NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
75 reportsClear category filterMileage unknown · Nov 23, 2014
Engine And Engine Cooling
WE HAVE RECEIVED THE RECALL LETTER DATED OCTOBER 2014. WE HAD COMPLAINED ABOUT THE SAFETY OF THE VEHICLE AS IT SHUT OFF AS WE WERE GOING DOWN THE INTERSTATE ACROSS A BRIDGE WHICH HAS A BUMP ON IT WE LOST ALL POWER AND WAS LIKE OLD FASHION STEERING. WE COASTED TO THE END OF THE EXIT RAMP AND HAD TO PLAY WITH THE KEY AND AFTER A…
Read full complaint
WE HAVE RECEIVED THE RECALL LETTER DATED OCTOBER 2014. WE HAD COMPLAINED ABOUT THE SAFETY OF THE VEHICLE AS IT SHUT OFF AS WE WERE GOING DOWN THE INTERSTATE ACROSS A BRIDGE WHICH HAS A BUMP ON IT WE LOST ALL POWER AND WAS LIKE OLD FASHION STEERING. WE COASTED TO THE END OF THE EXIT RAMP AND HAD TO PLAY WITH THE KEY AND AFTER AWHILE IT STARTED AND THIS CONTINUED OFF AND ON AND THEY TOLD US HAD TO TURN KEY FOR 10 MIN ON AUX TILL LIGHT BLINKED AND RESET ITSELF THEY TOLD US WOULD RESET SECURITY SYSTEM AND START. WHICH IT DID MOST OF THE TIME WAS A PAIN AN INCONVENIENT. WE GOT RID OF IT IN 06 OR 07. IT WAS INTERESTING AND GM SAID IT WAS OUR PROBLEM. HAVEN'T PURCHASED ANOTHER GM VEHICLE. HAD A LOT OF CLOSE CALLS WITH THIS VEHICLE....BUT WAS OUR ISSUE THEY TOLD US.... *TR
NHTSA ODI #10660350
182,000 miles · Sep 19, 2014
Engine And Engine CoolingStructureCrash
GOING THROUGH AN INTERSECTION, THE CAR SHUTS OFF AND THE CAR FOLLOWING RUNS INTO THE THE BACK OF US. *TR
NHTSA ODI #10637521
122,000 miles · Apr 2, 2014
Engine And Engine CoolingFuel/propulsion System
I WAS DRIVING DOWN THE STREET AND THE CAR JUST SHUTS OFF WHILE DRIVING OR SLOWING DOWN. THEY ARE SAYING THE FUEL INJECTOR IS BAD. *TR
NHTSA ODI #10576744
65,000 miles · Apr 26, 2012
Electrical SystemEngine And Engine Cooling
TL* THE CONTACT OWNS A 2001 PONTIAC GRAND AM. THE CONTACT STATED THE SECURITY SYSTEM WARNING INDICATOR ILLUMINATED AND THE ENGINE FAILED TO START. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER FOR DIAGNOSIS. THE TECHNICIAN INFORMED THE CONTACT THAT THE MALFUNCTION WAS CONTRIBUTED TO A DEFECT WITHIN THE ENGINE. THE VEHICLE WAS NO…
Read full complaint
TL* THE CONTACT OWNS A 2001 PONTIAC GRAND AM. THE CONTACT STATED THE SECURITY SYSTEM WARNING INDICATOR ILLUMINATED AND THE ENGINE FAILED TO START. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER FOR DIAGNOSIS. THE TECHNICIAN INFORMED THE CONTACT THAT THE MALFUNCTION WAS CONTRIBUTED TO A DEFECT WITHIN THE ENGINE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE RECURRED SIX MONTHS LATER. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 65,000. UPDATED 6/4/12 *CN THE CONSUMER STATED THAT SECURITY LOCKS IGNITION FOR 10 MINUTES. THESE OCCURRENCES HAPPEN EVERDAY. UPDATED 06/07/12 *JS
NHTSA ODI #10456553
100,000 miles · Apr 9, 2012
Engine And Engine CoolingExterior Lighting
TL* THE CONTACT OWNS A 2001 PONTIAC GRAND AM. THE CONTACT STATED THAT WHILE DRIVING 30 MPH, HE NOTICED THAT THE VEHICLE WAS RUNNING LOW ON COOLANT. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT THE HEAD GASKET WAS LEAKING. THE VEHICLE WAS REPAIRED. THE CONTACT ALSO STATED THAT THE TURN SIGNALS…
Read full complaint
TL* THE CONTACT OWNS A 2001 PONTIAC GRAND AM. THE CONTACT STATED THAT WHILE DRIVING 30 MPH, HE NOTICED THAT THE VEHICLE WAS RUNNING LOW ON COOLANT. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT THE HEAD GASKET WAS LEAKING. THE VEHICLE WAS REPAIRED. THE CONTACT ALSO STATED THAT THE TURN SIGNALS ONLY ILLUMINATED INTERMITTENTLY. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 100,000.
NHTSA ODI #10454487
130,000 miles · Feb 17, 2012
Engine And Engine Cooling
TL* THE CONTACT OWNS A 2001 PONTIAC GRAND AM. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, THE VEHICLE STALLED WITH THE ILLUMINATION OF THE CHECK ENGINE AND SECURITY WARNING LAMPS. THE CONTACT ALSO MENTIONED THAT THERE WERE TIMES THAT THE VEHICLE COULD NOT BE STARTED. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE S…
Read full complaint
TL* THE CONTACT OWNS A 2001 PONTIAC GRAND AM. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, THE VEHICLE STALLED WITH THE ILLUMINATION OF THE CHECK ENGINE AND SECURITY WARNING LAMPS. THE CONTACT ALSO MENTIONED THAT THERE WERE TIMES THAT THE VEHICLE COULD NOT BE STARTED. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE SECURITY PASS LOCK SYSTEM WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN NUMBER WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 130,000.
NHTSA ODI #10448369
Mileage unknown · Oct 27, 2011
Engine And Engine CoolingService Brakes, HydraulicSteering
WHEN I TRY TO USE MY SIGNALS IT WONT WORK, THEY WONT COME ON, IT ALSO LILE TO HAVE CAUSED AN ACCIDENT, WHEN I CRANK THE CAR UP OT MAKES A LOUD NOISE FOR ABOUT FIVE MINUTES, OR SOMETIMES IT WONT START, I HAVE TO WAIT THIRTY MINUTES, BEFORE IT COULD CRANK ON NUMEROUS OCCASIONS, IT HAS DONE THAT, I ALSO HAVE TO KEEP REPLACING BRAKE…
Read full complaint
WHEN I TRY TO USE MY SIGNALS IT WONT WORK, THEY WONT COME ON, IT ALSO LILE TO HAVE CAUSED AN ACCIDENT, WHEN I CRANK THE CAR UP OT MAKES A LOUD NOISE FOR ABOUT FIVE MINUTES, OR SOMETIMES IT WONT START, I HAVE TO WAIT THIRTY MINUTES, BEFORE IT COULD CRANK ON NUMEROUS OCCASIONS, IT HAS DONE THAT, I ALSO HAVE TO KEEP REPLACING BRAKES FOR THIS CAR, MY COOLANT JUG I HAVE REPLACED THAT MANY OF TIMES AND ITS STILL HAS A LEAK IN IT I HAVE TO PUT COOLANT IN THERE FOUR TIMES A WEEK, AND ALSO IF IM MAKING A LEFT MY STEERING WHEEL IT GETS STUCK SOMETIMES. *TT
NHTSA ODI #10433017
100,000 miles · Jun 21, 2011
Engine And Engine Cooling
TL* THE CONTACT OWNS A 2001 PONTIAC GRAND AM. WHILE DRIVING APPROXIMATELY 45 MPH, THE ENGINE STALLED WITH THE ILLUMINATION OF THE ABS WARNING INDICATOR. THE VEHICLE RESTARTED AFTER THE CONSUMER WAITED FOR A PERIOD OF FIVE HOURS. ALSO, THERE WAS A SMALL AMOUNT OF COOLANT AND WATER LEAKAGE ON THE GROUND AS THE ENGINE WOULD OVERHEA…
Read full complaint
TL* THE CONTACT OWNS A 2001 PONTIAC GRAND AM. WHILE DRIVING APPROXIMATELY 45 MPH, THE ENGINE STALLED WITH THE ILLUMINATION OF THE ABS WARNING INDICATOR. THE VEHICLE RESTARTED AFTER THE CONSUMER WAITED FOR A PERIOD OF FIVE HOURS. ALSO, THERE WAS A SMALL AMOUNT OF COOLANT AND WATER LEAKAGE ON THE GROUND AS THE ENGINE WOULD OVERHEAT SPORADICALLY. THE VEHICLE WAS DIAGNOSED BY TWO DIFFERENT INDEPENDENT MECHANICS WHO INFORMED THE CONTACT THAT THE HEAD GASKET, INTAKE GASKET AND THERMOSTAT WOULD NEED TO BE REPLACED. THE FAILURES CONTINUED TO OCCUR. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOT MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 100,000. UPDATED 08/01/11*LJ UPDATED 08/11/11
NHTSA ODI #10407736
130,000 miles · Feb 22, 2011
Engine And Engine Cooling
COOLANT LEVEL WAS GOING DOWN ON CAR AND LIGHT WAS COMING ON, TOOK CAR FOR CHECKUP AND INTAKE GASKET CRACKED AND COOLANT MIXED WITH OIL, HAD GASKET REPAIRED , BUT WHILE DRIVING GASKET BLEW AGAIN AND POWERSTEERING FUNCTIONS OF CAR DID NOT WORK AND COOLANT LEAKED ALL OVER GROUND , HARD TO CONTROL CAR AND SINCE IN TRAFFIC ALMOST WA…
Read full complaint
COOLANT LEVEL WAS GOING DOWN ON CAR AND LIGHT WAS COMING ON, TOOK CAR FOR CHECKUP AND INTAKE GASKET CRACKED AND COOLANT MIXED WITH OIL, HAD GASKET REPAIRED , BUT WHILE DRIVING GASKET BLEW AGAIN AND POWERSTEERING FUNCTIONS OF CAR DID NOT WORK AND COOLANT LEAKED ALL OVER GROUND , HARD TO CONTROL CAR AND SINCE IN TRAFFIC ALMOST WAS IN ACCIDENT < PONTIAC KNOWS ABOUT ISSUES WITH PONTIAC GARND AM SE 2001 AND ALSO WITH SIGNAL TURN PROBLEM SINCE SIGNALS STOP WORKING,NOW CAR NEEDS NEW MOTOR SINCE GASKET REPLACED ABOUT 3 TIMES AND EACH TIME IT BLEW AFTER TAKING OUT OF REPAIR SHOP AND WHILE DRIVING.WHEN SOMEONE IS HURT IS THAT WHAT THEY ARE WAITING FOR SO THAT THES CARS WILL BE RECALLED? *TR
NHTSA ODI #10383918
90,000 miles · Oct 25, 2010
Engine And Engine Cooling
TL*THE CONTACT OWNS A 2001 PONTIAC GRAND AM. WHEN THE CONTACT ATTEMPTED TO START THE VEHICLE, IT WOULD NOT RESPOND. THE VEHICLE WAS TOWED TO A LOCAL REPAIR SHOP WHERE THE IGNITION SWITCH WAS REPLACED. THE FAILURE OCCURRED FIVE MONTHS LATER; THIS TIME, THE VEHICLE WAS ABLE TO BE STARTED AFTER IT WAS TOWED. THE VEHICLE WAS TAKEN T…
Read full complaint
TL*THE CONTACT OWNS A 2001 PONTIAC GRAND AM. WHEN THE CONTACT ATTEMPTED TO START THE VEHICLE, IT WOULD NOT RESPOND. THE VEHICLE WAS TOWED TO A LOCAL REPAIR SHOP WHERE THE IGNITION SWITCH WAS REPLACED. THE FAILURE OCCURRED FIVE MONTHS LATER; THIS TIME, THE VEHICLE WAS ABLE TO BE STARTED AFTER IT WAS TOWED. THE VEHICLE WAS TAKEN TO ANOTHER LOCAL REPAIR SHOP BUT THE FAILURE COULD NOT BE DUPLICATED. THE VEHICLE HAD NOT BEEN REPAIRED AGAIN. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS APPROXIMATELY 90,000 AND THE CURRENT MILEAGE WAS APPROXIMATELY 175,000.
NHTSA ODI #10362327
Official recalls
4Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Aug 28, 2003
CERTAIN PASSENGER VEHICLES HAVE HAZARD WARNING SWITCHES THAT MAY EXPERIENCE SOLDER JOINT CRACKING CAUSED BY RAPID TEMPERATURE TRANSITIONS AND THE SOLDERING PROCESS. IF SOLDER JOINT CRACKING OCCURS AND RESULTS IN AN OPEN CIRCUIT, THE TURN SIGNALS/HAZARD LAMPS BECOME INTERMITTENT OR INOPERATIVE.
Consequence & remedy
Consequence: WHEN THE TURN SIGNALS ARE INOPERATIVE, THE DRIVER CANNOT USE THEM TO SIGNAL INTENT TO TURN THAT COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD WARNING SWITCH. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
Jul 15, 2003
CERTAIN MINIVANS, PASSENGER AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEM." THE OWNER'S MANUAL DOES NOT EXPLAIN THE MEANING OF THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT LOWER UNIVERSAL ANCHORAGE SYSTEM.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: OWNERS WILL BE PROVIDED WITH A SUPPLEMENT FOR THEIR OWNER'S MANUAL. THIS SUPPLEMENT DESCRIBES AND SHOWS THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT ANCHORS THAT ARE LOCATED IN THE VEHICLE AND ON THE CHILD RESTRAINT OR BOOSTER CUSHION. OWNER NOTIFICATION BEGAN AUGUST 18, 2003. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
Nov 13, 2000
VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES EQUIPPED WITH MANUAL TRANSAXLES (RPO M86) FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 114, "THEFT PROTECTION." WHEN A DRIVER ATTEMPTS TO SHIFT FROM 5TH GEAR TO REVERSE, A SHIFT INHIBITOR CAUSES THE TRANSMISSION TO BE MECHANICALLY IN 4TH GEAR EVEN THOUGH THE SHIFT LEVER INDICATES REVERSE GEAR.
Consequence & remedy
Consequence: IN THIS SITUATION, THE KEY CAN BE REMOVED FROM THE IGNITION WHILE THE TRANSMISSION IS IN A FORWARD GEAR, WHICH IS NOT PERMITTED BY THE STANDARD.
Remedy: DEALERS WILL DISABLE THE 5TH/REVERSE INHIBITOR BY REMOVING A RETAINING PIN AND REPLACE THE SHIFTER ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA02037 · Turn Signal Failures
Opened Dec 23, 2002 · Closed Sep 5, 2003
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights; Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:turn Signal; Exterior Lighting:turn Signal:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Exterior Lighting:hazard Flashing Warning Lights
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:hazard Flashing Warning Lights:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:turn Signal
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:turn Signal:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
EA02028 · Erratic Fuel Gauge
Opened Sep 30, 2002 · Closed Dec 30, 2003
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Other:storage:fuel Gauge System
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Fuel System, Gasoline
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Fuel System, Other:storage:fuel Gauge System
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
SQ01002 · Erratic Fuel Gauge
Opened Jan 26, 2001 · Closed Sep 30, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
Illustration