IllustrationWATER GETTING INTO VEHICLE SOMEWHERE BEHIND FIREWALL. STARTED APPROXIMATELY 1YR. AGO. CAUSED ALL LIGHTS ON DASH TO LIGHT UP, NOW VEHICLE WILL NOT START, COULD NOT AFFORD TO HAVE PONTIAC FIX, ALTHOUGH THEY DID ISSUE A WARNING REGARDING ISSUE, BUT WILL NOT HELP WITH REMEDY. *TR
1996 Pontiac Grand Am
Owner reports · Recalls · Investigations
More warning signs than most Grand Am years
Owner complaints for the 1996 Pontiac Grand Am are substantially higher than the model-year median of 82.
About this comparison →How this year compares
Owner complaints by model year
Compare all Grand Am years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 78 of 450 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 122 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 104 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 74 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
32 crash reports14 fire reports52 injury reports
Engine And Engine Cooling complaints
74 reportsI HAVE TWO PONTIAC GRAND AM 1995, 1996 BOTH CARS HAS THE SAME PROBLEM THE INTAKE AND HEAD GASKET NEEDS REPLACE THEY SENT ME A PAPER IN THE MAIL AND SAID THERE WAS A RECALL ON MY CARS BUT NEVER HEARD ANY THING ABOUT IT MY CAR IT ABOUT TO STOP RUNNING AND MY 1995 WON'T RUN WITH OUT OVER HEATING IF SOMEONE COULD GET ME ANY I…
Read full complaint
I HAVE TWO PONTIAC GRAND AM 1995, 1996 BOTH CARS HAS THE SAME PROBLEM THE INTAKE AND HEAD GASKET NEEDS REPLACE THEY SENT ME A PAPER IN THE MAIL AND SAID THERE WAS A RECALL ON MY CARS BUT NEVER HEARD ANY THING ABOUT IT MY CAR IT ABOUT TO STOP RUNNING AND MY 1995 WON'T RUN WITH OUT OVER HEATING IF SOMEONE COULD GET ME ANY INFO PLEASE DO AND PASS IT MY WAY I COULD REALLY USE THE HELP. *TR
I WENT TO A CAR SERVICE PLACE TO HAVE AN OIL CHANGE AND I HAD THEM CHECK MY COOLANT TO SEE IF IT WAS LEAKING; SURE ENOUGH IT WAS. THEY HAD TOLD ME MY CAR IS LEAKING COOLANT FROM THE INTAKE MANIFOLD GASKET AND IT WOULD COST ME $700.00 + TO REPAIR IN WHICH I DON'T HAVE. *NM
AS MY HUSBAND WAS PUTTING GAS INTO MY 1996 GRAND AM HE NOTICED ORANGE COOLENT ( DEX COOL) LEAKING FROM THE CAR. THE NEXT MORNING ON HIS WAY TO WORK THE CAR MOTOR TEMPERATURE INCREASED TO A POINT WERE HE HAD TO PULL OVER AND LET THE CAR COOL DOWN. AFTER WORK HE TOOK THE CAR TO GATEWAY TIRE AND SERVICE FOR THE PROBLEM. GATEWAY…
Read full complaint
AS MY HUSBAND WAS PUTTING GAS INTO MY 1996 GRAND AM HE NOTICED ORANGE COOLENT ( DEX COOL) LEAKING FROM THE CAR. THE NEXT MORNING ON HIS WAY TO WORK THE CAR MOTOR TEMPERATURE INCREASED TO A POINT WERE HE HAD TO PULL OVER AND LET THE CAR COOL DOWN. AFTER WORK HE TOOK THE CAR TO GATEWAY TIRE AND SERVICE FOR THE PROBLEM. GATEWAY SERVICE STATED THAT THE FOLLOWING FAILURES OCCURED -THE INTAKE MANIFOLD GASKET AND TIMING COVER GASKET FAILED. WHAT NEEDS TO BE DONE TO CORRECT THE PROBLEM? -REPLACE MANIFOLD GASKET (B) -REPLACE UPPER AND LOWER MANIFOLD GASKET -REPLACE SEAL KIT LUBE OIL AND FILTER -REPLACE TIMING COVER GASKET -REPLACE COVER GASKET -REPLACE TIMING COVER GASKET IF DONE WITH LOWER INTAKE CURRENTLY CAR AT GATEWAY TIRE SERVICE (10-18-04). *AK
VEHICLE LEAKING COOLANT FROM LOWER INTAKE MANIFOLD GASKET. LEAK WAS BOTH INTERIOR AND EXTERIOR. *JB
WHILE DRIVING AND TURNING TO THE LEFT THERE WAS NO STEERING. ALSO, BRAKE FAILED, AND VEHICLE INTERMITTENTLY STALLED. *AK
THE CHECK OIL LIGHT APPEARED ON THE DASHBOARD INTERMITTENTLY. VEHICLE STALLED AND SHUT DOWN. DEALER WAS AWARE OF THE PROBLEM. THE DRIVER REQUESTED THE DEALERSHIP MECHANIC TO LOOK AT VEHICLE BECAUSE IT WAS ON RECALL A YEAR AGO. *AK
PERIODICALLY THE KEY GETS STUCK IN THE "ON" POSITION. THIS HAS CAUSED DAMAGE TO THE SENDING UNIT TO THE CRANKCASE. *AK
I HAVE A 1996 PONTIAC GRAND AM WITH A QUAD 4 ENGINE IN IT. THE ENGINE HAS 100,050 MILES ON IT, I TOOK VERY GOOD CARE OF IT, OIL CHANGES ON TIME DID ALL OF THE MAINTENANCE ON IT REQUIRED IN THE BOOK, ETC, ETC. I STARTED THE CAR THE OTHER DAY AND THE WHOLE THING JERKED FORWARD, MADE A LOUD BANG THEN WOULD NOT DO ANY THING BUT TURN…
Read full complaint
I HAVE A 1996 PONTIAC GRAND AM WITH A QUAD 4 ENGINE IN IT. THE ENGINE HAS 100,050 MILES ON IT, I TOOK VERY GOOD CARE OF IT, OIL CHANGES ON TIME DID ALL OF THE MAINTENANCE ON IT REQUIRED IN THE BOOK, ETC, ETC. I STARTED THE CAR THE OTHER DAY AND THE WHOLE THING JERKED FORWARD, MADE A LOUD BANG THEN WOULD NOT DO ANY THING BUT TURN OVER REALLY FAST. I HAD IT TOWED IN TO MY MECHANIC AND FOUND OUT THAT MY ENGINE NEEDS TO BE REPLACED BECAUSE THE EXHAUST VALVES SMASHED INTO THE PISTONS AND DID A LOT OF DAMAGE. FROM WHAT I WAS TOLD BY THREE DIFFERENT MECHANICS IS THAT THE QUAD 4 ENGINE MADE BY GM IS THE WORST ENGINE EVER DESIGNED AND SHOULD NOT HAVE BEEN PUT OUT ON THE MARKET. I WAS ALSO TOLD THAT ON THIS TYPE OF CAR OVER 100,000 MILES WAS LUCKY AND THAT KIND OF MILES ON THIS ENGINE IS CONSIDERED HIGH MILEAGE. I WAS TOLD ONE OF TWO THINGS COULD HAVE CAUSED THIS AND THAT BOTH PROBLEMS ARE COMMON IN THIS CAR. THE FIRST CAUSE COULD HAVE BEEN THE HYDRAULIC FLUID THAT CAUSES THE MANIFOLD GASKET TO OPEN WHEN THE CAR IS SHUT OFF SLUDGED UP AND THIS CAUSED THE TIMING TO MIS ALIGN AT START UP AND CAUSED THE VALVES AND PISTONS TO SMASH TOGETHER. THE SECOND COMMON CAUSE FOR THIS IN THIS TYPE OF ENGINE IS THE PIN IN THE CAM SHAFT SNAPPED OFF AT START UP AND CAUSED THE TIMING TO JUMP AND CRASH THE PISTONS AND VALVES TOGETHER. BOTH PROBLEMS ARE KNOWN BY GM, YET THE CONSUMER IS NOT ALERTED SO THEY CAN GO IN AND GET THE CAM PIN CHECKED OR HAVE THE FLUID CHECKED FOR SLUDGING. *JB
I OWN A 1996 PONTIAC GRAND AM, I NOTICED SB #020601014 REGARDING THE MANIFOLD INTAKE GASKET - I HAD TO REPLACE TWO ON MY GRAND AM. I WAS TOLD IT IS TYPICAL EVERY 50,000 MILES, YET I PREVIOUSLY OWNED A GRAND AM AND KNOW PLENTY OF PEOPLE WHO DO AND HAVE NOT EXPERIENCED THIS PROBLEM. WHAT MAKES MATTERS WORSE IS THAT IT IS A $900…
Read full complaint
I OWN A 1996 PONTIAC GRAND AM, I NOTICED SB #020601014 REGARDING THE MANIFOLD INTAKE GASKET - I HAD TO REPLACE TWO ON MY GRAND AM. I WAS TOLD IT IS TYPICAL EVERY 50,000 MILES, YET I PREVIOUSLY OWNED A GRAND AM AND KNOW PLENTY OF PEOPLE WHO DO AND HAVE NOT EXPERIENCED THIS PROBLEM. WHAT MAKES MATTERS WORSE IS THAT IT IS A $900.00 JOB, AND I HAD TO DO IT TWICE! I AM LISTING THE MOST RECENT DATE - THE SECOND OCCURRENCE. *JB
Official recalls
402V070000 · Electrical System:ignition:switch
Mar 6, 2002
ON CERTAIN PASSENGER VEHICLES. IF THE ENGINE FAILS TO START AND THE DRIVER HOLDS THE KEY IN THE "START" POSITION FOR AN EXTENDED PERIOD, HIGH CURRENT FLOWS THROUGH THE IGNITION SWITCH, AND SOMETIMES PRODUCES ENOUGH HEAT TO MELT INTERNAL SWITCH PARTS.
Consequence & remedy
Consequence: IF THE SWITCH IS DAMAGED, A FIRE COULD OCCUR IN THE STEERING COLUMN, EVEN WITH THE ENGINE OFF AND THE KEY REMOVED.
Remedy: DEALERS WILL INSTALL A RELAY KIT IN THESE VEHICLES TO PREVENT HIGH CURRENT FROM FLOWING THROUGH THE IGNITION SWITCH. OWNER NOTIFICATION BEGAN MARCH 27, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, BUICK AT 1-800-521-7300, OR OLDSMOBILE AT 1-800-442-6537.
98V027000 · Interior Lighting
Feb 17, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THESE VEHICLES WERE BUILT WITH THE POTENTIAL FOR THE INTERIOR LAMPS TO COME ON UNEXPECTEDLY WHILE THE VEHICLES ARE BEING DRIVEN. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS NO. 101, "CONTROLS AND DISPLAYS."
Consequence & remedy
Consequence: THE INTERIOR LAMPS COMING ON UNEXPECTEDLY COULD STARTLE A DRIVER CAUSING A MOMENTARY LOSS OF CONTROL INCREASING THE RISK OF A VEHICLE ACCIDENT.
Remedy: DEALERS WILL RUN A DIAGNOSTIC TEST ON THE LAMP CONTROL MODULE AND, IF NECESSARY, REPLACE IT.
96V249000 · Steering: Steering Wheel/handle Bar
Dec 17, 1996
THE STEERING COLUMN LOWER PINCH BOLT WAS NOT PROPERLY TIGHTENED DURING ASSEMBLY.
Consequence & remedy
Consequence: AN UNDERTORQUED PINCH BOLT CAN RATTLE AND CAUSE LOOSENESS IN THE STEERING SYSTEM. IF THE PINCH BOLT BACKED OUT OF THE JOINT COMPLETELY, ROTATION OF THE STEERING SHAFT AGAINST THE CONNECTOR COULD CAUSE INCREASING LOOSENESS IN THE STEERING SYSTEM AND RESULT IN LOSS OF STEERING AND AN ACCIDENT.
Remedy: DEALERS WILL INSPECT THE STEERING COLUMN PINCH BOLT FOR CORRECT TORQUE AND, IF NECESSARY, TIGHTEN THE BOLT TO THE SPECIFIED TORQUE.
96V250000 · Exterior Lighting:hazard Flashing Warning Lights
Dec 17, 1996
THE FRONT AND/OR REAR HAZARD WARNING LAMPS (FOUR-WAY FLASHERS) DO NOT FLASH WHEN THE HAZARD SWITCH IS ACTIVATED. THIS FAILS TO COMPLY WITH FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence & remedy
Consequence: IF THESE LAMPS WERE NOT FLASHING, OTHER VEHICLES WOULD NOT BE AWARE THAT THIS VEHICLE WAS STOPPED INCREASING THE RISK OF AN ACCIDENT.
Remedy: DEALERS OR VEHICLE OWNERS WILL INSPECT FOR PROPER FUNCTION OF THE HAZARD WARNING LAMPS. IF NECESSARY, DEALERS WILL REPLACE THE HAZARD LAMP SWITCH.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2RQ03001 · Power Rack And Pinion Steering Failure
Opened Jan 2, 2003 · Closed Sep 15, 2003
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Additional source detail variants (2)
Steering
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
RQ98013 · Oversensitive Air Bag Deployments
Opened Aug 26, 1998 · No close date supplied
Status: open (inferred from source dates) · Air Bags
ON JUNE 26, 1998, GENERAL MOTORS BEGAIN A SAFETY RECALL, 98V-146, TO RECALIBRATE THE AIR BAG SENSING AND DIAGNOSTIC MODULE (SDM) IN THE 1996 AND SOME 1997 J BODY CARS, CAVALIER AND SUNFIRE.DUE TO CERTAIN CALIBRATIONS IN THE AIR BAG SDM, THERE IS AN INCREASED RISK OF INADVERTENT AIR BAG DEPLOYMENT IN A LOW SPEED CRASH OR WHEN AN OBJECT STRIKES THE FLOOR PAN.THE RECALL POPULATION CONSISTS OF 675,302 VEHICLES BUILT FROM APRIL 1995 THROUGH MAY 1997.ODI HAS RECEIVED 8 OWNER REPORTS ALLEGING INADVERTENT AIR BAG DEPLOYMENT WITHOUT A CRASH.THE PURPOSER OF THE RQ IS TO DETERMINE WHETHER GM SHOULD EXPAND THE RECALL TO INCLUDE THESE VEHICLES.CLOSING RESUME NOTE:AS OF AUGUST 5, 1999, ODI RECEIVED ONE ADDITIONAL COMPLAINT REGARDING THE ALLEGED DEFECT.THE INCIDENT RATES FOR THE SUBJECT VEHICLES ARE ABOUT ONE-THRID OF THE RATES OF THE RECALLED VEHICLES (WHEN THE RECALL WAS INITIATED).BASED ON THE AVAILABLE INFORMATION, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOSE NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY FUTURE CIRCUMSTANCES.