WHILE DRIVING AT 20 MPH, THE CONSUMER NOTICED THE SEAT WAS GETTING EXTREMELY WARM. THE VEHICLE WAS TAKEN TO A MECHANIC AND IT WAS DISCOVERED THAT THE ELECTRIC SEAT MOTOR WAS BECOMING RED HOT, AND INTERIOR NEARLY CAUGHT ON FIRE. VEHICLE WAS BROUGHT IN AT PRECISELY THE RIGHT TIME. BY THE TIME THE MECHANIC GOT TO THE MOTOR HE WAS…
Read full complaint
WHILE DRIVING AT 20 MPH, THE CONSUMER NOTICED THE SEAT WAS GETTING EXTREMELY WARM. THE VEHICLE WAS TAKEN TO A MECHANIC AND IT WAS DISCOVERED THAT THE ELECTRIC SEAT MOTOR WAS BECOMING RED HOT, AND INTERIOR NEARLY CAUGHT ON FIRE. VEHICLE WAS BROUGHT IN AT PRECISELY THE RIGHT TIME. BY THE TIME THE MECHANIC GOT TO THE MOTOR HE WAS UNABLE TO TOUCH IT WITH HIS BARE HANDS. HE HAD TO PUT ON INSULATED GLOVES AND DISCONNECT THE MOTOR.*AK CONSUMER SAW SMOKE COMING FROM UNDER THE SEAT AND THATS WHEN SHE DROVE TO A MECHANIC. THE MECHANIC SAW THE SMOKE AND UNPLUGGED THE SEAT WITH SOME PLIERS. THE MECHANIC STATED IF THE CONSUMER WOULD'VE TOOK ANY LONGER GETTING THERE, THE VEHICLE WOULD HAVE CAUGHT FIRE. *PH *JB
NHTSA ODI #10034153
Mileage unknown · May 24, 2001
Seat BeltsSeatsCrashInjury
MY HUSBAND AND MYSELF WERE INVOLVED IN A HIGH IMPACT REAR END COLLISION. DUE TO THE SEAT BACK FAILURE MY SEAT BELT DID NOT RESTRAINT ME. I AM NOW A GRAND MAUL EPILEPTIC DUE TO MY HEAD INJURIES. I ALSO SUFFER FROM NECK AND SHOULDER PAIN.
NHTSA ODI #745868
Mileage unknown · Jul 31, 1999
Seats
FRONT DRIVER SEAT IS NOT COMPLETELY STATIONARY IT MOVES SLIGHTLY FRONTWARD AND BACKWARD WHEN DRIVER CHANGES POSITION POSSIBLY DUE TO POOR DESIGN. NLM
NHTSA ODI #547680
Mileage unknown · Sep 4, 1996
SeatsStructure
FAILURE OF THE DRIVER'S AND PASSENGER'S SIDE SEATBACKS, WHEN MAKING A SUDDEN STOP THE SEAT WILL MOVE, THE PASSENGER'S SIDE DOOR STRICKER IS MISSING.*AK
CERTAIN PASSENGER VEHICLES HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE RETAINERS COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OLDSMOBILE AT 1-800-630-6537; OR PONTIAC AT 1-800-620-7668.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
PE02050 · Engine Compartment Fires
Opened Jun 13, 2002 · Closed Oct 22, 2002
Status: closed (inferred from source dates) · Engine And Engine Cooling
No summary supplied.
EA99026 · Inadvertent Air Bag Deployment
Opened Aug 31, 1999 · Closed Dec 28, 2001
Status: closed (inferred from source dates) · Air Bags
There is no summary currently available
EA96023 · Inappropriate Air Bag Deployment
Opened Sep 27, 1996 · Closed Feb 13, 1998
Status: closed (inferred from source dates) · Air Bags
THE FAILURE RATE (1.25/100K) ON THIS ISSUE IS LOW.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF THE AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITURE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.ODI WILL CONTINUE TO CLOSELY MONITOR THIS ISSUE.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.AN ENGINEERING ANALYSIS CLOSING REPORT IS INCLUDED IN THE PUBLIC FILE.
1996 Pontiac Grand Prix Problems, Complaints & Recalls | Skip That Year
Illustration