Engine. Review the 31 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 20 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine And Engine Cooling. Review the 16 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

5 crash reports37 fire reports7 injury reports

Suspension complaints

3 reports

Clear category filter

180,000 miles · Jan 26, 2015

SteeringSuspensionWheels

VEHICLE WAS TURNING NORTH ONTO PARKER BLVD. OFF W. BRIDGE ROAD WHEN THE STEERING WHEEL BEGAN TO VIBRATE AND LOCK UP. DRIVER WAS UNABLE TO STRAIGHTEN THE WHEEL HEADING NORTH ON BROADWAY. UNABLE TO CONTROL THE STEERING WHEEL THE VEHICLE HIT THE EAST CURB BEFORE THE VEHICLE CAME TO A STOP THE RIGHT PASSENGER TIRE BROKE OFF AND TH…

Read full complaint

NHTSA ODI #10679031

Mileage unknown · Sep 27, 2014

EngineSuspension

Read full complaint

I BOUGHT THE CAR IN 2009, IT WAS OK FOR A FEW MONTHS, THE PLACE I BOUGHT MY VEHICLE PROVIDED A CARFAX AND CONTAINED 0 INFORMATION STATING NO REPAIRS HAVE EVER BEEN MADE. IT WAS THEN BEGINNING OF 2010. IT FELT LIKE THE FRONT SUSPENSION OR TY ROD CAME APART OR BROKE. THE STEERING IS OFF AND THE THE SUSPENSION JUMPS WHEN I DRIVE IT AND THE "OFF TRAC LIGHT CAME ON AND HAS NEVER GONE OFF. THEN I STARTED SMELLING SMOKE OR BURNING SMELL THAT WAS COMING FROM THE VENTS. NOW I'M BEING TOLD WHEN I HAD A RADIATOR FLUSH THAT THE COMPARTMENT HAS MASSIVE AMOUNT OF SLUDGE AT THE BOTTOM. THE ONLY WAY TO GET RID OF THAT IS TO GET A NEW RADIATOR. PLEASE ADVISE IF THESE COMPLAINTS HAVE BEEN REPORTED BY OTHER SAME VEHICLES. I NEED TO KNOW WHERE TO TAKE MY CAR FOR REPLACEMENT REPAIRS IN THE JOLIET/PLAINFIELD IL. AREA. *TR

NHTSA ODI #10639555

92,000 miles · Sep 15, 2011

Suspension

Read full complaint

I HAVE NOTICED FOR SOME TIME A CLANG ON THE FRONT END WHEN I HIT A POT HOLE. I TOOK IT IN TO BE CHECKED OUT ON THREE SEPARATE OCCASIONS AND TO THREE DIFFERENT SERVICE PLACES AND NO ONE SEEN ANYTHING WRONG. OVER TIME IT GOT LOUDER AND LOUDER. I TOOK IT IN THIS PAST TIME AND FOUND THAT I HAD TWO VERY LARGE CRACKS IN BOTH SWAY BARS THE WORST BEING ON THE FRONT LEFT SIDE. THE SERVICE TECHNICIAN STATED A CRASH WAS BOUND TO HAPPEN IF IT HAD GONE UNDISCOVERED. I HAVE HAD THIS VEHICLE SINCE IT WAS A FEW MONTHS OLD AND IT HAS NEVER BEEN WRECKED IN IS IN VERY GOOD CONDITION. THE SERVICE TECHNICIAN ALSO STATED THAT THIS SHOULD OF NEVER HAPPENED CONSIDERING CONDITION OF THE REST OF MY VEHICLE AND MY MILEAGE. *KB

NHTSA ODI #10425668

Official recalls

15V701000 · Engine And Engine Cooling:engine; Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe

Oct 26, 2015

General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.

Consequence & remedy

Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.

Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.

Additional source detail variants (2)

Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe

Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.

Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.

Engine And Engine Cooling:engine

Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.

09V116000 · Engine And Engine Cooling

Apr 8, 2009

GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.

Consequence & remedy

Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.

Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.

08V118000 · Engine And Engine Cooling

Mar 12, 2008

GM IS RECALLING 207,542 MY 1997-2003 BUICK REGAL AND PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L SUPERCHARGED V-6 ENGINE. THESE VEHICLES HAVE HIGHER FRONT ROCKER COVER GASKET TEMPERATURES, CREATING THE POTENTIAL FOR EARLIER DEGRADATION OF THE FRONT ROCKER COVER GASKET AND EVENTUAL OIL SEEPAGE.

Consequence & remedy

Consequence: CERTAIN UNDERHOOD FIRES MAY BE CAUSED BY DROPS OF ENGINE OIL, FROM SEEPAGE OR SPILLAGE, BEING DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING. IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND, IN SOME INSTANCES, THE FIRE MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND.

Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, ALONG WITH THE 1-3-5 SPARK PLUG WIRE RETAINERS, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. , FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. UNTIL THE REMEDY IS COMPLETED, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS (1) THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CAR PORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE. THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL. OWNERS MAY CONTACT BUICK AT 1-866-608-8080 OR PONTIAC AT 1-800-620-7668, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

No exact-year investigations in this snapshot.