IllustrationTL* THE CONTACT OWNS A 2003 NISSAN XTERRA. THE CONTACT STATED THAT THE REAR DRIVER AND PASSENGER SIDE CATALYTIC CONVERTERS FAILED. THE CONTACT ALSO MENTIONED THE EGR SYSTEM FAILED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 120,000.
2003 Nissan Xterra
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2003 Nissan Xterra do not stand out strongly from the model-year median of 78.
About this comparison →How this year compares
Owner complaints by model year
Compare all Xterra years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
150–25K
325–50K
850–75K
875–100K
13100–150K
6150K+
53 reports with mileage · 19 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 12 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
16 crash reports2 fire reports10 injury reports
Engine And Engine Cooling complaints
7 reportsWE WERE DRIVING ON VACATION AND THE CAR STOPPED. IT STARTED BACK UP AND THEN AFTER A COUPLE OF MILES STOPPED AGAIN. WE WERE STRANDED AND DIDN'T GET HOME FOR THREE DAYS.I HAVE TAKE CODES OFF THE ENGINE AND IT SHOWED A 0462 CODE. WENT BACK TO GET XTERRA WITH A CAR DOLLY AND DOLLY BROKE AND CAR CAME UNDONE. THIS UNFORTUNATE INCIDE…
Read full complaint
WE WERE DRIVING ON VACATION AND THE CAR STOPPED. IT STARTED BACK UP AND THEN AFTER A COUPLE OF MILES STOPPED AGAIN. WE WERE STRANDED AND DIDN'T GET HOME FOR THREE DAYS.I HAVE TAKE CODES OFF THE ENGINE AND IT SHOWED A 0462 CODE. WENT BACK TO GET XTERRA WITH A CAR DOLLY AND DOLLY BROKE AND CAR CAME UNDONE. THIS UNFORTUNATE INCIDENT WAS A DIRECT RESULT OF A BAD SENDING UNIT. *TR
RADIATOR IS FALLING OUT OF TRUCK ,DUE TO SERIOUS RUST ON FRAMING, HOOD LATCH IS STARTING TO BREAK FREE HOOD COULD FLY UP ONTO WINDSHIELD . *TR
ENGINE LIGHT CAME ON IN 09. VEHICLE FAILED EMISSIONS DUE TO PROBLEM WITH EVAC SYSTEM. GASKET AT FUEL TANK WAS REPLACED. WITHIN A YEAR, ENGINE LIGHT CAME BACK ON. THERE WAS ANOTHER PROBLEM WITH THE EVAC SYSTEM. AFTER $ 862.00 DOLLARS THAT WERE SPENT ON VEHICLE FOR O RING AND GASKET REPAIRS, VEHICLE PASSED EMISSIONS. WITHIN 8 MONT…
Read full complaint
ENGINE LIGHT CAME ON IN 09. VEHICLE FAILED EMISSIONS DUE TO PROBLEM WITH EVAC SYSTEM. GASKET AT FUEL TANK WAS REPLACED. WITHIN A YEAR, ENGINE LIGHT CAME BACK ON. THERE WAS ANOTHER PROBLEM WITH THE EVAC SYSTEM. AFTER $ 862.00 DOLLARS THAT WERE SPENT ON VEHICLE FOR O RING AND GASKET REPAIRS, VEHICLE PASSED EMISSIONS. WITHIN 8 MONTHS, ENGINE LIGHT WAS BACK ON DUE TO EVAC SYSTEM. MECHANIC STATES THAT THERE IS MAJOR CORROSION OF THE FUEL TANK AND THAT HE HAS SEEN THE SAME THING ON MANY NISSAN VEHICLES OF THIS AGE DUE TO THE MATERIAL USED TO CONSTRUCT THE FUEL TANK AND BELIEVES THAT IT IS A WIDESPREAD PROBLEM THAT SHOULD HAVE BEEN RECALLED AND THAT NISSAN STARTED USING A DIFFERENT MATERIAL ONCE THE PROBLEM WAS KNOWN. THE ENTIRE INTERIOR OF THE VEHICLE SMELLS OF GASOLINE AND MECHANIC STATES THAT ANYONE IN CLOSE PROXIMITY OF VEHICLE COULD CAUSE AN EXPLOSION IF A SPARK WAS CREATED. *TR
I OWN A 2003 NISSAN XTERRA 4WD. IT HAS 55,000 MILES AND ONLY BEEN SERVICED AT NISSAN DEALERSHIP. I NOTICED A SWEET SMELL COMING FROM THE ENGINE WHEN THE CAR WAS WARM SO WHEN I TOOK IN FOR OIL CHANGE ASKED THEM TO CHECK IT OUT. TOLD ME THE HEADS WERE WARPED AND NEEDED TO BE GROUND DOWN, NEW GASKET, BELTS AND SPARKPLUGS D/T THE…
Read full complaint
I OWN A 2003 NISSAN XTERRA 4WD. IT HAS 55,000 MILES AND ONLY BEEN SERVICED AT NISSAN DEALERSHIP. I NOTICED A SWEET SMELL COMING FROM THE ENGINE WHEN THE CAR WAS WARM SO WHEN I TOOK IN FOR OIL CHANGE ASKED THEM TO CHECK IT OUT. TOLD ME THE HEADS WERE WARPED AND NEEDED TO BE GROUND DOWN, NEW GASKET, BELTS AND SPARKPLUGS D/T THE HEAD LEAKING. THIS IS THE SECOND HEAD GASKET PROBLEM I'VE HAD WITH A NISSAN I'VE OWNED. THE OTHER ONE WAS UNDER WARRANTY AND WAS TOLD IT WAS A FREAK THING. I BELIEVED THEM, AND HAD NO PROBLEM BUYING ANOTHER NISSAN. NOW SAME PROBLEM AND I HAVE TO PAY $2,250.00 FOR REPLACEMENT. NO ONE CAN TELL ME WHY. I CONTACTED NISSAN CORP FOR REIMBURSEMENT ON THIS. IM STILL WAITING FOR A REPLY, BUT AFTER SEARCHING THE NET I SEE THAT THIS IS A FAMILIAR PROBLEM WITH NISSAN. I WILL NOT BE BUYING ANOTHER NISSAN PRODUCT. *TR
SINCE 2006, SENSOR LIGHT WAS COMING ON AND OFF. IN 2008 FAILED EMISSION INSPECTION DUE TO SENSOR LIGHT. HAD REPAIRED BY A STATE CERTIFIED REPAIR FACILITY, AS REQUIRED BY STATE OF MASS, FOR SENSOR AND CAT CONVERTER IN MAY 2008. IN AUG 2008 SENSOR LIGHT CAME BACK ON. HAD RESET - WAS SAME ISSUE THAT WAS REPAIRED IN MAY 2008. *TR
FUEL INJECTION SYSTEM WAS REPLACED FOUR TIMES. AFTER THE LAST REPAIR, WHILE DRIVING THE VEHICLE, IT CAUGHT ON FIRE IN THE ENGINE. *AK
Official recalls
310V554000 · Steering:column
Nov 11, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2002-2004 FRONTIER VEHICLES MANUFACTURED FROM JULY 9, 2001 THROUGH OCTOBER 20, 2004, AND MODEL YEAR 2002-2004, XTERRA VEHICLES MANUFACTURED FROM JULY 9, 2001, THROUGH JANUARY 6, 2005. OVER TIME CORROSION MAY FORM IN THE LOWER STEERING COLUMN JOINT AND LIMIT MOVEMENT OF THE JOINT. THE LIMITED MOVEMENT OF THIS JOINT MAY CREATE EXCESSIVE LOAD ON THE LOWER STEERING COLUMN SHAFT. IF THE VEHICLE CONTINUES TO BE DRIVEN IN THIS CONDITION, IT MAY LEAD TO CRACKING OF THE SHAFT DURING LOW SPEED MANEUVERS THAT REQUIRE LARGE STEERING INPUTS.
Consequence & remedy
Consequence: THE SHAFT MAY BREAK WHICH COULD RESULT IN LOSS OF STEERING CONTROL DURING THESE LOW SPEED MANEUVERS INCREASING THE RISK OF A CRASH.
Remedy: THE STEERING COLUMN SHAFT AND JOINT WILL BE REPLACED WITH A SHAFT OF A DIFFERENT DESIGN. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 13, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
04V230000 · Fuel System, Gasoline:delivery:fuel Pump
May 24, 2004
ON CERTAIN PICKUP TRUCKS EQUIPPED WITH SIX CYLINDER ENGINES AND SPORT UTILITY VEHICLES EQUIPPED WITH FOUR OR SIX CYLINDER ENGINES, THE FUEL PUMP TERMINAL ON THE FUEL-SENDING UNIT CAN DEVELOP A CRACK IN THE PLASTIC MOLDING. THIS CAN CAUSE THE TERMINAL STRIP TO CORRODE UNDER SOME ENVIRONMENTAL CONDITIONS.
Consequence & remedy
Consequence: IF CORROSION OCCURS, THE TERMINAL STRIP COULD EVENTUALLY BREAK CAUSING THE FUEL PUMP TO STOP OPERATION. THIS WILL RESULT IN NOT BEING ABLE TO START THE ENGINE OR CAUSE THE ENGINE TO STOP RUNNING WITHOUT WARNING, WHICH CAN RESULT IN A CRASH.
Remedy: IN THE FOLLOWING STATES, DEALERS WILL REPLACE THE FUEL-SENDING UNIT. THESE STATES ARE CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, TENNESSEE, VERMONT, VIRGINIA, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. IN THE OTHER STATES, THE DEALER WILL INSPECT THE FUEL PUMP TERMINAL ON THE SENDING UNIT FOR CORROSION. IF CORROSION IS PRESENT, THE DEALER WILL REPLACE THE UNIT. IF THERE IS NOT CORROSION, THE DEALER WILL APPLY SEALANT TO THE TERMINAL HOUSING TO HELP PREVENT CORROSION IN THE FUTURE. OWNER NOTIFICATION BEGAN ON JUNE 28, 2004. OWNERS SHOULD CONTACT NISSAN AT 1-800-647-7261.
02V299000 · Suspension:rear
Nov 12, 2002
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, WATER MAY ENTER THE REAR AXLE HOUSING DUE TO INADEQUATE SEALING OF THE ANTI-LOCK BRAKING SYSTEM (ABS) SENSOR.
Consequence & remedy
Consequence: THIS CAN RESULT IN CORROSION AND EVENTUAL FAILURE OF THE WHEEL BEARING. IF THIS OCCURS, THE WHEEL ASSEMBLY COULD SEPARATE FROM THE VEHICLE INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE REAR AXLE FOR WATER INTRUSION AND ANY AFFECTED COMPONENTS WILL BE REPLACED. THE ABS SENSOR WILL BE RESEALED TO PREVENT WATER INTRUSION. OWNER NOTIFICATION BEGAN DECEMBER 10, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NISSAN AT 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1DP03005 · Brake Rotor Warpage
Opened Jul 11, 2003 · Closed Jul 29, 2003
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:foundation Components:disc:rotor
MR. KENT JONES OF KERNERSVILLE, NC, SUBMITTED A PETITION TO NHTSA BY E-MAIL DATED JULY 1, 2003, REQUESTING NHTSA TO INVESTIGATE THE BRAKE ROTORS ON MY 2002 NISSAN XTERRA VEHICLES.THE PETITIONER ALLEGED THAT THE BRAKE ROTORS IN THESE VEHICLES WERE DEFECTIVE BECAUSE THE ROTORS OVERHEAT AND WARP FROM NORMAL USAGE.A REVIEW OF ODI'S DATABASE FOR COMPLAINTS REGARDING MY 2001 THROUGH MY 2003 NISSAN XTERRA VEHICLES IDENTIFIED ONLY TWO REPORTS RELATED TO BRAKE ROTOR WARPING; ONE FOR A MY 2001 AND ONE FOR A MY 2002.THE COMPLAINT FOR THE MY 2002 NISSAN XTERRA WAS REPORTED BY THE PETITIONER.BRAKE ROTOR WARPING CAN RESULT IN BRAKE PULSATION AND SHAKING WHEN THE BRAKE IS APPLIED.BRAKE PULSATION, TIRE OR SUSPENSION VIBRATION, AND SIMILAR CONDITIONS ARE AN OBVIOUS ANNOYANCE TO THE DRIVER, BUT GENERALLY DO NOT CAUSE A DRIVER TO LOSE CONTROL OF A VEHICLE.FURTHERMORE, EVEN IF LEFT UNCORRECTED, ANY POTENTIAL INCREASE IN STOPPING DISTANCE WILL BE NEGLIGIBLE. THEREFORE, THIS CONDITION DOES NOT NORMALLY CONSTITUTE A SAFETY DEFECT, EVEN IF IT OCCURS WITH FAR MORE OFTEN FREQUENCY. IN VIEW OF THE FOREGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF AN ALLEGED SAFETY-RELATED DEFECT AS DEFINED BY THE PETITIONER IN THE MY 2002 NISSAN XTERRA VEHICLES AT THE CONCLUSION OF AN INVESTIGATION.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S SAFETY MISSION, THE PETITION IS DENIED.