SkipThatYearREAL DATA. SMARTER CAR DECISIONS.
← New search

1994 Pontiac Sunbird

Owner reports · Recalls · Investigations

Limited comparison data

There is not enough comparable history to draw a useful model-year comparison.

About this comparison →
42Owner complaints

Model-year median: 4

1Recall campaigns

View recall details →

1Investigations

View investigation details →

How this year compares

Owner complaints by model year

Other model years Selected year
27
199130
199237
199342
19941
19954
19964
1997
Compare all Sunbird years →

Counts vary with age, sales and reporting. They are not failure rates.

What owners reported most

Service Brakes, Hydraulic
13Seats
5Engine And Engine Cooling
4Power Train
4Suspension
3
All reported categories
Tires
3Equipment
2Fuel System, Gasoline
2Seat Belts
2Structure
2Electrical System
1Exterior Lighting
1Service Brakes, Air
1Steering
1Vehicle Speed Control
1Visibility
1

Tap a category to read its complaints. One report may name several components.

When problems were reported

Mileage at the reported incident

Limited mileage data: 3 of 42 reports include usable mileage. There isn’t enough coverage to show a useful chart.

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Service Brakes, Hydraulic. Review the 13 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Seats. Review the 5 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine And Engine Cooling. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

6 crash reports0 fire reports6 injury reports

Structure complaints

2 reports
Clear category filter
109,000 miles · Aug 9, 2006
Structure

JUST DRIVING DOWN THE HIGHWAY WHEN A GRINDING NOISE STARTED COMING FROM THE REAR OF THE CAR(94 PONTIAC SUNBIRD)IMMEDIATELY PULLED TO THE SIDE OF THE ROAD,REAR OF CAR WAS SWERVING DANGEROUSLY,LOOKED UNDER THE CAR IN THE REAR, AND THERE WAS A GAPING HOLE ON THE LEFT SIDE WHEEL WELL WHERE THE SHOCK ABSORBER ATTACHES TO THE BODY,OPE…

Read full complaint

JUST DRIVING DOWN THE HIGHWAY WHEN A GRINDING NOISE STARTED COMING FROM THE REAR OF THE CAR(94 PONTIAC SUNBIRD)IMMEDIATELY PULLED TO THE SIDE OF THE ROAD,REAR OF CAR WAS SWERVING DANGEROUSLY,LOOKED UNDER THE CAR IN THE REAR, AND THERE WAS A GAPING HOLE ON THE LEFT SIDE WHEEL WELL WHERE THE SHOCK ABSORBER ATTACHES TO THE BODY,OPENED THE TRUNK AND THE LEFT REAR SHOCK HAD BROKEN THROUGH THE LEFT REAR WHEEL HOUSE, I PROCEEDED TO LOOK AT THE RIGHT SIDE AND THAT SIDE IS ABOUT READY TO BREAK THROUGH TOO, MAKING FOR A MOST DANGEROUS SITUATION, A BODY SHOP HAS STATED THAT IF THE OTHER HAD BROKE AT THE SAME TIME THE WHOLE REAR WOULD HAVE COME OUT, PROBABLY CAUSING A MAJOR CRASH, WITH TOTAL LOSS OF CONTROL OF THE VEHICLE. NOW THIS CAR IS NOT A RUST BUCKET BY ANY MEANS AND HAS ONLY 109,00 MILES ON THE ODOMETER. *JB

NHTSA ODI #10165084

Mileage unknown · Oct 15, 1999
Structure

DRUVER'S SIDE DOOR OUTSIDE PANEL DEATACHES FROM FRAME AND JAMS DRIVER'S DOOR ,WHICH WILL NOT ALLOW DRIVER TO OPEN DOOR FROM THE INSIDE. DEALER HAS REGLUED IT TWICE, BUT DEFECT KEEPS OCCURRING. *AK

NHTSA ODI #850859

Official recalls

1

94V115000 · Steering:linkages:knuckle:spindle:arm

Jun 24, 1994

THESE VEHICLES WERE BUILT WITH OVERTORQUED DRIVE AXLE SPINDLE NUTS. THIS CONDITION CAN CAUSE EXCESSIVE LOADS ON THE SPINDLE NUT AND DRIVE AXLE RESULTING IN FAILURE OF THE DRIVE AXLE OR THE SPINDLE NUT. FAILURE OF EITHER OF THESE COMPONENTS CAN RESULT IN SEPARATION OF THE STEERING KNUCKLE TIRE-WHEEL ASSEMBLY FROM THE DRIVE AXLE.

Consequence & remedy

Consequence: THIS CAN RESULT IN LOSS OF VEHICLE CONTROL AND A VEHICLE ACCIDENT.

Remedy: DEALERS WILL REPLACE THE LEFT-HAND AND RIGHT-HAND DRIVE AXLES, BEARING-HUB ASSEMBLIES, SPINDLE NUTS, AND WASHERS ON ALL INVOLVED VEHICLES. CORRECTIVE ACTION: DEALERS WILL REPLACE LEFT-HAND AND RIGHT-HAND DRIVE AXLES, BEARING-HUB ASSEMBLIES, SPINDLE NUTS, AND WASHERS ON ALL INVOLVED VEHICLES.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

1

PE94042 · Horn Button Falling Off

Opened May 23, 1994 · Closed Sep 29, 1994

Status: closed (inferred from source dates) · Exterior Lighting

There is no summary currently available