IllustrationRECALL NOTICE FOR CLOCKSPRING ON A 1997 PLYMOUTH VOYAGER. *NJ THE CONSUMER HAD THE RECALL WORK DONE PRIOR TO RECEIVING THE NOTICE. RECALL 02V293000
1997 Plymouth Voyager
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1997 Plymouth Voyager do not stand out strongly from the model-year median of 197.
About this comparison →How this year compares
Owner complaints by model year
Compare all Voyager years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 58 of 346 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 64 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 56 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 55 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
14 crash reports16 fire reports13 injury reports
Air Bags complaints
64 reportsMY WIFE WAS DRIVING OUR 1997 VOYAGER UP A GRAVEL DRIVEWAY ABOUT 5-10 MPH. BOTH THE DRIVER SIDE AND PASSENGER SIDE AIR BAGS INADVERTENTLY DEPLOYED. THERE WAS NO COLLISION OF ANY KIND. MY WIFE AND DAUGHTER BOTH SUFFERED BRUISING AND FACIAL ABRASIONS FROM THE AIR BAGS. IT IS NOT COVERED BY INSURANCE STATING IT IS A MECHANICAL FAI…
Read full complaint
MY WIFE WAS DRIVING OUR 1997 VOYAGER UP A GRAVEL DRIVEWAY ABOUT 5-10 MPH. BOTH THE DRIVER SIDE AND PASSENGER SIDE AIR BAGS INADVERTENTLY DEPLOYED. THERE WAS NO COLLISION OF ANY KIND. MY WIFE AND DAUGHTER BOTH SUFFERED BRUISING AND FACIAL ABRASIONS FROM THE AIR BAGS. IT IS NOT COVERED BY INSURANCE STATING IT IS A MECHANICAL FAILURE. I FEEL THIS IS VERY DANGEROUS AND SHOULD COVERED BY CHRYSLER FOR ALL PARTS AND SERVICE. *NM
WHILE DRIVING THE AIR BAG LIGHT APPEARED ON THE DASHBOARD AND REMAINED ON. WHEN THE CONSUMER PRESSED THE BORN BUTTON IT WOULD NOT WORK. THE CONSUMER DROVE THE VEHICLE TO THE DEALER FOR INSPECTION. THE MECHANIC DETERMINED THAT THE CLOCK SPRING NEEDED TO BE REPLACED. *AK *NM
CONSUMER STATED THAT AIR BAGS AND HORN DID NOT WORK. SHE TOOK VEHICLE TO THE MECHANIC, AND WAS TOLD THAT THERE WAS A RECALL ON THE AIR BAGS. BUT, CONSUMER DID NOT RECEIVE A RECALL NOTICE. ALSO, REAR VIEW MIRROR DID NOT WORK PROPERLY. *AK
DEALERSHIP CONTACTED THE CONSUMER TO INFORM HIM THAT THE SEAT BELT RECALL 02V076000 AND AIR BAG CLOCK SPRING RECALL 02V293000 REPAIRS WERE ALREADY PERFORMED. THEN, CONSUMER NEVER TOOK VEHICLE TO DEALER HAVE THE RECALL REPAIRS PERFORMED. MANUFACTURER WILL BE CONTACTED. *AK
CONSUMER EXPERIENCED SYMPTOMS OF THE CLOCKSPRING RECALL. *PH THE VEHICLE WAS TAKEN TO THE DEALER WHO INDICATED THAT THE COCKSPRING WAS NOT THE CAUSE OF THE PROBLEM. THE DEALER INDICATED THAT IN ORDER TO DIGNOSE THE PROBLE THE CONSUMER WOULD HAVE TO PAY A DIAGNOSTIC FEE. THE CONSUMER TOOK THE VEHICLE TO AN INDEPENDENT MECHANI…
Read full complaint
CONSUMER EXPERIENCED SYMPTOMS OF THE CLOCKSPRING RECALL. *PH THE VEHICLE WAS TAKEN TO THE DEALER WHO INDICATED THAT THE COCKSPRING WAS NOT THE CAUSE OF THE PROBLEM. THE DEALER INDICATED THAT IN ORDER TO DIGNOSE THE PROBLE THE CONSUMER WOULD HAVE TO PAY A DIAGNOSTIC FEE. THE CONSUMER TOOK THE VEHICLE TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THE PROBLEM AS A FAULTY CLOCKSPRING AND REPL;ACED IT. THE CONSUMER REQUEST RIMBURSEMENT FOR THE EXPENSES PAID TO REPAIR THE VEHICLE. *NM
I PURCHASED A VEHICLE IN 1997 FROM A FRIEND. ALL OF A SUDDEN MY HORN STOPPED WORKING. I HAVE REPLAED THE FUSES. I HAVE CHECKED ALL THE WIRES. I HAVE REPLACED THE HORN. THEIR IS NOTHING WRONG. I THINK THE PROBLEM IS WHERE THE AIRBAG IS BEHIND THE STEERING WHEEL. WHAT DO I DO. I DONT THINK THAT IS MY RESPONSIBILITY IF THEI…
Read full complaint
I PURCHASED A VEHICLE IN 1997 FROM A FRIEND. ALL OF A SUDDEN MY HORN STOPPED WORKING. I HAVE REPLAED THE FUSES. I HAVE CHECKED ALL THE WIRES. I HAVE REPLACED THE HORN. THEIR IS NOTHING WRONG. I THINK THE PROBLEM IS WHERE THE AIRBAG IS BEHIND THE STEERING WHEEL. WHAT DO I DO. I DONT THINK THAT IS MY RESPONSIBILITY IF THEIR IS A PROBLEM WITH THE AIR BAG IS IT?*AK
WHILE TRAVELING 25-30 VEHICLE RAN OFF ROAD AND HIT A PIPE WITH LEFT FRONT WHEEL. AIR BAGS DID NOT DEPLOY. *AK
1. THE REAR HATCH LEAKED UPON DELIVERY. THREE ATTEMPTS WERE MADE TO PUT SOME KING OF SEALANT ON THE EXTERIOR TO PREVENT LEAKAGE. SOME WATER DAMAGE TO INTERIOR WAS NEVER FIXED. 2. AIR BAG LIGHT ON DUE TO CLOCK SPRING FAILURE. WAITED FOR ALMOST TWO YEARS FOR CHRYSLER TO ISSUE RECALL WHILE PROBLEM WAS BEING INVESTIGATED BY NHT…
Read full complaint
1. THE REAR HATCH LEAKED UPON DELIVERY. THREE ATTEMPTS WERE MADE TO PUT SOME KING OF SEALANT ON THE EXTERIOR TO PREVENT LEAKAGE. SOME WATER DAMAGE TO INTERIOR WAS NEVER FIXED. 2. AIR BAG LIGHT ON DUE TO CLOCK SPRING FAILURE. WAITED FOR ALMOST TWO YEARS FOR CHRYSLER TO ISSUE RECALL WHILE PROBLEM WAS BEING INVESTIGATED BY NHTSA. 3. TRANSMISSION FAILURE AT 115,800KM. ESTIMATED $1,800 TO REPAIR AT TRANSMISSION SHOP.
WHILE DRIVING DRIVER'S SIDE AIR BAG DEPLOYED WITHOUT IMPACT. *AK
Official recalls
602V293000 · Air Bags:frontal
Nov 7, 2002
ON CERTAIN MINI VANS, THE CLOCKSPRING ASSEMBLY MAY HAVE BEEN WOUND INCORRECTLY DURING THE VEHICLE ASSEMBLY PROCESS.
Consequence & remedy
Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL VEHICLES WITH 70,000 MILES OR LESS. AN EXTENDED LIFETIME WARRANTY WILL ALSO BE PLACED ON THIS COMPONENT FOR ALL AFFECTED VEHICLES, REGARDLESS OF MILEAGE. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. OWNER NOTIFICATION BEGAN NOVEMBER 18, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
02V076000 · Seat Belts:rear/other
Mar 8, 2002
ON CERTAIN MINIVANS, SOME TRIM MATERIAL CAN LOOSEN AND DROP INTO THE REAR OUTBOARD SEAT BELT ASSEMBLY, CAUSING THE SEAT BELT TO BECOME INOPERATIVE.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE TRIM WITH FOAM BLOCKERS AND INSPECT AND REPLACE ALL 3RD ROW SEAT BELT ASSEMBLIES. OWNER NOTIFICATION BEGAN JUNE 3, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
00V268000 · Fuel System, Gasoline:fuel Injection System
Sep 13, 2000
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
98V185000 · Child Seat
Aug 6, 1998
VEHICLE DESCRIPTION: MINI VANS EQUIPPED WITH INTEGRATED CHILD SEATS. THE SHOULDER HARNESS RESTRAINT ON THE INTEGRATED CHILD SEAT CAN BECOME DIFFICULT TO EXTRACT WHEN THE SAFETY BELT LATCH PLATE BECOMES CONTAMINATED.
Consequence & remedy
Consequence: THIS CAN CAUSE DIFFICULTY IN RELEASING A CHILD FROM THE RESTRAINT.
Remedy: DEALERS WILL CLEAN THE LATCH MECHANISM. AN EXTENDER WILL BE ADDED TO THE EMERGENCY RELEASE ANCHOR FOR THE CHILD SEAT SAFETY BELTS SO THAT THE RELEASE CLIPS ARE MORE VISIBLE AND ACCESSIBLE TO THE OPERATOR IN THE EVENT THAT THE RETRACTOR MECHANISM CAN NOT BE UNLOCKED. IN ADDITION, AN INSTRUCTIONAL OWNER'S MANUAL SUPPLEMENT CARD WILL BE PROVIDED.
97V200000 · Tires:bead
Nov 13, 1997
VEHICLE DESCRIPTION: PASSENGER MINIVANS EQUIPPED WITH P215/65R15 GOODYEAR CONQUEST TIRES MOUNTED ON STEEL WHEEL. THE TIRES CAN EXPERIENCE A SUDDEN AIR PRESSURE LOSS WITHOUT WARNING.
Consequence & remedy
Consequence: SUDDEN TIRE FAILURE COULD RESULT IN A LOSS OF DRIVER CONTROL OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE TIRES THAT WERE MOUNTED ON STEEL WHEELS.
97V070000 · Wheels:rim
Apr 28, 1997
THE STEEL ROAD WHEELS WERE DAMAGED BY THE EQUIPMENT USED TO MATCH MOUNT THE WHEEL TO THE TIRE.
Consequence & remedy
Consequence: A SCORE MARK WAS MADE ON THE WHEEL, AFFECTING THE DURABILITY OF THE WHEEL.
Remedy: DEALERS WILL REPLACE ALL ROAD WHEELS (AND FULL SIZE SPARE TIRES) WITH NEW WHEELS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
7PE02004 · Rear Seat Belt Malfunction
Opened Jan 16, 2002 · Closed Mar 11, 2002
Status: closed (inferred from source dates) · Seat Belts:rear/other
THIS INVESTIGATION WAS OPENED JANUARY 16, 2002, BASED ON SEVEN REPORTS ALLEGING THE THIRD ROW SEAT BELT RETRACTORS FAILED ON CERTAIN 1997 AND 1998 MODEL YEAR CARAVAN AND VOYAGER VEHICLES.THE REPORTS INDICATED A TAR LIKE SUBSTANCE ENTERED THE RETRACTOR MECHANISM, THUS CAUSING THE RETRACTOR TO JAM OR BIND.IN THIS CONDITION THE SEAT BELT IS RENDERED INOPERABLE, AS THE WEBBING CANNOT RETRACT OR BE WITHDRAWN FROM THE RETRACTORS FOR USE.RECALL SCOPE:THE AFFECTED VEHICLES ARE 1997 THROUGH 1999 DODGE CARAVAN, PLYMOUTH VOYAGER, AND CHRYSLER TOWN & CONTRY BUILT ON A SHORT WHEEL BASE CHASSIS.THE INCLUSIVE DATES OF PRODUCTION ARE JUNE 1996 THROUGH OCTOBER 31, 1999.RECALL REMEDY: DAIMLERCHRYSLER DEALERS WILL REPLACE THE MASTIC SOUND BARRIER PATCHES WITH FOAM BLOCKERS, AS WELL AS, INSPECT AND REPLACE ALL THIRD ROW REAR SEAT BELT ASSEMBLIES CONTAMINATED BY THE MASTIC PATCH.
EA01007 · Air Bag Clockspring
Opened Feb 21, 2001 · Closed Nov 22, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
RQ00008 · Dc Minivan Fuel Injector Rail Leak
Opened Mar 9, 2000 · Closed Mar 18, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA99013 · Post Collision Fuel System
Opened Jun 11, 1999 · Closed Aug 10, 2001
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
No summary supplied.
PE99010 · POST-COLLISION Fuel System Integrity
Opened Feb 3, 1999 · Closed Jun 11, 1999
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
There is no summary currently available
EA97003 · Integrated Child Seat Belt Lockup
Opened Jan 31, 1997 · Closed Aug 19, 1998
Status: closed (inferred from source dates) · Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
Additional source detail variants (2)
Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
SQ96016 · Integrated Child Seat Belt Lockup
Opened Sep 18, 1996 · Closed Feb 4, 1997
Status: closed (inferred from source dates) · Seat Belts:integrated Child Seat
ODI CONTINUES TO RECEIVE COMPLAINTS ALLEGING LATCHING/RETRACTOR MECHANISM PROBLEMS.CHRYSLER'S ASSESSMENT OF THE PROBLEM INDICATES THAT OWNERS OF THE VEHICLES ARE NOT ADHERING TO THE CLEANING REQUIREMENTS FOR THE SEAT.THE SEAT APPEARS TO MALFUNCTION IF CRUMBS OF FOOD OR BEVERAGE RESIDUE ACCUMULATES ON THE LATCHING TONGUE IN THEWELL LOCATED BETWEEN THE CHILD'S LEGS.ODI HAS 19 COMPLAINTS OF RETRACT LOCKUP.SEVEN OF THESE COMPLAINTS REPORT CUTTING THE STRAPS TO REMOVE THE CHILD.TWO OF THE SEVEN CONSUMERS ALLEGE THE CHILD WAS CHOKING.CHRYSLER REPORTS 60 OWNER/FIELD REPORTS WHICH INDICATED 19 HARNESSES WERE CUT TO REMOVE THE CHILDREN.ADDITIONAL INFORMATION IS NEEDED TO FULLY ASSESS THE SAFETY CONSEQUENCE OF THE ALLEGED DEFECT AND TO EVALUATE THE CHRYSLER CORPORATION'S RATIONAL FOR NOT CONDUCTING A SAFETY RECALL CAMPAIGN.