Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
120–25K
2925–50K
4050–75K
5375–100K
59100–150K
49150K+
242 reports with mileage · 88 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Engine. Review the 86 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine And Engine Cooling. Review the 62 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 56 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
19 crash reports96 fire reports12 injury reports
What owners actually said
330 reports
70,000 miles · Apr 1, 2014
Electrical System
TL* THE CONTACT OWNS A 2002 PONTIAC GRAND PRIX. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 40 MPH, THE ENTIRE INSTRUMENT PANEL AND ELECTRICAL SYSTEM FAILED. THE FAILURE WAS RECURRING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO WAS UNABLE TO DUPLICATE THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILUR…
Read full complaint
TL* THE CONTACT OWNS A 2002 PONTIAC GRAND PRIX. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 40 MPH, THE ENTIRE INSTRUMENT PANEL AND ELECTRICAL SYSTEM FAILED. THE FAILURE WAS RECURRING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO WAS UNABLE TO DUPLICATE THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 70,000.
NHTSA ODI #10576373
52,000 miles · Mar 31, 2014
Electrical System
THE IGNITION KEY GETS STUCK AND CANNOT BE REMOVED. THIS IS INTERMITTENT. DEALER COULD NOT FIX THE PROBLEM. *TR
NHTSA ODI #10575966
101,000 miles · Mar 5, 2014
EngineFire
WHILE DRIVING, THERE WAS SMOKE COMING FROM THE ENGINE COMPARTMENT AND ONLOOKERS WERE FLAGGING DOWN THE CAR. WHEN I GOT OUT OF THE CAR AND CALL FIRE RESCUE THE CAR CAUGHT ON FIRE FROM THE FRONT ENGINE PART AND THEN THROUGH THE WHOLE CAR. GM HAS ALREADY BEEN NOTIFIED AND LOOKING INTO THE CLAIM. *TR
NHTSA ODI #10567409
80,000 miles · Mar 3, 2014
Electrical System
TL* THE CONTACT OWNS A 2002 PONTIAC GRAND PRIX. THE CONTACT STATED THAT THE KEY FAILED TO BE REMOVED FROM THE IGNITION. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 80,000 AND THE CURRENT MILEAGE WAS 9…
Read full complaint
TL* THE CONTACT OWNS A 2002 PONTIAC GRAND PRIX. THE CONTACT STATED THAT THE KEY FAILED TO BE REMOVED FROM THE IGNITION. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 80,000 AND THE CURRENT MILEAGE WAS 90,000. *TR
NHTSA ODI #10566768
110,000 miles · Feb 13, 2014
Air BagsCrash
MY DAUGHTER WAS DRIVING MY CAR ON A SNOW DAY AND SHE STEP ON BRAKE AND THE CAR SPINE AND HIT BRIDGE BASE . DAMAGE ONLY THE FRONT BUMPER COVER , NOTHING ELSE IM TALKING ABOUT LIGHT DAMAGE AND I DON'T UNDERSTAND WHY THE BOTH DRIVER AND PASSENGER BAGS SPLOUD.., THE PASSENGER BAG WAS SO POWER FULL THAT CRACK THE WI…
Read full complaint
MY DAUGHTER WAS DRIVING MY CAR ON A SNOW DAY AND SHE STEP ON BRAKE AND THE CAR SPINE AND HIT BRIDGE BASE . DAMAGE ONLY THE FRONT BUMPER COVER , NOTHING ELSE IM TALKING ABOUT LIGHT DAMAGE AND I DON'T UNDERSTAND WHY THE BOTH DRIVER AND PASSENGER BAGS SPLOUD.., THE PASSENGER BAG WAS SO POWER FULL THAT CRACK THE WIND SHIELD , IF YOU WANT ME TO SEND A PICTURE I WILL. I JUST WANNA FIND OUT WHY THIS BAG NOT WORK RIGHT , AND WHO'S GOING TO BE RESPONSIBLE FOR THIS MESS. THANKS. *TR
NHTSA ODI #10564292
160,000 miles · Dec 15, 2013
EngineFire
MY PONTIAC GRAND PRIX 2002 CAUGHT FIRE IN MY DRIVEWAY A MERE 10 MINUTES AFTER I GOT OUT OF THE VEHICLE. 5 DAYS LATER I RECEIVED A LETTER STATING THAT THERE WAS A RECALL ON MY CAR FOR ENGINE COMPARTMENT FIRES. I CONTACTED GM WHO TOOK RESPONSIBILITY FOR THE RECALL AND THEY REFUSED TO COMPENSATED FOR THE DAMAGE THE FIRE DID TO ME C…
Read full complaint
MY PONTIAC GRAND PRIX 2002 CAUGHT FIRE IN MY DRIVEWAY A MERE 10 MINUTES AFTER I GOT OUT OF THE VEHICLE. 5 DAYS LATER I RECEIVED A LETTER STATING THAT THERE WAS A RECALL ON MY CAR FOR ENGINE COMPARTMENT FIRES. I CONTACTED GM WHO TOOK RESPONSIBILITY FOR THE RECALL AND THEY REFUSED TO COMPENSATED FOR THE DAMAGE THE FIRE DID TO ME CAR. THE FIRE WAS DUE TO THE EXACT RECALL THAT GM SENT ME IN THE MAIL. THEY NEGLECTED TO NOTIFY ME, UNTIL MY CAR HAD ALREADY BEEN TOTALED FROM THE DAMAGE. THEY NOW SAY MY CAR WAS "OUT OF WARRANTY" AND REFUSE TO HELP. IF ITS "OUT OF WARRANTY" WHY DID THEY SAID ME A NOTICE SAYING THEY WOULD REPAIR THE RECALL FREE OF CHARGE. IF THEY TAKE RESPONSIBILITY FOR THE RECALL HOW CAN THEY NOT TAKE RESPONSIBILITY FOR THE DAMAGE THAT THE RECALLED PART CAUSED? I COULD HAVE BEEN IN THE VEHICLE, MY HOUSE WAS A MERE TWO FEET FROM THE CAR AND THE FIRE AND COULD HAVE BURNED DOWN. *TR
NHTSA ODI #10556139
42,000 miles · Oct 7, 2013
EngineExterior LightingSteering
CAN NOT START UP AGAIN AFTER SHUT DOWN HAVE TO WAIT TILL CARS COOLS DOWN. *TR
NHTSA ODI #10547089
152,000 miles · Aug 16, 2013
Electrical SystemFire
PULLED INTO THE GARAGE AND TURNED THE CAR OFF. THE IGNITION SWITCH TURNED ENOUGH TO TURN THE CAR OFF BUT NOT FAR ENOUGH TO REMOVE THE KEY. TRIED JIGGLING THE KEY BACK AND FORTH AND IT STILL WOULD NOT COME OUT. LEFT KEY IN IGNITION AND PUSHED THE TRUNK RELEASE BUTTON ON THE KEY FOB, THE TRUNK OPENED AND THEN THE CAR TRIED TO S…
Read full complaint
PULLED INTO THE GARAGE AND TURNED THE CAR OFF. THE IGNITION SWITCH TURNED ENOUGH TO TURN THE CAR OFF BUT NOT FAR ENOUGH TO REMOVE THE KEY. TRIED JIGGLING THE KEY BACK AND FORTH AND IT STILL WOULD NOT COME OUT. LEFT KEY IN IGNITION AND PUSHED THE TRUNK RELEASE BUTTON ON THE KEY FOB, THE TRUNK OPENED AND THEN THE CAR TRIED TO START ITSELF WITHOUT ANYTHING TURNING THE KEY. THEN SMOKE STARTED COMING OUT FROM BEHIND THE STEERING WHEEL. THE CAR WAS STUCK IN PARK AND COULD NOT GET INTO NEUTRAL TO PUSH OUT OF GARAGE. I BELIEVE FINALLY A FUSE POPPED. I OPENED THE HOOD AND DISCONNECTED THE BATTERY AND THE SMOKE STOPPED. I CALLED THE DEALER TO CHECK AND SEE IF THERE WAS A RECALL THAT I MISSED BUT THEY TOLD ME THERE WERE NO RECALLS RELATING TO THE IGNITION. I TOOK SOME OF THE PLASTIC OFF UNDER THE STEERING WHEEL AND FOUND THAT ABOUT HALF OF THE IGNITION WIRING HARNESS WAS BURNED UP AND MELTED. *TR
NHTSA ODI #10535775
160,508 miles · Jul 22, 2013
Power Train
MY VEHICLE IS EXPERIENCING TSB: 06-07-30-023D 4T65E: TRANSMISSION 1-2 SHIFT SHUDDER AT LIGHT TO MODERATE ACCELERATION. I CALLED PONTIAC RECALL CENTER GAVE MY VIN AND WAS TOLD IT WAS NOT COVERED. EVENTHOUGH I GOT THIS RECALL AFTER TAKING MY CAR TO A NJ INSPECTION CENTER. *TR
NHTSA ODI #10526091
140,000 miles · Jun 26, 2013
EngineStructureFire
AFTER TEN MINUTE DRIVE FROM WORK TO HOME, PARKED THE CAR & 5 MIN. LATER WAS INFORMED BY A NEIGHBOR THAT THE CAR WAS ON FIRE! I DID NOT SMELL BURNING OR ANYTHING UNUSUAL WHEN I PARKED IT. THE FLAMES WERE COMING OUT OF THE AIR INTAKE ON THE HOOD AND BURNING PLASTIC WAS DRIPPING OFF BELOW. MY SMALL FIRE EXTINGUISHER SETTLED DO…
Read full complaint
AFTER TEN MINUTE DRIVE FROM WORK TO HOME, PARKED THE CAR & 5 MIN. LATER WAS INFORMED BY A NEIGHBOR THAT THE CAR WAS ON FIRE! I DID NOT SMELL BURNING OR ANYTHING UNUSUAL WHEN I PARKED IT. THE FLAMES WERE COMING OUT OF THE AIR INTAKE ON THE HOOD AND BURNING PLASTIC WAS DRIPPING OFF BELOW. MY SMALL FIRE EXTINGUISHER SETTLED DOWN THE FLAMES, HOWEVER BY THE TIME THE FIRE DEPARTMENT ARRIVED THE FIRE AND SMOKE HAD BECOME LARGER THAN BEFORE. THE CAR IS NOW TOTALED AND ALTHOUGH I HAD PREVIOUSLY RECEIVED A NOTICE FOR A EARLIER RECALL, AND TAKEN THE CAR IN TO THE DEALER, I NEVER RECEIVED A NOTICE FOR THE FIRE ISSUE. THE REPRESENTATIVE AT GM CLAIMS DIVISION SAID SINCE THE CAR WAS MORE THAN TEN YEARS OLD (DESPITE THE FACT I BOUGHT IT FROM THE PONTIAC DEALER MORE RECENTLY) I HAD NO RECOURSE. AFTER VERY LITTLE RESEARCH I FOUND THIS SAME SCENARIO ALL OVER THE INTERNET AND ASSUME IT WILL ONLY BECOME MORE COMMON AS THESE CARS CONTINUE TO AGE. HOPEFULLY A CLASS ACTION LAWSUIT WILL EMERGE AS THOSE PEOPLE WHO LOST THEIR INVESTMENT IN THEIR VEHICLE CONTINUE TO GROW. *TR
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
GM IS RECALLING 207,542 MY 1997-2003 BUICK REGAL AND PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L SUPERCHARGED V-6 ENGINE. THESE VEHICLES HAVE HIGHER FRONT ROCKER COVER GASKET TEMPERATURES, CREATING THE POTENTIAL FOR EARLIER DEGRADATION OF THE FRONT ROCKER COVER GASKET AND EVENTUAL OIL SEEPAGE.
Consequence & remedy
Consequence: CERTAIN UNDERHOOD FIRES MAY BE CAUSED BY DROPS OF ENGINE OIL, FROM SEEPAGE OR SPILLAGE, BEING DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING. IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND, IN SOME INSTANCES, THE FIRE MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, ALONG WITH THE 1-3-5 SPARK PLUG WIRE RETAINERS, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. , FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. UNTIL THE REMEDY IS COMPLETED, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS (1) THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CAR PORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE. THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL. OWNERS MAY CONTACT BUICK AT 1-866-608-8080 OR PONTIAC AT 1-800-620-7668, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4
EA07008 · Engine Compartment Fire
Opened Jun 12, 2007 · Closed May 1, 2008
Status: closed (inferred from source dates) · Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Additional source detail variants (2)
Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
PE07006 · Engine Compartment Fire
Opened Jan 29, 2007 · Closed Jun 12, 2007
Status: closed (inferred from source dates) · Engine And Engine Cooling
ON JANUARY 29, 2007, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE ALLEGED NON-CRASH FIRES ORIGINATING IN THE ENGINE COMPARTMENT IN CERTAIN MODEL YEAR (MY) 1999-2002 PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE ?L67? SUPERCHARGED VERSION OF THE GENERAL MOTORS (GM) 3800 SERIES II V6 ENGINE.TO DATE, ODI IS AWARE OF 121 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES THAT ALLEGE NON-CRASH RELATED FIRES ORIGINATING IN THE ENGINE COMPARTMENT WHILE DRIVING OR AFTER THE VEHICLE IS PARKED AND THE IGNITION SWITCHED OFF. WHILE NO SUBJECT COMPONENT HAS YET BEEN IDENTIFIED, ODI ANALYSIS OF AVAILABLE INFORMATION INDICATES THAT THE ALLEGED FIRE INCIDENT RATE AMONG THE SUBJECT VEHICLES IS SIGNIFICANTLY HIGHER THAN GM PEER VEHICLES THAT USE THE NON-SUPERCHARGED ?L36? VERSION OF THE GM 3800 SERIES II V6 ENGINE.IN SOME CASES, THE FIRE INCIDENT RATE IS TWICE AS HIGH IN THE SUBJECT VEHICLES AND UP TO AS MUCH AS AN ORDER OF MAGNITUDE GREATER THAN IN NON-SUPERCHARGED PEER VEHICLES.FOR INSTANCE, THE SUBJECT FIRE INCIDENT RATE FOR THE SUPERCHARGED MY 2000 PONTIAC GRAND PRIX GTP IS APPROXIMATELY 236 PER 100,000 VEHICLES PRODUCED (58 FIRES / 24,509 SUBJECT VEHICLES OR 0.236%) WHILE THE FIRE INCIDENT RATE FOR MY 2000 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH THE NATURALLY ASPIRATED ?L36? ENGINE IS APPROXIMATELY 18 PER 100,000 VEHICLES PRODUCED (17 FIRES / 90,338 VEHICLES OR 0.018%). THE MANUFACTURER?S INVESTIGATION INTO ALLEGED ENGINE COMPARTMENT FIRES ON THE SUBJECT VEHICLES IS ONGOING.ACCORDINGLY, THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-008) TO FURTHER STUDY THE FREQUENCY AND SCOPE OF THE ALLEGED DEFECT. BASED ON THE INFORMATION REVIEWED IN PE07-006, THE RANGE OF SUBJECT VEHICLES UNDER INVESTIGATION WILL BE EXPANDED TO INCLUDE ALL MY 1999-2002 BUICK PARK AVENUE, REGAL, AND RIVIERA, OLDSMOBILE LSS, AND PONTIAC BONNEVILLE AND GRAND PRIX VEHICLES THAT USE THE SAME OR SUBSTANTIALLY SIMILAR TRANSVERSE MOUNTED ?L67? ENGINE.
THE AGENCY'S ANALYSIS OF GM'S COMPLAINT AND WARRANTY DATA FOR THE SUBJECT VEHICLES, INCLUDING A COMPARISON WITH OTHER AGENCY AND MANUFACTURER DATA PERTAINING TO OTHER VEHICLE BRAKE LAMP INVESTIGATIONS, INDICATED A LOW FAILURE HISTORY FOR THE SUBJECT VEHICLES.THIS INVESTIGATION INCLUDED A REVIEW AND ANALYSIS OF DATA FOR RELEVANT BRAKE LAMP MALFUNCTIONS THAT REQUIRE REPLACEMENT OF THE MULTIFUNCTION SWITCH (MFS) MODULE.THE HAZARD WARNING SWITCH IS AN INTEGRAL PART OF THE MFS MODULE.OTHER COMPONENTS THAT AFFECT BRAKE LAMP ILLUMINATION SUCH AS WIRING, BULB SOCKETS, AND THE PLUNGER-TYPE BRAKE LAMP SWITCH, WERE NOT A PART OF THIS INVESTIGATION.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY DEFECT DOES NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Electrical System
THE AGENCY'S ANALYSIS OF GM'S COMPLAINT AND WARRANTY DATA FOR THE SUBJECT VEHICLES, INCLUDING A COMPARISON WITH OTHER AGENCY AND MANUFACTURER DATA PERTAINING TO OTHER VEHICLE BRAKE LAMP INVESTIGATIONS, INDICATED A LOW FAILURE HISTORY FOR THE SUBJECT VEHICLES.THIS INVESTIGATION INCLUDED A REVIEW AND ANALYSIS OF DATA FOR RELEVANT BRAKE LAMP MALFUNCTIONS THAT REQUIRE REPLACEMENT OF THE MULTIFUNCTION SWITCH (MFS) MODULE.THE HAZARD WARNING SWITCH IS AN INTEGRAL PART OF THE MFS MODULE.OTHER COMPONENTS THAT AFFECT BRAKE LAMP ILLUMINATION SUCH AS WIRING, BULB SOCKETS, AND THE PLUNGER-TYPE BRAKE LAMP SWITCH, WERE NOT A PART OF THIS INVESTIGATION.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY DEFECT DOES NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:brake Lights
THE AGENCY'S ANALYSIS OF GM'S COMPLAINT AND WARRANTY DATA FOR THE SUBJECT VEHICLES, INCLUDING A COMPARISON WITH OTHER AGENCY AND MANUFACTURER DATA PERTAINING TO OTHER VEHICLE BRAKE LAMP INVESTIGATIONS, INDICATED A LOW FAILURE HISTORY FOR THE SUBJECT VEHICLES.THIS INVESTIGATION INCLUDED A REVIEW AND ANALYSIS OF DATA FOR RELEVANT BRAKE LAMP MALFUNCTIONS THAT REQUIRE REPLACEMENT OF THE MULTIFUNCTION SWITCH (MFS) MODULE.THE HAZARD WARNING SWITCH IS AN INTEGRAL PART OF THE MFS MODULE.OTHER COMPONENTS THAT AFFECT BRAKE LAMP ILLUMINATION SUCH AS WIRING, BULB SOCKETS, AND THE PLUNGER-TYPE BRAKE LAMP SWITCH, WERE NOT A PART OF THIS INVESTIGATION.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY DEFECT DOES NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
2002 Pontiac Grand Prix Problems, Complaints & Recalls | Skip That Year
Illustration