEERING ASSEMBLY MAY FAIL.GM WILL RECALL 1997-98 GRAND PRIX BUILT BETWEEN 1-MAR-96 AND 31-OCT-97; AND 1996-98 U-VANS/J-CARS BUILT BETWEEN 1-JAN-96 AND 31-OCT-97.SEE ATTACHED SUMMARY.
Steering:rack And Pinion
THE LOWER PINION BEARING IN THE RACK AND PINION STEERING ASSEMBLY MAY FAIL.GM WILL RECALL 1997-98 GRAND PRIX BUILT BETWEEN 1-MAR-96 AND 31-OCT-97; AND 1996-98 U-VANS/J-CARS BUILT BETWEEN 1-JAN-96 AND 31-OCT-97.SEE ATTACHED SUMMARY.
PE02017 · Shoulder Harness Clip
Opened Feb 11, 2002 · Closed Aug 2, 2002
Status: closed (inferred from source dates) · Seat Belts
No summary supplied.
PE01038 · Steering Rack And Pinion
Opened Nov 14, 2001 · Closed Apr 4, 2002
Status: closed (inferred from source dates) · Steering
ODI HAS RECEIVED 200 COMPLAINTS FROMT CONSUMERS AND 1,238 FROM GM ALLEGING FAILURE OR LOCKUP OF THE STEERING RACK AND PINION UNIT (R&P).THIS ALLEGED CONDITION CAN RESULT IN THE LOSS OF STEERING CONTROL OF THE VEHICLE AND A CRASH CAN RESULT.GM HAS REPORTED SIX CRASHES IN WHICH EIGHT PEOPLE HAVE SUSTAINED INJURIES RANGING FROM BRUISES, AIRBAG BURN, SEAT BELT ABRASION, FACIAL INJURY, NECK AND BACK PAIN.ALL CRASHES WERE SINGLE VEHICLE CRASHES.GM STATES THAT ONE POSSIBLE FAILURE MODE IS FAILURE OF THE LOWER PINION BEARING IN THE R&P.AN ENGINEERING ANALYSIS HAS BEEN OPENED TO DETERMINE IF A SAFETY DEFECT TREND EXISTS.
SQ00014 · Unexpected Opening Of Sliding Door
Opened Jul 25, 2000 · Closed Oct 22, 2001
Status: closed (inferred from source dates) · Structure
There is no summary currently available
Illustration