Steering. Review the 12 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Air Bags. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Fuel System, Gasoline. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

16 crash reports2 fire reports10 injury reports

Tires complaints

4 reports

Clear category filter

122,000 miles · Mar 22, 2015

StructureTires

Read full complaint

CALLED ROADSIDE ASSISTANCE TO CHANGE A TIRE. THE SPARE TIRE RUBBER WAS BURNED IN THREE OR MORE PLACES FROM THE HEAT SPREADING UNDER THE VEHICLE, AND THE CHAR/MELTING/BURNING WENT THROUGH THE VEHICLE BODY FROM THE BOTTOM OF THE VEHICLE OUTSIDE TO THE FLOOR INSIDE. THE MAN CHANGING MY TIRE SUGGESTED IT WAS A FIRE WAITING TO HAPPEN AND THAT THERE COULD BE A RECALL FOR THIS SORT OF ISSUE. I CHECKED AND DO NOT SEE ANYTHING LISTED. MY TIRED IS NOW DAMAGED FROM THE HEAT MELTING THE RUBBER, AND MY VEHICLE IS CHARRED IN PLACES. *TR

NHTSA ODI #10700996

70,400 miles · Jul 9, 2009

Tires

Read full complaint

PURCHASED MASTERCRAFT COURSER A/T2 265/70R16 TIRES 9/13/2007, TOOK TO MECHANIC FOR SHIMMY, WAS INFORMED THAT BELTS IN TIRES SHIFTED, BROUGHT TO TOWN FAIR TIRE IN WESTFIELD, MA. BALANCED TIRES SENT ME ON MY WAY, WENT BACK 2 WEEKS LATER FOR SAME PROBLEM, WAS INFORMED THAT THERE WAS A SAFETY CONCERN, HOWEVER IT STILL COST ME $322.01 WITH OLD TIRES BEING PRORATED. I ONLY HAD 12000 MILES ON THE TIRES AND IF IT WAS A SAFETY CONCERN SHOULDN'T THE TIRES BEEN COVERED UNDER A RECALL OR WORKMANSHIP WARRANTY. I DID CHECK FOR RECALLS DIFFERENT SIZE TIRE HAD A RECALL FOR BELT SHIFTING IN TIRE, HOWEVER THIS SIZE WAS NOT AFFECTED BY RECALL. I FEEL THIS IS A PROBLEM AND I AM VERY UPSET THAT I HAD TO PAY FOR THE PROBLEM WITH COULD HAVE BEEN WORSE. SO IN LESS THAN TWO YEARS I HAD TO SPEND ALMOST $900.00 WITH ONE SET BEING PRORATED ON TIRES.... VERY CONCERNED VERY UPSET. PLEASE NOTE THIS WAS A PROBLEM ON MORE THAN ONE TIRE. *TR

NHTSA ODI #10276178

7,500 miles · Sep 14, 2004

Tires

WHILE DRIVING 65 MPH, THE CONSUMER HEARD A NOISE COMING FROM THE REAR. THE CONSUMER PULLED OVER AND NOTICED THAT THE DRIVER'S REAR TIRE SIDEWALL SPLIT. *AK *SC

NHTSA ODI #10075789

Mileage unknown · Aug 7, 2003

TiresCrashInjury

WHILE DRIVING ON THE HIGHWAY AT 55 MPH THE CONSUMER LOSS CONTROL OF THE VEHICLE AND FLIPPED OVER THREE TIMES. WITNESSES TO THE ACCIDENT STATED THE REAR RIGHT TIRE BLEWOUT. GENERAL GRABBER AW P265/70R16. *AK BRAKES AND STEERING WERE INOPERABLE PRIOR TO TIRE BLOW OUT. THE VEHICLE WAS TOTALED. *PH *JB

NHTSA ODI #10024916

Official recalls

10V554000 · Steering:column

Nov 11, 2010

NISSAN IS RECALLING CERTAIN MODEL YEAR 2002-2004 FRONTIER VEHICLES MANUFACTURED FROM JULY 9, 2001 THROUGH OCTOBER 20, 2004, AND MODEL YEAR 2002-2004, XTERRA VEHICLES MANUFACTURED FROM JULY 9, 2001, THROUGH JANUARY 6, 2005. OVER TIME CORROSION MAY FORM IN THE LOWER STEERING COLUMN JOINT AND LIMIT MOVEMENT OF THE JOINT. THE LIMITED MOVEMENT OF THIS JOINT MAY CREATE EXCESSIVE LOAD ON THE LOWER STEERING COLUMN SHAFT. IF THE VEHICLE CONTINUES TO BE DRIVEN IN THIS CONDITION, IT MAY LEAD TO CRACKING OF THE SHAFT DURING LOW SPEED MANEUVERS THAT REQUIRE LARGE STEERING INPUTS.

Consequence & remedy

Consequence: THE SHAFT MAY BREAK WHICH COULD RESULT IN LOSS OF STEERING CONTROL DURING THESE LOW SPEED MANEUVERS INCREASING THE RISK OF A CRASH.

Remedy: THE STEERING COLUMN SHAFT AND JOINT WILL BE REPLACED WITH A SHAFT OF A DIFFERENT DESIGN. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 13, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.

04V230000 · Fuel System, Gasoline:delivery:fuel Pump

May 24, 2004

ON CERTAIN PICKUP TRUCKS EQUIPPED WITH SIX CYLINDER ENGINES AND SPORT UTILITY VEHICLES EQUIPPED WITH FOUR OR SIX CYLINDER ENGINES, THE FUEL PUMP TERMINAL ON THE FUEL-SENDING UNIT CAN DEVELOP A CRACK IN THE PLASTIC MOLDING. THIS CAN CAUSE THE TERMINAL STRIP TO CORRODE UNDER SOME ENVIRONMENTAL CONDITIONS.

Consequence & remedy

Consequence: IF CORROSION OCCURS, THE TERMINAL STRIP COULD EVENTUALLY BREAK CAUSING THE FUEL PUMP TO STOP OPERATION. THIS WILL RESULT IN NOT BEING ABLE TO START THE ENGINE OR CAUSE THE ENGINE TO STOP RUNNING WITHOUT WARNING, WHICH CAN RESULT IN A CRASH.

Remedy: IN THE FOLLOWING STATES, DEALERS WILL REPLACE THE FUEL-SENDING UNIT. THESE STATES ARE CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, TENNESSEE, VERMONT, VIRGINIA, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. IN THE OTHER STATES, THE DEALER WILL INSPECT THE FUEL PUMP TERMINAL ON THE SENDING UNIT FOR CORROSION. IF CORROSION IS PRESENT, THE DEALER WILL REPLACE THE UNIT. IF THERE IS NOT CORROSION, THE DEALER WILL APPLY SEALANT TO THE TERMINAL HOUSING TO HELP PREVENT CORROSION IN THE FUTURE. OWNER NOTIFICATION BEGAN ON JUNE 28, 2004. OWNERS SHOULD CONTACT NISSAN AT 1-800-647-7261.

02V299000 · Suspension:rear

Nov 12, 2002

ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, WATER MAY ENTER THE REAR AXLE HOUSING DUE TO INADEQUATE SEALING OF THE ANTI-LOCK BRAKING SYSTEM (ABS) SENSOR.

Consequence & remedy

Consequence: THIS CAN RESULT IN CORROSION AND EVENTUAL FAILURE OF THE WHEEL BEARING. IF THIS OCCURS, THE WHEEL ASSEMBLY COULD SEPARATE FROM THE VEHICLE INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSPECT THE REAR AXLE FOR WATER INTRUSION AND ANY AFFECTED COMPONENTS WILL BE REPLACED. THE ABS SENSOR WILL BE RESEALED TO PREVENT WATER INTRUSION. OWNER NOTIFICATION BEGAN DECEMBER 10, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NISSAN AT 1-800-647-7261.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

DP03005 · Brake Rotor Warpage

Opened Jul 11, 2003 · Closed Jul 29, 2003

Status: closed (inferred from source dates) · Service Brakes, Hydraulic:foundation Components:disc:rotor

MR. KENT JONES OF KERNERSVILLE, NC, SUBMITTED A PETITION TO NHTSA BY E-MAIL DATED JULY 1, 2003, REQUESTING NHTSA TO INVESTIGATE THE BRAKE ROTORS ON MY 2002 NISSAN XTERRA VEHICLES.THE PETITIONER ALLEGED THAT THE BRAKE ROTORS IN THESE VEHICLES WERE DEFECTIVE BECAUSE THE ROTORS OVERHEAT AND WARP FROM NORMAL USAGE.A REVIEW OF ODI'S DATABASE FOR COMPLAINTS REGARDING MY 2001 THROUGH MY 2003 NISSAN XTERRA VEHICLES IDENTIFIED ONLY TWO REPORTS RELATED TO BRAKE ROTOR WARPING; ONE FOR A MY 2001 AND ONE FOR A MY 2002.THE COMPLAINT FOR THE MY 2002 NISSAN XTERRA WAS REPORTED BY THE PETITIONER.BRAKE ROTOR WARPING CAN RESULT IN BRAKE PULSATION AND SHAKING WHEN THE BRAKE IS APPLIED.BRAKE PULSATION, TIRE OR SUSPENSION VIBRATION, AND SIMILAR CONDITIONS ARE AN OBVIOUS ANNOYANCE TO THE DRIVER, BUT GENERALLY DO NOT CAUSE A DRIVER TO LOSE CONTROL OF A VEHICLE.FURTHERMORE, EVEN IF LEFT UNCORRECTED, ANY POTENTIAL INCREASE IN STOPPING DISTANCE WILL BE NEGLIGIBLE. THEREFORE, THIS CONDITION DOES NOT NORMALLY CONSTITUTE A SAFETY DEFECT, EVEN IF IT OCCURS WITH FAR MORE OFTEN FREQUENCY. IN VIEW OF THE FOREGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF AN ALLEGED SAFETY-RELATED DEFECT AS DEFINED BY THE PETITIONER IN THE MY 2002 NISSAN XTERRA VEHICLES AT THE CONCLUSION OF AN INVESTIGATION.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S SAFETY MISSION, THE PETITION IS DENIED.