NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
232 reportsClear category filter95,000 miles · Sep 26, 2010
Electrical System
I OWN A 2001 PONTIAC GRAND AM. IT USES THE "PASSLOCK II" FACTORY SECURITY SYSTEM. I WAS TOLD BY A FORMER GM MECHANIC THAT THE PASSLOCK II SYSTEM WILL FAIL WHEN THE CAR REACHES APPROXIMATELY 95,000 MILES ON THE ODOMETER. THE PASSLOCK II SYSTEM NOW REQUIRES DAILY RESETS, CAUSING THE CAR TO START NORMALLY ONLY UNTIL IT SITS FOR …
Read full complaint
I OWN A 2001 PONTIAC GRAND AM. IT USES THE "PASSLOCK II" FACTORY SECURITY SYSTEM. I WAS TOLD BY A FORMER GM MECHANIC THAT THE PASSLOCK II SYSTEM WILL FAIL WHEN THE CAR REACHES APPROXIMATELY 95,000 MILES ON THE ODOMETER. THE PASSLOCK II SYSTEM NOW REQUIRES DAILY RESETS, CAUSING THE CAR TO START NORMALLY ONLY UNTIL IT SITS FOR ANY LENGTH OF TIME. I HAVE TALKED WITH THE DEALERSHIPS ABOUT THIS AND THEY "AREN'T EXACTLY SURE" WHAT THE ROOT CAUSE IS. I HAVE DONE RESEARCH ACROSS THE INTERNET, AND IT SEEMS THAT HUNDREDS, IF NOT THOUSANDS OF PEOPLE ARE AFFECTED BY THIS, SPECIFICALLY THOSE WHO OWN PONTIAC GRAND AMS AND OLDSMOBILE ALEROS EMPLOYING THE PASSLOCK II ANTI-THEFT SYSTEM. THERE ARE "SHADE-TREE FIXES FOR THIS PROBLEM, BUT NOW THAT GM IS A GOVERNMENT OWNED CORPORATION, THIS PROBLEM SHOULD BE ADDRESSED AND REMEDIED IN THE FORM OF A RECALL. THE OWNER OF EACH VEHICLE SHOULD NOT BE SUBJECTED TO HUNDREDS TO THOUSANDS OF DOLLARS IN DEALERSHIP REPAIR COSTS FOR PARTS DESIGNED TO FAIL AT 100,000 MILES. GM AS A WHOLE CAN CHARGE THE SUBCONTRACTOR FOR REPLACEMENT PARTS. THANK YOU FOR YOUR TIME. PLEASE CONTACT ME FOR ANY OTHER INFORMATION YOU MAY NEED. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10357654
Mileage unknown · Sep 10, 2010
Electrical System
TL* THE CONTACT OWNS A 2001 PONTIAC GRAND AM SE. THE CONTACT STATED THE VEHICLE WOULD INTERMITTENTLY FAIL TO START. HE WAS ABLE TO TURN THE KEY IN THE IGNITION BUT THE ENGINE WOULD NOT ENGAGE. THE VEHICLE WAS TOWED TO A LOCAL MECHANIC WHO ADVISED THAT THE PASS LOCK SECURITY SYSTEM WAS DEFECTIVE. THE MECHANIC RESET THE SECURITY S…
Read full complaint
TL* THE CONTACT OWNS A 2001 PONTIAC GRAND AM SE. THE CONTACT STATED THE VEHICLE WOULD INTERMITTENTLY FAIL TO START. HE WAS ABLE TO TURN THE KEY IN THE IGNITION BUT THE ENGINE WOULD NOT ENGAGE. THE VEHICLE WAS TOWED TO A LOCAL MECHANIC WHO ADVISED THAT THE PASS LOCK SECURITY SYSTEM WAS DEFECTIVE. THE MECHANIC RESET THE SECURITY SYSTEM. THE FAILURE RECURRED. THE CONTACT STATED HE WOULD HAVE TO TURN THE KEY TO THE ON POSITION FOR APPROXIMATLEY 10 MINUTES AND THEN RETURN TO THE OFF POSITION IN THREE SETS OF 12 BEFORE THE VEHICLE WOULD RESTART. THE DEALER CONFIRMED THAT THE SECURITY PASS LOCK WAS FAULTY AND REPLACED A PART RELATIVE TO THE SECURITY SYSTEM BUT TO NO AVAIL. THE FAILURE PERSISTED AND THE CONTACT WAS UNABLE TO RESTART THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 132,500.
NHTSA ODI #10354857
60,000 miles · Aug 26, 2010
Electrical System
I HAVE OWNED MY 2001 PONTIAC GRAND AM SE FOR 2 YEARS. IT WAS GIVEN TO ME FROM MY MOTHER. BEFORE OWNING THE CAR, MY MOTHER COMPLAINED OF THE TURN SIGNAL NOISE CONSTANTLY GOING AT A SPORADIC RATE AT RANDOM TIMES. IT STILL MAKES THIS NOISE AT A CONSTANT RATE TO THIS VERY DAY. AT TIMES, I EVEN NOTICE A VERY TINY AMOUNT OF SMOKE COMI…
Read full complaint
I HAVE OWNED MY 2001 PONTIAC GRAND AM SE FOR 2 YEARS. IT WAS GIVEN TO ME FROM MY MOTHER. BEFORE OWNING THE CAR, MY MOTHER COMPLAINED OF THE TURN SIGNAL NOISE CONSTANTLY GOING AT A SPORADIC RATE AT RANDOM TIMES. IT STILL MAKES THIS NOISE AT A CONSTANT RATE TO THIS VERY DAY. AT TIMES, I EVEN NOTICE A VERY TINY AMOUNT OF SMOKE COMING FROM THE STEERING COLUMN. I RESEARCHED THIS ONLINE AND THIS IS A COMMON PROBLEM AMONG GRAND AM OWNERS. SINCE I HAVE SEEN OTHERS ARE HAVING THE SAME PROBLEM, I CALLED THE DEALERSHIP TO SEE IF THERE IS A RECALL ON THE VEHICLE. I GAVE MY VIN AND I WAS TOLD THAT THERE IS NO RECALL ON THE CAR ALTHOUGH I DO SEE A RECALL ABOUT THE HAZARD LIGHT SWITCH ONLINE. I BELIEVE THIS COULD POSSIBLY CAUSE AN ELECTRICAL FIRE. IT HAS NOT HAPPENED TO ME YET, BUT IF IT DOES ANY I AM HURT AS A RESULT, THERE WILL BE A LAWSUIT. *TR
NHTSA ODI #10352182
78,152 miles · Aug 5, 2010
Electrical SystemEquipmentLatches/locks/linkages
CAR WON'T START. LEAVES ME (WIDOW) STRANDED WHEREVER I AM, AWAITING TOW TRUCK. THESE ARE WHAT HAVE BEEN REPEATED CULPRITS - DEFECTIVE PASS DOOR LOCK, DEFECTIVE HAZARD SWITCH (2 REPLACEMENTS) FAULTY IGNITION SWITCH (2 REPLACEMENTS), FAULTY IGNITION PASS LOCK SENSOR... THIS CAR HAS ALOT OF FAULTY REPLACED OVER AND OVER AGAIN SINC…
Read full complaint
CAR WON'T START. LEAVES ME (WIDOW) STRANDED WHEREVER I AM, AWAITING TOW TRUCK. THESE ARE WHAT HAVE BEEN REPEATED CULPRITS - DEFECTIVE PASS DOOR LOCK, DEFECTIVE HAZARD SWITCH (2 REPLACEMENTS) FAULTY IGNITION SWITCH (2 REPLACEMENTS), FAULTY IGNITION PASS LOCK SENSOR... THIS CAR HAS ALOT OF FAULTY REPLACED OVER AND OVER AGAIN SINCE 2004, 2006, 2008, 2009 AND 2010... LATEST REPLACEMENT OF FAULTY PASS DOOR LOCK SENSOR IS LISTED BELOW... *TR
NHTSA ODI #10347562
120,000 miles · Jul 26, 2010
Electrical System
TL* THE CONTACT OWNS A 2001 PONTIAC GRAND AM. THE CONTACT STATED THAT THE VEHICLE WOULD NOT START ON AN INTERMITTENT BASIS. THE CONTACT STATED THE FAILURE WAS CONTRIBUTED TO THE PASS LOCK MECHANISM. WHEN THE VEHICLE THOUGHT IT WAS BEING STOLEN, IT WOULD NOT ALLOW HER TO ACCELERATE. SHE WOULD MAKE SEVERAL ATTEMPTS TO TURN THE KE…
Read full complaint
TL* THE CONTACT OWNS A 2001 PONTIAC GRAND AM. THE CONTACT STATED THAT THE VEHICLE WOULD NOT START ON AN INTERMITTENT BASIS. THE CONTACT STATED THE FAILURE WAS CONTRIBUTED TO THE PASS LOCK MECHANISM. WHEN THE VEHICLE THOUGHT IT WAS BEING STOLEN, IT WOULD NOT ALLOW HER TO ACCELERATE. SHE WOULD MAKE SEVERAL ATTEMPTS TO TURN THE KEY IN THE IGNITION BUT TO NO AVAIL. THE MANUFACTURER WOULD NOT PROVIDE ANY ASSISTANCE. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS APPROXIMATELY 120,000 AND THE CURRENT MILEAGE WAS APPROXIMATELY 156,000.
NHTSA ODI #10345252
120,000 miles · Jul 9, 2010
Electrical System
TL*THE CONTACT OWNS A 2001 PONTIAC GRAND AM. THE CONTACT STATED THAT THE VEHICLE WOULD NOT START. AFTER REPEATED ATTEMPTS THE VEHICLE WAS UNABLE TO START. THE FAILURE WAS NOT DIAGNOSED BY A DEALER TO DETERMINE THE CAUSE OF FAILURE. THE FAILURE AND CURRENT MILEAGES WERE 120,000. UPDATED 09/29/10. *LJ UPDATED 10/25/10 *BF …
Read full complaint
TL*THE CONTACT OWNS A 2001 PONTIAC GRAND AM. THE CONTACT STATED THAT THE VEHICLE WOULD NOT START. AFTER REPEATED ATTEMPTS THE VEHICLE WAS UNABLE TO START. THE FAILURE WAS NOT DIAGNOSED BY A DEALER TO DETERMINE THE CAUSE OF FAILURE. THE FAILURE AND CURRENT MILEAGES WERE 120,000. UPDATED 09/29/10. *LJ UPDATED 10/25/10 *BF THE CONSUMER STATED VEHICLE FINALLY STARTED AFTER LEAVING THE KEY IN THE ON POSITION FOR 10 MINUTES OR UNTIL THE SECURITY LIGHT STOPPED BLINKING. UPDATED 10/27/10
NHTSA ODI #10342143
94,000 miles · Jul 7, 2010
Electrical SystemService Brakes, Hydraulic
TL*THE CONTACT OWNS A 2001 PONTIAC GRAND AM. THE CONTACT STATED THAT THE BRAKES MADE A NOISE AND BEGAN TO VIBRATE WHILE DRIVING APPROXIMATELY 15 MPH. A LOCAL MECHANIC WAS UNABLE TO DIAGNOSE THE FAILURE. THE CONTACT ALSO STATED THAT THE SECURITY LIGHT ILLUMINATED WHENEVER SHE TRIED TO START THE VEHICLE. SHE HAD TO WAIT APPROXIM…
Read full complaint
TL*THE CONTACT OWNS A 2001 PONTIAC GRAND AM. THE CONTACT STATED THAT THE BRAKES MADE A NOISE AND BEGAN TO VIBRATE WHILE DRIVING APPROXIMATELY 15 MPH. A LOCAL MECHANIC WAS UNABLE TO DIAGNOSE THE FAILURE. THE CONTACT ALSO STATED THAT THE SECURITY LIGHT ILLUMINATED WHENEVER SHE TRIED TO START THE VEHICLE. SHE HAD TO WAIT APPROXIMATELY 10 MINUTES, REMOVE THE KEY FROM THE IGNITION, AND THEN THE VEHICLE BEGAN TO FUNCTION NORMALLY. THE SPEEDOMETER ALSO BEGAN TO MALFUNCTION. GENERAL MOTORS WAS NOTIFIED BUT THE CONTACT HAS NOT RECEIVED A RESPONSE FROM THEM. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE AND CURRENT MILEAGES WERE APPROXIMATELY 84,000.
NHTSA ODI #10341805
140,000 miles · Jun 29, 2010
Electrical System
01 PONTIAC GRAND AM HAVING PROBLEMS STARTING. IT SEEMS THAT IT IS AN OVERALL PROBLEM WITH THESE MODELS OF GRAND AMS. I RESEARCH THE WEB AND FIND MANY UPON MANY OF OTHER PEOPLE HAVING THE SAME EXACT PROBLEMS. WHEN GOING TO START THE CAR SOMETIMES IT WILL NOT. WHEN THIS HAPPENS YOU HAVE TO RESET THE SECURITY WHICH YOU HAVE TO LEAV…
Read full complaint
01 PONTIAC GRAND AM HAVING PROBLEMS STARTING. IT SEEMS THAT IT IS AN OVERALL PROBLEM WITH THESE MODELS OF GRAND AMS. I RESEARCH THE WEB AND FIND MANY UPON MANY OF OTHER PEOPLE HAVING THE SAME EXACT PROBLEMS. WHEN GOING TO START THE CAR SOMETIMES IT WILL NOT. WHEN THIS HAPPENS YOU HAVE TO RESET THE SECURITY WHICH YOU HAVE TO LEAVE THE KEY ON FOR OVER 11 MINS TO RESET IT. I HAVE HAD THIS PROBLEM WITH MY CAR FOR OVER 6 MONTHS NOW. AND TODAY IT HAS STARTED DOING IT EVERY TIME I START THE CAR. THERE SHOULD OF DEFINITELY BEEN A RECALL ON THIS. LIKE OTHER MODELS HAVE HAD. *TR
NHTSA ODI #10340648
125,000 miles · Jun 23, 2010
Electrical System
I HAVE A 2001 PONTIAC GRAND AM GT V6 3400. THE PASSLOCK/SECURITY SYSTEM HAS PROVEN TO BE FAULTY ON NUMEROUS OCCASIONS. IN THE RECENT PAST THE SECURITY LIGHT WOULD RANDOMLY FLASH PREVENTING ME FROM STARTING MY CAR FOR UP TO 10-15 MINUTES. IT HAS MORE RECENTLY TAKEN A TURN FOR THE WORSE. NOW MY SECURITY LIGHT IS ON SOLID. I C…
Read full complaint
I HAVE A 2001 PONTIAC GRAND AM GT V6 3400. THE PASSLOCK/SECURITY SYSTEM HAS PROVEN TO BE FAULTY ON NUMEROUS OCCASIONS. IN THE RECENT PAST THE SECURITY LIGHT WOULD RANDOMLY FLASH PREVENTING ME FROM STARTING MY CAR FOR UP TO 10-15 MINUTES. IT HAS MORE RECENTLY TAKEN A TURN FOR THE WORSE. NOW MY SECURITY LIGHT IS ON SOLID. I CAN TURN MY CAR ON BUT WITHIN 1-2 SECONDS IT SHUTS OFF. I HAVE NOT HAD ANY THEFT ATTEMPTS, YET MY CAR THINKS I AM TRYING TO STEAL IT. I BELIEVE THE COMPUTER IS FAULTY AND RECOGNIZING PROBLEMS THAT DO NOT EXIST. ALONG WITH THE PROBLEM OF THE CAR NOT STARTING, THE KEYLESS ENTRY (ALSO PROVIDED BY MY GM DEALER, NOT SECOND HAND) IS USELESS. I HAVE NO CONTROL OVER MY CAR, FOR IT IS IN SHUTDOWN. IF I WERE TO REPLACE THE IGNITION CYLINDER IT WOULD COST $200 FOR THE PART AND ANOTHER $2000 TO GET THE PART REPLACED PROFESSIONALLY. I WISH GM COULD STAND BEHIND THIS FAULTY PRODUCT THAT SO MANY PEOPLE LIKE MYSELF HAVE STRUGGLED WITH. I AM A PROUD OWNER OF MY CAR AND WOULD LOVE NOTHING MORE THAN TO KEEP IT, BUT I WOULD LIKE TO BE ABLE TO DRIVE IT. PASSLOCK/SECURITY SYSTEMS IN THIS MODEL ARE FAULTY AND I'M NOT ALONE IN THIS RECOGNITION. *TR
NHTSA ODI #10339740
Mileage unknown · Jun 10, 2010
Electrical System
I HAVE HAD TO REPLACE MY PASSLOCK CHIP 3 TIMES IN MY PONTIAC GRAND AM. THIS HAS TO BE SOME SORT OF DEFECT. *TR
NHTSA ODI #10335749
Official recalls
4Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Aug 28, 2003
CERTAIN PASSENGER VEHICLES HAVE HAZARD WARNING SWITCHES THAT MAY EXPERIENCE SOLDER JOINT CRACKING CAUSED BY RAPID TEMPERATURE TRANSITIONS AND THE SOLDERING PROCESS. IF SOLDER JOINT CRACKING OCCURS AND RESULTS IN AN OPEN CIRCUIT, THE TURN SIGNALS/HAZARD LAMPS BECOME INTERMITTENT OR INOPERATIVE.
Consequence & remedy
Consequence: WHEN THE TURN SIGNALS ARE INOPERATIVE, THE DRIVER CANNOT USE THEM TO SIGNAL INTENT TO TURN THAT COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD WARNING SWITCH. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
Jul 15, 2003
CERTAIN MINIVANS, PASSENGER AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEM." THE OWNER'S MANUAL DOES NOT EXPLAIN THE MEANING OF THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT LOWER UNIVERSAL ANCHORAGE SYSTEM.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: OWNERS WILL BE PROVIDED WITH A SUPPLEMENT FOR THEIR OWNER'S MANUAL. THIS SUPPLEMENT DESCRIBES AND SHOWS THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT ANCHORS THAT ARE LOCATED IN THE VEHICLE AND ON THE CHILD RESTRAINT OR BOOSTER CUSHION. OWNER NOTIFICATION BEGAN AUGUST 18, 2003. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
Nov 13, 2000
VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES EQUIPPED WITH MANUAL TRANSAXLES (RPO M86) FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 114, "THEFT PROTECTION." WHEN A DRIVER ATTEMPTS TO SHIFT FROM 5TH GEAR TO REVERSE, A SHIFT INHIBITOR CAUSES THE TRANSMISSION TO BE MECHANICALLY IN 4TH GEAR EVEN THOUGH THE SHIFT LEVER INDICATES REVERSE GEAR.
Consequence & remedy
Consequence: IN THIS SITUATION, THE KEY CAN BE REMOVED FROM THE IGNITION WHILE THE TRANSMISSION IS IN A FORWARD GEAR, WHICH IS NOT PERMITTED BY THE STANDARD.
Remedy: DEALERS WILL DISABLE THE 5TH/REVERSE INHIBITOR BY REMOVING A RETAINING PIN AND REPLACE THE SHIFTER ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA02037 · Turn Signal Failures
Opened Dec 23, 2002 · Closed Sep 5, 2003
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights; Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:turn Signal; Exterior Lighting:turn Signal:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Exterior Lighting:hazard Flashing Warning Lights
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:hazard Flashing Warning Lights:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:turn Signal
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:turn Signal:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
EA02028 · Erratic Fuel Gauge
Opened Sep 30, 2002 · Closed Dec 30, 2003
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Other:storage:fuel Gauge System
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Fuel System, Gasoline
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Fuel System, Other:storage:fuel Gauge System
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
SQ01002 · Erratic Fuel Gauge
Opened Jan 26, 2001 · Closed Sep 30, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
Illustration