IllustrationPASSENGER AIR BAG HAS FAILED, THIS IS A SERIOUS SAFETY ISSUE AND OBVIOUSLY HAS MULTIPLE COMPLAINTS AGAINST GM. I NEVER SEEN AN AIRBAG SENSOR FAIL ESPECIALLY WITH SO FEW MILES. *TR
2007 Pontiac Solstice
Owner reports · Recalls · Investigations
More warning signs than most Solstice years
Owner complaints for the 2007 Pontiac Solstice are substantially higher than the model-year median of 97.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Solstice years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
580–25K
7025–50K
6250–75K
1675–100K
11100–150K
2150K+
219 reports with mileage · 70 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 225 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 27 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 24 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
12 crash reports1 fire reports7 injury reports
Air Bags complaints
225 reports2007 PONTIAC SOLSTICE WITH JUST OVER 20,000 MILES ON IT, THIS SHOULD NOT HAPPEN. I AM MEMBER OF PONTIAC FORUM, I KNOW OTHERS HAVE SAME PROBLEM AND YOU HAVE THEIR INFO. THIS IS A HUGE SAFETY CONCERN. PASSENGER AIR BAG ON LIGHT DOES NOT COME ON, STAYS OFF WITH PASSENGER. , SERVICE AIR BAG MESSAGE ON DIC.. *TR
THE PASSENGER SEAT AIR BAG OCCUPANT SENSOR HAS FAILED, DISABLING THE AIR BAG SYSTEM. THIS IS A COMMON PROBLEM TO THIS CAR, AND A SERIOUS SAFETY ISSUE FOR OURSELVES AND ANY PASSENGERS. WE REQUEST AN INVESTIGATION AND RECALL TO REPAIR THIS KNOWN SAFETY ISSUE. I BELIEVE REVIEWING THE GM RECORDS FOR THE NUMBER OF UNITS SOLD AS REP…
Read full complaint
THE PASSENGER SEAT AIR BAG OCCUPANT SENSOR HAS FAILED, DISABLING THE AIR BAG SYSTEM. THIS IS A COMMON PROBLEM TO THIS CAR, AND A SERIOUS SAFETY ISSUE FOR OURSELVES AND ANY PASSENGERS. WE REQUEST AN INVESTIGATION AND RECALL TO REPAIR THIS KNOWN SAFETY ISSUE. I BELIEVE REVIEWING THE GM RECORDS FOR THE NUMBER OF UNITS SOLD AS REPLACEMENTS WILL REINFORCE MY COMPLAINT. *TR
2007 PONTIAC SOLSTICE. CONSUMER WRITES IN REGARDS TO A DEFECTIVE MODULE OR SENSOR IN THE PASSENGER SEAT AND SIDE AIRBAGS. *SMD THE CONSUMER STATED THE AIR BAG MAY NOT DEPLOY IN THE EVEN OF A COLLISION. THE DEFECT WAS CONFIRMED WHEN DIAGNOSED BY A LOCAL GM DEALER. *JB
THE OCCUPANT MODULE SENSOR (GM PART #19124219) LOCATED IN THE PASSENGER SEAT FAILED AFTER ONLY 52,000 MILES. THIS MODULE, WHEN FAULTY, CUTS OFF THE PASSENGER AIRBAG RESTRAINT SYSTEM.THIS IS A SAFETY ISSUE. IN THE LIFETIME OF OWNERSHIP I ONLY HAD A PASSENGER IN THE SEAT APPROX 20% OF THE TIME SO WEAR IS NOT THE ISSUE.ON FURTH…
Read full complaint
THE OCCUPANT MODULE SENSOR (GM PART #19124219) LOCATED IN THE PASSENGER SEAT FAILED AFTER ONLY 52,000 MILES. THIS MODULE, WHEN FAULTY, CUTS OFF THE PASSENGER AIRBAG RESTRAINT SYSTEM.THIS IS A SAFETY ISSUE. IN THE LIFETIME OF OWNERSHIP I ONLY HAD A PASSENGER IN THE SEAT APPROX 20% OF THE TIME SO WEAR IS NOT THE ISSUE.ON FURTHER CHECKING OF THE 40+ SOLSTICE OWNERS I KNOW, MOST HAVE THE PROBLEM.THE REPLACEMENT COST FOR PARTS LABOR AND RECALIBRATION IS BETWEEN $500 TO $800. MOST OWNERS IGNORE IT AND THE FACT THAT HALF THE AIRBAGS WILL NOT DEPLOY IN A CRASH BECAUSE OF COST. GM IS AWARE OF THE PROBLEM PART BUT APPARENTLY DOES NOT SEE IT AS A SAFETY ISSUE. A ONE TIME REPROGRAMMING TO A "ALWAYS ON" STATE WOULD BE A CHEAP ACCEPTABLE FIX. *TR
THE PASSENGER (SERVICE) AIRBAG LIGHT HAS COME ON AND REMAINS ON AT ALL TIMES. THE LIGHT WHICH SAYS THAT THE PASSENGER AIRBAG HAS BEEN ARMED NO LONGER ILLUMINATES. FROM THE RESEARCH I HAVE DONE, IT IS A PROBLEM WITH THE AIRBAG SENSOR WHICH MUST BE REPLACED. THE PART IS VERY EXPENSIVE AND BREAKS EASILY. I AM WORRIED THAT NOT O…
Read full complaint
THE PASSENGER (SERVICE) AIRBAG LIGHT HAS COME ON AND REMAINS ON AT ALL TIMES. THE LIGHT WHICH SAYS THAT THE PASSENGER AIRBAG HAS BEEN ARMED NO LONGER ILLUMINATES. FROM THE RESEARCH I HAVE DONE, IT IS A PROBLEM WITH THE AIRBAG SENSOR WHICH MUST BE REPLACED. THE PART IS VERY EXPENSIVE AND BREAKS EASILY. I AM WORRIED THAT NOT ONLY IS THERE A CHANCE THAT THE PASSENGER AIRBAG MAY NOT DEPLOY DURING AN ACCIDENT BUT THAT IF I DO GET THE PART REPLACED, IT WILL SOON BREAK AGAIN. THIS IS A VERY COMMON PROBLEM AND I BELIEVE THIS IS A MAJOR SAFETY CONCERN THAT NEEDS TO BE ADDRESSED RIGHT AWAY! THERE HAVE BEEN TOO MANY COMPLAINTS ABOUT THIS PART, WHICH SYSTEMATICALLY GOES OUT ON EVERY CAR, FOR THIS ISSUE TO BE IGNORED! *TR
TL* THE CONTACT OWNS A 2007 PONTIAC SOLSTICE. THE CONTACT STATED THAT WHILE A PASSENGER WAS SEATED IN THE FRONT PASSENGER SEAT, THE PASSENGER SIDE AIR BAG SYSTEM WOULD NOT ACTIVATE. THE VEHICLE WAS TAKEN TO THE DEALER, WHO DIAGNOSED THAT THE PASSENGER PRESENCE SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT RECURRED. …
Read full complaint
TL* THE CONTACT OWNS A 2007 PONTIAC SOLSTICE. THE CONTACT STATED THAT WHILE A PASSENGER WAS SEATED IN THE FRONT PASSENGER SEAT, THE PASSENGER SIDE AIR BAG SYSTEM WOULD NOT ACTIVATE. THE VEHICLE WAS TAKEN TO THE DEALER, WHO DIAGNOSED THAT THE PASSENGER PRESENCE SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT RECURRED. THE VEHICLE WAS TAKEN BACK TO THE DEALER, WHO DIAGNOSED THAT THE REPLACEMENT PASSENGER PRESENCE SENSOR NEEDED TO BE REPLACED AGAIN. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 63,000. UPDATED 03/02/15*LJ UPDATED 6/15/2015 *JS
AIR BAG LIGHT CAME ON WHILE DRIVING THE VEHICLE. I TOOK THE VEHICLE TO HAVE THE VEHICLE SCANNED TO SEE WHAT THE PROBLEM WAS. IT WAS DETERMINED THAT THE PPS MODULE NEEDS TO BE REPLACED. I DECIDED NOT TO DO THE REPAIR BECAUSE IT WAS GOING TO BE OVER $800. I AM QUITE UPSET BECAUSE THE VEHICLE AT THE TIME ONLY HAD 38,000 MILES ON I…
Read full complaint
AIR BAG LIGHT CAME ON WHILE DRIVING THE VEHICLE. I TOOK THE VEHICLE TO HAVE THE VEHICLE SCANNED TO SEE WHAT THE PROBLEM WAS. IT WAS DETERMINED THAT THE PPS MODULE NEEDS TO BE REPLACED. I DECIDED NOT TO DO THE REPAIR BECAUSE IT WAS GOING TO BE OVER $800. I AM QUITE UPSET BECAUSE THE VEHICLE AT THE TIME ONLY HAD 38,000 MILES ON IT, BUT WAS OUT OF WARRANTY ( BEING OVER 36 MONTHS). WHY WOULD A VEHICLE WITH ONLY 38,000 MILES ON IT HAVE A FAULTY AIRBAG MODULE? *TR
ADD MY COMPLAINT TO THE SEAT BELT LIGHT LIST. GM HIDING IT'S HEAD IN THE SAND AGAIN. IN AUGUST OF 2014, MY DAUGHTER HAD HER IGNITION SWITCH REPLACED PER THE RECALL NOTICE ON HER 2007 PONTIAC SOLSTICE. A FEW WEEKS LATER, THE RED AIR BAG LIGHT WENT ON ALONG WITH MALFUNCTIONING OF THE PASSENGER AIR BAG STATUS INDICATOR LIGHT.…
Read full complaint
ADD MY COMPLAINT TO THE SEAT BELT LIGHT LIST. GM HIDING IT'S HEAD IN THE SAND AGAIN. IN AUGUST OF 2014, MY DAUGHTER HAD HER IGNITION SWITCH REPLACED PER THE RECALL NOTICE ON HER 2007 PONTIAC SOLSTICE. A FEW WEEKS LATER, THE RED AIR BAG LIGHT WENT ON ALONG WITH MALFUNCTIONING OF THE PASSENGER AIR BAG STATUS INDICATOR LIGHT. MILEAGE 61,000. THE YELLOW WARNING LIGHT WILL NOT COME ON WHEN A PERSON SITS IN THE PASSENGER SEAT! THE RED AIRBAG READINESS LIGHT ON THE INSTRUMENT PANEL CLUSTER IS ON ALL THE TIME ALONG WITH THE SERVICE AIR BAG DISPLAY ON THE DIC. GM FIXED ONE AIR BAG ISSUE AND NOW ANOTHER ONE HAS SURFACED. IN REVIEWING THE MANY ARTICLES ON THE WEB, THERE HAVE BEEN NUMEROUS COMPLAINTS TO NHTSA ABOUT ON THE AIRBAG HAZARD ON ALL 06 THRU 10 PONTIAC SOLSTICES, SATURN SKY AND VARIOUS OTHER GM VEHICLES. THE PROBLEMS WITH THE PASSENGER SEAT RENDERS IT UNSAFE AND MAY RESULT IN SERIOUS INJURY OR DEATH IN A CRASH. THIS PROBLEM WAS REPORTED TO GM, THEY DIAGNOSED SAME, SAID IT WAS NOT RELATED TO THE IGNITION SWITCH RECALL AND REPORTED CODE 1063 - PASSENGER PRESSURE SENSOR DEFECTIVE. REPLACEMENT COST APPROXIMATELY $900.00. THIS DEFECT WILL NOT ALLOW THE AIRBAG TO OPERATE IF INVOLVED IN AN ACCIDENT. THE COST TO REPLACE THIS SENSOR IS PROHIBITIVE AND SHOULD NOT FAIL. THE SENSOR WAS MANUFACTURED IN LUXEMBOURG, GERMANY (MANUFACTURE UNKNOWN #BR53008361171M8H). THIS IS AN INSPECTION ISSUE IN SOME STATES AND WHERE THERE IS NO INSPECTION, MANY PEOPLE ARE JUST DRIVING AROUND WITH THE LIGHT ON NOT KNOWING THEIR BAGS ARE INOPERATIVE. THE DEFECTIVE SEAT MODULE RENDERS THE PASSENGER SEAT UNSAFE AS THE AIRBAG WILL NOT DEPLOY WHICH COULD RESULT IN SERIOUS INJURY OR DEATH IN A CRASH. PLEASE REVIEW THE COMPLAINTS DECLARE IT RECALL. THANK YOU *TR
MY AIRBAG LIGHTS SUDDENLY CAME ON AND THE DEALER SHIP SAYS MY AIRBAG MODULE HAS GONE OUT. WHY WOULD A VEHICLE WITH ONLY 62133 MILES AIRBAG MODULE GO OUT, ITS BEEN ONE THING AFTER ANOTHER, CUP HOLDER BROKE FIRST MONTH I HAD CAR, THEN REAR AXLE RECALL,,THEN IGNITION SWITCH AND GOD KNOWS WHAT ELSE.I HAD TO REPLACE BOTH DOOR HANDLES…
Read full complaint
MY AIRBAG LIGHTS SUDDENLY CAME ON AND THE DEALER SHIP SAYS MY AIRBAG MODULE HAS GONE OUT. WHY WOULD A VEHICLE WITH ONLY 62133 MILES AIRBAG MODULE GO OUT, ITS BEEN ONE THING AFTER ANOTHER, CUP HOLDER BROKE FIRST MONTH I HAD CAR, THEN REAR AXLE RECALL,,THEN IGNITION SWITCH AND GOD KNOWS WHAT ELSE.I HAD TO REPLACE BOTH DOOR HANDLES AND THE PASSENGER DOOR WAS HARDLY EVER USED BUT THEY BROKE OFF FROM JUST REGULAR USE. NOW I AM TOLD I NEED AN AIR BAG MODULE, SHOULDN'T THAT HAVE LASTED FOR THE LIFE OF THE CAR. THAT'S A SAFETY ISSUE BECAUSE MY AIRBAGS AREN'T WORKING. I AM GONNA HAVE TO FORK OVER 557 DOLLARS NOT TO MENTION THE 92 I JUST HAD TO PAY JUST TO FIND OUT WHY MY AIRBAG INDICATOR LIGHT IS ON. I PAID OVER THIRTY THOUSAND FOR THIS CAR AND IT SHOULD STILL HAVE WORKING AIR BAGS.THE COMPANY SHOULD HAVE TO FIX IT, THEY TOOK THAT BAIL OUT FROM ME THE TAX PAYER. *TR
Official recalls
417V061000 · Air Bags:sensor:occupant Classification
Jan 26, 2017
General Motors LLC (GM) is recalling certain 2006-2010 Pontiac Solstice and 2007-2010 Saturn Sky vehicles. The Passenger Air Bag Suppression System (PPS) sensor may become bent or damaged within the front passenger seat, possibly disabling the front passenger air bag.
Consequence & remedy
Consequence: In the event of a crash, if the front passenger air bag does not deploy as intended, the front passenger has an increased risk of injury.
Remedy: The remedy for this recall is still under development. A permanent remedy is currently under development. The recall began February 26, 2018. Owners may contact Pontiac customer service at 1-800-762-2737 or Saturn customer service at 1-800-553-6000. GM's number for this recall is 17036.
14V171000 · Electrical System:ignition
Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
14V047000 · Air Bags; Electrical System:ignition:switch
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
07V589000 · Power Train:axle Assembly:axle Shaft:seal
Dec 20, 2007
ON CERTAIN PASSENGER VEHICLES, THE REAR AXLE PINION SEAL DOES NOT MEET ALL OF THE SPECIFICATIONS AND MAY EXPERIENCE A FLUID LEAK.
Consequence & remedy
Consequence: A REAR DIFFERENTIAL FAILURE MAY CAUSE LOSS OF MOTIVE POWER AND POSSIBLY LOSS OF CONTROL INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE PINION SEAL FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 1, 2008. OWNERS MAY CONTACT CADILLAC AT 1-800-458-8006 OR HTTP://WWW.CADILLAC.COM; PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM; AND SATURN AT 1-800-972-8876 OR HTTP://WWW.SATURN.COM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3DP20002 · Hvac Blower Motor Connector
Opened Feb 7, 2020 · Closed Oct 27, 2022
Status: closed (inferred from source dates) · Electrical System:wiring:interior/under Dash
The Office of Defects Investigation (ODI) has completed its review of a Defect Petition received December 12, 2019 requesting an investigation into the possibility of passenger compartment fires attributed to overheating HVAC blower motor connectors in Model Years (MY) 2006-2010 Pontiac Solstice and Saturn Sky vehicles.An analysis of General Motors (GM) complaint data and information in NHTSA?s databases identified thirteen unique vehicle identification numbers (VINs) with reported incidents that could pertain to blower motor overheating, smoking, or melting in the 90,938 MY2006-2010 Saturn Sky and Pontiac Solstice vehicles produced. Two of the thirteen cited incidents reported smoke and thermal damage that may be attributed to the HVAC blower motor although neither incident was confirmed through vehicle inspection. One incident, a MY2008 Saturn Sky with substantial field exposure from a frontal collision, could not have the root cause identified. The other, a MY2007 Pontiac Solstice, did not inform the manufacturer nor take the vehicle to a dealer for evaluation.Most of the 13 incidents reported an overheated or discolored connector with attendant loss of HVAC blower fan function. GM reported 354 warranty claims with the subject components for the Sky and Solstice, none of which included a report of fire and only one report of smoke. Over a period of ten to fourteen years in service, there are two reports of smoke or thermal damage.While the subject Sky and Solstice vehicles and the recalled Hummer H3 and H3T vehicles do share common components, the Sky and Solstice vehicles have demonstrated very different behavior and their HVAC system has a lower power draw than the recalled Hummer H3 and H3T vehicles. The recalled H3 and H3T vehicles generate over triple the failure rate of the Sky and Solstice vehicles. GM suggested in its response to the ODI?s information request that this difference was due to the larger interior volume of a recalled Hummer vehicle imposing a heavier electrical load and duty cycle on its HVAC blower. The duty cycle is defined as how long it takes for the vehicle to cool down enough before the HVAC blower motor fan speed is lowered or turned off completely.Additionally, due to the size differential between the Sky and Solstice vehicles and the recalled Hummer H3 and H3T vehicles, the parts have a different power draw. The Sky and Solstice vehicles, due to their smaller size, draw less wattage, which reduces the likelihood of a thermal event. This condition in the Sky and Solstice vehicles typically leads to an inoperable HVAC blower motor as opposed to a thermal event.Despite the commonality of parts in the Sky and Solstice vehicles with those that were the basis of a safety recall, the subject vehicles have not demonstrated a safety defect trend that would likely lead to a safety recall or merit further investigation by the ODI. The subject vehicles have a low rate of reported thermal events over the ten to fourteen years they have been in service with the most recent occurring in 2017 with no confirmed fires. The HVAC blower motor was not confirmed to be the root cause for either thermal event cited above.After thoroughly assessing the material submitted by the petitioner, information already in NHTSA?s possession, information submitted by GM in response to an information request, and the potential risks to safety implicated by the petitioner?s allegation, NHTSA does not believe that the petition warrants a formal investigation at this time. Consequently, the petition is denied.The entire petition denial can be viewed in the October 14, 2022 Federal Register under DP20-002.(https://www.f
DP16001 · Passenger Sensing System Sensor Mat
Opened May 16, 2016 · Closed Apr 24, 2017
Status: closed (inferred from source dates) · Air Bags:sensor:occupant Classification
The Office of Defects Investigation (ODI) received a petition requesting the opening of an investigation into the air bag system on model year 2006-2010 Pontiac Solstice and 2007-2010 Saturn Sky, the subject vehicles.The petitioner raised the issue of failure of the Passenger Sensing System for the front passenger seating position.On January 26, 2017, General Motors filed a defect information report recalling the subject vehicles to address the issue raised by the petition.In view of the recall, ODI considers the petition moot and is closing the action.The closing of the petition does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by future circumstances.
PE07037 · Failure Of The Rear Differential
Opened Jul 17, 2007 · Closed Dec 27, 2007
Status: closed (inferred from source dates) · Power Train:driveline:differential Unit
ODI EVALUATED TWO DIFFERENT ALLEGED DEFECTS INVOLVING REAR DRIVETRAIN COMPONENTS DURING THIS PRELIMINARY EVALUATION.GM IS CONDUCTING A RECALL TO ADDRESS ONE OF THE DEFECT CONDITIONS AND ODI HAS OPENED AN ENGINEERING ANALYSIS TO CONTINUE ITS INVESTIGATION OF THE OTHER ALLEGED DEFECT. ON DECEMBER 19, 2007, GM SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING DEFECTIVE REAR AXLE PINION SEALS IN APPROXIMATELY 275,936 MODEL YEAR (MY) 2005-07 CADILLAC CTS, STS AND SRX VEHICLES AS WELL AS MY 2006-07 PONTIAC SOLSTICE AND MY 2007 SATURN SKY VEHICLES (RECALL 07V-589).ON STS AND SRX VEHICLES WITH ALL WHEEL DRIVE, THE FRONT AXLE PINION SEAL ALSO DOES NOT MEET ALL OF GM'S SPECIFICATIONS AND MAY EXPERIENCE A FLUID LEAK.GM INDICATED THAT THE SEAL SUPPLIER MADE AN UNAUTHORIZED CHANGE TO THE PINION SEAL MATERIAL.LEAKING PINION SEALS COULD RESULT IN LOSS OF REAR DIFFERENTIAL LUBRICATION WHICH COULD RESULT IN REAR WHEEL LOCK-UP AND LOSS OF VEHICLE CONTROL. ON DECEMBER 7, 2007, ODI OPENED AN ENGINEERING ANALYSIS (EA07-017) TO INVESTIGATE COMPLAINTS OF REAR DRIVETRAIN COMPONENT FAILURE (E.G., FRACTURED REAR DIFFERENTIAL CARRIER HOUSING OR REAR AXLE HALF SHAFTS) WHILE DRIVING IN APPROXIMATELY 7,600 MY 2004 THROUGH 2006 CADILLAC CTS-V VEHICLES.THIS CONDITION MAY RESULT IN A LOSS OF MOTIVE POWER AND VEHICLE DISABLEMENT AND IS NOT ADDRESSED BY RECALL 07V-589.ODI IDENTIFIED 35 COMPLAINTS (16 TO ODI AND 19 TO GM) AND 128 WARRANTY CLAIMS POTENTIALLY RELATED TO THIS CONDITION (SEE EA07-017 OPENING RESUME).THESE COMPLAINTS ARE NOT INCLUDED IN THE FAILURE REPORT SUMMARY OF THIS CLOSING RESUME. THE COMPLAINTS AND WARRANTY FIGURES GIVEN IN THIS RESUME ARE LIMITED TO THOSE THAT (A) ARE MOST LIKELY CAUSED BY A LEAKING REAR PINION SEAL; AND (B) RESULTED IN AN ALLEGATION OF A REAR DIFFERENTIAL FAILURE WHILE DRIVING.THE DATA DO NOT INCLUDE ALL REPORTS OF SEAL LEAKAGE.