THE SMOG PUMP BLOWS THE FUSE, THE COOLING FANS AND CHECK ENGINE LIGHT COMES ON. THE DEALERSHIP CHARGED NEARLY $500.00 TO REPLACE THE PUMP, WIRING, AND FUSE. THEY FIXED THE PROBLEM USING BIGGER RATED WIRE AND FUSE, WHICH USUALLY MEANS ORIGINAL PARTS WERE NOT ADDEQUATE. I AM GOING TO CONTACT GM'S CORPORATE OFFICES ABOUT THIS PROBL…
Read full complaint
THE SMOG PUMP BLOWS THE FUSE, THE COOLING FANS AND CHECK ENGINE LIGHT COMES ON. THE DEALERSHIP CHARGED NEARLY $500.00 TO REPLACE THE PUMP, WIRING, AND FUSE. THEY FIXED THE PROBLEM USING BIGGER RATED WIRE AND FUSE, WHICH USUALLY MEANS ORIGINAL PARTS WERE NOT ADDEQUATE. I AM GOING TO CONTACT GM'S CORPORATE OFFICES ABOUT THIS PROBLEM. IF THE T.S.B. CALLS FOR FIXING THE PROBLEM WITH BIGGER RATED WIRE AND FUSE, THEN GM KNOWS IT IS POSSIBLY A DESIGN DEFECT. I THINK THIS SHOULD BE UNDER A RECALL OR AN EMISSIONS WARRANTY OF SOME KIND. *AK
NHTSA ODI #722664
Mileage unknown · Feb 10, 1999
Electrical SystemEngine And Engine CoolingUnknown Or Other
DIAGNOSTIC TROUBLE CODE #29, AIR PUMP FUSE AND WIRING ARE NOT ADEQUATE TO PREVENT FUSE FROM BLOWING. FUSE BLOWS AFTER ENGINE GOES INTO CLOSED LOOP OPERATION. AIR PUMP DOES NOT WORK AFTER THIS, CAUSING CHECK ENGINE LIGHT TO APPEAR.
NHTSA ODI #703128
Mileage unknown · Aug 8, 1996
Power TrainUnknown Or Other
DURING OPERATION THE CHECK ENGINE LIGHT STAYS ON AT ALL TIMES. WHEN GOING FROM SECOND GEAR TO THIRD THE VEHICLE MAKES A LOUD NOISE.*AK
NHTSA ODI #800676
Mileage unknown · Sep 5, 1995
Unknown Or Other
INSTRUMENTAL CONTROL PANEL MALFUNCTIONED, DUE TO RAP MODULE FAILURE. TT
THE STEERING INTERMEDIATE SHAFT COULD HAVE BEEN IMPROPERLY ASSEMBLED CAUSING THE SHAFT LOWER COUPLING TO LOOSEN AND ROTATE ON THE STEERING GEAR INPUT SHAFT.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN A LOSS OF STEERING CONTROL INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL INSPECT THE INTERMEDIATE STEERING SHAFT FOR THE CORRECT LOWER COUPLING AND REPLACE IT AS REQUIRED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
EA97024 · Fuel Tube Retaining Clip Failure
Opened Nov 13, 1997 · Closed Sep 29, 1998
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
MOST OF THE REPORTS REVIEWED IN THIS INVESTIGATION ARE FIRE INCIDENTS IN WHICH FUEL LEAKAGE HAS BEEN ALLEGED AS THE CAUSE OR THE AREA OF ORIGIN IS CONSISTENT WITH THE ALLEGED DEFECT.THERE IS NO EVIDENCE THAT THE SUBJECT CLIP WAS A FACTOR IN ANY OF THESE FIRE INCIDENTS AND NHTSA TESTING INDICATES THATBROKEN OR DISLODGED RETENTION CLIP DOES NOT RESULT IN SIGNIFICANT MOVEMENT OF THE FUEL LINE BUNDLE TOWARD THE LEFT SECONDARY AIR INJECTION CHECK VALVE.FAILURE OF THE CLIP PLACES THE FUEL LINE BUNDLE ASSEMBLY IN THE SAME CONFIGURATION AS THE 1993 MODEL YEAR LTI VEHICLES.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE97036 · Fuel Tub Retaining Clip Failure
Opened Jul 24, 1997 · Closed Nov 13, 1997
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
OWNERS HAVE REPORTED FAILURES OF THE FUEL TUBE RETENTION CLIP THAT ATTACHES TO THE PLASTIC THROTTLE LINKAGE COVER.ACCORDING TO GM, THE SUBJECT RETENTION CLIP (P/N 12048089) WAS IMPLEMENTED IN PRODUCTION ON OCTOBER 12, 1993, TO ADDRESS A CONCERN WITH INCORRECT ASSEMBLY PLANT FUEL LINE ROUTING.MIS-ROUTED FUEL TUBES MAY FAIL FROM CONTACT WITH A HOT AIR CHECK VALVE, CREATING A FIRE HAZARD IN THE ENGINE COMPARTMENT.GM MAINTAINS THAT NO PROBLEMS SHOULD OCCUR IF THE CLIP IS PROPERLY INSTALLED AND ISN'T MISHANDLED DURING SUBSEQUENT SERVICE OPERATIONS.SOME OWNERS HAVE ALLEGED TO ODI THAT THE SUBJECT CLIP BECOMES BRITTLE OVER TIME AND MAY ALSO PULL FREE OF THE THROTTLE LINKAGE COVER ATTACHMENT HOLE.
1995 Pontiac Firebird Problems, Complaints & Recalls | Skip That Year
Illustration