IllustrationWIRE HARNESS HAS FAILED, CAUSING THE HORN TO BE INOPERATIVE. THERE WAS A RECALL ASSOCIATED WITH THIS DESCRIPTION; HOWEVER, THIS VEHICLE WAS NOT INCLUDED DUE TO VIN. *AK *MR
1999 Plymouth Grand Voyager
Owner reports · Recalls · Investigations
More warning signs than most Grand Voyager years
Owner complaints for the 1999 Plymouth Grand Voyager are substantially higher than the model-year median of 80.
About this comparison →How this year compares
Owner complaints by model year
Compare all Grand Voyager years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
10–25K
925–50K
3750–75K
2275–100K
16100–150K
15150K+
100 reports with mileage · 108 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 52 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 49 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 39 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
9 crash reports3 fire reports4 injury reports
What owners actually said
208 reportsTHE PRINTED CIRCUIT BOARD THAT CONTROLS THE INSTRUMENT CLUSTER HAS FAILED TWICE AND HAD TO BE REPLACED. THE MECHANIC ADMITTED THAT THIS HAPPENS FREQUENTLY WITH MY VEHICLE AND I CAN EXPECT IT TO FAIL AGIAN. THERE IS AN ELECTRICAL PROBLEM THAT THE DEALERSHIP SAYS DOES NOT EXSIST, YET MY CAR CONSTANTLY FAILS TO OPERATE PROPERLY A…
Read full complaint
THE PRINTED CIRCUIT BOARD THAT CONTROLS THE INSTRUMENT CLUSTER HAS FAILED TWICE AND HAD TO BE REPLACED. THE MECHANIC ADMITTED THAT THIS HAPPENS FREQUENTLY WITH MY VEHICLE AND I CAN EXPECT IT TO FAIL AGIAN. THERE IS AN ELECTRICAL PROBLEM THAT THE DEALERSHIP SAYS DOES NOT EXSIST, YET MY CAR CONSTANTLY FAILS TO OPERATE PROPERLY AND MANY ELECTRICAL FAULTS OCCUR REGULARLY. THE HEADLIGHTS STOP WORKING, THE RADIO CUTS OUT, THE INSTRUMENT PANEL GOES OUT, THE DOOR LOCKS WONT WORK, THE HAZZARD FLASHERS COME ON & WILL NOT SHUT OFF. THE DEALER INSISTS THAT THERE IS NOTHING WRONG, YET THE PROBLEMS CONTINUE TO PLAUGE MY VEHICLE.*AK
EGR SYSTEM FAILURE (FAILING AIRBAGS, HORN, AND CRUISE CONTROL SYSTEM)-AS PER AN ARTICLE IN TODAYS ATLANTA JOURNAL-CONSTITUTION, YOU ARE CURRENTLY PROBING PLYMOUTH GRAND VOYAGERS FROM MODEL YEARS 1998 & 1999 DUE TO 109 COMPLAINTS REGARDING FAILING AIRBAGS, HORNS, AND CRUISE CONTROL SYSTEMS. THEREFORE, SINCE MY VAN HAD THE SAME PR…
Read full complaint
EGR SYSTEM FAILURE (FAILING AIRBAGS, HORN, AND CRUISE CONTROL SYSTEM)-AS PER AN ARTICLE IN TODAYS ATLANTA JOURNAL-CONSTITUTION, YOU ARE CURRENTLY PROBING PLYMOUTH GRAND VOYAGERS FROM MODEL YEARS 1998 & 1999 DUE TO 109 COMPLAINTS REGARDING FAILING AIRBAGS, HORNS, AND CRUISE CONTROL SYSTEMS. THEREFORE, SINCE MY VAN HAD THE SAME PROBLEM, I WANT TO BE ADDED TO YOUR LIST.*AK
HORN WON'T WORK AND AIR BAG LIGHT IS ON CONSISTENT WITH 1996-1998 CHRYSLER MINIVAN CLOCKSPRING RECALL. CHRYSLER SAID MY MINIVAN WAS NOT COVERED UNDER THE RECALL AND SO WILL NOT REPLACE THE CLOCKSPRING.*AK
THIS VAN HAS HAD 2 REBUILT TRANSMISIONS INSTALLED. ONE AT 74,000 & THE OTHER AT 77,000 MILES. I WAS INFORMED WHEN THE TRANSMISSION WAS REPLACED THE 2ND TIME THAT THIS IS A DESIGN FLAW IN THE TRANSMISSION AREA WHERE THE DIFFERENTIAL PIN IS LOCATED. I CONTACTED CHRYSLER AND THEY WILL NOT COVER ANY OF THE EXPENSE.
AIR BAG WARNING LAMP CONTINUOUSLY ILLUMINATED WITH FAILURE OF HORN & CRUISE CONTROL. PREVIOUS YEAR MODELS ARE BEING RECALLED FOR SAME CLOCKSPRING NOT BEING WOUND CORRECTLY DURING INSTALLATION.
STARTED OVERHEATING 12/20/02. REPLACED COOLANT. COOLANT LEAKED OUT QUICKLY. TAKEN TO MECHANIC ON 12/23-REPLACED WATER TO DRIVE THERE, NO OVERHEATING. MECHANIC FOUND BADLY DETERIORATED HEAD GASKETS,LEAKING PROFUSELY UNDER PRESSURE. WILL HAVE VAN TOWED TO DEALERSHIP ON 12/30/02.
HEAD GASKET WENT BAD. THE CAR NEVER OVERHEATED SO OUR ONLY CLUE WAS A PUDDLE OF ANTI-FREEZE IN THE DRIVEWAY.
WE JUST PURCHASED THE PREOWNED VAN ON APRIL 8, 2003 IT HAS 41600 MILES ON IT ONE TIME OWNER PREVIOUSLY 1. PAINT IS CHIPPING OFF OF THE DRIVER SIDE DOOR HANDLE. THE DEALER IS GOING TO GET US TOUCH UP PAINT TO FIX. 2. THE POWER STEERING RETURN HOSE TO THE POWER STEERING RESERVOIR WAS CUT WHEN WE LOOKED AT IT. THE DEALER HAD THE…
Read full complaint
WE JUST PURCHASED THE PREOWNED VAN ON APRIL 8, 2003 IT HAS 41600 MILES ON IT ONE TIME OWNER PREVIOUSLY 1. PAINT IS CHIPPING OFF OF THE DRIVER SIDE DOOR HANDLE. THE DEALER IS GOING TO GET US TOUCH UP PAINT TO FIX. 2. THE POWER STEERING RETURN HOSE TO THE POWER STEERING RESERVOIR WAS CUT WHEN WE LOOKED AT IT. THE DEALER HAD THE MECHANIC LOOK AT IT AND THOUGHT MAYBE THE HOSE GOT CAUGHT IN THE FAN BELT AND CUT IT. THE DEALER REPAIRED IT AND SAID NO OTHER DAMAGE WAS DONE. THIS TIME THEY TIDE DOWN THE HOSE AWAY FROM THE BELT.
AIR BAG WARNING LIGHT CONSTANTLY ON AND LED TO HORN FAILURE. ALMOST RESULTED IN ACCIDENT(S) WHEN WE ARE UNABLE TO SOUND HORN WHEN OTHER UNSAFE DRIVER(S) MANUEVER IN A MANNER WHICH WOULD CAUSE COLLISION WITH US.
Official recalls
304V480000 · Air Bags
Oct 6, 2004
ON CERTAIN MINIVANS, THE DRIVER'S AIR BAG MAY BECOME DISABLED DUE TO A FAILURE OF THE CLOCKSPRING, WHICH IS LOCATED IN THE HUB OF THE STEERING WHEEL.
Consequence & remedy
Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL COVERED VEHICLES WITH 70,000 MILES OR LESS. FOR THOSE VEHICLES WITH MORE THAN 70,000 MILES, DAIMLERCHRYSLER WILL OFFER AN EXTENDED LIFETIME WARRANTY UNDER WHICH IT WILL REPLACE THE CLOCKSPRING AT NO CHARGE IF IT FAILS. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. THE RECALL BEGAN ON OCTOBER 12, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
00V268000 · Fuel System, Gasoline:fuel Injection System
Sep 13, 2000
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
99V116000 · Exterior Lighting:headlights
May 6, 1999
VEHICLE DESCRIPTION: MINI VANS BUILT FOR FLEET SALES ONLY. THE HEADLAMP MODULE DOES NOT IDENTIFY THE PARK LAMP AS "DRL" AS REQUIREMENT OF FMVSS 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence & remedy
Consequence: THESE VEHICLES DO NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 108.
Remedy: ALL FLEET OWNERS/OPERATORS WILL BE MAILED NON-REMOVABLE DECALS WITH THE REQUIRED "DRL" LETTERS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6EA04013 · Driver Air Bag Clockspring Failure
Opened Jun 4, 2004 · Closed May 25, 2005
Status: closed (inferred from source dates) · Air Bags:frontal
THE DRIVER AIR BAG CLOCKSPRING CAN DEVELOP AN OPEN-CIRCUIT CONDITION RESULTING IN NONFUNCTIONAL DRIVER-SIDE FRONTAL AIR BAG, HORN, CRUISE CONTROL (IF EQUIPPED), AND/OR STEERING WHEEL RADIO CONTROL (IF EQUIPPED).IN ITS OCTOBER 5, 2004 LETTER TO NHTSA, DAIMLERCHRYSLER STATED THAT IT WILL CONDUCT A SAFETY RECALL AND REPLACE THE CLOCKSPRING ASSEMBLY ON ALL MY 1998.5-2000 DAIMLERCHRYSLER MINIVANS, BUILT BETWEEN MARCH 1998 AND AUGUST 2000, WITH 70,000 MILES OR LESS.IT WILL ALSO PROVIDE A LIFETIME WARRANTY FOR THIS COMPONENT ON MY 1998.5-2000 MINIVANS, REGARDLESS OF MILEAGE.THE DETAILS OF THE CORRECTIVE ACTION ARE DESCRIBED IN DAIMLERCHRYSLER'S LETTER (SEE RECALL NO. 04V-480).THE AGENCY BELIEVES THAT FURTHER EXPENDITURE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS WITH RESPECT TO THOSE VEHICLES COVERED ONLY BY THE LIFETIME WARRANTY.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE PAGE 2 FOR ADDITIONAL INFORMATION.
RQ04001 · Driver Air Bag Clockspring Failure
Opened Jan 28, 2004 · Closed Jun 4, 2004
Status: closed (inferred from source dates) · Air Bags:frontal
COMPLAINTS REPORT AIR BAG WARNING LIGHT ILLUMINATES, AND THIS MAY BE ACCOMPANIED WITH A NON-FUNCTIONING HORN AND/OR CRUISE CONTROL (IF EQUIPPED).THIS IS INDICATIVE OF AN OPEN-CIRCUIT CLOCKSPRING FAILURE (RESULTS IN NON-FUNCTIONING DRIVER'S AIR BAG), SIMILAR TO THE FAILURE CONDITION THAT WAS THE SUBJECT OF DAIMLERCHRYSLER'S RECALL OF MODEL YEAR 1996-1998.5 MINIVANS (RECALL NO. 02V-293).THIS RECALL QUERY HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA04-013).
EA01007 · Air Bag Clockspring
Opened Feb 21, 2001 · Closed Nov 22, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
RQ00008 · Dc Minivan Fuel Injector Rail Leak
Opened Mar 9, 2000 · Closed Mar 18, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA99013 · Post Collision Fuel System
Opened Jun 11, 1999 · Closed Aug 10, 2001
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
No summary supplied.
PE99010 · POST-COLLISION Fuel System Integrity
Opened Feb 3, 1999 · Closed Jun 11, 1999
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
There is no summary currently available