Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 7 of 176 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Service Brakes, Hydraulic. Review the 92 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Structure. Review the 25 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 17 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
10 crash reports1 fire reports7 injury reports
What owners actually said
176 reports
260,000 miles · Oct 19, 2007
SteeringStructure
REAR SUBFRAME RETAINERS RUSTED OUT CAUSING ENGINE/TRANSAXLE TO DROP AND STEERING SHAFT TO SEPARATE CAUSING LOSS OF CONTROL WHERE THE VEHICLE ENDED UP IN THE ON COMING LANE OF TRAFFIC. THE RETAINERS HAVE BEEN REPLACED AT LEAST ONCE BEFORE. REPLACEMENT PARTS HAVE THE SAME DEFECT AS THE ORIGINAL PARTS. I DON'T BELIEVE THAT IS A S…
Read full complaint
REAR SUBFRAME RETAINERS RUSTED OUT CAUSING ENGINE/TRANSAXLE TO DROP AND STEERING SHAFT TO SEPARATE CAUSING LOSS OF CONTROL WHERE THE VEHICLE ENDED UP IN THE ON COMING LANE OF TRAFFIC. THE RETAINERS HAVE BEEN REPLACED AT LEAST ONCE BEFORE. REPLACEMENT PARTS HAVE THE SAME DEFECT AS THE ORIGINAL PARTS. I DON'T BELIEVE THAT IS A SOLUTION. ONE GM DEALER (DON MILLER IN MADISON) DENIED ANY KNOWLEDGE OF A RECALL. ANOTHER GM DEALER SAID GM WILL OFFER A COUPLE HUNDRED DOLLARS AND TAKE THE CAR, BUT THERE IS NO REPAIR OPTION. YOUR PERSON I SPOKE WITH AT THE (888) PHONE NUMBER DIRECTED BE TO A GM (800) NUMBER WHO COULD NOT FIND ANY INFORMATION EVEN THOUGH I GAVE THEM THE RECALL NUMBER. IN ADDITION TO THE BOLTS AND RETAINERS THAT ARE "COVERED", THE RUBBER CUSHIONS AND TOP RETAINERS WERE UNABLE TO BE FOUND AND WILL REQUIRE REPLACEMENT. I HAVE ORDERED THE PARTS AT A COST OF ABOUT $110 AND A $60 TOW BILL PLUS ANY LABOR CHARGE I INCUR. LOOKING OVER THE NUMBER OF THESE FAILURES ON YOUR SITE, IT IS AMAZING TO ME THAT NO ACCIDENTS HAVE RESULTED THAT HAVE BEEN REPORTED. I WONDER HOW MANY HAVE OCCURRED AND THE CAUSE WAS NOT DISCOVERED. IT SEEMS TO ME THAT THE RECALL SHOULD BE CONTINUED TO INSPECT VEHICLES THAT HAVE BEEN "REPAIRED" WITH THE SAME DEFECTIVE PARTS. *TR
NHTSA ODI #10206369
105,000 miles · Apr 28, 2006
SuspensionCrashInjury
DT*: THE CONTACT STATED WHILE DRIVING 40MPH THE LEFT REAR WHEEL STEERED 45 DEGREES TO THE SIDE AND THE VEHICLE WENT OUT OF CONTROL. THE VEHICLE COLLIDED HEAD ON WITH A TREE. THE DRIVER WAS WEARING A SEAT BELT, BUT SUSTAINED INJURIES. THE POLICE TOOK A REPORT AT THE SCENE. THE VEHICLE WAS TOWED TO A JUNK YARD AND INSPECTED B…
Read full complaint
DT*: THE CONTACT STATED WHILE DRIVING 40MPH THE LEFT REAR WHEEL STEERED 45 DEGREES TO THE SIDE AND THE VEHICLE WENT OUT OF CONTROL. THE VEHICLE COLLIDED HEAD ON WITH A TREE. THE DRIVER WAS WEARING A SEAT BELT, BUT SUSTAINED INJURIES. THE POLICE TOOK A REPORT AT THE SCENE. THE VEHICLE WAS TOWED TO A JUNK YARD AND INSPECTED BY THE MANUFACTURER, WHO PROVIDED NO CLEAR DETERMINATION AS TO WHAT CAUSED THE ACCIDENT. AN ENGINEER INSPECTED THE VEHICLE AND DETERMINED THE TRAILING ARM FAILED AND CAUSED THE ACCIDENT.
NHTSA ODI #10156381
72,050 miles · Mar 9, 2006
Engine And Engine Cooling
CAR WOULD GET HORRID GAS MILEAGE, OCCASIONALLY STALL, EXHAUST SMELL UNDER HOOD, BLACK EXHAUST. THE CROSSOVER PIPE FROM EACH EXHAUST MANIFOLD HAS A COMMON CRACKING ON THE BELLOWS AND MUST BE REPLACED, THEY RUN $2500 FROM GM WHICH JUST CRACK AGAIN, OR $425 FOR JEFF M ONE THAT DOESN'T CRACK. THE PIPE CRACKS CAUSE FRESH AIR TO ENTER…
Read full complaint
CAR WOULD GET HORRID GAS MILEAGE, OCCASIONALLY STALL, EXHAUST SMELL UNDER HOOD, BLACK EXHAUST. THE CROSSOVER PIPE FROM EACH EXHAUST MANIFOLD HAS A COMMON CRACKING ON THE BELLOWS AND MUST BE REPLACED, THEY RUN $2500 FROM GM WHICH JUST CRACK AGAIN, OR $425 FOR JEFF M ONE THAT DOESN'T CRACK. THE PIPE CRACKS CAUSE FRESH AIR TO ENTER THE EXHAUST AND THE OXYGEN SENSOR THINKS THE CARS RUNNING RICH, CAUSING HORRIBLE GAS MILEAGE, OIL CONTAMINATION, AND STALLING. THE EXTRA HEAT FROM THE CAR RUNNING RICH CRACKS THE TURBO HOUSING. *NM
NHTSA ODI #10152257
50,000 miles · Nov 28, 2005
Electrical System
IF YOU USE THE TURN SIGNAL, THE STEERING WHEEL WILL START SMOKING. TOOK VEHICLE TO DEALER AND DEALER DIDN'T WANT TO FIX IT. TURN SIGNALS STILL WORKED WHEN APPLIED. *NM
NHTSA ODI #10143848
Mileage unknown · Jan 6, 2005
Structure
RECALL CAMPAIGN, HAVING SOME PROBLEMS WITH RECALLS NEVER RECEIVED. *BF THE REAR CRADLE BOLTS PULLED THROUGH THE RETAINERS DUE TO CORROSION. RECALL# 00V189000. *SC *JB
NHTSA ODI #10109406
Mileage unknown · Jun 23, 2004
Unknown Or Other
CONSUMER INQUIRING ABOUT RECALLS FOR 1990 PONTIAC GRAND PRIX. *MR RECALL #'S 90V185000 EXTERIOR LIGHTING BRAKE LIGHT SWITCH, 90V036000 FUEL SYSTEM TANK ASSEMBLY, 90V054000 SEAT BELTS, 00V189000 STRUCTURE, AND 94V041000 WHEELS. *SC *JB
NHTSA ODI #10079860
74,987 miles · Feb 19, 2004
Structure
CONSUMER STATED THAT WHILE WAITING AT AN ATM ENGINE FELL OUT OF VEHICLE. CONSUMER HAD VEHICLE TOWED TO THE MECHANIC, WHO SAID THAT THE CRADLE BOLTS RUSTED. CONSUMER INDICATED HE NEVER RECEIVED A RECALL NOTICE. BUT WHEN HE CALLED GMC HE WAS TOLD THAT THIS VEHICLE WAS INCLUDED IN THE RECALL. *AK
NHTSA ODI #10052280
65,000 miles · Dec 30, 2003
Engine And Engine Cooling
WHILE DRIVING THE ENGINE FELL. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DETERMINED THAT THE RETAINER CRADLE BROKE. CONSUMER NEVER RECEIVED A RECALL NOTICE. *NM *MR
NHTSA ODI #10052115
Mileage unknown · May 14, 2003
Service Brakes, Hydraulic
WHEN THE BRAKES WERE APPLIED, THE PEDAL TRAVELED TO THE FLOOR. *JB
NHTSA ODI #10019876
900,000 miles · Mar 24, 2003
Service Brakes, Hydraulic
VEHICLE'S REAR BRAKES WERE INOPERATIVE. RUST ACCUMULATED ON THE SURFACE OF THE BRAKES. AS A RESULT THE ROTORS AND PADS DID NOT COME IN CONTACT. *NLM
VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, WHERE ROAD SALT USE IS HEAVY. A CONDITION WHERE ONE OR BOTH FRONT ENGINE CRADLE BOLTS CAN PULL THROUGH THE RETAINERS DUE TO CORROSION OF THE RETAINERS.
Consequence & remedy
Consequence: IF BOTH BOLTS PULL THROUGH, THE FRONT OF THE CRADLE WOULD NO LONGER BE SUPPORTED AT THE MOUNTING LOCATIONS AND THE STEERING INTERMEDIATE SHAFT COULD SEPARATE FROM THE STEERING GEAR.
Remedy: DEALERS WILL REPLACE THE FRONT AND REAR FRAME/CRADLE BOLTS AND RETAINERS.
VEHICLE DESCRIPTION: PASSENGER VEHICLES AND MINI VANS ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: CONNECTICUT, ILLINOIS, INDIANA, MAINE, MASSACHUSETTS, MICHIGAN, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT AND WISCONSIN. THE REAR CRADLE BOLTS PULL THROUGH THE RETAINERS DUE TO CORROSION OF THE RETAINER. IF BOTH BOLTS PULL THROUGH, THE REAR CRADLE WOULD NOT LONGER BE SUPPORTED AT THESE MOUNTING LOCATIONS AND THE STEERING INTERMEDIATE SHAFT CAN SEPARATE FROM THE STEERING GEAR.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR WHILE THE VEHICLE WAS IN MOTION, A VEHICLE CRASH COULD RESULT.
Remedy: DEALERS WILL REPLACE THE REAR CRADLE BOLTS AND RETAINERS.
CRACKS DEVELOP IN THE WHEEL MOUNTING SURFACE. IF THESE CRACKS BECOME SEVERE ENOUGH, THE WHEEL WILL COMPLETELY SEPARATE FROM THE VEHICLE.
Consequence & remedy
Consequence: IF WHEEL SEPARATION OCCURS WHILE THE VEHICLE IS IN MOTION, LOSS OF STEERING AND BRAKE CONTROL OF THE VEHICLE OCCURS, AND A VEHICLE CRASH COULD RESULT WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL INSPECT THE MANUFACTURING DATE CODES STAMPED ON EACH WHEEL OF THE VEHICLE AND IF A WHEEL FALLS WITHIN THE SPECIFIED DATE CODE RANGE, THE DEALER WILL REPLACE THAT WHEEL ASSEMBLY.
CRACKS DEVELOP IN THE WHEEL MOUNTING SURFACE. IF THESE CRACKS BECOME SEVERE ENOUGH, THE WHEEL WILL COMPLETELY SEPARATE FROM THE VEHICLE.
Consequence & remedy
Consequence: IF WHEEL SEPARATION OCCURS WHILE THE VEHICLE IS IN MOTION, LOSS OF STEERING AND BRAKE CONTROL OF THE VEHICLE OCCURS, AND A VEHICLE CRASH COULD RESULT WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL INSPECT THE MANUFACTURING CODES STAMPED ON EACH WHEEL OF THE VEHICLE AND IF A WHEEL FALLS WITHIN THE SPECIFIED DATE CODE RANGE, THE DEALER WILL REPLACE THAT WHEEL ASSEMBLY.
FRONT SHOULDER SAFETY BELT WEBBING MAY SEPARATE AT FRONT BELT UPPER GUIDE LOOPS ON EITHER SIDE OF THE FRONT SEAT.
Consequence & remedy
Consequence: WEBBING SEPARATION COULD OCCUR WITHOUT PRIOR WARNING ANDINCREASE THE RISK OF INJURY TO BELTED FRONT OUTBOARD OCCUPANTS IN A HIGH ENERGYCRASH.
Remedy: INSTALL A CONTROLLED ROTATION BRACKET ON DRIVER AND PASSENGER SIDE FRONT SEAT BELT GUIDE LOOPS.
BRAKE STOPLAMPS MAY NOT ILLUMINATE OR, IN SOME CASES, STOPLAMPS WILL NOT STAY ILLUMINATED ALL THE TIME WHEN BRAKES ARE APPLIED DUE TO A FAULTY STOPLAMP SWITCH. ALSO IN VEHICLES EQUIPPED WITH CRUISE CONTROL, A FAULTY STOPLAMP SWITCH CAN RESULT IN RESUMPTION OF THE CRUISE CONTROL FUNCTION UPON RELEASE OF THE BRAKE PEDAL.
Consequence & remedy
Consequence: A TRAILING VEHICLE MAY NOT RECOGNIZE A BRAKING ACTIONIN TIME TO RESPOND APPROPRIATELY. ALSO, CRUISE CONTROL WILL REENGAGE UPONRELEASE OF THE BRAKE PEDAL AND RESUME THE SET SPEED. IN EITHER CASE, IT COULDRESULT IN A CRASH WITHOUT PRIOR WARNING.
Remedy: INSTALL AN IMPROVED DESIGN STOPLAMP SWITCH.
FRONT SHOULDER BELT GUIDE LOOP ATTACHMENT FASTENER MAY PULL THROUGH DOOR MOUNTED ANCHOR PLATE.
Consequence & remedy
Consequence: SEAT BELT MAY NOT SUSTAIN LOADS REQUIRED BY FMVSS 210, AND IN A VEHICLE ACCIDENT, THE SEAT BELT MAY NOT PROPERLY RESTRAIN A PASSENGER, RESULTING IN INCREASED RISK OF GREATER INJURY TO AN OCCUPANT.
Remedy: REPLACE FRONT SHOULDER BELT GUIDE LOOP ATTACHMENT NUTS AND INSTALL NEW GUIDE COVER.
DURING A REAR END COLLISION, THE REAR EXHAUST SYSTEM HEAT SHIELD, WHICH IS WELDED TO THE TAIL PIPE ASSEMBLY, MAY PUNCTURE THE FUEL TANK.
Consequence & remedy
Consequence: IN THE PRESENCE OF AN EXTERNAL SOURCE OF IGNITION, THIS COULD RESULT IN A FIRE.
Remedy: REMOVE REAR EXHAUST SYSTEM HEAT SHIELD FROM THE PIPE ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
10
RP01001 · Structure
Opened Nov 28, 2001 · Closed Jun 13, 2002
Status: closed (inferred from source dates) · Structure
There is no summary currently available
EA00011 · Engine Cradle Separation
Opened Apr 10, 2000 · Closed Jan 12, 2001
Status: closed (inferred from source dates) · Engine And Engine Cooling
THE ENGINE CRADLE FRONT BOLTS AND/OR RETAINERS MAY FAIL, ALLOWING THE FRONT OF THE ENGINE CRADLE TO FALL, POSSIBLY SEPARATING THE STEERING INTERMEDIATE SHAFT FROM THE STEERING GEAR, WITH COMPLETE LOSS OF STEERING CONTROL
RQ97017 · Cradle Bolt Failures
Opened Oct 2, 1997 · No close date supplied
Status: open (inferred from source dates) · Structure
There is no summary currently available
PE94063 · Corroded Rear Disk Brakes
Opened Aug 12, 1994 · Closed Dec 21, 1994
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
PE93085 · Wheel Failures
Opened Sep 29, 1993 · Closed Feb 28, 1994
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
EA92024 · Sticking Throttle
Opened Jun 26, 1992 · Closed Jan 31, 1994
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA91049 · Jack Failure
Opened Nov 26, 1991 · Closed Oct 28, 1992
Status: closed (inferred from source dates) · Equipment
===
PE91107 · Jack Failure
Opened Aug 1, 1991 · Closed Nov 26, 1991
Status: closed (inferred from source dates) · Equipment
There is no summary currently available
PE91072 · Steering Wheel Separation
Opened May 1, 1991 · Closed Jul 8, 1991
Status: closed (inferred from source dates) · Steering
There is no summary currently available
PE90088 · Failure Stop Lamp Switch
Opened Jun 11, 1990 · Closed Oct 31, 1990
Status: closed (inferred from source dates) · Exterior Lighting
There is no summary currently available
1990 Pontiac Grand Prix Problems, Complaints & Recalls | Skip That Year
Illustration