Suspension. Review the 9 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 8 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Structure. Review the 8 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

1 crash reports0 fire reports8 injury reports

Engine And Engine Cooling complaints

7 reports

Clear category filter

70,825 miles · Nov 2, 2007

Engine And Engine Cooling

INTAKE MANIFOLD GASKET LEAKING COOLANT EXTERNALY.AND ENGINE OIL LEAKING INTO COOLANT INTERNALY. INTAKE GASKET FAILURE. INTAKE GASKET WAS REPLACED. *TR

NHTSA ODI #10207794

39,000 miles · May 26, 2007

Engine And Engine CoolingEquipmentPower TrainInjury

Read full complaint

2002 SILHOUETTE, 39000 MILES. FRONT WHEEL BEARINGS FAILED. HAD REPAIRED, WITHIN 50 MILES AFTER PICKING UP FROM DEALERSHIP, THERE WAS A GRINDING WHEN TURNING RIGHT. BOTH HEATED SEATS DIDN'T HEAT. DRIVER'S SIDE WINDOW OPERATED EXTREMELY SLOW. INTAKE MANIFOLD GASKET NEEDED REPLACEMENT!, $1000!, 39000 MILES FOLKS! AIR SUSPENSION DID NOT OPERATE CRACKLED. POWER DOORS DID NOT OPEN WHEN SOMETHING GOT IN THE WAY. BRUISED SHOULDER BECAUSE OF THIS. PREMATURE TIRE WEAR, REPLACED TIRES AT 30,000 MILES. ALL SCHEDULED MAINTENANCE DONE. STORED IN A GARAGE MORE HIGHWAY MILES THAN CITY. HOW DID GM WANT TO HELP ME? DEALER DID PAPERWORK WHEN PURCHASING, TRIED TO PUSH OFF A CHEAPER MODEL ON AN ELDERLY WOMEN, AND CHANGED THE PROMISED 5 YEAR WARRANTY TO A 3 YEAR WARRANTY. MOTHER WAS JUST SO HAPPY SHE GOT THE RIGHT VEHICLE TO TAKE HOME, SHE NEVER NOTICED THE CHANGE IN THE WARRANTY. TRIED TO WORK WITH THE DEALER ON REPAIRS SINCE THERE WERE ONLY 39000 MILES, AND WE GOT A 'GEE, REALLY SORRY MA'AM, I UNDERSTOOD, BUT THERE WASN'T ANYTHING WE COULD DO ABOUT IT. WENT TO THE GM SERVICE LINE, AND DID NOT GET ANY HELP THERE EITHER, BUT SHE HAD A REAL PURDY FIRST NAME! SEEMED TO ME THESE WERE ALL RECURRING PREMATURE KNOWN FAILURES , YET GM DID NOT CARE TO STAND BEHIND THEIR PRODUCT! IT WAS A SHAME THEY PUSHED THE 5 YEAR WARRANTY SO EXTENSIVELY WHEN THEY HAD ALL THESE VEHICLES ON THEIR LOTS. PEOPLE, WE'VE BEEN HAD. I GREW UP IN OLDSMOBILE, BUT THE MORE I READ ABOUT GM - THE MORE LIKELY I AM TO BUY TOYOTA! THE GOOD NEWS IS THAT I FOUND A DEALER (NOT CLOSE TO HOME THOUGH) THAT WAS WILLING TO AT LEAST REPAIR THE FIRST SET OF WHEEL BEARINGS FOR $100. GOT THAT ON MY OWN, NOT THROUGH GM SERVICE HELP. I JUST HOPE THEY WILL BE AS NICE FOR THE NEXT SET OF WHEEL BEARINGS THAT NEED REPLACEMENT AND FOR THE GASKET THAT WAS JUST DISCOVERED. STILL WAITING TO HEAR FROM GM ON THE OTHER ISSUES. (NOT AS AN IMMEDIATE NEED AS THE WHEEL BEARINGS) I'M NOT HOLDING MY BREATH.*AK

NHTSA ODI #10191801

70,000 miles · Nov 7, 2006

Engine And Engine Cooling

I HAVE A 2002 OLDS SILHOUETTE MINIVAN WHICH HAD TO HAVE THE INTAKE MANIFOLD GASKET REPLACED. IN TALKING TO THE MECHANIC WHO FIXED IT, THIS IS SO COMMON WITH THESE GM VEHICLES THAT IT IS LAUGHABLE. *JB

NHTSA ODI #10172872

1,000 miles · Sep 14, 2006

Engine And Engine CoolingEquipmentExterior Lighting

SLIDING DOOR PROBLEMS SINCE PURCHASE. DRIVER ELECTRIC SEAT "REPAIRED" SEVERAL TIMES AND STILL DOES NOT WORK. DEALER REPAIRED REAR COMPRESSOR AND BROKE COVER LATCH. THEY PUT A HOLE IN THE FRONT BUMPER AT THIS TIME. PASSENGER FRONT WINDOW CHOOSES NOT TO WORK AT RANDOM AND BACK LEFT SIDE WINDOW SOMETIMES DOES NOT CLOSE. TAPE PL…

Read full complaint

NHTSA ODI #10168292

64,442 miles · Aug 24, 2005

Electrical SystemEngine And Engine CoolingEquipment

AWD DISABLE AND ABS LIGHTS ILLUMINATED. LEFT REAR WHEEL BEARING AND HUB ASSEMBLY FAILED AND WERE REPLACED (FOUR TIMES).*AK THE EVAP SOLENOID, FUEL SENDER AND PUMP ASSEMBLY WERE REPLACED. THE HEATING ELEMENT FOR THE FRONT DRIVER'S SEAT FAILED TWICE. THE RIGHT REAR SEAT BELT FAILED. THE RIGHT POWER SLIDING DOOR ACTUATOR MODUL…

Read full complaint

NHTSA ODI #10114146

17,000 miles · Jun 14, 2004

Engine And Engine Cooling

WHEN THE VEHICLE WAS TURNED OFF AND WHEN THE CONSUMER CAME BACK INTO VEHICLE IT WOULD NOT START. AFTER ABOUT AN HOUR TO TWO HOURS VEHICLE WOULD START. THIS PROBLEM OCCURRED FIVE TIMES SINCE APRIL 2003. DEALER EXAMINED THE VEHICLE SEVERAL TIMES AND COULD NOT DUPLICATE OR RESOLVE THE PROBLEM. *AK

NHTSA ODI #10076213

12,000 miles · Jan 29, 2003

Engine And Engine Cooling

WHILE DRIVING DOWN THE HIGHWAY AT ABOUT 45 MPH, THE VEHICLE LOST ALL POWER AND STALLED. HAD TO MANUVER THE VEHICLE TO THE SHOULDER WITH OUT POWER STEERING AND POWER BRAKES. ONCE VEHICLE WAS RESTARTED THE IDLE WAS VERY SPARATIC. WHEN REVED TO ENSURE ENOUGH RPM'S TO ALTERNATOR TO CHARGE BATTERY (IN CASE THAT WAS THE PROBLEM), F…

Read full complaint

NHTSA ODI #10004885

Official recalls

04V597000 · Latches/locks/linkages:doors:latch

Dec 22, 2004

ON CERTAIN MINIVANS EQUIPPED WITH SECOND-ROW BUCKET SEATS OR CAPTAIN'S CHAIRS AND A POWER SLIDING DOOR ON THE PASSENGER SIDE OF THE VEHICLE, A PASSENGER USING THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR COULD BE INJURED.

Consequence & remedy

Consequence: IF A PASSENGER USES THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR AND HOLDS ONTO THE HANDLE WHILE IT IS BEING OPENED BY THE MOTOR, THE PASSENGER'S ARM MAY BE PUSHED INTO THE SEAT BACK OR ARMREST AND A WRIST OR LOWER ARM INJURY MAY RESULT.

Remedy: DEALERS WILL REPLACE THE POWER SLIDING DOOR INTERIOR HANDLE ON THE PASSENGER-SIDE. IF THE VEHICLE IS EQUIPPED WITH A POWER OR MANUAL SLIDING DOOR ON THE DRIVER-SIDE, THE INTERIOR HANDLE WILL ALSO BE REPLACED FOR APPEARANCE REASONS. NOTE: BEFORE THE VEHICLE IS SERVICED, GM ADVISES OWNERS TO NOT USE THE INTERIOR DOOR HANDLE TO OPEN THE DOOR. THE DRIVER CAN OPEN AND CLOSE THE DOOR FROM SWITCHES AT THE DRIVER'S POSITION OR BY USING THE REMOTE KEY FOB. THE DRIVER SHOULD TELL PASSENGERS TO USE THE SWITCH LOCATED IN FRONT OF THE DOOR TO OPEN OR CLOSE IT. THE DRIVER SHOULD USE THE OVERRIDE SWITCH TO PREVENT OPERATION OF THE POWER DOOR BY CHILDREN OR BY OTHERS WHO ARE NOT FAMILIAR WITH ITS USE. THE OWNER NOTIFICATION LETTER MAILING WILL BE CONDUCTED IN PHASES WITH THE FIRST PHASE BEGINNING ON MAY 31, 2005. THE SECOND PHASE MAILING BEGAN ON JULY 18, 2005. THE RECALL BEGAN ON MAY 31, 2005. PHASE 2 BEGAN ON JULY 18, 2005. PHASE 3 (FINAL PHASE) BEGAN ON AUGUST 24, 2005, TO ALL REMAINING CUSTOMERS. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438; PONTIAC AT 1-800-620-7668; OR OLDSMOBILE AT 1-800-630-6537.

02V222000 · Air Bags:frontal

Aug 9, 2002

CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.

Consequence & remedy

Consequence: PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.

Remedy: DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

PE04064 · POWER-SLIDING Door

Opened Sep 17, 2004 · Closed Dec 22, 2004

Status: closed (inferred from source dates) · Structure:body:door

SUBJECT VEHICLES ARE AVAILABLE WITH AN OPTIONAL POWER SLIDING DOOR.THE INTERIOR HANDLE IS ORIENTED IN THE VERTICAL POSITION IN THE DOOR PANEL AND LINES UP AT THE ELBOW LEVEL WHEN THE OCCUPANT IS SEATED IN THE 2ND-ROW OUTBOARD POSITION.IF THE OCCUPANT HOLDS THE INTERIOR HANDLE IN THE THUMB UP POSITION DURING POWER-ASSISTED OPENING, THE ARM/WRIST CAN BE PUSH BACK WITH FORCE AGAINST THE 2ND-ROW BUCKET SEAT OR CAPTAIN'S CHAIR SEAT BACK CREATING A RISK OF INJURY (OTHER SEATING CONFIGURATIONS HAVE AMPLE SEAT TO DOOR CLEARANCE TO AVOID ENTRAPMENT OF THE LOWER ARM).AMONG THE 103 TOTAL REPORTS, THERE WERE 102 ALLEGED INJURIES INCLUDING ARM/WRIST, THUMB AND SHOULDER INJURIES.A COUNT OF INJURIES REVEALS THAT 76 INJURIES WERE A FRACTURED OR A BROKEN ARM/WRIST REQUIRING AN IMMOBILIZING CAST FOR FOUR-TO-SIX WEEKS.ALL INJURIES INVOLVE THE RIGHT SIDE POWER SLIDING DOOR.THE LEFT SIDE POWER SLIDING DOOR IS ON FAR FEWER VEHICLES, BUT MORE IMPORTANTLY, IT PRODUCES LESS FORCE.GM NOTIFIED THE AGENCY BY LETTER DATED DECEMBER 21, 2004, THAT IT WILL RECALL MODEL YEAR 1997 THOUGH EARLY 2005 GM U-VAN VEHICLES EQUIPPED WITH A RIGHT SIDE POWER SLIDING DOOR AND WITH 2ND-ROW BUCKET SEATS OR CAPTAIN CHAIRS (NHTSA RECALL #04V597).AS PART OF THE RECALL REMEDY, GM WILL REPLACE THE DOOR HANDLE WITH A FLUSH MOUNTED HANDLE THAT WILL PREVENT AN OCCUPANT FROM GRASPING THE HANDLE WITH THE PALM BETWEEN THE HANDLE AND DOOR PANEL (THUMB UP ORIENTATION) AND THUS ELIMINATE THE POTENTIAL FOR ARM/WRIST ENTRAPMENT.THIS INVESTIGATION IS CLOSED.