IllustrationAFTER STARTING THE IGNITION, THE AIR BAG WARNING LIGHT WOULD STAY ILLUMINATED. THE CRUISE CONTROL AND HORN FAILED TO WORK AT TIMES. *JB THE EGR VALVE FAILED. *SC *JB
1999 Plymouth Voyager
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1999 Plymouth Voyager do not stand out strongly from the model-year median of 197.
About this comparison →How this year compares
Owner complaints by model year
Compare all Voyager years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
50–25K
1825–50K
3150–75K
2975–100K
19100–150K
7150K+
109 reports with mileage · 164 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 65 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 52 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 41 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
23 crash reports10 fire reports11 injury reports
Engine And Engine Cooling complaints
52 reportsVEHICLE NOT WANTING TO SWITCH GEARS. IT GOES VERY SLOW UNTIL FINALLY IT SWITCHES OVER. THE OIL WAS LEAKING OUT OF THE VAN. THE OIL LEAK WAS REPAIRED. AS FOR THE TRANSMISSION, IT ALL STARTED OFF WHEN IT WOULD SLOW BY ITSELF. THEN IT GRADUALLY GOT WORSE. ON 02-12-03 I HAD TAKEN IT IN TO GET CHECKED FOR A OIL LEAK AND THE PRO…
Read full complaint
VEHICLE NOT WANTING TO SWITCH GEARS. IT GOES VERY SLOW UNTIL FINALLY IT SWITCHES OVER. THE OIL WAS LEAKING OUT OF THE VAN. THE OIL LEAK WAS REPAIRED. AS FOR THE TRANSMISSION, IT ALL STARTED OFF WHEN IT WOULD SLOW BY ITSELF. THEN IT GRADUALLY GOT WORSE. ON 02-12-03 I HAD TAKEN IT IN TO GET CHECKED FOR A OIL LEAK AND THE PROBLEM WITH THE GEARS NOT SHIFTING. I WAS TOLD I NEEDED TRANSMISSION SERVICE, TO REPLACE THE VALVE COVER GASKET, AND TO REPLACE THE TRANSMISSION OUTPUT SHAFT SEAL. I DID THE REPAIR THAT WAS SUPPOSED TO FIX THE PROBLEM BUT OF COURSE IT DIDN'T. I TOOK IT IN TO THE DEALER AND THEY FOUND NOTHING WRONG WITH THE GEARS. BUT SAID A FUEL INJECTION CLEANING, THROTTLE BODY CLEANING, AND A TUNE UP WOULD FIX THE PROBLEM. THIS WAS DONE ON MARCH 26, 2003. THEY REPLACED THE THROTTLE BODY GASKET AND SPARK PLUGS. THEY DID FIND A LEAK IN THE HEAD GASKET. THEY HAD TO REPLACE CYLINDER HEAD GASKET, WATER PUMP AND TIMING BELT. IN NOVEMBER OF 2000 THE FRONT PUMP SEAL WAS LEAKING, PAN GASKET LEAKING, SIDE COVER LEAKING, DIFFERENTIAL COVER LEAKING, AND REAR MAIN OIL SEAL LEAKING. THEY REMOVED THE TRANSAXLE, REMOVED AND REPLACED THE REAR MAIN SEAL. A FEW MONTHS AGO THE ENGINE LIGHT STARTED COMING ON WHEN GEARS WOULDN'T SHIFT. AND IT GOT WORSE EVERYDAY. NOW THE ENGINE LIGHT IS ON ALL THE TIME. I TOOK IT INTO AAMCO ON 04-23-2004 TO GET IT CHECKED OUT. THEY SAID IT WASN'T SAFE TO DRIVE SO THEY HAD TO TOW IT TO THEIR STATION. IT PASSED ALL THE EQUIPMENT TESTING AND WAS TOLD IT MAY JUST BE THE SPARK PLUGS. SO I REPLACED THE SPARK PLUGS THAT DAY. IT RAN WELL FOR A LITTLE WHILE. THEN IT STARTED AGAIN. I HAD TO STOP DRIVING MY VEHICLE BECAUSE IT IS A POTENTIAL DANGER TO MY FAMILY. IT WOULD GO VERY VERY SLOW WHEN I WAS TRYING TO CROSS THE ROAD. AND WITH ON COMING VEHICLES ON BOTH SIDES WE COULD EASILY GET INTO A MAJOR COLLISION. I HAVE TRIED TO TALK TO THE CHRYSLER BUT THEY REFUSED TO HELP ME. AND AT THIS POINT I STILL DON'T KNOW WHAT IS WRONG WITH IT. *JB
1999 PLYMOUTH VOYAGER THE CROSS OVER PIPE ON THE MANIFOLD HOLE AND CAN'T BE REPAIRED MECHANIC TOLD ME HE NEVER SEEN ONE BREAK BEFORE ON A VEHCILE THAT ONLY HAS 59,000 MILES. *AK
INFERIOR QUALITY OIL PAN...OIL PAN LEAKED THRU ON 99 PLYMOUTH VOYAGER AT 5 YS AND 84T MILE.RELEASING OIL ALONG VAN FRAME AND BRAKES ..CAUSING SMOKE AND STRONG ODOR IN VAN COMAPRTMENT.HAD TO REPLACE OIL PAN THRU CHYRSLER AS NO ONE ELSE HAD IT.PER DEALER AND MECHANICS THIS SHOULD NOT HAVE HAPPENED AT THAT MILEAGE AND YEAR.CHRYSLER…
Read full complaint
INFERIOR QUALITY OIL PAN...OIL PAN LEAKED THRU ON 99 PLYMOUTH VOYAGER AT 5 YS AND 84T MILE.RELEASING OIL ALONG VAN FRAME AND BRAKES ..CAUSING SMOKE AND STRONG ODOR IN VAN COMAPRTMENT.HAD TO REPLACE OIL PAN THRU CHYRSLER AS NO ONE ELSE HAD IT.PER DEALER AND MECHANICS THIS SHOULD NOT HAVE HAPPENED AT THAT MILEAGE AND YEAR.CHRYSLER CORPORATE REFUSED TO HELP AND COULD CARE LESS..LETTER TO CEO AT DAIMLER CHRYSLER AND FAX WENT UNANSWERED..
EXCESS ENGINE OIL LEAK, OIL FOUND IN COOLING SYSTEM DUE TO FAILED ENGINE HEAD GASKET TO 2.4 LITER DOHC EGINE WITH 78,000 MILES ON IT.*AK
HEAD GASKET LEAKING OIL. NEEDS REPLACMENT WITH TRANSMISSION FLUSH, NEW SPARK PLUGS, WIRES AND OIL CHANGE. NEEDS NEW BATTERY, REPLACED STARTER IN 2003. IT IS NOT EVEN FIVE YEARS OLD.*AK
MY CAR ONLY HAS 39,000 MILES AND IT ALREADY HAS A WARPED MAIN GASKET. I TOOK IT TO GET REPAIRED THE MECHANIC SAID IT MUST BE A RECALL BECAUSE THAT'S NOT NORMAL. THE REPAIRS CLOSE TO 1,000 DLS. *LA
SERPENTINE BELT CAME OFF TWICE IN ONE MONTH. HAD TENSIONER REPLACED. DID NOT HELP. FOUND THAT THIS HAS HAPPENED TO MANY OTHER OWNERS OF PLYMOUTH VOYEGER IN HEAVY RAIN AND SNOW. VERY DANGEROUS, BECAUSE OF LOSS OF POWER STEERING ON FREEWAY DURING BAD WEATHER CONDITIONS.*AK
HEAD GASKET FAILURE WITH SUSPECTED CRACKED CYLINDER HEAD. THIS VEHICLE HAS 77K MILES AND IS NOW UNDRIVEABLE. THE HEATER DOES NOT WORK NOW, SO I CAN'T DEFROST THE WINDSHIELD. ESTIMATED REPAIR COSTS $900-1,500.*AK MECHANICS TELL ME IT'S CHEAPER TO REPLACE THE ENGINE. I CAN'T AFFORD THIS.
VEHICLE HAD A MAJOR OIL LEAK DUE TO ENGINE HEAD GASKET FAILURE WHILE DRIVING. DEALERSHIP WAS AWARE OF THE PROBLEM. OIL WAS LEAKING INTO THE ENGINE, CAUSING VEHICLE TO BECOME IMMOBILE. VEHICLE WAS TOWED TO THE DEALERSHIP FOR ANALYSIS. *AK
Official recalls
404V480000 · Air Bags
Oct 6, 2004
ON CERTAIN MINIVANS, THE DRIVER'S AIR BAG MAY BECOME DISABLED DUE TO A FAILURE OF THE CLOCKSPRING, WHICH IS LOCATED IN THE HUB OF THE STEERING WHEEL.
Consequence & remedy
Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL COVERED VEHICLES WITH 70,000 MILES OR LESS. FOR THOSE VEHICLES WITH MORE THAN 70,000 MILES, DAIMLERCHRYSLER WILL OFFER AN EXTENDED LIFETIME WARRANTY UNDER WHICH IT WILL REPLACE THE CLOCKSPRING AT NO CHARGE IF IT FAILS. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. THE RECALL BEGAN ON OCTOBER 12, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
02V076000 · Seat Belts:rear/other
Mar 8, 2002
ON CERTAIN MINIVANS, SOME TRIM MATERIAL CAN LOOSEN AND DROP INTO THE REAR OUTBOARD SEAT BELT ASSEMBLY, CAUSING THE SEAT BELT TO BECOME INOPERATIVE.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE TRIM WITH FOAM BLOCKERS AND INSPECT AND REPLACE ALL 3RD ROW SEAT BELT ASSEMBLIES. OWNER NOTIFICATION BEGAN JUNE 3, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
00V268000 · Fuel System, Gasoline:fuel Injection System
Sep 13, 2000
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
99V116000 · Exterior Lighting:headlights
May 6, 1999
VEHICLE DESCRIPTION: MINI VANS BUILT FOR FLEET SALES ONLY. THE HEADLAMP MODULE DOES NOT IDENTIFY THE PARK LAMP AS "DRL" AS REQUIREMENT OF FMVSS 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence & remedy
Consequence: THESE VEHICLES DO NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 108.
Remedy: ALL FLEET OWNERS/OPERATORS WILL BE MAILED NON-REMOVABLE DECALS WITH THE REQUIRED "DRL" LETTERS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6EA04013 · Driver Air Bag Clockspring Failure
Opened Jun 4, 2004 · Closed May 25, 2005
Status: closed (inferred from source dates) · Air Bags:frontal
THE DRIVER AIR BAG CLOCKSPRING CAN DEVELOP AN OPEN-CIRCUIT CONDITION RESULTING IN NONFUNCTIONAL DRIVER-SIDE FRONTAL AIR BAG, HORN, CRUISE CONTROL (IF EQUIPPED), AND/OR STEERING WHEEL RADIO CONTROL (IF EQUIPPED).IN ITS OCTOBER 5, 2004 LETTER TO NHTSA, DAIMLERCHRYSLER STATED THAT IT WILL CONDUCT A SAFETY RECALL AND REPLACE THE CLOCKSPRING ASSEMBLY ON ALL MY 1998.5-2000 DAIMLERCHRYSLER MINIVANS, BUILT BETWEEN MARCH 1998 AND AUGUST 2000, WITH 70,000 MILES OR LESS.IT WILL ALSO PROVIDE A LIFETIME WARRANTY FOR THIS COMPONENT ON MY 1998.5-2000 MINIVANS, REGARDLESS OF MILEAGE.THE DETAILS OF THE CORRECTIVE ACTION ARE DESCRIBED IN DAIMLERCHRYSLER'S LETTER (SEE RECALL NO. 04V-480).THE AGENCY BELIEVES THAT FURTHER EXPENDITURE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS WITH RESPECT TO THOSE VEHICLES COVERED ONLY BY THE LIFETIME WARRANTY.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE PAGE 2 FOR ADDITIONAL INFORMATION.
RQ04001 · Driver Air Bag Clockspring Failure
Opened Jan 28, 2004 · Closed Jun 4, 2004
Status: closed (inferred from source dates) · Air Bags:frontal
COMPLAINTS REPORT AIR BAG WARNING LIGHT ILLUMINATES, AND THIS MAY BE ACCOMPANIED WITH A NON-FUNCTIONING HORN AND/OR CRUISE CONTROL (IF EQUIPPED).THIS IS INDICATIVE OF AN OPEN-CIRCUIT CLOCKSPRING FAILURE (RESULTS IN NON-FUNCTIONING DRIVER'S AIR BAG), SIMILAR TO THE FAILURE CONDITION THAT WAS THE SUBJECT OF DAIMLERCHRYSLER'S RECALL OF MODEL YEAR 1996-1998.5 MINIVANS (RECALL NO. 02V-293).THIS RECALL QUERY HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA04-013).
EA01007 · Air Bag Clockspring
Opened Feb 21, 2001 · Closed Nov 22, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
RQ00008 · Dc Minivan Fuel Injector Rail Leak
Opened Mar 9, 2000 · Closed Mar 18, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA99013 · Post Collision Fuel System
Opened Jun 11, 1999 · Closed Aug 10, 2001
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
No summary supplied.
PE99010 · POST-COLLISION Fuel System Integrity
Opened Feb 3, 1999 · Closed Jun 11, 1999
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
There is no summary currently available