Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 78 of 450 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Electrical System. Review the 122 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Air Bags. Review the 104 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine And Engine Cooling. Review the 74 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
32 crash reports14 fire reports52 injury reports
What owners actually said
450 reports
Mileage unknown · Nov 19, 1999
Engine And Engine Cooling
I'M HAVING PROBLEMS WITH MY COOLING SYSTEM.I'M ALWAYS LOSING COOLANT . SOMETIMES IT'S VISBLE AND LEAKS TO THE GROUND. OTHER TIMES I CAN'T FIND WHERE THE COOLANT IS LEAKING TOO. I ALWAYS HAVE TO CHECK MY COOLANT LEVEL AND ADD COOLANT MOST OF THE TIME. I HEAR A LOUD NOISE IN MY DASHBOARD WHILE DRIVING SOMETIMES. IT SOUNDS LIK…
Read full complaint
I'M HAVING PROBLEMS WITH MY COOLING SYSTEM.I'M ALWAYS LOSING COOLANT . SOMETIMES IT'S VISBLE AND LEAKS TO THE GROUND. OTHER TIMES I CAN'T FIND WHERE THE COOLANT IS LEAKING TOO. I ALWAYS HAVE TO CHECK MY COOLANT LEVEL AND ADD COOLANT MOST OF THE TIME. I HEAR A LOUD NOISE IN MY DASHBOARD WHILE DRIVING SOMETIMES. IT SOUNDS LIKE SOMETHING IS LOOSE. *AK
NHTSA ODI #715028
Mileage unknown · Nov 17, 1999
Engine And Engine CoolingSuspensionFire
WHILE DRIVING UPHILL CAR MADE A LOUD NOISE AND THE FRONT END WAS SHIFTING TO THE RIGHT. ALSO, ENGINE HAD EXPLODED AND VEHICLE WAS ON FIRE. VEHICLE WAS TOTALED. *AK
NHTSA ODI #850399
Mileage unknown · Nov 3, 1999
Air BagsCrashInjury
WHILE DRIVING 35- 40 MPH, VEHICLE HAD A DIRECT FRONTAL IMPACT, AND DRIVER/PASSENGER AIRBAGS DID NOT DEPLOY, WHICH DID NOT PROTECT THE OCCUPANT. ALSO, DRIVER'S SEATBELT DID NOT RETRACT DURING THE IMPACT, CAUSING THE DRIVER TO SUSTAIN INJURIES. NO PREVIOUS PROBLEMS WITH AIRBAG OR SEATBELT. PLEASE PROVIDE FURTHER INFORMATION. …
Read full complaint
WHILE DRIVING 35- 40 MPH, VEHICLE HAD A DIRECT FRONTAL IMPACT, AND DRIVER/PASSENGER AIRBAGS DID NOT DEPLOY, WHICH DID NOT PROTECT THE OCCUPANT. ALSO, DRIVER'S SEATBELT DID NOT RETRACT DURING THE IMPACT, CAUSING THE DRIVER TO SUSTAIN INJURIES. NO PREVIOUS PROBLEMS WITH AIRBAG OR SEATBELT. PLEASE PROVIDE FURTHER INFORMATION. *AK
NHTSA ODI #852469
Mileage unknown · Nov 3, 1999
Service Brakes, HydraulicVehicle Speed Control
WHILE DRIVING ENGINE MALFUNCTIONED, CAUSING THE IDLE TO BE TOO HIGH, RESULTING IN VEHICLE ACCLERATING AND SLOWING DOWN. THIS MAY CAUSE A CRASH. THE BRAKING SYSTEM IS HAVING MORE WEAR AND TEAR. PLEASE PROVIDE FURTHER INFORMATION. *AK
NHTSA ODI #852454
Mileage unknown · Nov 3, 1999
Exterior Lighting
THE DRL SENSOR CAUSES THE LOW BEAM HEAD LIGHTS TO BE ON DURING DAYLIGHT HOURS
NHTSA ODI #714268
Mileage unknown · Oct 29, 1999
Air Bags
THE SENSOR, DUE TO WATER IN AND UNDER THE CARPETING,CAUSED THE DRIVER SIDE AIR BAG TO DEPLOY. YH
NHTSA ODI #549366
Mileage unknown · Oct 13, 1999
Steering
WHILE TRAVELING AND MAKING A TURN STERRING WHIEEL LOCKED UP, CAUSING CONSUMER TO JERK THE STERRING WHEEL . PLEASE PROVIDE FURTHER INFORJMATON. DRL HAS BEEN CONTACTED. *AK
NHTSA ODI #850578
Mileage unknown · Oct 10, 1999
Electrical SystemEngine And Engine CoolingService Brakes, Air
MY EXTENDED WARANTY PUT A USED ENGINE IN AFTER THE ORIGINAL BLEW UP. THE ENGINE THEY SENT HAD TO BE SENT BACK BECAUSE IT WAS ALSO NO GOOD . IT HAD 18,000 ON IT WHEN IT WAS SENT TO REPLACE. NOW THEY ARE SENDING ANOTHER ENGINE . IT IS NOW A MONTH LATER THEN WHEN I TOOK IT TO THE SHOP AND IT IS STILL NOT FIXED. I THINK SOMEONE OWES…
Read full complaint
MY EXTENDED WARANTY PUT A USED ENGINE IN AFTER THE ORIGINAL BLEW UP. THE ENGINE THEY SENT HAD TO BE SENT BACK BECAUSE IT WAS ALSO NO GOOD . IT HAD 18,000 ON IT WHEN IT WAS SENT TO REPLACE. NOW THEY ARE SENDING ANOTHER ENGINE . IT IS NOW A MONTH LATER THEN WHEN I TOOK IT TO THE SHOP AND IT IS STILL NOT FIXED. I THINK SOMEONE OWES ME SOMETHING.
NHTSA ODI #713087
Mileage unknown · Oct 4, 1999
Visibility
ON 09/09/99 MY LEFT REAR DOOR POWER WINDOW MOTOR FAILED ME AND WAS REPLACED AT THE COST OF $310.27. ON 10/02/99 THE RIGHT REAR DOOR POWER WINDOW MOTOR FAILED AND I AM SCHEDULED TO HAVE IT REPLACED ON 10/06/99.
NHTSA ODI #712803
Mileage unknown · Oct 3, 1999
Electrical SystemEngine And Engine CoolingEquipment
CONTINUALLY DISREGARDED BY DEALERSHIPS AND CORPORATE OFFICES
ON CERTAIN PASSENGER VEHICLES. IF THE ENGINE FAILS TO START AND THE DRIVER HOLDS THE KEY IN THE "START" POSITION FOR AN EXTENDED PERIOD, HIGH CURRENT FLOWS THROUGH THE IGNITION SWITCH, AND SOMETIMES PRODUCES ENOUGH HEAT TO MELT INTERNAL SWITCH PARTS.
Consequence & remedy
Consequence: IF THE SWITCH IS DAMAGED, A FIRE COULD OCCUR IN THE STEERING COLUMN, EVEN WITH THE ENGINE OFF AND THE KEY REMOVED.
Remedy: DEALERS WILL INSTALL A RELAY KIT IN THESE VEHICLES TO PREVENT HIGH CURRENT FROM FLOWING THROUGH THE IGNITION SWITCH. OWNER NOTIFICATION BEGAN MARCH 27, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, BUICK AT 1-800-521-7300, OR OLDSMOBILE AT 1-800-442-6537.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THESE VEHICLES WERE BUILT WITH THE POTENTIAL FOR THE INTERIOR LAMPS TO COME ON UNEXPECTEDLY WHILE THE VEHICLES ARE BEING DRIVEN. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS NO. 101, "CONTROLS AND DISPLAYS."
Consequence & remedy
Consequence: THE INTERIOR LAMPS COMING ON UNEXPECTEDLY COULD STARTLE A DRIVER CAUSING A MOMENTARY LOSS OF CONTROL INCREASING THE RISK OF A VEHICLE ACCIDENT.
Remedy: DEALERS WILL RUN A DIAGNOSTIC TEST ON THE LAMP CONTROL MODULE AND, IF NECESSARY, REPLACE IT.
THE STEERING COLUMN LOWER PINCH BOLT WAS NOT PROPERLY TIGHTENED DURING ASSEMBLY.
Consequence & remedy
Consequence: AN UNDERTORQUED PINCH BOLT CAN RATTLE AND CAUSE LOOSENESS IN THE STEERING SYSTEM. IF THE PINCH BOLT BACKED OUT OF THE JOINT COMPLETELY, ROTATION OF THE STEERING SHAFT AGAINST THE CONNECTOR COULD CAUSE INCREASING LOOSENESS IN THE STEERING SYSTEM AND RESULT IN LOSS OF STEERING AND AN ACCIDENT.
Remedy: DEALERS WILL INSPECT THE STEERING COLUMN PINCH BOLT FOR CORRECT TORQUE AND, IF NECESSARY, TIGHTEN THE BOLT TO THE SPECIFIED TORQUE.
THE FRONT AND/OR REAR HAZARD WARNING LAMPS (FOUR-WAY FLASHERS) DO NOT FLASH WHEN THE HAZARD SWITCH IS ACTIVATED. THIS FAILS TO COMPLY WITH FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence & remedy
Consequence: IF THESE LAMPS WERE NOT FLASHING, OTHER VEHICLES WOULD NOT BE AWARE THAT THIS VEHICLE WAS STOPPED INCREASING THE RISK OF AN ACCIDENT.
Remedy: DEALERS OR VEHICLE OWNERS WILL INSPECT FOR PROPER FUNCTION OF THE HAZARD WARNING LAMPS. IF NECESSARY, DEALERS WILL REPLACE THE HAZARD LAMP SWITCH.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
RQ03001 · Power Rack And Pinion Steering Failure
Opened Jan 2, 2003 · Closed Sep 15, 2003
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Additional source detail variants (2)
Steering
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
RQ98013 · Oversensitive Air Bag Deployments
Opened Aug 26, 1998 · No close date supplied
Status: open (inferred from source dates) · Air Bags
ON JUNE 26, 1998, GENERAL MOTORS BEGAIN A SAFETY RECALL, 98V-146, TO RECALIBRATE THE AIR BAG SENSING AND DIAGNOSTIC MODULE (SDM) IN THE 1996 AND SOME 1997 J BODY CARS, CAVALIER AND SUNFIRE.DUE TO CERTAIN CALIBRATIONS IN THE AIR BAG SDM, THERE IS AN INCREASED RISK OF INADVERTENT AIR BAG DEPLOYMENT IN A LOW SPEED CRASH OR WHEN AN OBJECT STRIKES THE FLOOR PAN.THE RECALL POPULATION CONSISTS OF 675,302 VEHICLES BUILT FROM APRIL 1995 THROUGH MAY 1997.ODI HAS RECEIVED 8 OWNER REPORTS ALLEGING INADVERTENT AIR BAG DEPLOYMENT WITHOUT A CRASH.THE PURPOSER OF THE RQ IS TO DETERMINE WHETHER GM SHOULD EXPAND THE RECALL TO INCLUDE THESE VEHICLES.CLOSING RESUME NOTE:AS OF AUGUST 5, 1999, ODI RECEIVED ONE ADDITIONAL COMPLAINT REGARDING THE ALLEGED DEFECT.THE INCIDENT RATES FOR THE SUBJECT VEHICLES ARE ABOUT ONE-THRID OF THE RATES OF THE RECALLED VEHICLES (WHEN THE RECALL WAS INITIATED).BASED ON THE AVAILABLE INFORMATION, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOSE NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY FUTURE CIRCUMSTANCES.
1996 Pontiac Grand Am Problems, Complaints & Recalls | Skip That Year
Illustration