NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes, Hydraulic complaints
76 reportsClear category filterMileage unknown · Nov 8, 2003
Service Brakes, Hydraulic
I HAVE A 1991 PONTIAC GRAND PRIX W/ A 3.4L V-6 AND I HAVE BEEN HAVING PROBLEMS W/ THE BRAKE SYSTEM SINCE 1999. I WAS DRIVING DOWN THE STREET AND THE BRAKES WOULD WORK ONE SECOND AND NOT THE NEXT ( WOULD GET REALLY STIFF AND FIRM, NO ASSIST), SO A COUPLE DAYS LATER IT JUST WENT STIFF FOR GOOD. I DECIDED TO CHECK THE CAR FOR THE…
Read full complaint
I HAVE A 1991 PONTIAC GRAND PRIX W/ A 3.4L V-6 AND I HAVE BEEN HAVING PROBLEMS W/ THE BRAKE SYSTEM SINCE 1999. I WAS DRIVING DOWN THE STREET AND THE BRAKES WOULD WORK ONE SECOND AND NOT THE NEXT ( WOULD GET REALLY STIFF AND FIRM, NO ASSIST), SO A COUPLE DAYS LATER IT JUST WENT STIFF FOR GOOD. I DECIDED TO CHECK THE CAR FOR THE BRAKE FUSES AND FOUND THE ABS PUMP FUSE HAD BURNT OUT. I REPLACED AND AS SOON AS I STEPPED ON THE BRAKE IT WENT SOFT FOR A SPLIT SECOND AND THEN STIFF AGAIN. HAD A FRIEND WATCH THE FUSE AND HE SAID AS SOON AS I STEPPED ON THE BRAKE IT BLEW THE FUSE. NO MATTER WHAT I DO I CAN NOT FIX THIS ISSUE AND THE DEALERSHIP IS TRYING TO CHARGE ME A COUPLE THOUSAND DOLLARS FOR THE BOOSTER THAT IS FAULTY. THIS IS SUCH A POPULAR ISSUE HER IN WASHINGTON THAT PEOPLE CONSTANTLY KEEP AN EYE OUT FOR THESE CARS IN THE JUNK YARD SO THEY CAN HAVE FIRST CHANCE AT PULLING THE UNITS OUT TO FIX FAULTY ONES. THERE NEEDS TO BE A RECALL ON THIS NO MATTER HOW OLD THE CAR IS! I HAVE OVER $8,000 DOLLARS UNDER THE HOOD TO KEEP IT AND STILL CANT FIX THIS ISSUE. *AK
NHTSA ODI #10045779
Mileage unknown · Jan 29, 2003
Service Brakes, Hydraulic
BRAKE PEDAL GOES TO THE FLOOR CAUSING VEHICLE TO HAVE EXTENDED STOPPING DISTANCE. DEALER HAS BEEN NOTIFIED. PH
NHTSA ODI #10005932
Mileage unknown · Sep 29, 2002
Service Brakes, Hydraulic
VEHICLE'S MASTER CYLINDER FAILED. MR
NHTSA ODI #767873
Mileage unknown · Oct 29, 2001
Electrical SystemExterior LightingFuel System, Gasoline
THE ALTERNATOR/STARTER GO OUT EVERY 6 MONTHS, THE FUEL PUMP HAS BEEN REPLACED 8 TIMES, THE LEFT TURN SIGNAL DOES NOT BLINK, THE BRAKES GO OUT EVERY 6 MONTHS, I THINK THERE WAS A RECALL ON THE BRAKE SYSTEM. THE POWER STEERING HAS TO BE REFILLED EVERY 100 MILES. THE DRIVERS SIDE POWER WINDOW DOES NOT WORK. THE WINDOW IS DOWN AB…
Read full complaint
THE ALTERNATOR/STARTER GO OUT EVERY 6 MONTHS, THE FUEL PUMP HAS BEEN REPLACED 8 TIMES, THE LEFT TURN SIGNAL DOES NOT BLINK, THE BRAKES GO OUT EVERY 6 MONTHS, I THINK THERE WAS A RECALL ON THE BRAKE SYSTEM. THE POWER STEERING HAS TO BE REFILLED EVERY 100 MILES. THE DRIVERS SIDE POWER WINDOW DOES NOT WORK. THE WINDOW IS DOWN ABOUT AN INCH AND WILL NOT GO UP OR DOWN.
NHTSA ODI #753865
Mileage unknown · Nov 24, 2000
Electrical SystemEngine And Engine CoolingService Brakes, Hydraulic
WHILE DRIVING DURING DAY TIME VEHICLE WAS FINE. BUT, AT NIGHT NOTICED VEHICLE WOULD IDLE HIGH & START TO OVERHEAT. VEHICLE WOULD STUTTER LIKE IT WAS STALLING. APPLIED BRAKES & VEHICLE FAILED TO STOP. ALSO, SMOKE WOULD BE COMING INSIDE OF VEHICLE FROM UNDER HOOD. PROBLEMS WERE INTERMITTENT. *AK
NHTSA ODI #875432
Mileage unknown · Nov 20, 2000
Power TrainService Brakes, HydraulicSteering
POWER STEERING FLUID IS LEAKING. *SLC
NHTSA ODI #557739
Mileage unknown · Sep 19, 2000
Service Brakes, Hydraulic
THIS PROBLEM HAS BEEN LISTED AS A COMMON PROBLEM ON CARPOINT.COM. HERE IS THE URL FOR THAT PROBLEM HTTP://CARPOINT.MSN.COM/VIP/USEDSINGLEYEAR/PONTIAC/GRAND%20PRIX/1991.ASP#ENGINE THE OTHER PROBLEMS LISTED HAVE ALSO OCCURRED WITH THE CAR. IT FIRST APPEARED ON JUNE 24 1997 AND THE FAILURE OCCURRED AT 20 MPH. THERE IS A COMPLET…
Read full complaint
THIS PROBLEM HAS BEEN LISTED AS A COMMON PROBLEM ON CARPOINT.COM. HERE IS THE URL FOR THAT PROBLEM HTTP://CARPOINT.MSN.COM/VIP/USEDSINGLEYEAR/PONTIAC/GRAND%20PRIX/1991.ASP#ENGINE THE OTHER PROBLEMS LISTED HAVE ALSO OCCURRED WITH THE CAR. IT FIRST APPEARED ON JUNE 24 1997 AND THE FAILURE OCCURRED AT 20 MPH. THERE IS A COMPLETE LOSS OF BRAKING DUE TO THIS. IT HAPPENS WITH LITTLE OR NO WARNING AT ALL. THE BRAKES ON THE CAR HAVE LESS THAN 20,000 MILES ON THEM. I WILL BE SENDING A LETTER TO PONTIAC AND GM WITHING 1 DAY.
NHTSA ODI #731854
Mileage unknown · Sep 6, 2000
Service Brakes, Hydraulic
WHILE TRAVELING AND WHEN DEPRESSING BRAKE PEDAL VEHICLE WOULD CONTINUE TO TRAVEL, RESULTING IN EXTENDED STOPPING DISTANCE. PLEASE PROVIDE FURTHER INFORMATION.*AK
NHTSA ODI #869733
Mileage unknown · Sep 6, 2000
Exterior LightingService Brakes, Hydraulic
REAR BRAKE LIGHTS STAY ON AFTER RELEASING BRAKE PEDAL. CAR WAS DROPPED OFF AT PALM PONTIAC SERVICE DEPARTMENT A TOTAL OF 9 TIMES FROM 11/4/99 TO 7/24/00. THE REPAIRS PERFORMED ON THSES 9 VISITS INCLUDED REPLACING ABS BRAKE MASTER CYLINDER, REPLACING BRAKE LIGHT SWITCH, ADJUSTING BRAKE LIGHT SWITCH AND ADJUSTING BRAKE PEDAL. PR…
Read full complaint
REAR BRAKE LIGHTS STAY ON AFTER RELEASING BRAKE PEDAL. CAR WAS DROPPED OFF AT PALM PONTIAC SERVICE DEPARTMENT A TOTAL OF 9 TIMES FROM 11/4/99 TO 7/24/00. THE REPAIRS PERFORMED ON THSES 9 VISITS INCLUDED REPLACING ABS BRAKE MASTER CYLINDER, REPLACING BRAKE LIGHT SWITCH, ADJUSTING BRAKE LIGHT SWITCH AND ADJUSTING BRAKE PEDAL. PROBLEM STILL PERSISTS AS OF 9/5/00 WHEN I CONTACTED WAYNE TURNER, SERVICE DIRECTOR AT PALM PONTIAC AND HE ADVICED ME TO CONTACT PONTIAC CUSTOMER SERVICE. I CALLED PONTIAC CUSTOMER ASSISTANCE CENTER AT !-800-762--2737 AND SPOKE TO PATRICK CLEMMINS. HE GAVE ME A REQUEST # C01463354 AND SEND HE WOULD CHECK WITH HIS SUPERIOR AND CALL ME BACK.
NHTSA ODI #730511
Mileage unknown · Jun 14, 2000
Service Brakes, Hydraulic
CONSUMER FOUND OUT FROM REPAIR SHOP THAT REAR BRAKES HAD NO POWER. ONE OF THE BRAKES WAS COMPLETELY DISCONNECTED. ALSO, THEY WERE BOTH RUSTED. CONSUMER WILL CONTACT MANUFACTURER. *AK *ML
NHTSA ODI #863564
Official recalls
4Jul 11, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, WHERE ROAD SALT USE IS HEAVY. A CONDITION WHERE ONE OR BOTH FRONT ENGINE CRADLE BOLTS CAN PULL THROUGH THE RETAINERS DUE TO CORROSION OF THE RETAINERS.
Consequence & remedy
Consequence: IF BOTH BOLTS PULL THROUGH, THE FRONT OF THE CRADLE WOULD NO LONGER BE SUPPORTED AT THE MOUNTING LOCATIONS AND THE STEERING INTERMEDIATE SHAFT COULD SEPARATE FROM THE STEERING GEAR.
Remedy: DEALERS WILL REPLACE THE FRONT AND REAR FRAME/CRADLE BOLTS AND RETAINERS.
Apr 8, 1997
VEHICLE DESCRIPTION: PASSENGER VEHICLES AND MINI VANS ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: CONNECTICUT, ILLINOIS, INDIANA, MAINE, MASSACHUSETTS, MICHIGAN, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT AND WISCONSIN. THE REAR CRADLE BOLTS PULL THROUGH THE RETAINERS DUE TO CORROSION OF THE RETAINER. IF BOTH BOLTS PULL THROUGH, THE REAR CRADLE WOULD NOT LONGER BE SUPPORTED AT THESE MOUNTING LOCATIONS AND THE STEERING INTERMEDIATE SHAFT CAN SEPARATE FROM THE STEERING GEAR.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR WHILE THE VEHICLE WAS IN MOTION, A VEHICLE CRASH COULD RESULT.
Remedy: DEALERS WILL REPLACE THE REAR CRADLE BOLTS AND RETAINERS.
Dec 15, 1992
THE FOG LAMPS, LOW BEAM HEADLAMPS, AND HIGH BEAM HEADLAMPS CAN BE OPERATED SIMULTANEOUSLY. THIS CAN CAUSE THE HEADLAMP CIRCUIT BREAKER TO OVERLOAD AND TRIP, RESULTING IN LOSS OF HEADLAMPS (LOW AND HIGH BEAM) AND FOG LIGHTS.
Consequence & remedy
Consequence: LOSS OF HEADLAMPS WITHOUT PRIOR WARNING REDUCES DRIVERVISIBILITY IN INCLEMENT WEATHER CONDITIONS OR AT NIGHT, AND COULD RESULT IN AVEHICLE ACCIDENT. IN ADDITION, THE USE OF MORE THAN FOUR (4) WHITE LIGHTS ON AVEHICLE AT THE SAME TIME VIOLATES THE LAW IN SOME STATES.
Remedy: INSTALL NEW FOG LAMP RELAYS, NEW CIRCUIT BREAKERS AND NEW CIRCUIT BREAKER TERMINALS. ALSO, MODIFY THE LIGHTING CIRCUIT TO PREVENT THE FOG LAMPS AND HIGH BEAM LAMPS FROM OPERATING SIMULTANEOUSLY.
Jan 10, 1992
THE FRONT DOOR SHOULDER BELT GUIDE LOOPS MAY BE CRACKED AND ARE NOT IN COMPLIANCE WITH FMVSS 208.
Consequence & remedy
Consequence: THE SEAT OCCUPANT FACES INCREASED RISK OF INJURY IN THEEVENT OF A SUDDEN STOP OR ACCIDENT.
Remedy: INSTALL REINFORCING PLATES ON THE CRACKED SHOULDER BELT GUIDES.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
7RP01001 · Structure
Opened Nov 28, 2001 · Closed Jun 13, 2002
Status: closed (inferred from source dates) · Structure
There is no summary currently available
EA00011 · Engine Cradle Separation
Opened Apr 10, 2000 · Closed Jan 12, 2001
Status: closed (inferred from source dates) · Engine And Engine Cooling
THE ENGINE CRADLE FRONT BOLTS AND/OR RETAINERS MAY FAIL, ALLOWING THE FRONT OF THE ENGINE CRADLE TO FALL, POSSIBLY SEPARATING THE STEERING INTERMEDIATE SHAFT FROM THE STEERING GEAR, WITH COMPLETE LOSS OF STEERING CONTROL
RQ97017 · Cradle Bolt Failures
Opened Oct 2, 1997 · No close date supplied
Status: open (inferred from source dates) · Structure
There is no summary currently available
PE94063 · Corroded Rear Disk Brakes
Opened Aug 12, 1994 · Closed Dec 21, 1994
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
EA92024 · Sticking Throttle
Opened Jun 26, 1992 · Closed Jan 31, 1994
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA91049 · Jack Failure
Opened Nov 26, 1991 · Closed Oct 28, 1992
Status: closed (inferred from source dates) · Equipment
===
PE91072 · Steering Wheel Separation
Opened May 1, 1991 · Closed Jul 8, 1991
Status: closed (inferred from source dates) · Steering
There is no summary currently available
Illustration