Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 78 of 450 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Electrical System. Review the 122 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Air Bags. Review the 104 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine And Engine Cooling. Review the 74 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
32 crash reports14 fire reports52 injury reports
What owners actually said
450 reports
146,242 miles · Mar 23, 2011
Air BagsInjury
TL*THE CONTACT OWNS A 1996 PONTIAC GRAND AM. THE CONTACT STATED THAT WHILE DRIVING 30 MPH THE DRIVERS SIDE AIR BAG EXPLODED AND THEN THE PASSENGER SIDE AIR BAG EXPLODED. AFTER THE EXPLOSION THE CONTACT CONTINUED TO DRIVE HOME AND PARK THE VEHICLE. THE AIR BAG HIT HER IN THE CHEST BUT SHE DID NOT GO TO THE HOSPITAL. THE VEHICLE W…
Read full complaint
TL*THE CONTACT OWNS A 1996 PONTIAC GRAND AM. THE CONTACT STATED THAT WHILE DRIVING 30 MPH THE DRIVERS SIDE AIR BAG EXPLODED AND THEN THE PASSENGER SIDE AIR BAG EXPLODED. AFTER THE EXPLOSION THE CONTACT CONTINUED TO DRIVE HOME AND PARK THE VEHICLE. THE AIR BAG HIT HER IN THE CHEST BUT SHE DID NOT GO TO THE HOSPITAL. THE VEHICLE WAS TAKEN TO THE DEALER WHO INSPECTED THE VEHICLE, FOUND NO OTHER DAMAGE AND CONTACTED THE MANUFACTURER. THE MANUFACTURER OFFERED HER $500 AS A BUY BACK FOR THE VEHICLE. COMPLAINT FILE#297715 WAS FILED WITH THE MANUFACTURER. THE FAILURE MILEAGE WAS 146,242.
NHTSA ODI #10392579
230,000 miles · Mar 21, 2011
Air Bags
TL* THE CONTACT OWNS A 1996 PONTIAC GRAND AM. THE CONTACT STATED THAT WHILE DRIVING 5 MPH, THE DRIVER AND PASSENGER AIR BAGS DEPLOYED WITHOUT WARNING. THE VEHICLE WAS NOT INSPECTED OR REPAIRED BY A DEALER OR MECHANIC. THE MANUFACTURER WAS CONTACTED BUT THE CONTACT WAS ADVISED TO CALL BACK THE FOLLOWING DAY. THE VEHICEL WAS NOT R…
Read full complaint
TL* THE CONTACT OWNS A 1996 PONTIAC GRAND AM. THE CONTACT STATED THAT WHILE DRIVING 5 MPH, THE DRIVER AND PASSENGER AIR BAGS DEPLOYED WITHOUT WARNING. THE VEHICLE WAS NOT INSPECTED OR REPAIRED BY A DEALER OR MECHANIC. THE MANUFACTURER WAS CONTACTED BUT THE CONTACT WAS ADVISED TO CALL BACK THE FOLLOWING DAY. THE VEHICEL WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS APPROXIMATELY 230,000.
NHTSA ODI #10392395
180,000 miles · Feb 28, 2011
Air BagsFire
TL - THE CONTACT OWNS A 1996 PONTIAC GRAND AM . THE CONTACT STATED THAT WHILE DRIVING 65 MPH THE AIR BAGS DEPLOYED WITHOUT ANY EXPLANATION. HE ALSO MENTIONED THAT THE AIR BAG ITSELF HAD BURN MARKS. THE DEALER NOR THE MANUFACTURER WERE NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 180,000. PM
NHTSA ODI #10384779
150,000 miles · Sep 3, 2010
Electrical System
ANTI-THEFT SYSTEM KEEPS ACTIVATING. HAD KEY SWITCH AND INSTRUMENT CLUSTER REPLACED. STILL HAPPENING!!!!! *TR
NHTSA ODI #10353700
145,000 miles · Aug 9, 2010
Air Bags
MY DAUGHTER WAS DRIVING OUR 1996 PONTIAC GRAND AM AT APPROXIMATELY 30MPH WHEN THE AIRBAG SUDDENLY DEPLOYED. *TR
NHTSA ODI #10348153
183,000 miles · Jul 21, 2010
Air Bags
TL-THE CONTACT OWNS A 1996 PONTIAC GRAND AM. WHILE THE VEHICLE WAS PARKED THE CONTACT HAD JUST PUT THE KEY IN THE IGNITION WHEN THE DRIVERS AIRBAG DEPLOYED. THE CONTACT WAS THEN DRIVING AT 30MPH WHEN THE PASSENGERS AIRBAG DEPLOYED WITHOUT A CRASH. THE DEALER WAS CONTACTED AND THEY STATED THAT THEY NEEDED TO INSPECT IT. AFTER THE…
Read full complaint
TL-THE CONTACT OWNS A 1996 PONTIAC GRAND AM. WHILE THE VEHICLE WAS PARKED THE CONTACT HAD JUST PUT THE KEY IN THE IGNITION WHEN THE DRIVERS AIRBAG DEPLOYED. THE CONTACT WAS THEN DRIVING AT 30MPH WHEN THE PASSENGERS AIRBAG DEPLOYED WITHOUT A CRASH. THE DEALER WAS CONTACTED AND THEY STATED THAT THEY NEEDED TO INSPECT IT. AFTER THE INSPECTION WAS DONE THEY TOLD HIM THE WIRES WERE CORRODED WHICH CAUSED THE DEPLOYMENT. THERE HAVE BEEN NO REPAIRS TO THE VEHICLE AND THEY STATED THIS ISSUE CAN'T BE REPAIRED. THE FAILURE MILEAGE WAS 183000 AND THE CURRENT MILEAGE WAS 185000.CV
NHTSA ODI #10344542
20,478 miles · Jun 29, 2010
Air BagsCrashInjury
I WAS TRAVELING ALONG THE HIGHWAY GOING EXACTLY 60 MPH WHEN SOMETHING POPPED CAUSING ME TO LOSE CONTROL OF MY VEHICLE ( ALL PASSENGERS WERE IN SEAT BELTS) WE SLID DOWN A DITCH HITTING A LIGHT POLE CAUSING THE VEHICLE TO COME TO A STOP NEITHER THE DRIVER OR THE PASSENGER BAG DEPLOYED. WE WERE TRAVELING AT A HIGH RATE OF SPEED AND…
Read full complaint
I WAS TRAVELING ALONG THE HIGHWAY GOING EXACTLY 60 MPH WHEN SOMETHING POPPED CAUSING ME TO LOSE CONTROL OF MY VEHICLE ( ALL PASSENGERS WERE IN SEAT BELTS) WE SLID DOWN A DITCH HITTING A LIGHT POLE CAUSING THE VEHICLE TO COME TO A STOP NEITHER THE DRIVER OR THE PASSENGER BAG DEPLOYED. WE WERE TRAVELING AT A HIGH RATE OF SPEED AND THE AIR BAGS MALFUNCTIONED CAUSING MY FIANCE TO HIT HER HEAD ON THE DASH. *TR
NHTSA ODI #10340695
98,000 miles · Apr 9, 2010
Electrical SystemEngine And Engine CoolingFuel System, GasolineCrashInjury
WATER GETTING INTO VEHICLE SOMEWHERE BEHIND FIREWALL. STARTED APPROXIMATELY 1YR. AGO. CAUSED ALL LIGHTS ON DASH TO LIGHT UP, NOW VEHICLE WILL NOT START, COULD NOT AFFORD TO HAVE PONTIAC FIX, ALTHOUGH THEY DID ISSUE A WARNING REGARDING ISSUE, BUT WILL NOT HELP WITH REMEDY. *TR
NHTSA ODI #10324647
175,000 miles · Apr 1, 2010
Air Bags
TL*THE CONTACT OWNS A 1996 PONTIAC GRAND AM. WHILE DRIVING AT APPROXIMATELY 65 MPH, THE DRIVER'S SIDE AIR SUDDENLY DEPLOYED. THE CONTACT WAS ABLE TO DRIVE ONTO THE EMERGENCY LANE AND WRAP THE DEFLATED AIR BAG TO KEEP IT FROM OBSTRUCTING HIS VISION. THE VEHICLE WAS NOT TAKEN TO AN AUTHORIZED DEALER. THE CURRENT AND FAILURE MILEAG…
Read full complaint
TL*THE CONTACT OWNS A 1996 PONTIAC GRAND AM. WHILE DRIVING AT APPROXIMATELY 65 MPH, THE DRIVER'S SIDE AIR SUDDENLY DEPLOYED. THE CONTACT WAS ABLE TO DRIVE ONTO THE EMERGENCY LANE AND WRAP THE DEFLATED AIR BAG TO KEEP IT FROM OBSTRUCTING HIS VISION. THE VEHICLE WAS NOT TAKEN TO AN AUTHORIZED DEALER. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 175,000.
NHTSA ODI #10323305
120,000 miles · Feb 9, 2010
Electrical SystemStructure
TL*THE CONTACT OWNS A 1996 PONTIAC GRAND AM. THE CONTACT STATED THAT THE PASSENGER SIDE AND THE DRIVER SIDE HAD TWO INCHES OF RAIN IN THE VEHICLE BUT WAS UNABLE TO IDENTIFY WHERE IT WAS COMING FROM. THE THEFT SYSTEM ACTIVATED AND THE VEHICLE RESPONDED AS IF IT WERE STOLEN WHICH MADE IT IMPOSSIBLE TO START THE VEHICLE. THE CONTAC…
Read full complaint
TL*THE CONTACT OWNS A 1996 PONTIAC GRAND AM. THE CONTACT STATED THAT THE PASSENGER SIDE AND THE DRIVER SIDE HAD TWO INCHES OF RAIN IN THE VEHICLE BUT WAS UNABLE TO IDENTIFY WHERE IT WAS COMING FROM. THE THEFT SYSTEM ACTIVATED AND THE VEHICLE RESPONDED AS IF IT WERE STOLEN WHICH MADE IT IMPOSSIBLE TO START THE VEHICLE. THE CONTACT ALSO HAD A LOT OF MAJOR COMPONENTS REPAIRED ON THE VEHICLE AND THE FAILURE CONTINUED TO OCCUR. THE DEALER ADVISED THE CONTACT THAT THERE WAS NOTHING THEY COULD DO TO ASSIST WITH THE FAILURE. THE FAILURE MILEAGE WAS CURRENTLY 141,000. THE FAILURE MILEAGE WAS 120,000.
ON CERTAIN PASSENGER VEHICLES. IF THE ENGINE FAILS TO START AND THE DRIVER HOLDS THE KEY IN THE "START" POSITION FOR AN EXTENDED PERIOD, HIGH CURRENT FLOWS THROUGH THE IGNITION SWITCH, AND SOMETIMES PRODUCES ENOUGH HEAT TO MELT INTERNAL SWITCH PARTS.
Consequence & remedy
Consequence: IF THE SWITCH IS DAMAGED, A FIRE COULD OCCUR IN THE STEERING COLUMN, EVEN WITH THE ENGINE OFF AND THE KEY REMOVED.
Remedy: DEALERS WILL INSTALL A RELAY KIT IN THESE VEHICLES TO PREVENT HIGH CURRENT FROM FLOWING THROUGH THE IGNITION SWITCH. OWNER NOTIFICATION BEGAN MARCH 27, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, BUICK AT 1-800-521-7300, OR OLDSMOBILE AT 1-800-442-6537.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THESE VEHICLES WERE BUILT WITH THE POTENTIAL FOR THE INTERIOR LAMPS TO COME ON UNEXPECTEDLY WHILE THE VEHICLES ARE BEING DRIVEN. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS NO. 101, "CONTROLS AND DISPLAYS."
Consequence & remedy
Consequence: THE INTERIOR LAMPS COMING ON UNEXPECTEDLY COULD STARTLE A DRIVER CAUSING A MOMENTARY LOSS OF CONTROL INCREASING THE RISK OF A VEHICLE ACCIDENT.
Remedy: DEALERS WILL RUN A DIAGNOSTIC TEST ON THE LAMP CONTROL MODULE AND, IF NECESSARY, REPLACE IT.
THE STEERING COLUMN LOWER PINCH BOLT WAS NOT PROPERLY TIGHTENED DURING ASSEMBLY.
Consequence & remedy
Consequence: AN UNDERTORQUED PINCH BOLT CAN RATTLE AND CAUSE LOOSENESS IN THE STEERING SYSTEM. IF THE PINCH BOLT BACKED OUT OF THE JOINT COMPLETELY, ROTATION OF THE STEERING SHAFT AGAINST THE CONNECTOR COULD CAUSE INCREASING LOOSENESS IN THE STEERING SYSTEM AND RESULT IN LOSS OF STEERING AND AN ACCIDENT.
Remedy: DEALERS WILL INSPECT THE STEERING COLUMN PINCH BOLT FOR CORRECT TORQUE AND, IF NECESSARY, TIGHTEN THE BOLT TO THE SPECIFIED TORQUE.
THE FRONT AND/OR REAR HAZARD WARNING LAMPS (FOUR-WAY FLASHERS) DO NOT FLASH WHEN THE HAZARD SWITCH IS ACTIVATED. THIS FAILS TO COMPLY WITH FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence & remedy
Consequence: IF THESE LAMPS WERE NOT FLASHING, OTHER VEHICLES WOULD NOT BE AWARE THAT THIS VEHICLE WAS STOPPED INCREASING THE RISK OF AN ACCIDENT.
Remedy: DEALERS OR VEHICLE OWNERS WILL INSPECT FOR PROPER FUNCTION OF THE HAZARD WARNING LAMPS. IF NECESSARY, DEALERS WILL REPLACE THE HAZARD LAMP SWITCH.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
RQ03001 · Power Rack And Pinion Steering Failure
Opened Jan 2, 2003 · Closed Sep 15, 2003
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Additional source detail variants (2)
Steering
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
RQ98013 · Oversensitive Air Bag Deployments
Opened Aug 26, 1998 · No close date supplied
Status: open (inferred from source dates) · Air Bags
ON JUNE 26, 1998, GENERAL MOTORS BEGAIN A SAFETY RECALL, 98V-146, TO RECALIBRATE THE AIR BAG SENSING AND DIAGNOSTIC MODULE (SDM) IN THE 1996 AND SOME 1997 J BODY CARS, CAVALIER AND SUNFIRE.DUE TO CERTAIN CALIBRATIONS IN THE AIR BAG SDM, THERE IS AN INCREASED RISK OF INADVERTENT AIR BAG DEPLOYMENT IN A LOW SPEED CRASH OR WHEN AN OBJECT STRIKES THE FLOOR PAN.THE RECALL POPULATION CONSISTS OF 675,302 VEHICLES BUILT FROM APRIL 1995 THROUGH MAY 1997.ODI HAS RECEIVED 8 OWNER REPORTS ALLEGING INADVERTENT AIR BAG DEPLOYMENT WITHOUT A CRASH.THE PURPOSER OF THE RQ IS TO DETERMINE WHETHER GM SHOULD EXPAND THE RECALL TO INCLUDE THESE VEHICLES.CLOSING RESUME NOTE:AS OF AUGUST 5, 1999, ODI RECEIVED ONE ADDITIONAL COMPLAINT REGARDING THE ALLEGED DEFECT.THE INCIDENT RATES FOR THE SUBJECT VEHICLES ARE ABOUT ONE-THRID OF THE RATES OF THE RECALLED VEHICLES (WHEN THE RECALL WAS INITIATED).BASED ON THE AVAILABLE INFORMATION, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOSE NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY FUTURE CIRCUMSTANCES.
1996 Pontiac Grand Am Problems, Complaints & Recalls | Skip That Year
Illustration