Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 78 of 450 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Electrical System. Review the 122 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Air Bags. Review the 104 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine And Engine Cooling. Review the 74 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
32 crash reports14 fire reports52 injury reports
What owners actually said
450 reports
Mileage unknown · May 30, 2000
Electrical SystemSteering
THIS IS THE THIRD REPLACEMENT OF THE IGNITION LOCK CYLINDER WITHIN TWO YEARS 1998-2000. IT SEEMS TO NEED REPLACED EVERY 9-12 MONTHS. I FEEL THIS IS AN OBVIOUS PROBLEM AND SHOULD BE CORRECTED. THE SEAT ANCHOR HAS BEEN REPORTED EACH TIME I TAKE THE CAR TO THE DEALERSHIP. THE LAST TIME I WAS TOLD TO RECLINE THE SEAT TO PREVENT …
Read full complaint
THIS IS THE THIRD REPLACEMENT OF THE IGNITION LOCK CYLINDER WITHIN TWO YEARS 1998-2000. IT SEEMS TO NEED REPLACED EVERY 9-12 MONTHS. I FEEL THIS IS AN OBVIOUS PROBLEM AND SHOULD BE CORRECTED. THE SEAT ANCHOR HAS BEEN REPORTED EACH TIME I TAKE THE CAR TO THE DEALERSHIP. THE LAST TIME I WAS TOLD TO RECLINE THE SEAT TO PREVENT THE PROBLEM. I DO NOT FEEL THIS IS AN ACCEPTABLE ANSWER TO THE PROBLEM. *AK
NHTSA ODI #723334
Mileage unknown · May 26, 2000
Visibility
WHILE TRAVELING AT HIGHWAY SPEED OF 60 MPH REAR WINDOW DETACHED FROM VEHICLE AND SHATTERED IN MID -AIR, REASON UNKNOWN. DEALER / MANUFACTURER NOTIFIED, AND INFORMED CONSUMER THAT NOTHING WOULD BE DONE UNLESS COST GO TO CONSUMER. *AK
NHTSA ODI #862638
Mileage unknown · May 22, 2000
Electrical SystemFire
CONSUMER WAS INSIDE OF VEHICLE . STARTED VEHICLE UP, AND NOTICED SMOKE COMING UNDERNEATH THE DASHBOARD. FIRE DEPARTMENT WAS CALLED.*AK
NHTSA ODI #862338
Mileage unknown · May 10, 2000
Engine And Engine CoolingStructure
UNDER WARRANTY, REPORTED THE TRUNK AND REAR SPOILER FOR WATER LEAKAGE. EVERY TIME DEALER ANSWER, RESEALED TRUNK. AT 5TH ATTEMPT TO REPAIR LEAK OWNER REQUESTED SPOILER TO BE REPLACED DEALER REFUSED TO REPLACE, OWNER FRUSTRATED. 2. ENGINE CONSUMES 1 QUART OF OIL EVERY 1500-3000 MILES DEALER RESPONDS WITH NO PROBLEMS. 2ND ATTEMPT …
Read full complaint
UNDER WARRANTY, REPORTED THE TRUNK AND REAR SPOILER FOR WATER LEAKAGE. EVERY TIME DEALER ANSWER, RESEALED TRUNK. AT 5TH ATTEMPT TO REPAIR LEAK OWNER REQUESTED SPOILER TO BE REPLACED DEALER REFUSED TO REPLACE, OWNER FRUSTRATED. 2. ENGINE CONSUMES 1 QUART OF OIL EVERY 1500-3000 MILES DEALER RESPONDS WITH NO PROBLEMS. 2ND ATTEMPT DEALER PERFORMED OIL CONSUMPTION TEST RESULTS: NO PROBLEM, OWNER REPORTS STILL CONSUMES OIL AT SAME RATE. 3. CLUTCH: OWNER REPORTED THAT IT WAS DIFFICULT TO SHIFT OUT OF 1ST AND 3RD GEAR DEALER RESPONDED NO PROBLEM DRIVETRAIN. ALL REPORTED DURING WARRANTY PERIOD. OWNER CONTINUES TO DRIVE VEHICLE ALTHOUGH PROBLEM STILL CONTINUES. DEALER SERVICED VEHICLE OVERFILLED ALL FLUIDS OWNER DID NOT DISCOVER PROBLEM UNTIL AFTER 500 MILES OF DRIVING OWNER INFORMED DEALER THAT THEY WOULD BE RESPONSIBLE FOR DAMAGES TO VEHICLE AT A LATER DATE DUE TO PRE MATURE WEAR. CURRENT: 30000 LATER ENGINE CONTINUES TO CONSUME OIL AT HIGHER RATE APP. 1000 MILES 1 QT OF OIL , CLUTCH BURNED OUT AT 62000 MILES CURRENTLY IN SHOP AND GMAC WILL NOT REPAIR IN LUE OF PROIR SERVICE HISTORY. *AK
NHTSA ODI #722519
Mileage unknown · Apr 28, 2000
Electrical SystemSuspensionFire
THE STEERING WHEEL COLUMN MADE GRINDING NOISES WHEN MY 1996 GRAND AM SE WAS DRIVEN. THE NOISES EVEN PERSISTED AFTER THE GRAND AM WAS RETURNED TO THE ORIGINAL DEALERSHIP IN WASHINGTON, D.C. WHERE THE CAR WAS PURCHASED FROM FOR SERVICE/REPAIR IN DECEMBER 1999. THE SERVICE MANAGER INFORMED ME THE NOISES FROM THE STEERING WHEEL CO…
Read full complaint
THE STEERING WHEEL COLUMN MADE GRINDING NOISES WHEN MY 1996 GRAND AM SE WAS DRIVEN. THE NOISES EVEN PERSISTED AFTER THE GRAND AM WAS RETURNED TO THE ORIGINAL DEALERSHIP IN WASHINGTON, D.C. WHERE THE CAR WAS PURCHASED FROM FOR SERVICE/REPAIR IN DECEMBER 1999. THE SERVICE MANAGER INFORMED ME THE NOISES FROM THE STEERING WHEEL COLUMN COULD NOT BE FIXED AND SINCE THE CAR WAS "OLDER"- ONLY 3 YEARS OLD, ANY NOISES IN THE STEERING WHEEL COLUMN SHOULD BE EXPECTED AND ARE NORMAL FOR A 3 YEAR OLD CAR. THE SERVICE MANAGER TOLD ME HE WOULD LOOK AT THE STEERING WHEEL COLUMN AS WELL AS THE ELECTRICAL COMPONENETS UNDER THE DASHBOARD TO INVESTIGATE THE PROBLEM. THE SERVICE MANAGER INFORMED ME THAT HE DID THE BEST HE COULD DO TO FIND AND REPAIR THE NOISES IN THE STEERING WHEEL COLUMN. APPROXIMATELY THREE MONTHS LATER, AND CONTINUED TO HEAR GRINDING NOISES FROM THE STEERING WHEEL COLUMN, ON MARCH 31, 2000, AFTER DROPPING MY INFANT TO THE DAYCARE CENTER, I ATTEMPTED TO START THE CAR AND IT WOULD NOT START. THE STEERING WHEEL COLUMN IN ADDITION TO THE TURN SIGNAL CHAMBER ON THE STEERING WHEEL COLUMN BEGAN TO SMOKE. FLAMES BEGAN TO APPEAR FROM THE STEERING WHEEL COLUMN AND A STEADY FLOW OF SMOKE. THE ELECTRICAL FIRE INCREASED IN SIZE AND WAS FINALLY BROUGHT UNDER CONTROL BY TWO FIRE ENGINE COMPANIES. MY 1996 PONTIAC GRAND AM WAS TOWED, ASSESSED FOR DAMAGES AND FINALLY DEEMED UNSALVAGEABLE- A TOTAL LOSS. MY 1996 PONTIAC GRAND AM SE WAS ONLY THREE YEARS OLD. THIS INCIDENT SHOULD NOT HAVE OCCURRED.*AK( DOT NUMBER: )
NHTSA ODI #722065
Mileage unknown · Apr 13, 2000
Engine And Engine Cooling
SENSOR FAILED AND TEMPERATURE GAUGE DID NOT INDICATE THAT THE ENGINE WAS OVERHEATING. THE ENGINE SEIZED UP AND WAS SOLD FOR SALVAGE VALUE OR $1,500. THERE IS DOCUMENTED OIL CHANGES EVERY THREE THOUSAND MILES WITH SIMULTANEOUS COOLANT CHECKS. *AK
NHTSA ODI #721432
Mileage unknown · Mar 30, 2000
Electrical System
WHILE DRIVING VEHICLE COMPLETELY SHUT DOWN WITHOUT WARNING, DUE TO A MALFUNCTION WITHIN THE IGNITION SWITCH. PLEASE GIVE ANY FURTHER DETAILS. *AK
NHTSA ODI #859457
Mileage unknown · Mar 24, 2000
Engine And Engine CoolingPower Train
TRANSMISSION FAILED TWO TIMES. *ET
NHTSA ODI #784584
Mileage unknown · Mar 16, 2000
Suspension
BUSHING THAT HOLDS THE CONTROL ARM THAT IS CONNECTED TO THE CHASSIS MAY DEVELOP MORE WEAR AND TEAR. THIS COULD CAUSE IT TO BREAK OFF, AND RESULT IN LOSS OF CONTROL. PLEASE PROVIDE FURTHER INFORMATION. *AK
NHTSA ODI #858638
Mileage unknown · Mar 13, 2000
Engine And Engine CoolingPower TrainUnknown Or Other
ON CERTAIN PASSENGER VEHICLES. IF THE ENGINE FAILS TO START AND THE DRIVER HOLDS THE KEY IN THE "START" POSITION FOR AN EXTENDED PERIOD, HIGH CURRENT FLOWS THROUGH THE IGNITION SWITCH, AND SOMETIMES PRODUCES ENOUGH HEAT TO MELT INTERNAL SWITCH PARTS.
Consequence & remedy
Consequence: IF THE SWITCH IS DAMAGED, A FIRE COULD OCCUR IN THE STEERING COLUMN, EVEN WITH THE ENGINE OFF AND THE KEY REMOVED.
Remedy: DEALERS WILL INSTALL A RELAY KIT IN THESE VEHICLES TO PREVENT HIGH CURRENT FROM FLOWING THROUGH THE IGNITION SWITCH. OWNER NOTIFICATION BEGAN MARCH 27, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, BUICK AT 1-800-521-7300, OR OLDSMOBILE AT 1-800-442-6537.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THESE VEHICLES WERE BUILT WITH THE POTENTIAL FOR THE INTERIOR LAMPS TO COME ON UNEXPECTEDLY WHILE THE VEHICLES ARE BEING DRIVEN. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS NO. 101, "CONTROLS AND DISPLAYS."
Consequence & remedy
Consequence: THE INTERIOR LAMPS COMING ON UNEXPECTEDLY COULD STARTLE A DRIVER CAUSING A MOMENTARY LOSS OF CONTROL INCREASING THE RISK OF A VEHICLE ACCIDENT.
Remedy: DEALERS WILL RUN A DIAGNOSTIC TEST ON THE LAMP CONTROL MODULE AND, IF NECESSARY, REPLACE IT.
THE STEERING COLUMN LOWER PINCH BOLT WAS NOT PROPERLY TIGHTENED DURING ASSEMBLY.
Consequence & remedy
Consequence: AN UNDERTORQUED PINCH BOLT CAN RATTLE AND CAUSE LOOSENESS IN THE STEERING SYSTEM. IF THE PINCH BOLT BACKED OUT OF THE JOINT COMPLETELY, ROTATION OF THE STEERING SHAFT AGAINST THE CONNECTOR COULD CAUSE INCREASING LOOSENESS IN THE STEERING SYSTEM AND RESULT IN LOSS OF STEERING AND AN ACCIDENT.
Remedy: DEALERS WILL INSPECT THE STEERING COLUMN PINCH BOLT FOR CORRECT TORQUE AND, IF NECESSARY, TIGHTEN THE BOLT TO THE SPECIFIED TORQUE.
THE FRONT AND/OR REAR HAZARD WARNING LAMPS (FOUR-WAY FLASHERS) DO NOT FLASH WHEN THE HAZARD SWITCH IS ACTIVATED. THIS FAILS TO COMPLY WITH FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence & remedy
Consequence: IF THESE LAMPS WERE NOT FLASHING, OTHER VEHICLES WOULD NOT BE AWARE THAT THIS VEHICLE WAS STOPPED INCREASING THE RISK OF AN ACCIDENT.
Remedy: DEALERS OR VEHICLE OWNERS WILL INSPECT FOR PROPER FUNCTION OF THE HAZARD WARNING LAMPS. IF NECESSARY, DEALERS WILL REPLACE THE HAZARD LAMP SWITCH.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
RQ03001 · Power Rack And Pinion Steering Failure
Opened Jan 2, 2003 · Closed Sep 15, 2003
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Additional source detail variants (2)
Steering
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
RQ98013 · Oversensitive Air Bag Deployments
Opened Aug 26, 1998 · No close date supplied
Status: open (inferred from source dates) · Air Bags
ON JUNE 26, 1998, GENERAL MOTORS BEGAIN A SAFETY RECALL, 98V-146, TO RECALIBRATE THE AIR BAG SENSING AND DIAGNOSTIC MODULE (SDM) IN THE 1996 AND SOME 1997 J BODY CARS, CAVALIER AND SUNFIRE.DUE TO CERTAIN CALIBRATIONS IN THE AIR BAG SDM, THERE IS AN INCREASED RISK OF INADVERTENT AIR BAG DEPLOYMENT IN A LOW SPEED CRASH OR WHEN AN OBJECT STRIKES THE FLOOR PAN.THE RECALL POPULATION CONSISTS OF 675,302 VEHICLES BUILT FROM APRIL 1995 THROUGH MAY 1997.ODI HAS RECEIVED 8 OWNER REPORTS ALLEGING INADVERTENT AIR BAG DEPLOYMENT WITHOUT A CRASH.THE PURPOSER OF THE RQ IS TO DETERMINE WHETHER GM SHOULD EXPAND THE RECALL TO INCLUDE THESE VEHICLES.CLOSING RESUME NOTE:AS OF AUGUST 5, 1999, ODI RECEIVED ONE ADDITIONAL COMPLAINT REGARDING THE ALLEGED DEFECT.THE INCIDENT RATES FOR THE SUBJECT VEHICLES ARE ABOUT ONE-THRID OF THE RATES OF THE RECALLED VEHICLES (WHEN THE RECALL WAS INITIATED).BASED ON THE AVAILABLE INFORMATION, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOSE NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY FUTURE CIRCUMSTANCES.
1996 Pontiac Grand Am Problems, Complaints & Recalls | Skip That Year
Illustration