NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
330 reports138,000 miles · Jul 11, 2014
Electrical SystemService Brakes, Hydraulic
TL* THE CONTACT OWNS A 2002 PONTIAC GRAND PRIX. THE CONTACT STATED THAT THE ABS WARNING LIGHT ILLUMINATED. THE CONTACT ALSO STATED THAT UNKNOWN WARNING LIGHTS ILLUMINATED INTERMITTENTLY. THE FAILURE OCCURRED ON SEVERAL OCCASIONS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE …
Read full complaint
TL* THE CONTACT OWNS A 2002 PONTIAC GRAND PRIX. THE CONTACT STATED THAT THE ABS WARNING LIGHT ILLUMINATED. THE CONTACT ALSO STATED THAT UNKNOWN WARNING LIGHTS ILLUMINATED INTERMITTENTLY. THE FAILURE OCCURRED ON SEVERAL OCCASIONS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 138,000.
NHTSA ODI #10609791
168,000 miles · Jul 6, 2014
Air BagsSeat BeltsCrashInjury
WE WERE TRAVELING WEST BOUND ON 28TH STREET WHICH HAS TWO LANES EACH DIRECTION PLUS A TURNING LANE. WE WERE IN THE RIGHT LANE AND THE LEFT LANE TRAFFIC HAD COME TO A STOP. AS WE CAME UP TO THE STOPPED CAR A PICKUP TRUCK WAS TURNED LEFT INTO OUR LANE TRYING TO CROSS BOTH LANES. HE CAME ACROSS PRETTY FAST AND WE HIT THE FRONT LEFT…
Read full complaint
WE WERE TRAVELING WEST BOUND ON 28TH STREET WHICH HAS TWO LANES EACH DIRECTION PLUS A TURNING LANE. WE WERE IN THE RIGHT LANE AND THE LEFT LANE TRAFFIC HAD COME TO A STOP. AS WE CAME UP TO THE STOPPED CAR A PICKUP TRUCK WAS TURNED LEFT INTO OUR LANE TRYING TO CROSS BOTH LANES. HE CAME ACROSS PRETTY FAST AND WE HIT THE FRONT LEFT BUMPER PRETTY MUCH DEAD CENTER. I STEPPED ON THE BRAKES AS HARD AS I COULD HE WAS JUST TO CLOSE TO AVOID HIM. THE AIR BAGS DID NOT DEPLOY AND THE SEAT BELTS DID NOT LOCK UP RIGHT AWAY THEY EXTENDED TO FAR OUT BEFORE THEY LOCKED. MY FACE HIT THE STEERING WHEEL AND BENT UP MY GLASSES AND MY STOMACH AND FROM MY MIDDLE BACK TO THE MIDDLE OF MY HIP WHERE THE BUCKLE IS. I'VE BEEN HAVING A HEADACHE, BLURRY VISION AND MISERABLE EYE PAIN AND PAIN DOWN MY NECK AND TINGLING FINGERS. ER DOC SAID SPRAINED NECK AND BACK. MY WIFE HAS HUGE BRUISES ACROSS HER BODY. SHE IS SUFFERING FROM NECK PAIN,HEAD PAIN,HEADACHES,LEG PAIN, PELVIC PAIN AND IS NAUSEOUS AND HAS BEEN VOMITING. THE IMPACT WAS HARD ENOUGH TO PUSH THE TRUCK ABOUT 15 FEET SIDEWAYS. IT RIPPED HOOK FROM THE HOOD AND BENT THE HOOD UP.THE PASSENGER SIDE FENDER GOT PUSHED BACK INTO DOOR SO HARD TO OPEN AND FENDER WAS CAVED IN WHEN DOOR WAS PRIED OPEN. THE BATTERY BOX WAS BENT. WIPERS WERE BENT, WINDSHIELD GOT BROKE. THE BUMPER AND GRILLED WAS PUSHED BACK AND AIR VENTS RIPPED FREE. HEADLIGHTS WERE BROKEN. INSURANCE COMPANY TOTALED THE CAR. I ASKED THE GUY AT THE LOT WHY THE BAGS DIDN'T GO OFF AND HE SAID HE WAS SURPRISED BECAUSE IT WAS OBVIOUS TO HIM THAT THERE WAS MORE THAN ONE SENSOR HAD BEEN HIT. OF COURSE WAITING THE WEEK LIKE THE ER DOC SAID TO WAIT TO SEE OUR OWN DOCS AND BEING A HOLIDAY WEEKEND JUST DELAY THINGS. MY LAPTOP SCREEN GOT BROKE AND SO MUCH IS GOING TO COME OUT OF MY OWN POCKET. THEY THAN TELL ME I HAVE TO PAY SALES TAX ON THE MONEY I'M GETTING FOR THE CAR. *TR UPDATED 1/28/2015 *JS
NHTSA ODI #10608436
168,000 miles · Jul 2, 2014
Air BagsSeat BeltsCrashInjury
TL* THE CONTACT OWNS A 2002 PONTIAC GRAND PRIX. WHILE DRIVING APPROXIMATELY 40 MPH, THE CONTACT WAS INVOLVED IN A VEHICLE CRASH. THE AIR BAGS FAILED TO DEPLOY AND THE SEAT BELTS FAILED TO PROVIDE RESTRAINT. A POLICE REPORT WAS FILED AND THERE WERE NO INJURIES. THE VEHICLE WAS DESTROYED. THE FAILURE MILEAGE WAS 168,000. UPDATED…
Read full complaint
TL* THE CONTACT OWNS A 2002 PONTIAC GRAND PRIX. WHILE DRIVING APPROXIMATELY 40 MPH, THE CONTACT WAS INVOLVED IN A VEHICLE CRASH. THE AIR BAGS FAILED TO DEPLOY AND THE SEAT BELTS FAILED TO PROVIDE RESTRAINT. A POLICE REPORT WAS FILED AND THERE WERE NO INJURIES. THE VEHICLE WAS DESTROYED. THE FAILURE MILEAGE WAS 168,000. UPDATED 11/12/14*LJ THE CONSUMER STATED THE CRASH WAS A HEAD ON COLLISION. THE DRIVER AND PASSENGER RECEIVED HEAD INJURIES, HEADACHES, LOW BACK AND LEG PAIN. THE CONSUMER HAD A HERNIATED DISC. UPDATED 4/30/2015 *JS
NHTSA ODI #10607871
90,500 miles · Jul 2, 2014
Engine
VEHICLE WOULD RANDOMLY JUST SHUT OFF WHILE DRIVING.THERE WOULD BE NO INDICATION BEFOREHAND(LIKE SPUTTERING OR STALLING). IT WOULD JUST COMPLETELY SHUT OFF SOMETIMES WHILE DRIVING AT A REGULAR SPEED SOMETIMES AT A STOP. I WOULD LOSE ALL POWER STEERING POWER BRAKES ETC. I CONTACTED PONTIAC AND THEY TOLD ME THAT THERE WAS A LETTER …
Read full complaint
VEHICLE WOULD RANDOMLY JUST SHUT OFF WHILE DRIVING.THERE WOULD BE NO INDICATION BEFOREHAND(LIKE SPUTTERING OR STALLING). IT WOULD JUST COMPLETELY SHUT OFF SOMETIMES WHILE DRIVING AT A REGULAR SPEED SOMETIMES AT A STOP. I WOULD LOSE ALL POWER STEERING POWER BRAKES ETC. I CONTACTED PONTIAC AND THEY TOLD ME THAT THERE WAS A LETTER (NOT A RECALL) SENT OUT ON THIS CAR THAT COULD HAVE A CATALYTIC CONVERTER. THEY SET UP AN APPT. WITH A LOCAL DEALER. CAR WAS TAKEN THERE TO HAVE CONVERTER CHECKED (WHICH THEY SAID WAS OK) AND ALSO TO FIX WHAT WAS CAUSING CAR TO SHUT OFF. BOTTOM LINE, THEY INFORMED ME CAR WAS SHOWING NUMEROUS CODES ON COMPUTER. I TOLD THEM I ONLY WANTED TO FIX WHAT WAS CAUSING VEHICLE TO SHUT OFF.THEY INFORMED THAT ANY ONE OF THE CODES COULD CAUSE THE PROBLEM. I LEFT THERE WITH A BILL OVER 1500.00 AND VEHICLE SHUT OFF ON ME WITHIN 2 DAYS OF REPAIRS(WHICH WE LATER ARGUED WOULD NOT CAUSE THE PARTICULAR PROBLEM).THEY HAD ME BRING CAR BACK AND TOLD ME THERE WAS NOTHING THEY COULD DO UNLESS IT THREW A CODE. WITH ALL THE GM IGNITION PROBLEMS, JUST WONDERING IF PERHAPS THIS COULD BE MY PROBLEM ALSO BUT HAVE YET TO SEE MY CAR ON RECALL. ANY HELP OR WHO I CONTACT/COMPLAIN TO WOULD BE GREATLY APPRECIATED. I HAVE BECOME VERY NERVOUS DRIVING AND HAVE GRANDCHILDREN THAT I DON'T WANT TO TRANSPORT IF THIS IS A SAFETY ISSUE BECAUSE IT CAN GO SEVERAL DAYS OK THEN SOMETIMES WILL SHUT OFF SEVERAL TIMES A DAY AT RANDOM TIMES. AFRAID THAT ONE DAY IT WILL SHUT OFF AND CAUSE A CRASH AS I HAVE BEEN CLOSE SEVERAL TIMES. *TR
NHTSA ODI #10607689
79,000 miles · Jun 29, 2014
Electrical SystemExterior LightingService BrakesCrash
THE MULTI FUNCTION SWITCH HAS MALFUNCTIONED THIS IS A COMMON OCCURRENCE ON THESE CARS. THE MALFUNCTION OF THIS SWITCH HAS MEANT THAT THE BRAKE LIGHTS DO NOT WORK CAUSING SOMEONE TO RUN INTO THE BACK OF MY CAR AS I WAS SLOWING IN TRAFFIC. THE SHIFT LEVER LOCK WILL NOT ENGAGE LEAVING THE KEYS UNABLE TO BE REMOVED AND THE SHIFTER …
Read full complaint
THE MULTI FUNCTION SWITCH HAS MALFUNCTIONED THIS IS A COMMON OCCURRENCE ON THESE CARS. THE MALFUNCTION OF THIS SWITCH HAS MEANT THAT THE BRAKE LIGHTS DO NOT WORK CAUSING SOMEONE TO RUN INTO THE BACK OF MY CAR AS I WAS SLOWING IN TRAFFIC. THE SHIFT LEVER LOCK WILL NOT ENGAGE LEAVING THE KEYS UNABLE TO BE REMOVED AND THE SHIFTER CAN BE MOVED OUT OF PARK WITHOUT THE BRAKE PEDAL BEING PRESSED. THE IGNITION SWITCH AND HARNESS MALFUNCTION CAUSING THE FAN TO NOT WORK IN ANYTHING BUT 5. LOOK AT THE MESSAGE BOARDS ALL THREE A COMMON OCCURRENCE AND WORSE GM KNOWS OF THESE PROBLEMS AND HAVE REFUSED TO ADDRESS THEM. *TR
NHTSA ODI #10606841
Mileage unknown · Jun 19, 2014
Electrical SystemSteering
I PURCHASED THIS VEHICLE FROM A LADY SHE WAS SELLING IT. A COUPLE WEEKS LATER I STARTED HAVING PROBLEMS WITH THE IGNITION. WHEN I TRY TO TURN MY CAR OFF BY TURNING THE KEY BACKWARDS IT GETS STUCK AND I HAVE TO SIT THERE ANDAND CONSTANTLY JIGGLE THE KEY UNTIL I'M ABLE TO GET IT TO RELEASE. THIS HAPPENS ABOUT ONCE A WEEK BUT SOMET…
Read full complaint
I PURCHASED THIS VEHICLE FROM A LADY SHE WAS SELLING IT. A COUPLE WEEKS LATER I STARTED HAVING PROBLEMS WITH THE IGNITION. WHEN I TRY TO TURN MY CAR OFF BY TURNING THE KEY BACKWARDS IT GETS STUCK AND I HAVE TO SIT THERE ANDAND CONSTANTLY JIGGLE THE KEY UNTIL I'M ABLE TO GET IT TO RELEASE. THIS HAPPENS ABOUT ONCE A WEEK BUT SOMETIMES TWICE A DAY THERE IS EVEN TIMES I CAN'T GET THE KEY OUT SO I'M FORCED TO LEAVE IT LIKE THAT REQUIRING A JUMP THE NEXT DAY. I JUST WANT TO KNOW IF MY CAR IS ON THE RECALL LIST FOR THE FAULTY IGNITION SWITCH. *TR
NHTSA ODI #10604580
160,000 miles · Jun 12, 2014
Engine
I BOUGHT THE CAR AUGUST 2013 AND IT SEEMS LIKE THE COOLING SYSTEM HAS THE ISSUES. THE ENGINE LIGHT AS WELL AS THE LOW COOLANT LIGHT HAVE ALWAYS BEEN ON EVEN THOUGH THERE WERE SUFFICIENT COOLANT. I SAW THERE WAS A RECALL REGARDING THE ISSUES BACK IN 2008 OR 2009. I CALLED THEM TODAY AND THEY TOLD ME THE RECALL HAS BEEN CLOSED. I …
Read full complaint
I BOUGHT THE CAR AUGUST 2013 AND IT SEEMS LIKE THE COOLING SYSTEM HAS THE ISSUES. THE ENGINE LIGHT AS WELL AS THE LOW COOLANT LIGHT HAVE ALWAYS BEEN ON EVEN THOUGH THERE WERE SUFFICIENT COOLANT. I SAW THERE WAS A RECALL REGARDING THE ISSUES BACK IN 2008 OR 2009. I CALLED THEM TODAY AND THEY TOLD ME THE RECALL HAS BEEN CLOSED. I CHECKED THE CAR FAX AND THERE WAS NO RECALLED DONE ON THIS CAR. EVERY TIME WHEN I AM DRIVING, I KEPT LOOKING AT THE ENGINE TEMPERATURE. EVERY TIME WHEN I AM DRIVING, I AM WORRY THERE WILL BE A BURNING SMELL. IT IS A SUCH METAL BURDEN FOR ME. I WISH I COULD BUY A NEWER CAR, BUT I AM A MEDICAL STUDENT AND I CANNOT AFFORD TOO MUCH FOR THE CAR. PLEASE LET ME KNOW IF THE RECALL IS STILL OPEN. *TR
NHTSA ODI #10597933
Mileage unknown · Jun 2, 2014
Engine
AS IM DRIVING THE VEHICLE STALLS AND TURNS OFF..THEN I HV TO PUT IT ON NEUTRO AND TURN IT BACK ON THEN IT TURNS ON LIKE IF NOTHING AND STOPS AGAIN. IT SHUTS DOWN WHILE IM DRIVING ON FREEWAY BUSY STREETS EVERYWHERE AND I ALMOST GOT HIT STRAIGHT ON CAUSE THE CAR JUST TURN OFF AND STOPPED IN THE MIDDLE OF INTERSECTION. *TR
NHTSA ODI #10595675
95,000 miles · May 22, 2014
Service Brakes
TL* THE CONTACT OWNS A 2002 PONTIAC GRAND PRIX. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 45 MPH AND ATTEMPTING TO STOP, THE BRAKES WERE DEPRESSED AND FAILED TO RESPOND. THE CONTACT DISCOVERED THAT THE LINER PANEL ABOVE THE BRAKE PEDAL HAD SAGGED MAKING CONTACT WITH THE BRAKE PEDAL AND CAUSING THE FAILURE. THE VEHICLE …
Read full complaint
TL* THE CONTACT OWNS A 2002 PONTIAC GRAND PRIX. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 45 MPH AND ATTEMPTING TO STOP, THE BRAKES WERE DEPRESSED AND FAILED TO RESPOND. THE CONTACT DISCOVERED THAT THE LINER PANEL ABOVE THE BRAKE PEDAL HAD SAGGED MAKING CONTACT WITH THE BRAKE PEDAL AND CAUSING THE FAILURE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND A DEALER WHERE BOTH WERE UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 95,000.
NHTSA ODI #10593539
144,995 miles · May 12, 2014
EngineFire
LAST MONDAY I WAS GOING TO THE BALL FIELD TO WATCH MY NEPHEW PRACTICE BASEBALL. I PULLED IN, SHUT MY CAR OFF AND WENT TO GET THE STROLLER OUT OF MY TRUNK FOR MY DAUGHTER. I STARTED TO SEE SMOKE, AND THEN I STARTED SMELLING IT ALSO. I HURRIED AND GOT MY DAUGHTER INTO THE STROLLER AND THEN SAW THE SMOKE STARTING TO GET HEAVIER. I …
Read full complaint
LAST MONDAY I WAS GOING TO THE BALL FIELD TO WATCH MY NEPHEW PRACTICE BASEBALL. I PULLED IN, SHUT MY CAR OFF AND WENT TO GET THE STROLLER OUT OF MY TRUNK FOR MY DAUGHTER. I STARTED TO SEE SMOKE, AND THEN I STARTED SMELLING IT ALSO. I HURRIED AND GOT MY DAUGHTER INTO THE STROLLER AND THEN SAW THE SMOKE STARTING TO GET HEAVIER. I POPPED MY HOOD AND OPENED IT AND IT WAS IN FLAMES. I TRIED TO GET WATER BUT I DIDN'T HAVE NONE. I THEN CALLED 911 AND THE FIRE SQUAD CAME AND PUT THE FIRE OUT. I HAD NO CLUE AT THE TIME WHY IN THE WORLD MY CAR CAUGHT ON FIRE I WAS JUST EXCITED THAT NEITHER MY DAUGHTER OR I WERE HARMED. UNFORTUNATELY I ONLY HAVE LIABILITY ON MY CAR SO THERE WAS NOTHING I COULD DO FOR IT. I DECIDED TO SEARCH GOOGLE THAT NIGHT AND SEE IF THIS HAD HAPPENED TO OTHERS BEFORE AND THERE I FOUND OUT THAT THERE HAD BEEN A RECALL ON MY CAR FOR ENGINE FIRES. I HAD NO CLUE THERE HAD BEEN A RECALL DONE IN 2009 FOR MY CAR. WAS WONDERING IF SOMEONE COULD HELP ME OUT WITH MY SITUATION. *TR
NHTSA ODI #10587781
Official recalls
3Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Mar 12, 2008
GM IS RECALLING 207,542 MY 1997-2003 BUICK REGAL AND PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L SUPERCHARGED V-6 ENGINE. THESE VEHICLES HAVE HIGHER FRONT ROCKER COVER GASKET TEMPERATURES, CREATING THE POTENTIAL FOR EARLIER DEGRADATION OF THE FRONT ROCKER COVER GASKET AND EVENTUAL OIL SEEPAGE.
Consequence & remedy
Consequence: CERTAIN UNDERHOOD FIRES MAY BE CAUSED BY DROPS OF ENGINE OIL, FROM SEEPAGE OR SPILLAGE, BEING DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING. IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND, IN SOME INSTANCES, THE FIRE MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, ALONG WITH THE 1-3-5 SPARK PLUG WIRE RETAINERS, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. , FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. UNTIL THE REMEDY IS COMPLETED, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS (1) THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CAR PORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE. THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL. OWNERS MAY CONTACT BUICK AT 1-866-608-8080 OR PONTIAC AT 1-800-620-7668, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA07008 · Engine Compartment Fire
Opened Jun 12, 2007 · Closed May 1, 2008
Status: closed (inferred from source dates) · Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Additional source detail variants (2)
Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
PE07006 · Engine Compartment Fire
Opened Jan 29, 2007 · Closed Jun 12, 2007
Status: closed (inferred from source dates) · Engine And Engine Cooling
ON JANUARY 29, 2007, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE ALLEGED NON-CRASH FIRES ORIGINATING IN THE ENGINE COMPARTMENT IN CERTAIN MODEL YEAR (MY) 1999-2002 PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE ?L67? SUPERCHARGED VERSION OF THE GENERAL MOTORS (GM) 3800 SERIES II V6 ENGINE.TO DATE, ODI IS AWARE OF 121 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES THAT ALLEGE NON-CRASH RELATED FIRES ORIGINATING IN THE ENGINE COMPARTMENT WHILE DRIVING OR AFTER THE VEHICLE IS PARKED AND THE IGNITION SWITCHED OFF. WHILE NO SUBJECT COMPONENT HAS YET BEEN IDENTIFIED, ODI ANALYSIS OF AVAILABLE INFORMATION INDICATES THAT THE ALLEGED FIRE INCIDENT RATE AMONG THE SUBJECT VEHICLES IS SIGNIFICANTLY HIGHER THAN GM PEER VEHICLES THAT USE THE NON-SUPERCHARGED ?L36? VERSION OF THE GM 3800 SERIES II V6 ENGINE.IN SOME CASES, THE FIRE INCIDENT RATE IS TWICE AS HIGH IN THE SUBJECT VEHICLES AND UP TO AS MUCH AS AN ORDER OF MAGNITUDE GREATER THAN IN NON-SUPERCHARGED PEER VEHICLES.FOR INSTANCE, THE SUBJECT FIRE INCIDENT RATE FOR THE SUPERCHARGED MY 2000 PONTIAC GRAND PRIX GTP IS APPROXIMATELY 236 PER 100,000 VEHICLES PRODUCED (58 FIRES / 24,509 SUBJECT VEHICLES OR 0.236%) WHILE THE FIRE INCIDENT RATE FOR MY 2000 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH THE NATURALLY ASPIRATED ?L36? ENGINE IS APPROXIMATELY 18 PER 100,000 VEHICLES PRODUCED (17 FIRES / 90,338 VEHICLES OR 0.018%). THE MANUFACTURER?S INVESTIGATION INTO ALLEGED ENGINE COMPARTMENT FIRES ON THE SUBJECT VEHICLES IS ONGOING.ACCORDINGLY, THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-008) TO FURTHER STUDY THE FREQUENCY AND SCOPE OF THE ALLEGED DEFECT. BASED ON THE INFORMATION REVIEWED IN PE07-006, THE RANGE OF SUBJECT VEHICLES UNDER INVESTIGATION WILL BE EXPANDED TO INCLUDE ALL MY 1999-2002 BUICK PARK AVENUE, REGAL, AND RIVIERA, OLDSMOBILE LSS, AND PONTIAC BONNEVILLE AND GRAND PRIX VEHICLES THAT USE THE SAME OR SUBSTANTIALLY SIMILAR TRANSVERSE MOUNTED ?L67? ENGINE.
PE07001 · Loss Of Brake Lamp Illumination
Opened Jan 17, 2007 · Closed Apr 30, 2007
Status: closed (inferred from source dates) · Electrical System; Exterior Lighting:brake Lights
THE AGENCY'S ANALYSIS OF GM'S COMPLAINT AND WARRANTY DATA FOR THE SUBJECT VEHICLES, INCLUDING A COMPARISON WITH OTHER AGENCY AND MANUFACTURER DATA PERTAINING TO OTHER VEHICLE BRAKE LAMP INVESTIGATIONS, INDICATED A LOW FAILURE HISTORY FOR THE SUBJECT VEHICLES.THIS INVESTIGATION INCLUDED A REVIEW AND ANALYSIS OF DATA FOR RELEVANT BRAKE LAMP MALFUNCTIONS THAT REQUIRE REPLACEMENT OF THE MULTIFUNCTION SWITCH (MFS) MODULE.THE HAZARD WARNING SWITCH IS AN INTEGRAL PART OF THE MFS MODULE.OTHER COMPONENTS THAT AFFECT BRAKE LAMP ILLUMINATION SUCH AS WIRING, BULB SOCKETS, AND THE PLUNGER-TYPE BRAKE LAMP SWITCH, WERE NOT A PART OF THIS INVESTIGATION.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY DEFECT DOES NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Electrical System
THE AGENCY'S ANALYSIS OF GM'S COMPLAINT AND WARRANTY DATA FOR THE SUBJECT VEHICLES, INCLUDING A COMPARISON WITH OTHER AGENCY AND MANUFACTURER DATA PERTAINING TO OTHER VEHICLE BRAKE LAMP INVESTIGATIONS, INDICATED A LOW FAILURE HISTORY FOR THE SUBJECT VEHICLES.THIS INVESTIGATION INCLUDED A REVIEW AND ANALYSIS OF DATA FOR RELEVANT BRAKE LAMP MALFUNCTIONS THAT REQUIRE REPLACEMENT OF THE MULTIFUNCTION SWITCH (MFS) MODULE.THE HAZARD WARNING SWITCH IS AN INTEGRAL PART OF THE MFS MODULE.OTHER COMPONENTS THAT AFFECT BRAKE LAMP ILLUMINATION SUCH AS WIRING, BULB SOCKETS, AND THE PLUNGER-TYPE BRAKE LAMP SWITCH, WERE NOT A PART OF THIS INVESTIGATION.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY DEFECT DOES NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:brake Lights
THE AGENCY'S ANALYSIS OF GM'S COMPLAINT AND WARRANTY DATA FOR THE SUBJECT VEHICLES, INCLUDING A COMPARISON WITH OTHER AGENCY AND MANUFACTURER DATA PERTAINING TO OTHER VEHICLE BRAKE LAMP INVESTIGATIONS, INDICATED A LOW FAILURE HISTORY FOR THE SUBJECT VEHICLES.THIS INVESTIGATION INCLUDED A REVIEW AND ANALYSIS OF DATA FOR RELEVANT BRAKE LAMP MALFUNCTIONS THAT REQUIRE REPLACEMENT OF THE MULTIFUNCTION SWITCH (MFS) MODULE.THE HAZARD WARNING SWITCH IS AN INTEGRAL PART OF THE MFS MODULE.OTHER COMPONENTS THAT AFFECT BRAKE LAMP ILLUMINATION SUCH AS WIRING, BULB SOCKETS, AND THE PLUNGER-TYPE BRAKE LAMP SWITCH, WERE NOT A PART OF THIS INVESTIGATION.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY DEFECT DOES NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Illustration