IllustrationTHE CLEAR ENAMEL HAS BEEN COMING OFF MY 2002 AZTEK VERY BADLY...IT HAS BEEN FOR THE PAST YEAR. IS THIS NORMAL...THE ENGINE BONNET IS TERRIBLE AND ALL ABOVE THE DOORS AND HATCHBACK. *TR
2002 Pontiac Aztek
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2002 Pontiac Aztek do not stand out strongly from the model-year median of 121.
About this comparison →How this year compares
Owner complaints by model year
Compare all Aztek years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
150–25K
1925–50K
1950–75K
1575–100K
12100–150K
5150K+
85 reports with mileage · 36 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 21 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 20 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 19 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
2 crash reports1 fire reports2 injury reports
Structure complaints
11 reportsI HAVE A 2002 PONTIAC AZTEK AND THERE'S A TICKING NOISE IN THE MOTOR AND THE OIL IS GOOD AND ALL THE OTHER FLUIDS ARE GOOD. MY A/C STOP WORKING AND THE BACK HATCH DOESN'T UNLOCK SOMETIMES AND TO FIX THE PROBLEM I HAVE TO DISCONNECT THE BATTERY FOR ABOUT 15MINS OR LONGER FOR IT TO WORK , CAN YOU TELL ME WHAT COULD BE THE PROBLEM…
Read full complaint
I HAVE A 2002 PONTIAC AZTEK AND THERE'S A TICKING NOISE IN THE MOTOR AND THE OIL IS GOOD AND ALL THE OTHER FLUIDS ARE GOOD. MY A/C STOP WORKING AND THE BACK HATCH DOESN'T UNLOCK SOMETIMES AND TO FIX THE PROBLEM I HAVE TO DISCONNECT THE BATTERY FOR ABOUT 15MINS OR LONGER FOR IT TO WORK , CAN YOU TELL ME WHAT COULD BE THE PROBLEM AND HOW TO FIX IT . *TR
MY TAILGATE BEGAN NOT OPENING AND THEN ALL OF MY ELECTRIC PANEL LIGHTS WENT OUT, WINDOWS LOCKED UP, RADIO LOCKED, SECURITY LIGHT ON. I AM TOLD THAT THE WIRE HARNESS IN THE DASH WENT BAD AND THERE WAS A COST OF OVER $400 TO REPAIR THE WIRING. *TR
IT BEGAN WITH MY REAR HATCH NOT WORKING ON MY 2002 PONTIAC AZTEK. THEN THE IGNITION BEGAN STICKING AND CULMINATED WITH THE ALARM GOING OFF (WHILE DRIVING) AND ALL ELECTRICAL SYSTEMS SHUTTING DOWN WITH INCREASING FREQUENCY. WHEN THIS OCCURS, ALL GAUGES ARE SHUT DOWN, THE DOORS ARE DISABLED, HEADLIGHTS (ALL LIGHTS) ARE DISABLED.…
Read full complaint
IT BEGAN WITH MY REAR HATCH NOT WORKING ON MY 2002 PONTIAC AZTEK. THEN THE IGNITION BEGAN STICKING AND CULMINATED WITH THE ALARM GOING OFF (WHILE DRIVING) AND ALL ELECTRICAL SYSTEMS SHUTTING DOWN WITH INCREASING FREQUENCY. WHEN THIS OCCURS, ALL GAUGES ARE SHUT DOWN, THE DOORS ARE DISABLED, HEADLIGHTS (ALL LIGHTS) ARE DISABLED. I'VE LOOKED ONLINE AND TALKED TO THE DEALERSHIP. IT WILL COST BETWEEN $400-$500 TO REPAIR (GM IS AWARE OF THE PROBLEM). THE DEALER SAYS THAT IT IS NOT A SAFETY ISSUE, BUT IT SEEMS LIKE NON-FUNCTIONING LIGHTS, GAUGES AND DOORS/WINDOWS WOULD CERTAINLY BE A SAFETY ISSUE. I DO LIKE TO CAR, BUT THIS IS A MAJOR PROBLEM -- ONE WHICH I CAN ILL AFFORD TO FIX RIGHT NOW. WE ARE JUST STRUGGLING TO KEEP A ROOF OVER OUR HEADS! *TR
HAD TO REPLACE 5 WHEEL BEARINGS AC CONDENSERS REAR LATCH DOES NOT UNLATCH AT TIMES DEALER SAID THEY PUT ON A STRONGER SPRING STILL ONLY WORKS HALF THE TIME. TRANSMISSION WENT OUT AT 70,000 DRIVER DOOR GETS OUT OF LINE BECAUSE OF HINGE BENDING. *JB
2002 AZTEK FRONT LEFT WHEEL BEARING AND CUPS NEEDED TO BE REPLACED, A COOLANT LEAK DEVELOPED, REPLACED INTAKE MANIFOLD GASKET AND THE ENGINE OIL LIGHT WOULD NOT TURN OFF DUE TO BROKE WIRE UNDER AIR CLEANER BOX .***NO ANSWER REQUIRED***. *MR THE REAR SPOILER REDUCES VISIBILITY THROUGH THE REAR WINDOW AND POWER DOOR SWITCH DOES N…
Read full complaint
2002 AZTEK FRONT LEFT WHEEL BEARING AND CUPS NEEDED TO BE REPLACED, A COOLANT LEAK DEVELOPED, REPLACED INTAKE MANIFOLD GASKET AND THE ENGINE OIL LIGHT WOULD NOT TURN OFF DUE TO BROKE WIRE UNDER AIR CLEANER BOX .***NO ANSWER REQUIRED***. *MR THE REAR SPOILER REDUCES VISIBILITY THROUGH THE REAR WINDOW AND POWER DOOR SWITCH DOES NOT UNLOCK THE REAR DOOR LATCH, HAD TO BE UNLOCKED USING THE KEY. *NM
THE DEALER HAD SERVICED THE VEHICLE SEVERAL TIMES REGARDING THE DRIVER'S SIDE DOOR. THE DOOR FAILED TO LATCH PROPERLY AND COULD OPEN WHEN DRIVING. DEALER DIAGNOSED THE HINGES WERE TOO WEAK, WHICH RESULTED IN THEM COMING OUT OF ADJUSTMENT AND CAUSED THE DOOR NOT TO LOCK PROPERLY.*AK *JB
WATER LEAKING IN UNDER FRONT DASH DURING RAIN STORMS; LED TO MILDEW AND MOLD GROWING ON SEATS, FLOOR, SHIFTER, WINDOWS, & DOORS THROUGHOUT CAR. HAPPENED SEVERAL TIMES, THOUGHT FIRST TIME WAS MY FAULT, NEXT TIME IT DEFINITELY WAS NOT. *NLM
WATER ENTERS THE AZTEK IN UNDER THE DASH AND RUNS DOWN THE ON THE FRONT PASSENGER SIDE. ONLY DURING A LONG HARD RAIN. *NLM
THE DRIVER SIDE DOOR SHEET METAL WHERE THE HINGES ARE BOLTED TO ARE WARPING OUTWARD. THIS RESULTS IN THE DOOR BEING LOOSE, AND CAN FALL OFF AT ANYTIME.*AK
Official recalls
207V349000 · Fuel System, Gasoline:storage
Aug 8, 2007
ON CERTAIN VEHICLES, VARIATIONS IN THE MANUFACTURING PROCESS OR EXPOSURE TO HIGH AMBIENT TEMPERATURES MAY LEAD TO FRACTURE OF THE FUEL TANK INLET CHECK VALVE (ICV).
Consequence & remedy
Consequence: A FRACTURE MAY ALLOW FUEL VAPORS TO PASS THROUGH AND ALLOW DROPLETS OF FUEL TO ACCUMULATE ON THE SIDE OF THE FUEL TANK. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL TANK. THE RECALL WILL BE MAILED IN TWO PHASES WITH THE FIRST PHASE BEGINNING ON DECEMBER 4, 2007. THE SECOND PHASE WILL BE MAILED ON DECEMBER 13, 2007. OWNERS MAY CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OR PONTIAC AT 1-800-620-7668. THE VEHICLE POPULATION INCLUDES BUICK RENDEZVOUS AND PONTIAC AZTEK VEHICLE BUILT IN MAY 2003; CHEVROLET VENTURE AND PONTIAC MONTANA VEHICLES BUILT FROM JUNE THROUGH AUGUST 2002; AND ALL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO, AND HAWAII.
03V250000 · Equipment:other:owners/service/other Manual
Jul 15, 2003
CERTAIN MINIVANS, PASSENGER AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEM." THE OWNER'S MANUAL DOES NOT EXPLAIN THE MEANING OF THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT LOWER UNIVERSAL ANCHORAGE SYSTEM.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: OWNERS WILL BE PROVIDED WITH A SUPPLEMENT FOR THEIR OWNER'S MANUAL. THIS SUPPLEMENT DESCRIBES AND SHOWS THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT ANCHORS THAT ARE LOCATED IN THE VEHICLE AND ON THE CHILD RESTRAINT OR BOOSTER CUSHION. OWNER NOTIFICATION BEGAN AUGUST 18, 2003. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA07006 · Fuel Tank Leakage
Opened Apr 18, 2007 · Closed Sep 13, 2007
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
GM IS RECALLING (NHTSA RECALL NO. 07V-349) CERTAIN MODEL YEAR (MY) 2002-2004 BUICK RENDEZVOUS, CHEVROLET VENTURE (REGULAR WHEELBASE) AND 2001-2004 PONTIAC AZTEK AND MONTANA (REGULAR WHEELBASE) VEHICLES TO REPLACE FUEL TANKS AND CORRECT A DEFECT THAT MAY ALLOW FUEL LEAKAGE.THE VEHICLE RECALL POPULATION IS RENDEZVOUS AND AZTEK VEHICLES BUILT IN MAY 2003, VENTURE AND MONTANA VEHICLE BUILT IN JUNE THROUGH AUGUST 2002 AND CERTAIN SAME MODEL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO AND HAWAII THAT WERE BUILT THROUGH NOV/DEC 2003 (DEPENDING ON MODEL).THE TOTAL NUMBER OF VEHICLES RECALLED IS 20,594 (INCLUDES 15,196 SUBJECT AZTEK AND RENDEZVOUS VEHICLES). IN ADDITION TO THE RECALL, GM WILL EXTEND THE WARRANTY ON MY 2002-2004 RENDEZVOUS AND REGULAR WHEEL BASE VENTURE VANS AND MY 2001-2004 AZTEK AND REGULAR WHEELBASE MONTANA VANS NOT INCLUDED IN THE RECALL TO PROVIDE WARRANTY COVERAGE FOR A PERIOD OF 10 YEARS OR 150,000 MILES, WHICHEVER OCCURS FIRST.GM WILL BEGIN NOTIFYING OWNERS IN DECEMBER 2007.GM REPORTS THAT THE FUEL INLET PIPE CONTAINING THE INLET CHECK VALVE (ICV) MAY FRACTURE AND ALLOW FUEL VAPORS OR FUEL TO LEAK OUT.GM DATA REVEALED THAT ELEVATED AMBIENT TEMPERATURES, HIGHER CARBON CONTENT IN THE ICV AND VARIATION IN THE MANUFACTURING PROCESS WERE THE CONTRIBUTING FACTORS FOR POTENTIAL CRACKS IN THE ICV.BEGINNING DECEMBER 2003, GM BUILT VEHICLES WITH A REDESIGNED FUEL TANK/ICV.SUBJECT VEHICLES NOT INCLUDED IN THE RECALL OR EXTENDED WARRANTY DID NOT SHOW A FAILURE TREND SIMILAR TO THE ABOVE VEHICLES..FOR ADDITIONAL DETAILS, SEE RECALL 07V-349.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (5)
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
GM IS RECALLING (NHTSA RECALL NO. 07V-349) CERTAIN MODEL YEAR (MY) 2002-2004 BUICK RENDEZVOUS, CHEVROLET VENTURE (REGULAR WHEELBASE) AND 2001-2004 PONTIAC AZTEK AND MONTANA (REGULAR WHEELBASE) VEHICLES TO REPLACE FUEL TANKS AND CORRECT A DEFECT THAT MAY ALLOW FUEL LEAKAGE.THE VEHICLE RECALL POPULATION IS RENDEZVOUS AND AZTEK VEHICLES BUILT IN MAY 2003, VENTURE AND MONTANA VEHICLE BUILT IN JUNE THROUGH AUGUST 2002 AND CERTAIN SAME MODEL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO AND HAWAII THAT WERE BUILT THROUGH NOV/DEC 2003 (DEPENDING ON MODEL).THE TOTAL NUMBER OF VEHICLES RECALLED IS 20,594 (INCLUDES 15,196 SUBJECT AZTEK AND RENDEZVOUS VEHICLES). IN ADDITION TO THE RECALL, GM WILL EXTEND THE WARRANTY ON MY 2002-2004 RENDEZVOUS AND REGULAR WHEEL BASE VENTURE VANS AND MY 2001-2004 AZTEK AND REGULAR WHEELBASE MONTANA VANS NOT INCLUDED IN THE RECALL TO PROVIDE WARRANTY COVERAGE FOR A PERIOD OF 10 YEARS OR 150,000 MILES, WHICHEVER OCCURS FIRST.GM WILL BEGIN NOTIFYING OWNERS IN DECEMBER 2007.GM REPORTS THAT THE FUEL INLET PIPE CONTAINING THE INLET CHECK VALVE (ICV) MAY FRACTURE AND ALLOW FUEL VAPORS OR FUEL TO LEAK OUT.GM DATA REVEALED THAT ELEVATED AMBIENT TEMPERATURES, HIGHER CARBON CONTENT IN THE ICV AND VARIATION IN THE MANUFACTURING PROCESS WERE THE CONTRIBUTING FACTORS FOR POTENTIAL CRACKS IN THE ICV.BEGINNING DECEMBER 2003, GM BUILT VEHICLES WITH A REDESIGNED FUEL TANK/ICV.SUBJECT VEHICLES NOT INCLUDED IN THE RECALL OR EXTENDED WARRANTY DID NOT SHOW A FAILURE TREND SIMILAR TO THE ABOVE VEHICLES..FOR ADDITIONAL DETAILS, SEE RECALL 07V-349.THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline
GM IS RECALLING (NHTSA RECALL NO. 07V-349) CERTAIN MODEL YEAR (MY) 2002-2004 BUICK RENDEZVOUS, CHEVROLET VENTURE (REGULAR WHEELBASE) AND 2001-2004 PONTIAC AZTEK AND MONTANA (REGULAR WHEELBASE) VEHICLES TO REPLACE FUEL TANKS AND CORRECT A DEFECT THAT MAY ALLOW FUEL LEAKAGE.THE VEHICLE RECALL POPULATION IS RENDEZVOUS AND AZTEK VEHICLES BUILT IN MAY 2003, VENTURE AND MONTANA VEHICLE BUILT IN JUNE THROUGH AUGUST 2002 AND CERTAIN SAME MODEL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO AND HAWAII THAT WERE BUILT THROUGH NOV/DEC 2003 (DEPENDING ON MODEL).THE TOTAL NUMBER OF VEHICLES RECALLED IS 20,594 (INCLUDES 15,196 SUBJECT AZTEK AND RENDEZVOUS VEHICLES). IN ADDITION TO THE RECALL, GM WILL EXTEND THE WARRANTY ON MY 2002-2004 RENDEZVOUS AND REGULAR WHEEL BASE VENTURE VANS AND MY 2001-2004 AZTEK AND REGULAR WHEELBASE MONTANA VANS NOT INCLUDED IN THE RECALL TO PROVIDE WARRANTY COVERAGE FOR A PERIOD OF 10 YEARS OR 150,000 MILES, WHICHEVER OCCURS FIRST.GM WILL BEGIN NOTIFYING OWNERS IN DECEMBER 2007.GM REPORTS THAT THE FUEL INLET PIPE CONTAINING THE INLET CHECK VALVE (ICV) MAY FRACTURE AND ALLOW FUEL VAPORS OR FUEL TO LEAK OUT.GM DATA REVEALED THAT ELEVATED AMBIENT TEMPERATURES, HIGHER CARBON CONTENT IN THE ICV AND VARIATION IN THE MANUFACTURING PROCESS WERE THE CONTRIBUTING FACTORS FOR POTENTIAL CRACKS IN THE ICV.BEGINNING DECEMBER 2003, GM BUILT VEHICLES WITH A REDESIGNED FUEL TANK/ICV.SUBJECT VEHICLES NOT INCLUDED IN THE RECALL OR EXTENDED WARRANTY DID NOT SHOW A FAILURE TREND SIMILAR TO THE ABOVE VEHICLES..FOR ADDITIONAL DETAILS, SEE RECALL 07V-349.THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline:storage
GM IS RECALLING (NHTSA RECALL NO. 07V-349) CERTAIN MODEL YEAR (MY) 2002-2004 BUICK RENDEZVOUS, CHEVROLET VENTURE (REGULAR WHEELBASE) AND 2001-2004 PONTIAC AZTEK AND MONTANA (REGULAR WHEELBASE) VEHICLES TO REPLACE FUEL TANKS AND CORRECT A DEFECT THAT MAY ALLOW FUEL LEAKAGE.THE VEHICLE RECALL POPULATION IS RENDEZVOUS AND AZTEK VEHICLES BUILT IN MAY 2003, VENTURE AND MONTANA VEHICLE BUILT IN JUNE THROUGH AUGUST 2002 AND CERTAIN SAME MODEL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO AND HAWAII THAT WERE BUILT THROUGH NOV/DEC 2003 (DEPENDING ON MODEL).THE TOTAL NUMBER OF VEHICLES RECALLED IS 20,594 (INCLUDES 15,196 SUBJECT AZTEK AND RENDEZVOUS VEHICLES). IN ADDITION TO THE RECALL, GM WILL EXTEND THE WARRANTY ON MY 2002-2004 RENDEZVOUS AND REGULAR WHEEL BASE VENTURE VANS AND MY 2001-2004 AZTEK AND REGULAR WHEELBASE MONTANA VANS NOT INCLUDED IN THE RECALL TO PROVIDE WARRANTY COVERAGE FOR A PERIOD OF 10 YEARS OR 150,000 MILES, WHICHEVER OCCURS FIRST.GM WILL BEGIN NOTIFYING OWNERS IN DECEMBER 2007.GM REPORTS THAT THE FUEL INLET PIPE CONTAINING THE INLET CHECK VALVE (ICV) MAY FRACTURE AND ALLOW FUEL VAPORS OR FUEL TO LEAK OUT.GM DATA REVEALED THAT ELEVATED AMBIENT TEMPERATURES, HIGHER CARBON CONTENT IN THE ICV AND VARIATION IN THE MANUFACTURING PROCESS WERE THE CONTRIBUTING FACTORS FOR POTENTIAL CRACKS IN THE ICV.BEGINNING DECEMBER 2003, GM BUILT VEHICLES WITH A REDESIGNED FUEL TANK/ICV.SUBJECT VEHICLES NOT INCLUDED IN THE RECALL OR EXTENDED WARRANTY DID NOT SHOW A FAILURE TREND SIMILAR TO THE ABOVE VEHICLES..FOR ADDITIONAL DETAILS, SEE RECALL 07V-349.THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
GM IS RECALLING (NHTSA RECALL NO. 07V-349) CERTAIN MODEL YEAR (MY) 2002-2004 BUICK RENDEZVOUS, CHEVROLET VENTURE (REGULAR WHEELBASE) AND 2001-2004 PONTIAC AZTEK AND MONTANA (REGULAR WHEELBASE) VEHICLES TO REPLACE FUEL TANKS AND CORRECT A DEFECT THAT MAY ALLOW FUEL LEAKAGE.THE VEHICLE RECALL POPULATION IS RENDEZVOUS AND AZTEK VEHICLES BUILT IN MAY 2003, VENTURE AND MONTANA VEHICLE BUILT IN JUNE THROUGH AUGUST 2002 AND CERTAIN SAME MODEL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO AND HAWAII THAT WERE BUILT THROUGH NOV/DEC 2003 (DEPENDING ON MODEL).THE TOTAL NUMBER OF VEHICLES RECALLED IS 20,594 (INCLUDES 15,196 SUBJECT AZTEK AND RENDEZVOUS VEHICLES). IN ADDITION TO THE RECALL, GM WILL EXTEND THE WARRANTY ON MY 2002-2004 RENDEZVOUS AND REGULAR WHEEL BASE VENTURE VANS AND MY 2001-2004 AZTEK AND REGULAR WHEELBASE MONTANA VANS NOT INCLUDED IN THE RECALL TO PROVIDE WARRANTY COVERAGE FOR A PERIOD OF 10 YEARS OR 150,000 MILES, WHICHEVER OCCURS FIRST.GM WILL BEGIN NOTIFYING OWNERS IN DECEMBER 2007.GM REPORTS THAT THE FUEL INLET PIPE CONTAINING THE INLET CHECK VALVE (ICV) MAY FRACTURE AND ALLOW FUEL VAPORS OR FUEL TO LEAK OUT.GM DATA REVEALED THAT ELEVATED AMBIENT TEMPERATURES, HIGHER CARBON CONTENT IN THE ICV AND VARIATION IN THE MANUFACTURING PROCESS WERE THE CONTRIBUTING FACTORS FOR POTENTIAL CRACKS IN THE ICV.BEGINNING DECEMBER 2003, GM BUILT VEHICLES WITH A REDESIGNED FUEL TANK/ICV.SUBJECT VEHICLES NOT INCLUDED IN THE RECALL OR EXTENDED WARRANTY DID NOT SHOW A FAILURE TREND SIMILAR TO THE ABOVE VEHICLES..FOR ADDITIONAL DETAILS, SEE RECALL 07V-349.THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline:storage:tank Assembly
GM IS RECALLING (NHTSA RECALL NO. 07V-349) CERTAIN MODEL YEAR (MY) 2002-2004 BUICK RENDEZVOUS, CHEVROLET VENTURE (REGULAR WHEELBASE) AND 2001-2004 PONTIAC AZTEK AND MONTANA (REGULAR WHEELBASE) VEHICLES TO REPLACE FUEL TANKS AND CORRECT A DEFECT THAT MAY ALLOW FUEL LEAKAGE.THE VEHICLE RECALL POPULATION IS RENDEZVOUS AND AZTEK VEHICLES BUILT IN MAY 2003, VENTURE AND MONTANA VEHICLE BUILT IN JUNE THROUGH AUGUST 2002 AND CERTAIN SAME MODEL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO AND HAWAII THAT WERE BUILT THROUGH NOV/DEC 2003 (DEPENDING ON MODEL).THE TOTAL NUMBER OF VEHICLES RECALLED IS 20,594 (INCLUDES 15,196 SUBJECT AZTEK AND RENDEZVOUS VEHICLES). IN ADDITION TO THE RECALL, GM WILL EXTEND THE WARRANTY ON MY 2002-2004 RENDEZVOUS AND REGULAR WHEEL BASE VENTURE VANS AND MY 2001-2004 AZTEK AND REGULAR WHEELBASE MONTANA VANS NOT INCLUDED IN THE RECALL TO PROVIDE WARRANTY COVERAGE FOR A PERIOD OF 10 YEARS OR 150,000 MILES, WHICHEVER OCCURS FIRST.GM WILL BEGIN NOTIFYING OWNERS IN DECEMBER 2007.GM REPORTS THAT THE FUEL INLET PIPE CONTAINING THE INLET CHECK VALVE (ICV) MAY FRACTURE AND ALLOW FUEL VAPORS OR FUEL TO LEAK OUT.GM DATA REVEALED THAT ELEVATED AMBIENT TEMPERATURES, HIGHER CARBON CONTENT IN THE ICV AND VARIATION IN THE MANUFACTURING PROCESS WERE THE CONTRIBUTING FACTORS FOR POTENTIAL CRACKS IN THE ICV.BEGINNING DECEMBER 2003, GM BUILT VEHICLES WITH A REDESIGNED FUEL TANK/ICV.SUBJECT VEHICLES NOT INCLUDED IN THE RECALL OR EXTENDED WARRANTY DID NOT SHOW A FAILURE TREND SIMILAR TO THE ABOVE VEHICLES..FOR ADDITIONAL DETAILS, SEE RECALL 07V-349.THIS INVESTIGATION IS CLOSED.
RQ06009 · Fuel Tank Leakage
Opened Dec 14, 2006 · Closed Apr 18, 2007
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
CERTAIN SUBJECT VEHICLES MAY EXHIBIT LEAKAGE OF ODOR AND/OR FUELFROM THE LOWER PORTION OF THE FUEL TANK INLET FILLER PIPE (INLET CHECK VALVE).THE INLET CHECK VALVE (ICV) AND THE FUEL TANK ARE JOINED TOGETHER USING A HOT PLATE WELDING PROCESS FOR PLASTIC PARTS.GM REPORTS THAT ITS ANALYSIS OF FIELD RETURNED PARTS SHOW EVIDENCE OF PROCESS VARIATIONS FOR DIFFERENT MANUFACTURING PERIODS.THESE VARIATIONS PRODUCED SOME ICV TO FUEL TANK JOINTS WITH POOR MELT FLOW LINES.ODI'S ANALYSIS OF GM'S WARRANTY CLAIM DATA FINDS MORE FREQUENT FUEL TANK REPLACEMENTS IN THE HOTTER CLIMATE STATES.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-006) TO FURTHER ASSESS THIS MATTER.
Additional source detail variants (4)
Fuel System, Gasoline
CERTAIN SUBJECT VEHICLES MAY EXHIBIT LEAKAGE OF ODOR AND/OR FUELFROM THE LOWER PORTION OF THE FUEL TANK INLET FILLER PIPE (INLET CHECK VALVE).THE INLET CHECK VALVE (ICV) AND THE FUEL TANK ARE JOINED TOGETHER USING A HOT PLATE WELDING PROCESS FOR PLASTIC PARTS.GM REPORTS THAT ITS ANALYSIS OF FIELD RETURNED PARTS SHOW EVIDENCE OF PROCESS VARIATIONS FOR DIFFERENT MANUFACTURING PERIODS.THESE VARIATIONS PRODUCED SOME ICV TO FUEL TANK JOINTS WITH POOR MELT FLOW LINES.ODI'S ANALYSIS OF GM'S WARRANTY CLAIM DATA FINDS MORE FREQUENT FUEL TANK REPLACEMENTS IN THE HOTTER CLIMATE STATES.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-006) TO FURTHER ASSESS THIS MATTER.
Fuel System, Gasoline:storage
CERTAIN SUBJECT VEHICLES MAY EXHIBIT LEAKAGE OF ODOR AND/OR FUELFROM THE LOWER PORTION OF THE FUEL TANK INLET FILLER PIPE (INLET CHECK VALVE).THE INLET CHECK VALVE (ICV) AND THE FUEL TANK ARE JOINED TOGETHER USING A HOT PLATE WELDING PROCESS FOR PLASTIC PARTS.GM REPORTS THAT ITS ANALYSIS OF FIELD RETURNED PARTS SHOW EVIDENCE OF PROCESS VARIATIONS FOR DIFFERENT MANUFACTURING PERIODS.THESE VARIATIONS PRODUCED SOME ICV TO FUEL TANK JOINTS WITH POOR MELT FLOW LINES.ODI'S ANALYSIS OF GM'S WARRANTY CLAIM DATA FINDS MORE FREQUENT FUEL TANK REPLACEMENTS IN THE HOTTER CLIMATE STATES.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-006) TO FURTHER ASSESS THIS MATTER.
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
CERTAIN SUBJECT VEHICLES MAY EXHIBIT LEAKAGE OF ODOR AND/OR FUELFROM THE LOWER PORTION OF THE FUEL TANK INLET FILLER PIPE (INLET CHECK VALVE).THE INLET CHECK VALVE (ICV) AND THE FUEL TANK ARE JOINED TOGETHER USING A HOT PLATE WELDING PROCESS FOR PLASTIC PARTS.GM REPORTS THAT ITS ANALYSIS OF FIELD RETURNED PARTS SHOW EVIDENCE OF PROCESS VARIATIONS FOR DIFFERENT MANUFACTURING PERIODS.THESE VARIATIONS PRODUCED SOME ICV TO FUEL TANK JOINTS WITH POOR MELT FLOW LINES.ODI'S ANALYSIS OF GM'S WARRANTY CLAIM DATA FINDS MORE FREQUENT FUEL TANK REPLACEMENTS IN THE HOTTER CLIMATE STATES.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-006) TO FURTHER ASSESS THIS MATTER.
Fuel System, Gasoline:storage:tank Assembly
CERTAIN SUBJECT VEHICLES MAY EXHIBIT LEAKAGE OF ODOR AND/OR FUELFROM THE LOWER PORTION OF THE FUEL TANK INLET FILLER PIPE (INLET CHECK VALVE).THE INLET CHECK VALVE (ICV) AND THE FUEL TANK ARE JOINED TOGETHER USING A HOT PLATE WELDING PROCESS FOR PLASTIC PARTS.GM REPORTS THAT ITS ANALYSIS OF FIELD RETURNED PARTS SHOW EVIDENCE OF PROCESS VARIATIONS FOR DIFFERENT MANUFACTURING PERIODS.THESE VARIATIONS PRODUCED SOME ICV TO FUEL TANK JOINTS WITH POOR MELT FLOW LINES.ODI'S ANALYSIS OF GM'S WARRANTY CLAIM DATA FINDS MORE FREQUENT FUEL TANK REPLACEMENTS IN THE HOTTER CLIMATE STATES.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-006) TO FURTHER ASSESS THIS MATTER.