NHTSA owner reports · September 18, 2026 snapshot.
Seats complaints
18 reportsClear category filterMileage unknown · Sep 4, 2023
Air BagsSeats
New in 2007 Pontiac Solstice. In May of 2018 the recall 17036 was completed at 28,000 after waiting several months for the solution and then several months for the part to arrive. PPS passenger seat weighted sensor module failed again August 2023 at 36,000 miles. Repair only lasted 8,000 miles. I was told this module controls t…
Read full complaint
New in 2007 Pontiac Solstice. In May of 2018 the recall 17036 was completed at 28,000 after waiting several months for the solution and then several months for the part to arrive. PPS passenger seat weighted sensor module failed again August 2023 at 36,000 miles. Repair only lasted 8,000 miles. I was told this module controls the passenger seat air bag. I was also told that if module fails the passenger seat air bag will not deploy putting the passenger in an unsafe position. The passenger present light will be off when seat is occupied. The DIC (information display) will only read service air bag until the fault code is corrected. I use this to mainly to monitor coolant temperature of the engine although it has other functions. There will also be a red warning light on in the middle of the dash cluster. Visiting the forums there are many on their third and fourth repair. The recall should be reopened. One quote I received was for over $ 1,200. I do not feel I should have to pay out of pocket for a safety issue. In order to protect my passenger that is why I paid to have the recalled part replaced again. Your passenger is also your lifeline. Yes, I know it is out of warranty on this Safety incident. Many say the manufacturer should cover the safety issues. I feel dealership should cover this expensive safety issue at the directive of manufacturer.
NHTSA ODI #11542501
Mileage unknown · Aug 23, 2022
Air BagsSeats
The airbag sensor in the passenger seat has been recalled before, their only fix was to wrap it in tape, which does not solve the issue, this is a continuing problem for owners of kappa platform cars (Pontiac Solstice, Saturn Sky, etc.) for years and gm continues to ignore it, it is absolutely a safety issue due to the exorbitan…
Read full complaint
The airbag sensor in the passenger seat has been recalled before, their only fix was to wrap it in tape, which does not solve the issue, this is a continuing problem for owners of kappa platform cars (Pontiac Solstice, Saturn Sky, etc.) for years and gm continues to ignore it, it is absolutely a safety issue due to the exorbitant price of the fix many people will just continue to drive the vehicle with no functioning passenger airbag.
NHTSA ODI #11480679
65,715 miles · Aug 26, 2017
Air BagsElectrical SystemSeats
SERVICE AIR BAG DUE TO FAULTY PASSENGER SYSTEM. RECALL ISSUED 7 MONTHS AGO WITH NO RESOLUTION YET. AIR BAG WILL NOT DEPLOY FOR PASSENGER IN CRASH. RECALL 17V-061 ISSUED WITH NO RESOLUTION.
NHTSA ODI #11019889
55,000 miles · Jul 1, 2017
Air BagsSeats
THE PASSENGER SIDE AIRBAG IS NOT FUNCTIONAL AS EVIDENCED BY A WARNING LIGHT. IT IS UNDERSTOOD THAT THIS IS A KNOWN ISSUE. THE VALUE OF THE VEHICLE HAS BEEN IMPACTED. UNABLE TO SELL CAR DUE TO CONCERN BY BUYERS.
NHTSA ODI #11002614
110,000 miles · Nov 22, 2016
Air BagsElectrical SystemSeats
PASSENGER AIRBAG SENSOR BROKEN/DEFECTIVE. I STARTED THE CAR ONE MORNING AND THE "SERVICE AIR BAG" CAME ON. I TOOK IT TO A MECHANIC, WHO SAID THE SEAT SENSOR IN THE PASSENGER SEAT IS BROKEN. HE TOLD ME IT WAS A COMMON PROBLEM FOR THIS MODEL, AND ADVISED ME TO FILE THIS COMPLAINT.
NHTSA ODI #10927538
38,000 miles · Aug 9, 2016
Air BagsSeats
07 - GXP CURRENTLY 46K MILES. I TURN MY CAR ON ONE DAY AFTER CLEANING IT AT HOME AND I AM GREETED WITH A MESSAGE ON MY DISPLAY SAYING SERVICE AIR BAG AND FOUR RAPID AUDIBLE CHIMES. THAT PASSENGER SEAT NEVER HAD ANYONE MORE THAN THE WEIGHT OF AN AVERAGE HUMAN ON IT. THIS IS A SAFETY CONCERN FOR ANY PASSENGER IN MY VEHICLE YET I…
Read full complaint
07 - GXP CURRENTLY 46K MILES. I TURN MY CAR ON ONE DAY AFTER CLEANING IT AT HOME AND I AM GREETED WITH A MESSAGE ON MY DISPLAY SAYING SERVICE AIR BAG AND FOUR RAPID AUDIBLE CHIMES. THAT PASSENGER SEAT NEVER HAD ANYONE MORE THAN THE WEIGHT OF AN AVERAGE HUMAN ON IT. THIS IS A SAFETY CONCERN FOR ANY PASSENGER IN MY VEHICLE YET I AM FORCED TO DEAL WITH IT UNLESS I FORK OVER CLOSE TO $1000 AT THE DEALER. OTHER VEHICLE MAKES HAVE BEEN REWARDED A RECALL FOR SIMILAR ISSUES, BUT NOT FOR PONTIAC/SATURN!!! COME ON! IT'S NOT OUR FAULT THEY PHASED OUT. I AM AFRAID TO HAVE A PASSENGER IN MY CAR IN FEAR OF THEIR SAFETY. I USED TO LOVE HAVING A PASSENGER WITH ME WITH THE TOP DOWN ENJOYING LIFE AND THE FUN OF THIS CAR - AS IT WAS BUILT FOR. FIX THIS MESS PLEASE....FOR ALL OF US SOLSTICE/SKY OWNERS AND FUTURE OWNERS. THANK YOU! *TR
NHTSA ODI #10894422
37,000 miles · Jun 3, 2016
Electrical SystemSeats
TL* THE CONTACT OWNS A 2007 PONTIAC SOLSTICE. THE CONTACT STATED THAT THE PASSENGER SEAT SENSOR ACTIVATED WHEN THE SEAT WAS UNOCCUPIED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE PASSENGER SEAT NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BY AN INDEPENDENT MECHANIC, BUT THE FAILURE PERSISTED. THE VEHICL…
Read full complaint
TL* THE CONTACT OWNS A 2007 PONTIAC SOLSTICE. THE CONTACT STATED THAT THE PASSENGER SEAT SENSOR ACTIVATED WHEN THE SEAT WAS UNOCCUPIED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE PASSENGER SEAT NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BY AN INDEPENDENT MECHANIC, BUT THE FAILURE PERSISTED. THE VEHICLE WAS TAKEN BACK TO AN INDEPENDENT MECHANIC WHERE THE DIAGNOSIS WAS THE SAME. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 37,000.
NHTSA ODI #10872413
65,000 miles · Apr 6, 2016
Air BagsSeats
MY PASSENGER AIRBAG SENSOR SYSTEM STOPPED WORKING WITHOUT ANY CAUSE RESULTING IN A "SERVICE AIRBAG" WARNING ON THE DIC IN THE DASH. SEARCHING FORUMS FOR ALL VARIETIES OF THE GM KAPPA PLATFORM (SATURN SKY, OPEL GT, AND PONTIAC SOLSTICE) IT APPEARS THIS FAILURE IS HAPPENING TO EVERY SINGLE VEHICLE MADE WITH THIS SYSTEM AND IS NOT…
Read full complaint
MY PASSENGER AIRBAG SENSOR SYSTEM STOPPED WORKING WITHOUT ANY CAUSE RESULTING IN A "SERVICE AIRBAG" WARNING ON THE DIC IN THE DASH. SEARCHING FORUMS FOR ALL VARIETIES OF THE GM KAPPA PLATFORM (SATURN SKY, OPEL GT, AND PONTIAC SOLSTICE) IT APPEARS THIS FAILURE IS HAPPENING TO EVERY SINGLE VEHICLE MADE WITH THIS SYSTEM AND IS NOT CAUSED BY USUAL WEAR, OR ANY SORT OF MISTREATMENT OF THE DEVICE OR THE CAR - IT IS A CLEAR MANUFACTURING DEFECT. GM HOLDS YOUR CAR HOSTAGE FOR $1000 TO FIX THIS PROBLEM WHEN THE PART CAN BE OBTAINED FROM EUROPE FOR $99 - DISGUSTING. IN MY CASE, THE CAR SAT IN THE GARAGE OVER THE WINTER, AND UPON GETTING IN THE CAR THIS SPRING TO START IT, THE WARNING LIGHT CAME ON, THE LAST TIME THE CAR WAS DRIVEN THE LIGHT WAS NOT ON, AND NO-ONE HAS TOUCHED THE PASSENGER SEAT SINCE, SO THE PROBLEM WAS NOT CAUSED BY ABUSE OR WEAR IT IS SIMPLY A DEFECTIVE PART THAT FAILS FOR NO REASON AFTER SOME PERIOD OF TIME.
NHTSA ODI #10853750
15,000 miles · Jan 25, 2016
Air BagsSeats
TL* THE CONTACT OWNS A 2007 PONTIAC SOLSTICE. WHILE IN PARK, THE AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE MODULAR IN THE FRONT PASSENGER SEAT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 15,00…
Read full complaint
TL* THE CONTACT OWNS A 2007 PONTIAC SOLSTICE. WHILE IN PARK, THE AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE MODULAR IN THE FRONT PASSENGER SEAT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 15,000. THE VIN WAS UNAVAILABLE. UPDATED 04/07/16*LJ *CN
NHTSA ODI #10821966
52,000 miles · Feb 13, 2015
Air BagsSeats
THE OCCUPANT MODULE SENSOR (GM PART #19124219) LOCATED IN THE PASSENGER SEAT FAILED AFTER ONLY 52,000 MILES. THIS MODULE, WHEN FAULTY, CUTS OFF THE PASSENGER AIRBAG RESTRAINT SYSTEM.THIS IS A SAFETY ISSUE. IN THE LIFETIME OF OWNERSHIP I ONLY HAD A PASSENGER IN THE SEAT APPROX 20% OF THE TIME SO WEAR IS NOT THE ISSUE.ON FURTH…
Read full complaint
THE OCCUPANT MODULE SENSOR (GM PART #19124219) LOCATED IN THE PASSENGER SEAT FAILED AFTER ONLY 52,000 MILES. THIS MODULE, WHEN FAULTY, CUTS OFF THE PASSENGER AIRBAG RESTRAINT SYSTEM.THIS IS A SAFETY ISSUE. IN THE LIFETIME OF OWNERSHIP I ONLY HAD A PASSENGER IN THE SEAT APPROX 20% OF THE TIME SO WEAR IS NOT THE ISSUE.ON FURTHER CHECKING OF THE 40+ SOLSTICE OWNERS I KNOW, MOST HAVE THE PROBLEM.THE REPLACEMENT COST FOR PARTS LABOR AND RECALIBRATION IS BETWEEN $500 TO $800. MOST OWNERS IGNORE IT AND THE FACT THAT HALF THE AIRBAGS WILL NOT DEPLOY IN A CRASH BECAUSE OF COST. GM IS AWARE OF THE PROBLEM PART BUT APPARENTLY DOES NOT SEE IT AS A SAFETY ISSUE. A ONE TIME REPROGRAMMING TO A "ALWAYS ON" STATE WOULD BE A CHEAP ACCEPTABLE FIX. *TR
NHTSA ODI #10683133
Official recalls
4Jan 26, 2017
General Motors LLC (GM) is recalling certain 2006-2010 Pontiac Solstice and 2007-2010 Saturn Sky vehicles. The Passenger Air Bag Suppression System (PPS) sensor may become bent or damaged within the front passenger seat, possibly disabling the front passenger air bag.
Consequence & remedy
Consequence: In the event of a crash, if the front passenger air bag does not deploy as intended, the front passenger has an increased risk of injury.
Remedy: The remedy for this recall is still under development. A permanent remedy is currently under development. The recall began February 26, 2018. Owners may contact Pontiac customer service at 1-800-762-2737 or Saturn customer service at 1-800-553-6000. GM's number for this recall is 17036.
Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Dec 20, 2007
ON CERTAIN PASSENGER VEHICLES, THE REAR AXLE PINION SEAL DOES NOT MEET ALL OF THE SPECIFICATIONS AND MAY EXPERIENCE A FLUID LEAK.
Consequence & remedy
Consequence: A REAR DIFFERENTIAL FAILURE MAY CAUSE LOSS OF MOTIVE POWER AND POSSIBLY LOSS OF CONTROL INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE PINION SEAL FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 1, 2008. OWNERS MAY CONTACT CADILLAC AT 1-800-458-8006 OR HTTP://WWW.CADILLAC.COM; PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM; AND SATURN AT 1-800-972-8876 OR HTTP://WWW.SATURN.COM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3DP20002 · Hvac Blower Motor Connector
Opened Feb 7, 2020 · Closed Oct 27, 2022
Status: closed (inferred from source dates) · Electrical System:wiring:interior/under Dash
The Office of Defects Investigation (ODI) has completed its review of a Defect Petition received December 12, 2019 requesting an investigation into the possibility of passenger compartment fires attributed to overheating HVAC blower motor connectors in Model Years (MY) 2006-2010 Pontiac Solstice and Saturn Sky vehicles.An analysis of General Motors (GM) complaint data and information in NHTSA?s databases identified thirteen unique vehicle identification numbers (VINs) with reported incidents that could pertain to blower motor overheating, smoking, or melting in the 90,938 MY2006-2010 Saturn Sky and Pontiac Solstice vehicles produced. Two of the thirteen cited incidents reported smoke and thermal damage that may be attributed to the HVAC blower motor although neither incident was confirmed through vehicle inspection. One incident, a MY2008 Saturn Sky with substantial field exposure from a frontal collision, could not have the root cause identified. The other, a MY2007 Pontiac Solstice, did not inform the manufacturer nor take the vehicle to a dealer for evaluation.Most of the 13 incidents reported an overheated or discolored connector with attendant loss of HVAC blower fan function. GM reported 354 warranty claims with the subject components for the Sky and Solstice, none of which included a report of fire and only one report of smoke. Over a period of ten to fourteen years in service, there are two reports of smoke or thermal damage.While the subject Sky and Solstice vehicles and the recalled Hummer H3 and H3T vehicles do share common components, the Sky and Solstice vehicles have demonstrated very different behavior and their HVAC system has a lower power draw than the recalled Hummer H3 and H3T vehicles. The recalled H3 and H3T vehicles generate over triple the failure rate of the Sky and Solstice vehicles. GM suggested in its response to the ODI?s information request that this difference was due to the larger interior volume of a recalled Hummer vehicle imposing a heavier electrical load and duty cycle on its HVAC blower. The duty cycle is defined as how long it takes for the vehicle to cool down enough before the HVAC blower motor fan speed is lowered or turned off completely.Additionally, due to the size differential between the Sky and Solstice vehicles and the recalled Hummer H3 and H3T vehicles, the parts have a different power draw. The Sky and Solstice vehicles, due to their smaller size, draw less wattage, which reduces the likelihood of a thermal event. This condition in the Sky and Solstice vehicles typically leads to an inoperable HVAC blower motor as opposed to a thermal event.Despite the commonality of parts in the Sky and Solstice vehicles with those that were the basis of a safety recall, the subject vehicles have not demonstrated a safety defect trend that would likely lead to a safety recall or merit further investigation by the ODI. The subject vehicles have a low rate of reported thermal events over the ten to fourteen years they have been in service with the most recent occurring in 2017 with no confirmed fires. The HVAC blower motor was not confirmed to be the root cause for either thermal event cited above.After thoroughly assessing the material submitted by the petitioner, information already in NHTSA?s possession, information submitted by GM in response to an information request, and the potential risks to safety implicated by the petitioner?s allegation, NHTSA does not believe that the petition warrants a formal investigation at this time. Consequently, the petition is denied.The entire petition denial can be viewed in the October 14, 2022 Federal Register under DP20-002.(https://www.f
DP16001 · Passenger Sensing System Sensor Mat
Opened May 16, 2016 · Closed Apr 24, 2017
Status: closed (inferred from source dates) · Air Bags:sensor:occupant Classification
The Office of Defects Investigation (ODI) received a petition requesting the opening of an investigation into the air bag system on model year 2006-2010 Pontiac Solstice and 2007-2010 Saturn Sky, the subject vehicles.The petitioner raised the issue of failure of the Passenger Sensing System for the front passenger seating position.On January 26, 2017, General Motors filed a defect information report recalling the subject vehicles to address the issue raised by the petition.In view of the recall, ODI considers the petition moot and is closing the action.The closing of the petition does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by future circumstances.
PE07037 · Failure Of The Rear Differential
Opened Jul 17, 2007 · Closed Dec 27, 2007
Status: closed (inferred from source dates) · Power Train:driveline:differential Unit
ODI EVALUATED TWO DIFFERENT ALLEGED DEFECTS INVOLVING REAR DRIVETRAIN COMPONENTS DURING THIS PRELIMINARY EVALUATION.GM IS CONDUCTING A RECALL TO ADDRESS ONE OF THE DEFECT CONDITIONS AND ODI HAS OPENED AN ENGINEERING ANALYSIS TO CONTINUE ITS INVESTIGATION OF THE OTHER ALLEGED DEFECT. ON DECEMBER 19, 2007, GM SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING DEFECTIVE REAR AXLE PINION SEALS IN APPROXIMATELY 275,936 MODEL YEAR (MY) 2005-07 CADILLAC CTS, STS AND SRX VEHICLES AS WELL AS MY 2006-07 PONTIAC SOLSTICE AND MY 2007 SATURN SKY VEHICLES (RECALL 07V-589).ON STS AND SRX VEHICLES WITH ALL WHEEL DRIVE, THE FRONT AXLE PINION SEAL ALSO DOES NOT MEET ALL OF GM'S SPECIFICATIONS AND MAY EXPERIENCE A FLUID LEAK.GM INDICATED THAT THE SEAL SUPPLIER MADE AN UNAUTHORIZED CHANGE TO THE PINION SEAL MATERIAL.LEAKING PINION SEALS COULD RESULT IN LOSS OF REAR DIFFERENTIAL LUBRICATION WHICH COULD RESULT IN REAR WHEEL LOCK-UP AND LOSS OF VEHICLE CONTROL. ON DECEMBER 7, 2007, ODI OPENED AN ENGINEERING ANALYSIS (EA07-017) TO INVESTIGATE COMPLAINTS OF REAR DRIVETRAIN COMPONENT FAILURE (E.G., FRACTURED REAR DIFFERENTIAL CARRIER HOUSING OR REAR AXLE HALF SHAFTS) WHILE DRIVING IN APPROXIMATELY 7,600 MY 2004 THROUGH 2006 CADILLAC CTS-V VEHICLES.THIS CONDITION MAY RESULT IN A LOSS OF MOTIVE POWER AND VEHICLE DISABLEMENT AND IS NOT ADDRESSED BY RECALL 07V-589.ODI IDENTIFIED 35 COMPLAINTS (16 TO ODI AND 19 TO GM) AND 128 WARRANTY CLAIMS POTENTIALLY RELATED TO THIS CONDITION (SEE EA07-017 OPENING RESUME).THESE COMPLAINTS ARE NOT INCLUDED IN THE FAILURE REPORT SUMMARY OF THIS CLOSING RESUME. THE COMPLAINTS AND WARRANTY FIGURES GIVEN IN THIS RESUME ARE LIMITED TO THOSE THAT (A) ARE MOST LIKELY CAUSED BY A LEAKING REAR PINION SEAL; AND (B) RESULTED IN AN ALLEGATION OF A REAR DIFFERENTIAL FAILURE WHILE DRIVING.THE DATA DO NOT INCLUDE ALL REPORTS OF SEAL LEAKAGE.
Illustration