TL*THE CONTACT OWNS A 1999 PONTIAC GRAND PRIX. THE VEHICLE CAUGHT FIRE TWICE WHERE DROPS OF ENGINE OIL FELL ON THE EXHAUST MANIFOLD. THE FIRES OCCURRED THREE DAYS AFTER PURCHASING THE VEHICLE. THE CONTACT WAS RESPONSIBLE FOR THE REPAIR COST OF $2000. THE CONTACT WAS NOT AWARE OF RECALL# 09V116000, COMPONENT: ENGINE AND ENGINE C…
Read full complaint
TL*THE CONTACT OWNS A 1999 PONTIAC GRAND PRIX. THE VEHICLE CAUGHT FIRE TWICE WHERE DROPS OF ENGINE OIL FELL ON THE EXHAUST MANIFOLD. THE FIRES OCCURRED THREE DAYS AFTER PURCHASING THE VEHICLE. THE CONTACT WAS RESPONSIBLE FOR THE REPAIR COST OF $2000. THE CONTACT WAS NOT AWARE OF RECALL# 09V116000, COMPONENT: ENGINE AND ENGINE COOLING WHEN THE FAILURE OCCURRED. THE MANUFACTURER STATED THAT THEY WOULD RESEARCH THE FAILURE AND CALL HIM; HOWEVER, HE HAS NOT RECEIVED A CALL. WHEN THE THIRD FIRE OCCURRED THE CONTACT WAS ABLE TO EXTINGUISH THE FIRE; ALTHOUGH, HE COULD HAVE BEEN INJURED. THE DEALER AND MANUFACTURER ADVISED THE CONTACT THAT THE VEHICLE WAS RENDERED INOPERABLE AND TO TOW IT TO A DEALER. THE CONTACT REQUESTED THAT THE DEALER ASSUME THE TOWING COST; HOWEVER, THEY DENIED TO DO SO. THERE WAS NO REPORT FILED WITH THE FIRE DEPARTMENT. HE HAS MADE SEVERAL ATTEMPTS TO SPEAK WITH THE MANUFACTURER AND HAS BEEN UNSUCCESSFUL. THE FAILURE MILEAGE WAS UNKNOWN.
NHTSA ODI #10282511
Mileage unknown · Mar 8, 2002
Engine And Engine Cooling
CONSUMER COMPLAINS THE HEATING SYSTEM HAS BECOME INOPERABLE. INSPECTION OF THE FAILURE LED TO THE DISCOVERY THAT THE VEHICLE IS IN NEED OF A NEW ENGINE. MECHANIC CAN NOT EXPLAIN WHY THIS OCCURED. *JG
NHTSA ODI #785652
Mileage unknown · May 10, 2001
Engine And Engine Cooling
ENGINE WAS OVERHEATING DURING NORMAL OPERATION OF VEHICLE. CONSUMER TOOK VEHICLE TO A DEALERSHIP AND REPLACED RADIATOR CAP BECAUSE OF A DEFECTIVE SPRING. THEN, WHEN TRAVELING AT APPROXIMATELY 70 MPH, ENGINE STALLED SUDDENLY. TOOK ALL OF CONSUMER'S EFFORT TO BRING VEHICLE TO SIDE OF ROAD. DEALERSHIP STATED THAT HEAD G…
Read full complaint
ENGINE WAS OVERHEATING DURING NORMAL OPERATION OF VEHICLE. CONSUMER TOOK VEHICLE TO A DEALERSHIP AND REPLACED RADIATOR CAP BECAUSE OF A DEFECTIVE SPRING. THEN, WHEN TRAVELING AT APPROXIMATELY 70 MPH, ENGINE STALLED SUDDENLY. TOOK ALL OF CONSUMER'S EFFORT TO BRING VEHICLE TO SIDE OF ROAD. DEALERSHIP STATED THAT HEAD GASKET WAS CONSIDERED TO BE DEFECTIVE WHICH CAUSED THE ENGINE TO STALL. PRIVATE MECHANIC WAS CURRENTLY REBUILDING/REMANUFACTURING THE ENGINE. *AK
NHTSA ODI #887918
Mileage unknown · Mar 27, 2001
Engine And Engine Cooling
WOULD BE DRIVING VEHICLE WHEN IT WOULD START TO HESITATE AT 40MPH. PROBLEM WAS SPORADIC. WOULD NOT BE ABLE TO PASS ANOTHER VEHICLE. TOOK TO DEALER NUMEROUS TIMES FOR PROBLEM. MECHANIC COULD NOT LOCATE CAUSE.*AK
NHTSA ODI #884383
Mileage unknown · Sep 29, 1999
Engine And Engine CoolingEquipmentFuel System, Gasoline
VEHICLE HESITATES ON ACCELERATION DUE TO EGR VALVE FAILURE. YH
NHTSA ODI #548613
Mileage unknown · Jun 29, 1999
Engine And Engine Cooling
I BEGAN TO HAVE ENGINE PROBLEMS WITH MY VEHICLE AT 36,000 MILES. I DECIDED TO TRACE THE VIN # THROUGH CARFAX. WHEN I DID I FOUND THAT THE ODOMETER HAS BEEN ROLLED BACK 71,000 MILES OR MORE. THE CAR DEALER DOES NOT WANT TO HANDLE THE PROBLEM. *AK
NHTSA ODI #708017
Mileage unknown · Jul 1, 1998
Engine And Engine CoolingUnknown Or OtherFire
ENGINE CAUGHT ON FIRE WHILE DRIVING VEHICLE. ALSO, ENGINE CHECK LIGHT CAME ON.
NHTSA ODI #780047
Mileage unknown · Jul 1, 1998
Engine And Engine Cooling
VEHICLE WITHOUT WARNING CAUSING POWER BRAKES AND POWER STEERING FAILURE.
NHTSA ODI #537676
Mileage unknown · Jul 22, 1997
Engine And Engine Cooling
CAR ENGINE CUTS OFF WHILE DRIVING TO ANOTHER LOCATION. *AK
NHTSA ODI #813567
Mileage unknown · Jul 15, 1997
Engine And Engine Cooling
ENGINE USES UP TO ONE TO TWO QUARTS OF OIL BETWEEN OIL CHANGES. NO OUTWARD SIGNS OF LEAK.
CERTAIN PASSENGER VEHICLES HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE RETAINERS COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OLDSMOBILE AT 1-800-630-6537; OR PONTIAC AT 1-800-620-7668.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
PE02050 · Engine Compartment Fires
Opened Jun 13, 2002 · Closed Oct 22, 2002
Status: closed (inferred from source dates) · Engine And Engine Cooling
No summary supplied.
EA99026 · Inadvertent Air Bag Deployment
Opened Aug 31, 1999 · Closed Dec 28, 2001
Status: closed (inferred from source dates) · Air Bags
There is no summary currently available
EA96023 · Inappropriate Air Bag Deployment
Opened Sep 27, 1996 · Closed Feb 13, 1998
Status: closed (inferred from source dates) · Air Bags
THE FAILURE RATE (1.25/100K) ON THIS ISSUE IS LOW.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF THE AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITURE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.ODI WILL CONTINUE TO CLOSELY MONITOR THIS ISSUE.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.AN ENGINEERING ANALYSIS CLOSING REPORT IS INCLUDED IN THE PUBLIC FILE.
1996 Pontiac Grand Prix Problems, Complaints & Recalls | Skip That Year
Illustration