NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes, Hydraulic complaints
42 reportsClear category filter52,300 miles · Jan 4, 2016
Electrical SystemService Brakes, Hydraulic
TL* THE CONTACT OWNS A 1997 PONTIAC GRAND PRIX. THE CONTACT STATED THAT WHILE DRIVING 70 MPH, WHEN THE HEATING SYSTEM WAS ACTIVATED, THE CONTACT NOTICED THAT THE HEAD LIGHTS FAILED WITHOUT WARNING. THE CONTACT ALSO NOTICED THAT THE INFORMATION SYSTEM IN THE DASHBOARD WOULD FAIL WHEN THE HEAT WAS ACTIVATED. IN ADDITION, THE CONTA…
Read full complaint
TL* THE CONTACT OWNS A 1997 PONTIAC GRAND PRIX. THE CONTACT STATED THAT WHILE DRIVING 70 MPH, WHEN THE HEATING SYSTEM WAS ACTIVATED, THE CONTACT NOTICED THAT THE HEAD LIGHTS FAILED WITHOUT WARNING. THE CONTACT ALSO NOTICED THAT THE INFORMATION SYSTEM IN THE DASHBOARD WOULD FAIL WHEN THE HEAT WAS ACTIVATED. IN ADDITION, THE CONTACT STATED THAT THE ABS WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC BUT WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT STATED THAT THE FAILURE RECURRED. IT WAS UNKNOWN IF THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 52,300. UPDATED 04/08/16*LJ THE CONSUMER STATED THE BRAKE MODULE NEEDS TO BE REPLACED. UPDATED 05/16/16.*JB
NHTSA ODI #10817591
Mileage unknown · Jan 24, 2004
Air BagsElectrical SystemEngine And Engine Cooling
MOST RECENT COMPLAINT IS, HEATED DRIVER SEAT GETS TOO HOT AND MAKES IT HARD TO STAY SEATED. HEATER BLOWER QUIT WORKING. HAVE HAD TO REPLACE THE ALTERNATOR EVERY 3RD YEAR (3 TIMES). HAVE HAD OIL PAN GASKET AND VALVE COVER LEAKAGE. POWER STEERING FAILED TO MAKE LEFT HAND TURNS. HEADLIGHTS CONTINUE TO HAVE POOR RANGE AND VISI…
Read full complaint
MOST RECENT COMPLAINT IS, HEATED DRIVER SEAT GETS TOO HOT AND MAKES IT HARD TO STAY SEATED. HEATER BLOWER QUIT WORKING. HAVE HAD TO REPLACE THE ALTERNATOR EVERY 3RD YEAR (3 TIMES). HAVE HAD OIL PAN GASKET AND VALVE COVER LEAKAGE. POWER STEERING FAILED TO MAKE LEFT HAND TURNS. HEADLIGHTS CONTINUE TO HAVE POOR RANGE AND VISIBILITY EVEN WITH BULB REPLACEMENT. CAR LURCHES FORWARD WHEN STARTING UP ENGINE. OUTSIDE TEMPERATURE DISPLAY KEEPS WRONG TEMPERATURE. A.M. RADIO WOULD NOT WORK. WATER PUMP HAD TO BE REPLACED. ABS LIGHT STAYED ON. AIR BAG LIGHT CAME ON WHEN GOING OVER BUMPS IN ROAD. *LA
NHTSA ODI #10054801
80,000 miles · Jan 15, 2004
Engine And Engine CoolingPower TrainService Brakes, Hydraulic
THIS IS THE WORST AUTOMOBILE I HAVE EVER OWNED. IT IS NICKEL AND DIMING ME TO DEATH. BOTH BACK WINDOWS ARE BEING HELD UP IN PLACE BY STICKS THAT I HAVE PROPED UNDER THEM. THE FRONT PASSENGER WINDOW I PAID $300 TO HAVE REPAIRED. THE STEERING LOCKED UP ON ME AND I HAD TO DISH OUT $500 TO GET THAT REPAIRED, GM RECALLED IT A COUPLE …
Read full complaint
THIS IS THE WORST AUTOMOBILE I HAVE EVER OWNED. IT IS NICKEL AND DIMING ME TO DEATH. BOTH BACK WINDOWS ARE BEING HELD UP IN PLACE BY STICKS THAT I HAVE PROPED UNDER THEM. THE FRONT PASSENGER WINDOW I PAID $300 TO HAVE REPAIRED. THE STEERING LOCKED UP ON ME AND I HAD TO DISH OUT $500 TO GET THAT REPAIRED, GM RECALLED IT A COUPLE OF WEEKS AFTER THAT, THANK GOD I GOT SOME OF MY MONEY BACK FOR THAT REPAIR. THE PASSENGERS SIDE HEAD LIGHT LENS COVER FELL OFF $75 TO REPLACE THAT. I AM PRESENTLY WORKING ON THE BRAKE TRANSMISSION SHIFT INDICATOR WHICH I JUST CALLED THE DEALER FOR A PRICE ON THE PART AND AM TOLD IT WILL BE $224.07 FOR THE PART AND PROBABLY $115 FOR THE LABOR. THE ENGINE LEAKS OIL I HAD MY WIFE TAKE IT TO THE SHOP FOR THEM TO TAKE A LOOK AT AND THEY TOLD HER THAT NO LEAKS WERE EVIDENT. WELL THE OIL IN MY DRIVEWAY IS COMING FROM SOMEWHERE. I WILL NEVER OWN ANOTHER GM PRODUCT IN MY LIFE AGAIN. NOT EVEN IF IT IS GIVEN TO ME AND 10,000 TO USE TOWARD THE REPAIRS OF IT.
NHTSA ODI #10070584
50,431 miles · Sep 14, 2003
Engine And Engine CoolingEquipmentExterior Lighting
EGR VALVE MADE OF CHEAP PLASTIC. HEADLIGHT LENS FALLING OFF CAR. FAULTY HYDRAULIC MODULATOR AND EXHAUST SYSTEM. *PH
NHTSA ODI #10038853
Mileage unknown · Jun 26, 2003
Electrical SystemSeatsService Brakes, Hydraulic
THE STEERING WHEEL FAILED TO TURN TO THE LEFT, INSTEAD IT TURNED COMPLETELY AROUND. *JB. ALSO THE VEHICLE EXPERIENCED PROBLEMS WITH THE ALTERNATOR, RACK AND PINION, BRAKES, SEATS, WINDOWS, BATTERY, BULBS, STEERING PUMP, AND THE SUN ROOF LEAKED. PH *JB
NHTSA ODI #10014880
35,000 miles · Jun 10, 2003
Service Brakes, Hydraulic
ABOUT 1 OUT OF 50 TIMES APPLYING BRAKES, THE ABS SYSTEM ACTIVATES THE ABS MOTORS ON THE MASTER BRAKE CYLINDER, CAUSING A BRIEF (1/2 TO 1 SECOND) LOSS OF BRAKES. ADDITIONAL BRAKE PEDALIS NOT EFFECTIVE DURING THIS TIME. CLICKING NOISE FROM ABS MOTORS AND BRAKE MASTER CYLINDER. ABLE TO REPRODUCE THE ABS MOTORS ACTIVATING FOR 1/2 T…
Read full complaint
ABOUT 1 OUT OF 50 TIMES APPLYING BRAKES, THE ABS SYSTEM ACTIVATES THE ABS MOTORS ON THE MASTER BRAKE CYLINDER, CAUSING A BRIEF (1/2 TO 1 SECOND) LOSS OF BRAKES. ADDITIONAL BRAKE PEDALIS NOT EFFECTIVE DURING THIS TIME. CLICKING NOISE FROM ABS MOTORS AND BRAKE MASTER CYLINDER. ABLE TO REPRODUCE THE ABS MOTORS ACTIVATING FOR 1/2 TO 1 SECOND BY: WITH KEY OFF, APPLY BRAKE, START ENGINE, RELEASE BRAKE. WHEN BRAKE LIGHTS TURN OFF, ABS MOTORS RUN FOR 1/2 TO 1 SECOND. UNABLE TO DEPRESS BRAKE PEDAL DURING THIS TIME.REMOVING ABS FUSE PREVENTS PROBLEM FROM OCCURRING, BUT THE ABS LIGHT IS ON.*AK
NHTSA ODI #10021378
Mileage unknown · Jan 30, 2002
Electrical SystemEngine And Engine CoolingService Brakes, Hydraulic
ENGINE COMPLETELY SHUT OFF WHILE DRIVING, STEERING COLUMN LOCKS, BRAKES BARELY FUNCTIONED. ALTERNATOR REPLACED TWICE. DIAGNOSED WITH SAME PROBLEM. ONCE IN JULY 2001, AGAIN IN AUGUST 2001. SERVICE ENGINE LIGHT COMES ON AGAIN. DRIVES OK NOW, BUT WORRIED IT WILL CONTINUE TO GIVE ME PROBLEMS. IN AND OUT OF SHOP 4 TIMES IN PAST …
Read full complaint
ENGINE COMPLETELY SHUT OFF WHILE DRIVING, STEERING COLUMN LOCKS, BRAKES BARELY FUNCTIONED. ALTERNATOR REPLACED TWICE. DIAGNOSED WITH SAME PROBLEM. ONCE IN JULY 2001, AGAIN IN AUGUST 2001. SERVICE ENGINE LIGHT COMES ON AGAIN. DRIVES OK NOW, BUT WORRIED IT WILL CONTINUE TO GIVE ME PROBLEMS. IN AND OUT OF SHOP 4 TIMES IN PAST YEAR FOR SAME PROBLEM. BACK IN SHOP TODAY FOR WHO KNOWS WHAT.
NHTSA ODI #757539
Mileage unknown · Jan 12, 2002
Power TrainService Brakes, Hydraulic
WHEN DRIVING OVER BUMPS SUCH AS SMALL POTHOLES OR RAILROAD TRACKS, SOMETIMES THE ABS AND LOW TRACTION LIGHTS COME ON. USUALLY THEY GO OFF. SOMETIMES THEY DON'T. ONLY METHOD TO TURN THE LIGHTS OFF ARE TO PULL OF THE ROAD OR HIGHWAY AND TURN THE ENGINE OFF. ADDITONALLY, SOMETIMES WHEN BRAKING OVER POTHOLES / RAILROAD TRACKS, T…
Read full complaint
WHEN DRIVING OVER BUMPS SUCH AS SMALL POTHOLES OR RAILROAD TRACKS, SOMETIMES THE ABS AND LOW TRACTION LIGHTS COME ON. USUALLY THEY GO OFF. SOMETIMES THEY DON'T. ONLY METHOD TO TURN THE LIGHTS OFF ARE TO PULL OF THE ROAD OR HIGHWAY AND TURN THE ENGINE OFF. ADDITONALLY, SOMETIMES WHEN BRAKING OVER POTHOLES / RAILROAD TRACKS, THE ABS ENGAGE AND THE CLICKING STARTS. FORTUNATELY, DUE TO MY CAREFUL DRIVING, I GIVE MYSELF PLENTY OF ROOM AND DON'T NEED TO PRESS HARDER TO PREVENT A COLLISION. ALSO, SOMETIMES WITH THE LOW TRACTION LIGHT COMING ON, THE ENGINE / TRANSMISSION WILL REV UP AND ENGAGE THE OTHER FRONT TIRE, WHICH IS COMPLETELY USELESS WHEN CONDITIONS ARE DRY AND NORMAL.*AK
NHTSA ODI #756771
Mileage unknown · Jan 12, 2002
Service Brakes, Hydraulic
WHEN DRIVING IN RAIN AT HIGH SPEEDS, BRAKES TAKE SOME TIME TO DRY OFF AND BEGIN TO BECOME EFFECTIVE. DRIVER MUST BE AWARE OF THIS AND ALLOW EXTRA STOPPING ROOM FOR WET BRAKES. *AK
NHTSA ODI #756761
Mileage unknown · Jan 3, 2002
Service Brakes, HydraulicSteeringCrashInjury
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
NHTSA ODI #756340
Official recalls
5Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Mar 12, 2008
GM IS RECALLING 207,542 MY 1997-2003 BUICK REGAL AND PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L SUPERCHARGED V-6 ENGINE. THESE VEHICLES HAVE HIGHER FRONT ROCKER COVER GASKET TEMPERATURES, CREATING THE POTENTIAL FOR EARLIER DEGRADATION OF THE FRONT ROCKER COVER GASKET AND EVENTUAL OIL SEEPAGE.
Consequence & remedy
Consequence: CERTAIN UNDERHOOD FIRES MAY BE CAUSED BY DROPS OF ENGINE OIL, FROM SEEPAGE OR SPILLAGE, BEING DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING. IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND, IN SOME INSTANCES, THE FIRE MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, ALONG WITH THE 1-3-5 SPARK PLUG WIRE RETAINERS, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. , FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. UNTIL THE REMEDY IS COMPLETED, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS (1) THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CAR PORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE. THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL. OWNERS MAY CONTACT BUICK AT 1-866-608-8080 OR PONTIAC AT 1-800-620-7668, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Nov 4, 2002
CERTAIN PASSENGER VEHICLES AND MINI VANS HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE AND SOME OTHER RETAINERS USED IN VEHICLES ASSEMBLED BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997, COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN JANUARY 24, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
Dec 16, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE WINDSHIELD WIPERS MAY STOP WORKING DUE TO A SEPARATION BETWEEN THE DRIVE PIN AND CRESCENT IN THE CRANK ARM ASSEMBLY.
Consequence & remedy
Consequence: DRIVER VISIBILITY COULD BE REDUCED, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THESE VEHICLES FOR THE PRESENCE OF A PLASTIC WATER DEFLECTOR AND, IF NECESSARY, REPLACE THE WIPER MOTOR CRANK ARM AND INSTALL A WATER DEFLECTOR. ON VEHICLES RECEIVING A REPLACEMENT CRANK ARM AND NEW WATER DEFLECTOR, DEALERS WILL ALSO APPLY ADDITIONAL SEALING MATERIAL TO IMPROVE WATER DEFLECTION AWAY FROM THE CRANK ARM ASSEMBLY AND WILL INSTALL A REINFORCEMENT TO IMPROVE THE PERFORMANCE OF THE WIPER PARK MECHANISM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
7EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE02050 · Engine Compartment Fires
Opened Jun 13, 2002 · Closed Oct 22, 2002
Status: closed (inferred from source dates) · Engine And Engine Cooling
No summary supplied.
EA02003 · Power Rack And Pinion Steering Failure
Opened Apr 4, 2002 · Closed Dec 10, 2002
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
THE LOWER PINION BEARING IN THE RACK AND PINION STEERING ASSEMBLY MAY FAIL.GM WILL RECALL 1997-98 GRAND PRIX BUILT BETWEEN 1-MAR-96 AND 31-OCT-97; AND 1996-98 U-VANS/J-CARS BUILT BETWEEN 1-JAN-96 AND 31-OCT-97.SEE ATTACHED SUMMARY.
Additional source detail variants (2)
Steering
THE LOWER PINION BEARING IN THE RACK AND PINION STEERING ASSEMBLY MAY FAIL.GM WILL RECALL 1997-98 GRAND PRIX BUILT BETWEEN 1-MAR-96 AND 31-OCT-97; AND 1996-98 U-VANS/J-CARS BUILT BETWEEN 1-JAN-96 AND 31-OCT-97.SEE ATTACHED SUMMARY.
Steering:rack And Pinion
THE LOWER PINION BEARING IN THE RACK AND PINION STEERING ASSEMBLY MAY FAIL.GM WILL RECALL 1997-98 GRAND PRIX BUILT BETWEEN 1-MAR-96 AND 31-OCT-97; AND 1996-98 U-VANS/J-CARS BUILT BETWEEN 1-JAN-96 AND 31-OCT-97.SEE ATTACHED SUMMARY.
PE01038 · Steering Rack And Pinion
Opened Nov 14, 2001 · Closed Apr 4, 2002
Status: closed (inferred from source dates) · Steering
ODI HAS RECEIVED 200 COMPLAINTS FROMT CONSUMERS AND 1,238 FROM GM ALLEGING FAILURE OR LOCKUP OF THE STEERING RACK AND PINION UNIT (R&P).THIS ALLEGED CONDITION CAN RESULT IN THE LOSS OF STEERING CONTROL OF THE VEHICLE AND A CRASH CAN RESULT.GM HAS REPORTED SIX CRASHES IN WHICH EIGHT PEOPLE HAVE SUSTAINED INJURIES RANGING FROM BRUISES, AIRBAG BURN, SEAT BELT ABRASION, FACIAL INJURY, NECK AND BACK PAIN.ALL CRASHES WERE SINGLE VEHICLE CRASHES.GM STATES THAT ONE POSSIBLE FAILURE MODE IS FAILURE OF THE LOWER PINION BEARING IN THE R&P.AN ENGINEERING ANALYSIS HAS BEEN OPENED TO DETERMINE IF A SAFETY DEFECT TREND EXISTS.
EA99024 · Windshield Wiper
Opened Aug 20, 1999 · Closed Jan 13, 2000
Status: closed (inferred from source dates) · Visibility
BY LETTER DATED DECEMBER 12, 1999, GM NOTIFIED NHTSA OF ITS PLANS TO CONDUCT A SAFETY RELATED DEFECT CAMPAIGN TO REMEDY 155,149 OF THE SUBJECT VEHICLES.THE VEHICLE POPULATION FOR THE CAMPAIGN INCLUDES THE 1997 BUICK REGAL/CENTURY AND PONTIAC GRAN PRIX MODELS BUILT DURING THE PERIOD FROM THE START OF PRODUCTION THROUGH MAY 1, 1997.GM DETERMINED THAT THE WIPERS INSTALLED PRIOR TO THIS DATE COULD STOP WORKING, USUALLY DURING HEAVY LOAD CONDITIONS, DUE TO SEPARATION BETWEEN THE DRIVE PIN AND THE CRESCENT IN THE WIPER CRANK ARM ASSEMBLY.EFFECTIVE MAY 1, 1997,GM CORRECTED THIS PROBLEM IN PRODUCTION BY MODIFYING THE DRIVE PIN AND STRENGTHENING THE CRESCENT.THESE SAME IMPROVED PARTS WILL BE INSTALLED IN THE VEHICLES TO BE RECALLED.THE SCOPE OF THE CAMPAIGN WILL INCLUDE ALL VEHICLES PRODUCED PRIOR TO THE MAY 1, 1997 CORRECTION (THE OLDSMOBILE INTRIQUE PRODUCTION DID NOT START UNTIL AFTER MAY 1, 1997, AND IS THEREFORE NOT INCLUDED).VEHICLES WITH THE SCOPE OF THIS INVESTIGATION AND PRODUCED AFTER MAY 1, 1997, CONTAIN THE MORE ROBUST CRESCENT AND IMPROVED PIN DESIGN AND ARE NOT INCLUDED IN THE RECALL CAMPAIGN.ODI WILL CONTINUE TO MONITOR COMPLAINT REPORTS ON THE VEHICLES PRODUCED AFTER MAY 1, 1997 AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.BASED ON GM'S RECALL ACTION (ODI 99V-348) THIS INVESTIGATION IS CLOSED.
PE99028 · Windshield Wiper
Opened Apr 16, 1999 · Closed Aug 20, 1999
Status: closed (inferred from source dates) · Visibility
INCIDENTS OF WIPER FAILURE (OWNER REPORTS AND WARRANTY) ARE VERY HIGH, AND MANY OF THE REPORTS INDICATE THAT THE FAILURES ARE STILL OCCURRING IN 1999.
RQ98013 · Oversensitive Air Bag Deployments
Opened Aug 26, 1998 · No close date supplied
Status: open (inferred from source dates) · Air Bags
ON JUNE 26, 1998, GENERAL MOTORS BEGAIN A SAFETY RECALL, 98V-146, TO RECALIBRATE THE AIR BAG SENSING AND DIAGNOSTIC MODULE (SDM) IN THE 1996 AND SOME 1997 J BODY CARS, CAVALIER AND SUNFIRE.DUE TO CERTAIN CALIBRATIONS IN THE AIR BAG SDM, THERE IS AN INCREASED RISK OF INADVERTENT AIR BAG DEPLOYMENT IN A LOW SPEED CRASH OR WHEN AN OBJECT STRIKES THE FLOOR PAN.THE RECALL POPULATION CONSISTS OF 675,302 VEHICLES BUILT FROM APRIL 1995 THROUGH MAY 1997.ODI HAS RECEIVED 8 OWNER REPORTS ALLEGING INADVERTENT AIR BAG DEPLOYMENT WITHOUT A CRASH.THE PURPOSER OF THE RQ IS TO DETERMINE WHETHER GM SHOULD EXPAND THE RECALL TO INCLUDE THESE VEHICLES.CLOSING RESUME NOTE:AS OF AUGUST 5, 1999, ODI RECEIVED ONE ADDITIONAL COMPLAINT REGARDING THE ALLEGED DEFECT.THE INCIDENT RATES FOR THE SUBJECT VEHICLES ARE ABOUT ONE-THRID OF THE RATES OF THE RECALLED VEHICLES (WHEN THE RECALL WAS INITIATED).BASED ON THE AVAILABLE INFORMATION, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOSE NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY FUTURE CIRCUMSTANCES.
Illustration