Illustration1997 GRAND PRIX FIRE IN ENGINE. *TR
1997 Pontiac Grand Prix
Owner reports · Recalls · Investigations
More warning signs than most Grand Prix years
Owner complaints for the 1997 Pontiac Grand Prix are substantially higher than the model-year median of 88.
About this comparison →How this year compares
Owner complaints by model year
Compare all Grand Prix years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 201 of 810 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 216 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 149 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 136 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
34 crash reports107 fire reports27 injury reports
What owners actually said
810 reportsTL*THE CONTACT OWNS A 1997 PONTIAC GRAND PRIX. WHEN PROCEEDING TO ENTER THE VEHICLE, THE CONTACT NOTICED SMOKE COMING FROM THE ENGINE COMPARTMENT. THE VEHICLE BECAME ENGULFED IN FLAMES. THE CONTACT EXTINGUISHED THE FIRE WITH A WATER HOSE AND CALLED THE FIRE DEPARTMENT. THE MANUFACTURER STATED THAT AN INVESTIGATOR WOULD COME …
Read full complaint
TL*THE CONTACT OWNS A 1997 PONTIAC GRAND PRIX. WHEN PROCEEDING TO ENTER THE VEHICLE, THE CONTACT NOTICED SMOKE COMING FROM THE ENGINE COMPARTMENT. THE VEHICLE BECAME ENGULFED IN FLAMES. THE CONTACT EXTINGUISHED THE FIRE WITH A WATER HOSE AND CALLED THE FIRE DEPARTMENT. THE MANUFACTURER STATED THAT AN INVESTIGATOR WOULD COME OUT AND INSPECT THE VEHICLE. THE VEHICLE WAS INSPECTED AND THE CONTACT WAS OFFERED A SETTLEMENT OF $11,080. HE WAS NOT INFORMED OF WHAT CAUSED THE FIRE AND REJECTED THE OFFER BECAUSE THE SETTLEMENT WAS NOT ENOUGH TO REPAIR THE VEHICLE. HE THEN FILED A CLAIM WITH THE ATTORNEY GENERAL. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 162,000.
1997 PONTIAC GRAND PRIX RECALL ID NHTSA: 08V118000. I HAD THIS REPAIR DONE AS REQUESTED. BUT MY COMPLAINT TO THE DEALER WAS THAT IF THE FRONT ONE IS FAILING, PUTTING OIL ON THE MANIFOLD TO CAUSE A FIRE. THEN WHY ARE THEY NOT REPLACING THE BACK ONE? MY GTP IS LEAKING OIL FROM THE BACK GASKET, DRIPPING ON THE PLUGS, WIRES AS W…
Read full complaint
1997 PONTIAC GRAND PRIX RECALL ID NHTSA: 08V118000. I HAD THIS REPAIR DONE AS REQUESTED. BUT MY COMPLAINT TO THE DEALER WAS THAT IF THE FRONT ONE IS FAILING, PUTTING OIL ON THE MANIFOLD TO CAUSE A FIRE. THEN WHY ARE THEY NOT REPLACING THE BACK ONE? MY GTP IS LEAKING OIL FROM THE BACK GASKET, DRIPPING ON THE PLUGS, WIRES AS WELL AND IS DRIPPING ON THE MANIFOLD AND EXHAUST PIPE. IT ALSO IS SMOKING AND HAS A BURNING OIL SMELL. WHY WERE THEY BOTH NOT REPLACED? *TR
FIRST OF ALL I LOVE MY GRAND PRIX. I HAVE HAD BOTH BOTH HEAD LIGHT LENS FALL OFF WITHIN A MONTH OF ONE ANOTHER. YOU CANT PURCHEASE THE LENS YOU NEED TO BUY THE WHOLE UNIT FORM PONTIAC. REPLACED MY SELF EACH UNIT WAS ABOUT $100. GEAR SHIFT LOCKED UP IN GARAGE WAS ABOUT $350 PLUS A TOW. ELECTRICAL ISSUES WITH BLOWER MOTOR WOR…
Read full complaint
FIRST OF ALL I LOVE MY GRAND PRIX. I HAVE HAD BOTH BOTH HEAD LIGHT LENS FALL OFF WITHIN A MONTH OF ONE ANOTHER. YOU CANT PURCHEASE THE LENS YOU NEED TO BUY THE WHOLE UNIT FORM PONTIAC. REPLACED MY SELF EACH UNIT WAS ABOUT $100. GEAR SHIFT LOCKED UP IN GARAGE WAS ABOUT $350 PLUS A TOW. ELECTRICAL ISSUES WITH BLOWER MOTOR WORKS ON 5 ONLY. LIGHTS WILL ONLY WORK WHEN BLOWER MOTOR IS OFF OR ON 5. REPLACED BLOWER RESISTOR AND DID NOT HELP. 2 ELECTRCAL WIDOW PROBLEMS. ALTERANTOR PROBLEM APPROX $350 NORMAL WITH GM. ALL ISSUES UNDER 80,000 MILES. IT APPEARS MOST PEOPLE HAVE HAD THE SAME ISSUES. VERY DISAPOINTED GM DOES NOT MAKE IT RIGHT WITH LOYAL GM OWNERS. THE FIRE ISSUE IS VERY CONCERNING I WILL BE TAKING MY GT TO DEALER SOON. *TR
I HAVE A 1997 GRAND PRIX GT N/A 3800 ENGINE WITH ENGINE OIL LEAKING FROM THE FRONT ROCKER PANEL GASKET HOWEVER THE RECALL ONLY COVERS THE S/C'D VERSION OF THIS VEHICLE THERE IS ENGINE OIL SITTING ON THE TOP OF THE MOTOR, ALSO THERE IS OIL BUILT UP ALL THE WAY DOWN THE ONE SIDE OF THE ENGINE COMING FROM THIS LOCATION I AM CONCERN…
Read full complaint
I HAVE A 1997 GRAND PRIX GT N/A 3800 ENGINE WITH ENGINE OIL LEAKING FROM THE FRONT ROCKER PANEL GASKET HOWEVER THE RECALL ONLY COVERS THE S/C'D VERSION OF THIS VEHICLE THERE IS ENGINE OIL SITTING ON THE TOP OF THE MOTOR, ALSO THERE IS OIL BUILT UP ALL THE WAY DOWN THE ONE SIDE OF THE ENGINE COMING FROM THIS LOCATION I AM CONCERNED THAT THERE WILL BE AN ENGINE FIRE WITH THIS LEAKING OIL. *TR
I HAD PARKED MY CAR OUTSIDE MY PARENTS' HOME AND I WAS INSIDE WHEN IT CAUGHT FIRE. SOMEONE CAME AND TOLD ME THAT MY CAR WAS ON FIRE. IT WAS COMPLETELY BURNED UP BEFORE THE FIRE DEPARTMENT ARRIVED. MY 1997 GRAND PRIX WAS A TOTAL LOSS. I HAD NOT HAD ANY TROUBLE WITH IT, I HAD IT SERVICED REGULARLY. IT JUST CAUGHT FIRE SPONTAN…
Read full complaint
I HAD PARKED MY CAR OUTSIDE MY PARENTS' HOME AND I WAS INSIDE WHEN IT CAUGHT FIRE. SOMEONE CAME AND TOLD ME THAT MY CAR WAS ON FIRE. IT WAS COMPLETELY BURNED UP BEFORE THE FIRE DEPARTMENT ARRIVED. MY 1997 GRAND PRIX WAS A TOTAL LOSS. I HAD NOT HAD ANY TROUBLE WITH IT, I HAD IT SERVICED REGULARLY. IT JUST CAUGHT FIRE SPONTANEOUSLY. I HAVE PREVIOUSLY REPORTED THIS INCIDENT TO YOU AND I HAVE JUST READ ON MSNBC THAT GM IS NOW IN THE PROCESS OF A RECALL ON THIS VEHICLE. *TR
TL*THE CONTACT OWNS A 1997 PONTIAC GRAND PRIX. WHILE DRIVING VARIOUS SPEEDS, THE HEADLIGHTS WOULD SPORADICALLY FAIL. THE CONTACT'S VISIBILITY WAS GREATLY REDUCED DUE TO THE FAILURE. THE DEALER REPLACED THE WIRING HARNESS. FOUR YEARS LATER, THE FAILURE RECURRED. HE TOOK THE VEHICLE BACK TO THE DEALER AND THEY REPLACED THE WI…
Read full complaint
TL*THE CONTACT OWNS A 1997 PONTIAC GRAND PRIX. WHILE DRIVING VARIOUS SPEEDS, THE HEADLIGHTS WOULD SPORADICALLY FAIL. THE CONTACT'S VISIBILITY WAS GREATLY REDUCED DUE TO THE FAILURE. THE DEALER REPLACED THE WIRING HARNESS. FOUR YEARS LATER, THE FAILURE RECURRED. HE TOOK THE VEHICLE BACK TO THE DEALER AND THEY REPLACED THE WIRING HARNESS AND OTHER ASSOCIATED PARTS AT THE COST OF $852.12. THE FAILURE MILEAGE WAS 95,000 AND CURRENT MILEAGE WAS 156,000.
WHEN USING WIPERS, WIPER WOULD STOP WORKING AND WOULD STOP IN THE MIDDLE OF THE WINDSHIELD MAKING IT DIFFICULT TO SEE WHEN DRIVING IN THE RAIN, HAD TO PULL OVER AND PUSH WIPERS DOWN MANUALLY BECAUSE WIPERS WOULD NOT GO BACK DOWN TO NORMAL POSITION I HAD TO DRIVE WITH NO WIPERS, ALMOST CAUSING AN ACCIDENT. THIS WAS HAPPENING FOR …
Read full complaint
WHEN USING WIPERS, WIPER WOULD STOP WORKING AND WOULD STOP IN THE MIDDLE OF THE WINDSHIELD MAKING IT DIFFICULT TO SEE WHEN DRIVING IN THE RAIN, HAD TO PULL OVER AND PUSH WIPERS DOWN MANUALLY BECAUSE WIPERS WOULD NOT GO BACK DOWN TO NORMAL POSITION I HAD TO DRIVE WITH NO WIPERS, ALMOST CAUSING AN ACCIDENT. THIS WAS HAPPENING FOR ABOUT 7 MONTHS NOW WIPERS DON'T WANT TO WORK AT ALL. CALLED GM RECALL NUMBER AND EXPLAINED WHAT HAPPENED AND WAS TOLD MY 1997 GRAND PRIX WAS NOT ON THE RECALL LIST. *TR
I DROVE MY CAR TO WORK AND PARKED IT IN A PRIVATE LOT. I WENT INTO WORK AND ATTENDED TO MY JOB FOR ABOUT 30 MINUTES. AFTER 30 MINUTES, A FRIEND INFORMED ME THAT MY CAR HAD CAUGHT ON FIRE IN THE PARKING LOT. I WENT OUTSIDE TO SEE FOR MYSELF, AND I FOUND THAT THE FIRE DEPARTMENT HAD ALREADY ARRIVED AND WERE EXTINGUISHING THE FI…
Read full complaint
I DROVE MY CAR TO WORK AND PARKED IT IN A PRIVATE LOT. I WENT INTO WORK AND ATTENDED TO MY JOB FOR ABOUT 30 MINUTES. AFTER 30 MINUTES, A FRIEND INFORMED ME THAT MY CAR HAD CAUGHT ON FIRE IN THE PARKING LOT. I WENT OUTSIDE TO SEE FOR MYSELF, AND I FOUND THAT THE FIRE DEPARTMENT HAD ALREADY ARRIVED AND WERE EXTINGUISHING THE FIRE. THERE WAS NO WARNING OR SIGNS OF A FIRE BEFORE I LEFT MY CAR TO GO INTO WORK, AND I STILL DO NOT KNOW HOW IT STARTED. AS A CONSEQUENCE OF THIS ENGINE FIRE, THE CAR WAS A TOTAL LOSS. THE FIRE WAS CONTAINED TO THE ENGINE COMPARTMENT, BUT IT TOTALLY DESTROYED THE ENGINE ITSELF. I REPORTED THE INCIDENT TO MY INSURANCE COMPANY AND THE CLAIM IS STILL BEING PROCESSED. *TR
MY 1997 PONTIAC GRAND PRIX GT 3.8LITER NOT SUPERCHARGED CAUGHT FIRE AND WHEN WE TRIED TO GET PARTS THE JUNK YARD HAD 2 THEY ALSO HAD CAUGHT FIRE GM DID A RECALL ON SUPER CHARGED NOT REGULAR 3.8 LITERS CARS! *TR
Official recalls
515V701000 · Engine And Engine Cooling:engine; Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
09V116000 · Engine And Engine Cooling
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
08V118000 · Engine And Engine Cooling
Mar 12, 2008
GM IS RECALLING 207,542 MY 1997-2003 BUICK REGAL AND PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L SUPERCHARGED V-6 ENGINE. THESE VEHICLES HAVE HIGHER FRONT ROCKER COVER GASKET TEMPERATURES, CREATING THE POTENTIAL FOR EARLIER DEGRADATION OF THE FRONT ROCKER COVER GASKET AND EVENTUAL OIL SEEPAGE.
Consequence & remedy
Consequence: CERTAIN UNDERHOOD FIRES MAY BE CAUSED BY DROPS OF ENGINE OIL, FROM SEEPAGE OR SPILLAGE, BEING DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING. IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND, IN SOME INSTANCES, THE FIRE MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, ALONG WITH THE 1-3-5 SPARK PLUG WIRE RETAINERS, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. , FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. UNTIL THE REMEDY IS COMPLETED, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS (1) THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CAR PORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE. THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL. OWNERS MAY CONTACT BUICK AT 1-866-608-8080 OR PONTIAC AT 1-800-620-7668, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
02V286000 · Steering:rack And Pinion
Nov 4, 2002
CERTAIN PASSENGER VEHICLES AND MINI VANS HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE AND SOME OTHER RETAINERS USED IN VEHICLES ASSEMBLED BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997, COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN JANUARY 24, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
99V348000 · Visibility:windshield Wiper/washer:linkages
Dec 16, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE WINDSHIELD WIPERS MAY STOP WORKING DUE TO A SEPARATION BETWEEN THE DRIVE PIN AND CRESCENT IN THE CRANK ARM ASSEMBLY.
Consequence & remedy
Consequence: DRIVER VISIBILITY COULD BE REDUCED, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THESE VEHICLES FOR THE PRESENCE OF A PLASTIC WATER DEFLECTOR AND, IF NECESSARY, REPLACE THE WIPER MOTOR CRANK ARM AND INSTALL A WATER DEFLECTOR. ON VEHICLES RECEIVING A REPLACEMENT CRANK ARM AND NEW WATER DEFLECTOR, DEALERS WILL ALSO APPLY ADDITIONAL SEALING MATERIAL TO IMPROVE WATER DEFLECTION AWAY FROM THE CRANK ARM ASSEMBLY AND WILL INSTALL A REINFORCEMENT TO IMPROVE THE PERFORMANCE OF THE WIPER PARK MECHANISM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
7EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE02050 · Engine Compartment Fires
Opened Jun 13, 2002 · Closed Oct 22, 2002
Status: closed (inferred from source dates) · Engine And Engine Cooling
No summary supplied.
EA02003 · Power Rack And Pinion Steering Failure
Opened Apr 4, 2002 · Closed Dec 10, 2002
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
THE LOWER PINION BEARING IN THE RACK AND PINION STEERING ASSEMBLY MAY FAIL.GM WILL RECALL 1997-98 GRAND PRIX BUILT BETWEEN 1-MAR-96 AND 31-OCT-97; AND 1996-98 U-VANS/J-CARS BUILT BETWEEN 1-JAN-96 AND 31-OCT-97.SEE ATTACHED SUMMARY.
Additional source detail variants (2)
Steering
THE LOWER PINION BEARING IN THE RACK AND PINION STEERING ASSEMBLY MAY FAIL.GM WILL RECALL 1997-98 GRAND PRIX BUILT BETWEEN 1-MAR-96 AND 31-OCT-97; AND 1996-98 U-VANS/J-CARS BUILT BETWEEN 1-JAN-96 AND 31-OCT-97.SEE ATTACHED SUMMARY.
Steering:rack And Pinion
THE LOWER PINION BEARING IN THE RACK AND PINION STEERING ASSEMBLY MAY FAIL.GM WILL RECALL 1997-98 GRAND PRIX BUILT BETWEEN 1-MAR-96 AND 31-OCT-97; AND 1996-98 U-VANS/J-CARS BUILT BETWEEN 1-JAN-96 AND 31-OCT-97.SEE ATTACHED SUMMARY.
PE01038 · Steering Rack And Pinion
Opened Nov 14, 2001 · Closed Apr 4, 2002
Status: closed (inferred from source dates) · Steering
ODI HAS RECEIVED 200 COMPLAINTS FROMT CONSUMERS AND 1,238 FROM GM ALLEGING FAILURE OR LOCKUP OF THE STEERING RACK AND PINION UNIT (R&P).THIS ALLEGED CONDITION CAN RESULT IN THE LOSS OF STEERING CONTROL OF THE VEHICLE AND A CRASH CAN RESULT.GM HAS REPORTED SIX CRASHES IN WHICH EIGHT PEOPLE HAVE SUSTAINED INJURIES RANGING FROM BRUISES, AIRBAG BURN, SEAT BELT ABRASION, FACIAL INJURY, NECK AND BACK PAIN.ALL CRASHES WERE SINGLE VEHICLE CRASHES.GM STATES THAT ONE POSSIBLE FAILURE MODE IS FAILURE OF THE LOWER PINION BEARING IN THE R&P.AN ENGINEERING ANALYSIS HAS BEEN OPENED TO DETERMINE IF A SAFETY DEFECT TREND EXISTS.
EA99024 · Windshield Wiper
Opened Aug 20, 1999 · Closed Jan 13, 2000
Status: closed (inferred from source dates) · Visibility
BY LETTER DATED DECEMBER 12, 1999, GM NOTIFIED NHTSA OF ITS PLANS TO CONDUCT A SAFETY RELATED DEFECT CAMPAIGN TO REMEDY 155,149 OF THE SUBJECT VEHICLES.THE VEHICLE POPULATION FOR THE CAMPAIGN INCLUDES THE 1997 BUICK REGAL/CENTURY AND PONTIAC GRAN PRIX MODELS BUILT DURING THE PERIOD FROM THE START OF PRODUCTION THROUGH MAY 1, 1997.GM DETERMINED THAT THE WIPERS INSTALLED PRIOR TO THIS DATE COULD STOP WORKING, USUALLY DURING HEAVY LOAD CONDITIONS, DUE TO SEPARATION BETWEEN THE DRIVE PIN AND THE CRESCENT IN THE WIPER CRANK ARM ASSEMBLY.EFFECTIVE MAY 1, 1997,GM CORRECTED THIS PROBLEM IN PRODUCTION BY MODIFYING THE DRIVE PIN AND STRENGTHENING THE CRESCENT.THESE SAME IMPROVED PARTS WILL BE INSTALLED IN THE VEHICLES TO BE RECALLED.THE SCOPE OF THE CAMPAIGN WILL INCLUDE ALL VEHICLES PRODUCED PRIOR TO THE MAY 1, 1997 CORRECTION (THE OLDSMOBILE INTRIQUE PRODUCTION DID NOT START UNTIL AFTER MAY 1, 1997, AND IS THEREFORE NOT INCLUDED).VEHICLES WITH THE SCOPE OF THIS INVESTIGATION AND PRODUCED AFTER MAY 1, 1997, CONTAIN THE MORE ROBUST CRESCENT AND IMPROVED PIN DESIGN AND ARE NOT INCLUDED IN THE RECALL CAMPAIGN.ODI WILL CONTINUE TO MONITOR COMPLAINT REPORTS ON THE VEHICLES PRODUCED AFTER MAY 1, 1997 AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.BASED ON GM'S RECALL ACTION (ODI 99V-348) THIS INVESTIGATION IS CLOSED.
PE99028 · Windshield Wiper
Opened Apr 16, 1999 · Closed Aug 20, 1999
Status: closed (inferred from source dates) · Visibility
INCIDENTS OF WIPER FAILURE (OWNER REPORTS AND WARRANTY) ARE VERY HIGH, AND MANY OF THE REPORTS INDICATE THAT THE FAILURES ARE STILL OCCURRING IN 1999.
RQ98013 · Oversensitive Air Bag Deployments
Opened Aug 26, 1998 · No close date supplied
Status: open (inferred from source dates) · Air Bags
ON JUNE 26, 1998, GENERAL MOTORS BEGAIN A SAFETY RECALL, 98V-146, TO RECALIBRATE THE AIR BAG SENSING AND DIAGNOSTIC MODULE (SDM) IN THE 1996 AND SOME 1997 J BODY CARS, CAVALIER AND SUNFIRE.DUE TO CERTAIN CALIBRATIONS IN THE AIR BAG SDM, THERE IS AN INCREASED RISK OF INADVERTENT AIR BAG DEPLOYMENT IN A LOW SPEED CRASH OR WHEN AN OBJECT STRIKES THE FLOOR PAN.THE RECALL POPULATION CONSISTS OF 675,302 VEHICLES BUILT FROM APRIL 1995 THROUGH MAY 1997.ODI HAS RECEIVED 8 OWNER REPORTS ALLEGING INADVERTENT AIR BAG DEPLOYMENT WITHOUT A CRASH.THE PURPOSER OF THE RQ IS TO DETERMINE WHETHER GM SHOULD EXPAND THE RECALL TO INCLUDE THESE VEHICLES.CLOSING RESUME NOTE:AS OF AUGUST 5, 1999, ODI RECEIVED ONE ADDITIONAL COMPLAINT REGARDING THE ALLEGED DEFECT.THE INCIDENT RATES FOR THE SUBJECT VEHICLES ARE ABOUT ONE-THRID OF THE RATES OF THE RECALLED VEHICLES (WHEN THE RECALL WAS INITIATED).BASED ON THE AVAILABLE INFORMATION, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOSE NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY FUTURE CIRCUMSTANCES.