IllustrationMY HUSBAND WAS INSTALLING MY SON'S CAR SEAT. WHEN HE GRABBED THE SHAFT OF THE SEAT BELT (THE PART ATTACHED TO THE FLOOR), IT CAME COMPLETELY OUT. APPARENTLY THE METAL PART THAT IS ATTACHED TO THE SEAT IS COMPLETELY GONE. THE DEALERSHIP IS TELLING ME I'M RESPONSIBLE FOR BUYING A NEW SEAT BECAUSE MY WARRANTY IS EXPIRED. *JB
2000 Plymouth Voyager
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2000 Plymouth Voyager do not stand out strongly from the model-year median of 197.
About this comparison →How this year compares
Owner complaints by model year
Compare all Voyager years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
60–25K
2325–50K
2050–75K
1675–100K
14100–150K
3150K+
82 reports with mileage · 86 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 34 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 30 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 17 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
22 crash reports5 fire reports15 injury reports
Seat Belts complaints
10 reportsREAR SEAT BELTS DO NOT CATCH (STOP LETTING OUT BELT) WHEN BRAKE APPLIED. THIS IS AN ISSUE CAUGHT AS PART OF A MASSACHUSETTS MANDATORY YEARLY INSPECTION WHICH CAUSE THE VEHICLE TO FAIL. CHRYSLER DEALERSHIP HAS INDICATED IT CAN BE FIXED FOR A CHARGE OF AT LEAST $82. *NM
ON SEVERAL OCCASIONS, I NOTICED THE SEATBELT HOLDING MY SON'S CARSEAT IN PLACE HAD COME UNLATCHED. TO THE BEST OF MY KNOWLEDGE, NOTHING WAS DONE TO CAUSE IT TO OPEN. I OWN A 2000 PLYMOUTH GRAND VOYAGER AND RECENTLY READ THAT APPARENTLY, THIS IS A PROBLEM WITH MY VEHICLE AND ITS GENERATION 3 SEATBELTS. I CONTACTED A DEALER THI…
Read full complaint
ON SEVERAL OCCASIONS, I NOTICED THE SEATBELT HOLDING MY SON'S CARSEAT IN PLACE HAD COME UNLATCHED. TO THE BEST OF MY KNOWLEDGE, NOTHING WAS DONE TO CAUSE IT TO OPEN. I OWN A 2000 PLYMOUTH GRAND VOYAGER AND RECENTLY READ THAT APPARENTLY, THIS IS A PROBLEM WITH MY VEHICLE AND ITS GENERATION 3 SEATBELTS. I CONTACTED A DEALER THIS MORNING TO REQUEST REPLACEMENT OF THE 7 SEATBELTS AND WAS TOLD THEY DON'T DO THAT. I WAS ASKED IF THERE WAS A PROBLEM WITH THEM AND I MENTIONED THAT THEY HAD SPONTANEOUSLY UNLATCHED AND THAT I'D BEEN READING OF PROBLEMS WITH THAT TYPE OF SEATBELT. I WAS THEN TOLD THAT THAT WAS A LEGAL ISSUE AND I NEEDED TO CONTACT THE CORPORATE OFFICE, WHICH I WILL DO THIS AFTERNOON. *AK
I WOULD LIKE TO HAVE THE GENERATION 3 SEAT BELTS RECALLED IN THE CHRYSLER CARS AND VANS AS THE LATCHES PROTRUDE AND MAY BE UNSAFE. *NLM
I OWN A 2000 PLYMOUTH VOYAGER. THE SEAT BELT IN MY MIDDLE SEAT ON THE DRIVERS SIDE SPONTANEOUSLY RELEASES. THIS IS THE SEAT I HAD MY 6 MONTH OLD INFANT IN. AFTER THE 4TH TIME IN A 3 WEEK PERIOD I SWITCHED MY SON TO A DIFFERENT SEAT. *NLM
I OWN A 2000 CHRYSLER MINI VAN AND ON TWO OCCASIONS THE SEAT BELT HAVE RELEASED WHILE I WAS STILL PARKED IN MY DRIVEWAY. ON BOTH OCCASIONS I WAS REACHING OVER TO GET SOMETHING FROM THE PASSENGER SEAT AND THE BUCKLE CAME UNDONE. I THOUGHT I HAD NOT SECURED IT PROPERLY BECAUSE MY ARM HIT THE LOCK ON THE SEAT BELT. NOW I FIND OU…
Read full complaint
I OWN A 2000 CHRYSLER MINI VAN AND ON TWO OCCASIONS THE SEAT BELT HAVE RELEASED WHILE I WAS STILL PARKED IN MY DRIVEWAY. ON BOTH OCCASIONS I WAS REACHING OVER TO GET SOMETHING FROM THE PASSENGER SEAT AND THE BUCKLE CAME UNDONE. I THOUGHT I HAD NOT SECURED IT PROPERLY BECAUSE MY ARM HIT THE LOCK ON THE SEAT BELT. NOW I FIND OUT TODAY THAT I MAY HAVE HIT THE BUCKLE BUT IT SHOULD NOT HAVE POPPED OPEN AS THERE IS A DEFECT IN THE SEAT BELT. EVEN THOUGHT IT IS A 2000 MODEL I DO NOT HAVE THE GEN 4 TYPE OF BELTS IN THE FRONT. THE VAN MUST HAVE BEEN MANUFACTURED IN THE LATE 1999. *NLM
CONSUMER STATED THE SEAT BELT IN THE REAR MIDDLE SEAT, WON'T STAY BUCKLED. CAUSE UNKNOWN. TS *TT
CHRYSLER REFUSES TO FIX MY BELTS AS OF WHEN THIS COMPLAINT IS BEING FILED. *AK
MY 4 YEAR OLD SON'S CAR SEAT IS BELTED INTO THE MIDDLE SEAT, DIRECTLY BEHIND THE DRIVERS SEAT. ON A MINIMUM OF 3 OCCASSIONS THE SEATBELT FROM THE VOYAGER SEAT HAS DISLOGGED WHILE THE VEHICLE HAS BEEN IN MOTION. I DID NOT KNOW THAT IT DISLOGGED UNTIL THE VEHICLE WAS STOPPED & I WOULD GO TO REMOVE MY SON FROM HIS CAR SEAT WHICH HE…
Read full complaint
MY 4 YEAR OLD SON'S CAR SEAT IS BELTED INTO THE MIDDLE SEAT, DIRECTLY BEHIND THE DRIVERS SEAT. ON A MINIMUM OF 3 OCCASSIONS THE SEATBELT FROM THE VOYAGER SEAT HAS DISLOGGED WHILE THE VEHICLE HAS BEEN IN MOTION. I DID NOT KNOW THAT IT DISLOGGED UNTIL THE VEHICLE WAS STOPPED & I WOULD GO TO REMOVE MY SON FROM HIS CAR SEAT WHICH HE IS BELTED IN ALSO. I THOUGHT THAT OTHER PEOPLE THAT WERE SITTING IN THE MIDDLE SEAT WERE ACCIDENTALLY RELEASING THE VOYAGER SEAT BELT;BUT IT HAS HAPPENED WHEN ONLY MY SON HAS BEEN IN HIS CAR SEAT & NO ONE ELSE IN THE MIDDLE SEAT. NLM
WHEN FASTENING SEATBELT IT LOOSENS UP AND RIDES UP CONSUMER'S NECK. IT'S DIFFERENT FROM ALL THE OTHER SEAT BELTS. CONSUMER FEELS THIS SEAT BELT IS UNSAFE BECAUSE IT DOES NOT STAY ON CONSUMER'S WAIST, IT GOES UP UNDER THE ARM. *AK
Official recalls
204V480000 · Air Bags
Oct 6, 2004
ON CERTAIN MINIVANS, THE DRIVER'S AIR BAG MAY BECOME DISABLED DUE TO A FAILURE OF THE CLOCKSPRING, WHICH IS LOCATED IN THE HUB OF THE STEERING WHEEL.
Consequence & remedy
Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL COVERED VEHICLES WITH 70,000 MILES OR LESS. FOR THOSE VEHICLES WITH MORE THAN 70,000 MILES, DAIMLERCHRYSLER WILL OFFER AN EXTENDED LIFETIME WARRANTY UNDER WHICH IT WILL REPLACE THE CLOCKSPRING AT NO CHARGE IF IT FAILS. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. THE RECALL BEGAN ON OCTOBER 12, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
00V268000 · Fuel System, Gasoline:fuel Injection System
Sep 13, 2000
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA04013 · Driver Air Bag Clockspring Failure
Opened Jun 4, 2004 · Closed May 25, 2005
Status: closed (inferred from source dates) · Air Bags:frontal
THE DRIVER AIR BAG CLOCKSPRING CAN DEVELOP AN OPEN-CIRCUIT CONDITION RESULTING IN NONFUNCTIONAL DRIVER-SIDE FRONTAL AIR BAG, HORN, CRUISE CONTROL (IF EQUIPPED), AND/OR STEERING WHEEL RADIO CONTROL (IF EQUIPPED).IN ITS OCTOBER 5, 2004 LETTER TO NHTSA, DAIMLERCHRYSLER STATED THAT IT WILL CONDUCT A SAFETY RECALL AND REPLACE THE CLOCKSPRING ASSEMBLY ON ALL MY 1998.5-2000 DAIMLERCHRYSLER MINIVANS, BUILT BETWEEN MARCH 1998 AND AUGUST 2000, WITH 70,000 MILES OR LESS.IT WILL ALSO PROVIDE A LIFETIME WARRANTY FOR THIS COMPONENT ON MY 1998.5-2000 MINIVANS, REGARDLESS OF MILEAGE.THE DETAILS OF THE CORRECTIVE ACTION ARE DESCRIBED IN DAIMLERCHRYSLER'S LETTER (SEE RECALL NO. 04V-480).THE AGENCY BELIEVES THAT FURTHER EXPENDITURE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS WITH RESPECT TO THOSE VEHICLES COVERED ONLY BY THE LIFETIME WARRANTY.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE PAGE 2 FOR ADDITIONAL INFORMATION.
EA01007 · Air Bag Clockspring
Opened Feb 21, 2001 · Closed Nov 22, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
RQ00008 · Dc Minivan Fuel Injector Rail Leak
Opened Mar 9, 2000 · Closed Mar 18, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available