NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
69 reportsClear category filter44,000 miles · Jan 15, 2004
Engine And Engine CoolingPower Train
TRANSMISSION WENT OUT AT AROUND 44000 MILES. DEALER SAID THE "LIP SEAL" FAILED INSIDE TRANSMISSION, AFTER TAKING IT IN SEVERAL TIMES FOR DIAGNOSIS. WOULD NOT ASSIST WITH REPAIR COST. ENDED UP HAVING IT REPAIRED AT AAMCO. A/C IS CURRENTLY OUT ON THE LOW SETTING (#1). NOT YET REPAIRED. JUST REPAIRED THE COOLING SYSTEM. …
Read full complaint
TRANSMISSION WENT OUT AT AROUND 44000 MILES. DEALER SAID THE "LIP SEAL" FAILED INSIDE TRANSMISSION, AFTER TAKING IT IN SEVERAL TIMES FOR DIAGNOSIS. WOULD NOT ASSIST WITH REPAIR COST. ENDED UP HAVING IT REPAIRED AT AAMCO. A/C IS CURRENTLY OUT ON THE LOW SETTING (#1). NOT YET REPAIRED. JUST REPAIRED THE COOLING SYSTEM. DEALER SAID IT WAS AN INTERNAL LEAK. VAN KEPT GETTING LOW ON COOLANT, HAD TO KEEP FILLING IT UP, HOWEVER NEVER SAW A LEAK. DEALER SAID PROBLEM WITH THE MANIFOLD, AND COOLANT WAS LEAKING THRU AND BEING EVAPORTATED, THEREFORE NO TELLTALE LEAK. COST $600 TO REPAIR (AT 53,000) MILES. I HATE THIS VAN. THIS IS THE WORST ONE I'VE HAD. UNFORTUNATELY, I DID NOT BUY AN EXTENDED WARRANTY.
NHTSA ODI #10070207
38,500 miles · Jan 15, 2004
Engine And Engine CoolingUnknown Or OtherVisibility
ENGINE - VEHICLE WAS LEAKING COOLANT THROUGH INTAKE MANIFOLD GASKET INTO ENGINE. INTAKE MANIFOLD NEEDED TO BE RESEALED. PONTIAC ASSISTANCE IS REFUSING TO HELP AT THIS TIME. THIS IS A COMMON PROBLEM WITH THE V6 AND GM IS REFUSING TO ACKNOWLEDGE IT. EMISSION - SECONDARY AIR INJECTION PUMP FAILED AT 33025 MILES AND WAS COVERED UN…
Read full complaint
ENGINE - VEHICLE WAS LEAKING COOLANT THROUGH INTAKE MANIFOLD GASKET INTO ENGINE. INTAKE MANIFOLD NEEDED TO BE RESEALED. PONTIAC ASSISTANCE IS REFUSING TO HELP AT THIS TIME. THIS IS A COMMON PROBLEM WITH THE V6 AND GM IS REFUSING TO ACKNOWLEDGE IT. EMISSION - SECONDARY AIR INJECTION PUMP FAILED AT 33025 MILES AND WAS COVERED UNDER WARRANTY. THIS PUMP FAILED AGAIN AT 44000 MILES, JUST 8 MONTHS LATER AND COST 160.00 FOR LABOR. EMISSION PUMPS SHOULD LAST LONGER THAN 8 MONTHS. POWER WINDOW - DRIVERS SIDE POWER WINDOW MOTOR FAILED 9/2002 AT 38500 MILES. FAULTY WIRING CLUSTER NEEDED TO BE REPLACED AT 12528 (N/C).
NHTSA ODI #10069878
Mileage unknown · Jan 6, 2004
Engine And Engine Cooling
1/3/04 VAN FAILED TO START-REASON UNKNOWN. TOOK TO MECHANIC TO CHECK OUT AND DISCOVERED OIL LEAK IN THE ENGINE AT 50,000 THIS IS CRAZY, THIS TYPE OF THING SHOULD NOT HAPPEN AT 50,000 MILES THIS IS OBVIOUSLY A PROBLEM IN THE ENGINEERING OR PART THAT ARE BEING USED.*AK
NHTSA ODI #10052493
33,000 miles · Jan 2, 2004
Engine And Engine Cooling
CONSUMER COMPLAINED ABOUT ENGINE PROBLEMS. A VARIETY OF GASKETS WERE REPLACED; HOWEVER, ENGINE PROBLEMS STILL EXIST. *AK
NHTSA ODI #10052262
48,900 miles · Dec 30, 2003
Engine And Engine Cooling
LOWER INTAKE MANAFOLD LEAKING COOLANT INTO ENGIN OIL.
NHTSA ODI #10051350
82,000 miles · Dec 18, 2003
Engine And Engine Cooling
MY WIFE AND I WERE ON A RURAL ROAD IN NORTHERN MICHIGAN WHEN OUR VAN STOPPED RUNNING WITH NO PRIOR PROBLEMS. WE ENDED UP WALKING ALMOST SEVEN MILES IN BITTER COLD TO GET BACK HOME. LATER ON WE LEARNED THAT THE DEX TYPE COOLANT HAD LEAKED INTO THE ENGINE AND CAUSED THE CAM TO FAIL.
NHTSA ODI #10050737
Mileage unknown · Dec 15, 2003
Engine And Engine Cooling
CONSUMER COMPLAINED ABOUT VEHICLE CUTTING OFF. TOOK VEHICLE TO A MECHANIC, AND MECHANIC STATED WATER WAS GETTING INTO THE OIL. *AK
NHTSA ODI #10050568
66,267 miles · Dec 12, 2003
Engine And Engine Cooling
INTAKE MANIFOLD GASKET LEAKED COOLANT INTO THE ENGINE CRANKCASE. THIS CAUSED HYDRAULIC LIFTER DAMAGE - LIFTERS HAD TO BE REPLACED AND GASKET REPLACED. ADDITIONAL ENGINE DAMAGE IS UNKNOWN AT THIS TIME.*AK
NHTSA ODI #10049665
49,000 miles · Nov 19, 2003
Engine And Engine Cooling
CONSUMER NOTICED THAT VEHICLE HAD A LOW COOLANT LEVEL. TOOK THE VEHICLE TO THE DEALER, WHO DETERMINED THAT THE INTAKE MANIFOLD WAS CRACKED, AND HAD TO BE REPLACED. *AK
NHTSA ODI #10048350
42,416 miles · Oct 12, 2003
Engine And Engine CoolingPower Train
LOWER MANIFOLD AND WATER PUMP ARE BOTH LEAKING ON VEHICLE.*MR THE WATER PUMP AND THE MANIFOLD GASKETS NEEDED TO BE REPLACED. THE FIRST MAJOR FAILURE OCCURRED THE DAY AFTER THE CONSUMER TOOK DELIVERY OF THE VEHICLE. THE VEHICLE WOULDN'T COME OUT OF FIRST GEAR. THIS WAS THE RESULT OF THE VEHICLE BEING SHIPPED WITHOUT TRANSMISS…
Read full complaint
LOWER MANIFOLD AND WATER PUMP ARE BOTH LEAKING ON VEHICLE.*MR THE WATER PUMP AND THE MANIFOLD GASKETS NEEDED TO BE REPLACED. THE FIRST MAJOR FAILURE OCCURRED THE DAY AFTER THE CONSUMER TOOK DELIVERY OF THE VEHICLE. THE VEHICLE WOULDN'T COME OUT OF FIRST GEAR. THIS WAS THE RESULT OF THE VEHICLE BEING SHIPPED WITHOUT TRANSMISSION FLUID. THE TRANSMISSION HAD TO BE REPLACED. *PH *JB
NHTSA ODI #10044012
Official recalls
5Dec 22, 2004
ON CERTAIN MINIVANS EQUIPPED WITH SECOND-ROW BUCKET SEATS OR CAPTAIN'S CHAIRS AND A POWER SLIDING DOOR ON THE PASSENGER SIDE OF THE VEHICLE, A PASSENGER USING THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR COULD BE INJURED.
Consequence & remedy
Consequence: IF A PASSENGER USES THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR AND HOLDS ONTO THE HANDLE WHILE IT IS BEING OPENED BY THE MOTOR, THE PASSENGER'S ARM MAY BE PUSHED INTO THE SEAT BACK OR ARMREST AND A WRIST OR LOWER ARM INJURY MAY RESULT.
Remedy: DEALERS WILL REPLACE THE POWER SLIDING DOOR INTERIOR HANDLE ON THE PASSENGER-SIDE. IF THE VEHICLE IS EQUIPPED WITH A POWER OR MANUAL SLIDING DOOR ON THE DRIVER-SIDE, THE INTERIOR HANDLE WILL ALSO BE REPLACED FOR APPEARANCE REASONS. NOTE: BEFORE THE VEHICLE IS SERVICED, GM ADVISES OWNERS TO NOT USE THE INTERIOR DOOR HANDLE TO OPEN THE DOOR. THE DRIVER CAN OPEN AND CLOSE THE DOOR FROM SWITCHES AT THE DRIVER'S POSITION OR BY USING THE REMOTE KEY FOB. THE DRIVER SHOULD TELL PASSENGERS TO USE THE SWITCH LOCATED IN FRONT OF THE DOOR TO OPEN OR CLOSE IT. THE DRIVER SHOULD USE THE OVERRIDE SWITCH TO PREVENT OPERATION OF THE POWER DOOR BY CHILDREN OR BY OTHERS WHO ARE NOT FAMILIAR WITH ITS USE. THE OWNER NOTIFICATION LETTER MAILING WILL BE CONDUCTED IN PHASES WITH THE FIRST PHASE BEGINNING ON MAY 31, 2005. THE SECOND PHASE MAILING BEGAN ON JULY 18, 2005. THE RECALL BEGAN ON MAY 31, 2005. PHASE 2 BEGAN ON JULY 18, 2005. PHASE 3 (FINAL PHASE) BEGAN ON AUGUST 24, 2005, TO ALL REMAINING CUSTOMERS. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438; PONTIAC AT 1-800-620-7668; OR OLDSMOBILE AT 1-800-630-6537.
Aug 21, 2001
VEHICLE DESCRIPTION: 1997-2001 CHEVROLET VENTURE, PONTIAC MONTANA/TRANSPORT, AND OLDSMOBILE SILHOUETTE MINI VANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS THAT WERE SERVICED IN CAMPAIGN 01013 (01V-067) FROM APRIL TO AUGUST 2001. ALSO 2001 CHEVROLET VENTURE, PONTIAC MONTANA, AND OLDSMOBILE SILHOUETTE MINI VANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS ASSEMBLED IN JANUARY THROUGH APRIL 2001. THESE VEHICLES HAVE INADEQUATE FRONT WELDS. IF A FRONT WELD FAILS, THE ACTUATOR CAN JAM IN THE UNLATCHED POSITION AND, WHEN THE SLIDING DOOR CLOSES, IT WILL NOT BE LATCHED.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE POWER SLIDING DOOR CAN OPEN WHILE THE VEHICLE IS IN MOTION, PARTICULARLY WHEN THE VEHICLE ASCENDS A HILL, MAKES A TURN, OR TRAVELS OVER A ROUGH ROAD SURFACE. AN UNRESTRAINED OCCUPANT COULD FALL OUT OF THE VAN AND BE INJURED.
Remedy: DEALERS WILL INSPECT AND, IF REQUIRED, INSTALL A NEW POWER SLIDING DOOR UNLATCH ACTUATOR ASSEMBLY. OWNER NOTIFICATION BEGAN ON OCTOBER 22, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
Mar 8, 2001
VEHICLE DESCRIPTION: MINIVANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS. THE DOOR CLOSES BUT MAY NOT BE LATCHED. IF THIS HAPPENS, THE POWER SLIDING DOOR CAN OPEN WHILE THE VEHICLE IS IN MOTION, PARTICULARLY WHEN THE VEHICLE ASCENDS A HILL, MAKES A TURN, OR TRAVELS OVER A ROUGH ROAD SURFACE.
Consequence & remedy
Consequence: AN UNRESTRAINED OCCUPANT COULD FALL OUT OF THE VAN AND BE INJURED.
Remedy: DEALERS WILL INSTALL A NEW UN-LATCH ACTUATOR ASSEMBLY TO THE POWER SLIDING DOOR. THIS RECALL HAS BEEN CONTINUED UNDER SAFETY RECALL 01V-264. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
Aug 7, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Sep 29, 1999
VEHICLE DESCRIPTION: MINI VANS WITH EXTENDED WHEELBASE. SOME OF THESE VEHICLES HAVE INOPERATIVE FUEL TANK ROLLOVER VALVES AND FUEL LEAKAGE WOULD EXCEED THE PERMISSIBLE AMOUNT IN A ROLLOVER TEST. THIS DOES NOT COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY."
Consequence & remedy
Consequence: IN A VEHICLE ROLLOVER ACCIDENT, IF AN IGNITION SOURCE IS PRESENT, A FIRE COULD RESULT.
Remedy: DEALERS WILL INSPECT THE VEHICLES TO LOCATE AND REPLACE THOSE FUEL TANKS THAT COULD HAVE INOPERATIVE ROLLOVER VALVES.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4PE04064 · POWER-SLIDING Door
Opened Sep 17, 2004 · Closed Dec 22, 2004
Status: closed (inferred from source dates) · Structure:body:door
SUBJECT VEHICLES ARE AVAILABLE WITH AN OPTIONAL POWER SLIDING DOOR.THE INTERIOR HANDLE IS ORIENTED IN THE VERTICAL POSITION IN THE DOOR PANEL AND LINES UP AT THE ELBOW LEVEL WHEN THE OCCUPANT IS SEATED IN THE 2ND-ROW OUTBOARD POSITION.IF THE OCCUPANT HOLDS THE INTERIOR HANDLE IN THE THUMB UP POSITION DURING POWER-ASSISTED OPENING, THE ARM/WRIST CAN BE PUSH BACK WITH FORCE AGAINST THE 2ND-ROW BUCKET SEAT OR CAPTAIN'S CHAIR SEAT BACK CREATING A RISK OF INJURY (OTHER SEATING CONFIGURATIONS HAVE AMPLE SEAT TO DOOR CLEARANCE TO AVOID ENTRAPMENT OF THE LOWER ARM).AMONG THE 103 TOTAL REPORTS, THERE WERE 102 ALLEGED INJURIES INCLUDING ARM/WRIST, THUMB AND SHOULDER INJURIES.A COUNT OF INJURIES REVEALS THAT 76 INJURIES WERE A FRACTURED OR A BROKEN ARM/WRIST REQUIRING AN IMMOBILIZING CAST FOR FOUR-TO-SIX WEEKS.ALL INJURIES INVOLVE THE RIGHT SIDE POWER SLIDING DOOR.THE LEFT SIDE POWER SLIDING DOOR IS ON FAR FEWER VEHICLES, BUT MORE IMPORTANTLY, IT PRODUCES LESS FORCE.GM NOTIFIED THE AGENCY BY LETTER DATED DECEMBER 21, 2004, THAT IT WILL RECALL MODEL YEAR 1997 THOUGH EARLY 2005 GM U-VAN VEHICLES EQUIPPED WITH A RIGHT SIDE POWER SLIDING DOOR AND WITH 2ND-ROW BUCKET SEATS OR CAPTAIN CHAIRS (NHTSA RECALL #04V597).AS PART OF THE RECALL REMEDY, GM WILL REPLACE THE DOOR HANDLE WITH A FLUSH MOUNTED HANDLE THAT WILL PREVENT AN OCCUPANT FROM GRASPING THE HANDLE WITH THE PALM BETWEEN THE HANDLE AND DOOR PANEL (THUMB UP ORIENTATION) AND THUS ELIMINATE THE POTENTIAL FOR ARM/WRIST ENTRAPMENT.THIS INVESTIGATION IS CLOSED.
PE02017 · Shoulder Harness Clip
Opened Feb 11, 2002 · Closed Aug 2, 2002
Status: closed (inferred from source dates) · Seat Belts
No summary supplied.
EA01014 · Air Bag Inflator
Opened Jun 11, 2001 · Closed Aug 26, 2002
Status: closed (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module
No summary supplied.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
Air Bags:frontal:driver Side:inflator Module
SQ00014 · Unexpected Opening Of Sliding Door
Opened Jul 25, 2000 · Closed Oct 22, 2001
Status: closed (inferred from source dates) · Structure
There is no summary currently available
Illustration