← New search

2008 Nissan Versa

Owner reports · Recalls · Investigations

More warning signs than most Versa years

Owner complaints for the 2008 Nissan Versa are substantially higher than the model-year median of 95.

About this comparison →

When problems were reported

Mileage at the reported incident

214 reports with mileage · 167 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Air Bags. Review the 171 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Suspension. Review the 70 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 25 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

24 crash reports8 fire reports17 injury reports

Suspension complaints

70 reports
Clear category filter
104,400 miles · Jul 16, 2015
Suspension

COIL SPRING ON DRIVERS SIDE BROKE CAUSING A SHAKE AND ALLOWING THE CAR TO DRAG WHEN IT SHOULD NOT OF BEEN ABLE TO...UPDATED 11/05/15 *BF THE CONSUMER STATED THE VEHICLE DID MOT STEER PROPERLY AFTER COIL SPRING FAILURE. UPDATED 1/8/2015 *JS

NHTSA ODI #10734459

118,000 miles · Jul 8, 2015
Suspension

THE FRONT PASSENGER SIDE COIL SPRING FRACTURED WHILE THE CAR WAS IN MOTION. I HAD BEEN DRIVING ABOUT 0.1 MILES AFTER A LEFT TURN AND WAS TRAVELING AT A LOW RATE OF SPEED WHEN THE COIL FRACTURED AND A SECTION OF THE COIL PUNCTURED AND TORE THE INNER WALL OF THE TIRE CAUSING A SUDDEN TIRE FAILURE. THE SOUND OF THE FRACTURE WAS VER…

Read full complaint

THE FRONT PASSENGER SIDE COIL SPRING FRACTURED WHILE THE CAR WAS IN MOTION. I HAD BEEN DRIVING ABOUT 0.1 MILES AFTER A LEFT TURN AND WAS TRAVELING AT A LOW RATE OF SPEED WHEN THE COIL FRACTURED AND A SECTION OF THE COIL PUNCTURED AND TORE THE INNER WALL OF THE TIRE CAUSING A SUDDEN TIRE FAILURE. THE SOUND OF THE FRACTURE WAS VERY LOUD METAL ON METAL SOUND, DRAWING PEOPLE OUT FROM NEARBY BUILDINGS. THE CAR WAS TOWED TO THE LOCAL DEALERSHIP WHERE NEW FRONT COIL SPRINGS WERE INSTALLED, THE FRONT PASSENGER TIRE REPLACED AND A FRONT END ALIGNMENT WAS PERFORMED.

NHTSA ODI #10733144

96,000 miles · Jul 3, 2015
Suspension

I WAS DRIVING ON A SMALL PAVED TWO LANE HIGHWAY AT APPROXIMATELY 45 MPH.I HEARD A LOUD NOISE AND SHORTLY AFTER THE TIRE BLEW OUT.THIS HAPPENED RIGHT BEFORE A SMALL SIDE ROAD SO I WAS ABLE TO TURN ONTO THAT ROAD SO I WASN'T ON THE HIGHWAY.DUE TO THE FLAT TIRE AND BROKEN SPRING THE CAR SAT TOO LOW FOR THE FACTORY PROVIDED JACK TO …

Read full complaint

I WAS DRIVING ON A SMALL PAVED TWO LANE HIGHWAY AT APPROXIMATELY 45 MPH.I HEARD A LOUD NOISE AND SHORTLY AFTER THE TIRE BLEW OUT.THIS HAPPENED RIGHT BEFORE A SMALL SIDE ROAD SO I WAS ABLE TO TURN ONTO THAT ROAD SO I WASN'T ON THE HIGHWAY.DUE TO THE FLAT TIRE AND BROKEN SPRING THE CAR SAT TOO LOW FOR THE FACTORY PROVIDED JACK TO FIT UNDER THE CAR.I CALLED MY BROTHER FOR ASSISTANCE AND HE SHOWED UP WITH MY NEPHEW.THEY WERE ABLE TO LIFT UP ON THE CAR JUST ENOUGH SO THAT I COULD PLACE THE JACK IN THE CORRECT POSITION.WE PUT THE FACTORY DONUT SPARE TIRE ON AND I DROVE TO WAREHOUSE TIRE...UNFORTUNATELY THEY WERE JUST CLOSING DOWN FOR THE DAY.I HAD FOUR NEW TIRES INSTALLED THE FOLLOWING TUESDAY AND THEN TOOK THE CAR TO MY MECHANIC.I PICKED THE CAR UP ON JULY 3RD.MY MECHANIC INFORMED THAT THE DRIVERS SIDE COIL SPRING WAS BROKEN ALSO.THE DRIVERS SIDE SPRING HAD BROKEN NEAR THE TOP;THE PASSENGER SIDE SPRING BROKE CLOSER TO BOTTOM WHICH ALLOWED IT TO SPIN OUT OF PLACE AND SLICE THE TIRE.

NHTSA ODI #10731901

61,460 miles · Jun 24, 2015
Suspension

FRONT RIGHT SPRING BROKE SHREDDING A RELATIVELY NEW TIRE. WE JUST TURNED ON TO A RESIDENTIAL STREET, SO FORTUNATELY WE WERE GOING SLOW AND NO ONE WAS HURT. CAR WAS TOWED TO A NEARBY SEAR'S AUTO CENTER WHERE BOTH FRONT SPRINGS AND STRUTS WERE REBUILT AND AN ALIGNMENT PERFORMED. PLUS NEW TIRE INSTALLED. INCIDENT ISSUE WAS OPEN…

Read full complaint

FRONT RIGHT SPRING BROKE SHREDDING A RELATIVELY NEW TIRE. WE JUST TURNED ON TO A RESIDENTIAL STREET, SO FORTUNATELY WE WERE GOING SLOW AND NO ONE WAS HURT. CAR WAS TOWED TO A NEARBY SEAR'S AUTO CENTER WHERE BOTH FRONT SPRINGS AND STRUTS WERE REBUILT AND AN ALIGNMENT PERFORMED. PLUS NEW TIRE INSTALLED. INCIDENT ISSUE WAS OPENED WITH NISSAN, BUT THEY REFUSE TO ACCEPT RESPONSIBILITY FOR THIS FREQUENTLY OCCURRING POOR QUALITY ISSUE...UPDATED 08/12/15 *BF UPDATED 11/27/2015*JS

NHTSA ODI #10730138

68,000 miles · Jun 10, 2015
Suspension

TL* THE CONTACT OWNS A 2008 NISSAN VERSA. WHILE PARKING, THE FRONT DRIVER SIDE COIL SPRING FRACTURED. THE VEHICLE WAS REPAIRED SHORTLY AFTER, BUT THE FAILURE RECURRED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 68,000. THE VIN WAS NOT AVAILABLE. UPDATED 8/6/15*CN THE CONSUMER STATED THE VEHICLE WAS PARKED IN THE D…

Read full complaint

TL* THE CONTACT OWNS A 2008 NISSAN VERSA. WHILE PARKING, THE FRONT DRIVER SIDE COIL SPRING FRACTURED. THE VEHICLE WAS REPAIRED SHORTLY AFTER, BUT THE FAILURE RECURRED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 68,000. THE VIN WAS NOT AVAILABLE. UPDATED 8/6/15*CN THE CONSUMER STATED THE VEHICLE WAS PARKED IN THE DRIVEWAY, WHEN THE LEFT FRONT COIL SPRING BROKE. BEFORE SHE WAS ABLE TO HAVE IT REPAIRED, IT BROKE EVEN FURTHER TWO WEEKS LATER. THE CONSUMER PAID FOR THE REPAIRS AT HER EXPENSE. UPDATED 08/11/15*JB

NHTSA ODI #10724514

55,823 miles · Jun 1, 2015
Suspension

TL* THE CONTACT OWNS A 2008 NISSAN VERSA. WHILE DRIVING OUT OF THE GARAGE AT 5 MPH, A POPPING SOUND WAS HEARD. THE CONTACT NOTICED THAT THE FRONT DRIVER SIDE COIL SPRING FRACTURED IN TWO PLACES. THE INCIDENT OCCURRED ON MAY 30, 2015. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED, BUT THE DEALER WAS NOTIFIED. THE VIN WAS UNKNOWN. THE…

Read full complaint

TL* THE CONTACT OWNS A 2008 NISSAN VERSA. WHILE DRIVING OUT OF THE GARAGE AT 5 MPH, A POPPING SOUND WAS HEARD. THE CONTACT NOTICED THAT THE FRONT DRIVER SIDE COIL SPRING FRACTURED IN TWO PLACES. THE INCIDENT OCCURRED ON MAY 30, 2015. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED, BUT THE DEALER WAS NOTIFIED. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 55,823.

NHTSA ODI #10722592

62,400 miles · May 30, 2015
Suspension

I FOUND A PIECE FRONT THE FRONT OF EACH COLI SPRING LAYING IN MY DRIVEWAY. I LOOKED UP THE NHTSA WEBSITE & FOUND THERE IS AN INVESTIGATION INTO THIS SPECIFIC PROBLEM. INVESTIGATION NO PE 15-019. I HAVE THE PIECES & CAN SEND A PICTURE OF THE FRACTURE IF YOU WOULD LIKE.

NHTSA ODI #10722459

65,000 miles · May 29, 2015
Suspension

TL* THE CONTACT OWNS A 2008 NISSAN VERSA. WHILE DRIVING APPROXIMATELY 25 MPH, A CLUNKING NOISE EMITTED FROM THE FRONT END OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DISCOVERED THAT THE FRONT DRIVER SIDE COIL SPRING DETACHED FROM THE HOUSING ONTO THE BRAKE ROTOR AND RACK AND PINION. THE MECHANIC REPLACE…

Read full complaint

TL* THE CONTACT OWNS A 2008 NISSAN VERSA. WHILE DRIVING APPROXIMATELY 25 MPH, A CLUNKING NOISE EMITTED FROM THE FRONT END OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DISCOVERED THAT THE FRONT DRIVER SIDE COIL SPRING DETACHED FROM THE HOUSING ONTO THE BRAKE ROTOR AND RACK AND PINION. THE MECHANIC REPLACED BOTH FRONT COIL SPRINGS. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 65,000. UPDATED 8/10/15*CN

NHTSA ODI #10722201

60,000 miles · May 28, 2015
Suspension

TL* THE CONTACT OWNS A 2008 NISSAN VERSA. WHILE THE VEHICLE WAS BACKING OUT OF A DRIVEWAY, THE FRONT COIL SPRINGS FRACTURED WITHOUT WARNING. THE VEHICLE HAD TO BE TOWED TO A DEALER; HOWEVER, IT HAS NOT YET BEEN DIAGNOSED. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VIN WAS UNKNOWN. THE …

Read full complaint

TL* THE CONTACT OWNS A 2008 NISSAN VERSA. WHILE THE VEHICLE WAS BACKING OUT OF A DRIVEWAY, THE FRONT COIL SPRINGS FRACTURED WITHOUT WARNING. THE VEHICLE HAD TO BE TOWED TO A DEALER; HOWEVER, IT HAS NOT YET BEEN DIAGNOSED. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 60,000. UPDATED 09/10/15*LJ UPDATED 10/17/2017*CN

NHTSA ODI #10721852

65,000 miles · May 22, 2015
Suspension

I WAS CONCERNED THAT SOMETHING WAS WRONG WITH THE CAR. I WAS TAKING IT TO THE GARAGE WHEN THE COIL SPRING BROKE. THE JAGGED END RUBBED AGAINST THE TIRE CAUSING IT TO BLOW OUT.

NHTSA ODI #10720958

Official recalls

7

20V008000 · Air Bags:frontal:passenger Side:inflator Module

Jan 9, 2020

Nissan North America, Inc. (Nissan) is recalling certain 2001-2003 Maxima, 2002-2006 Sentra, 2002-2004 Pathfinder, 2007-2011 Versa Sedan and Versa Hatchback, 2001-2004 Infiniti I30 and I35, 2002-2003 Inifiniti QX4, 2003-2008 Infiniti FX35 and FX45 and 2006-2010 M35 and M45 vehicles. The vehicles are equipped with non-desiccated, frontal passenger air bag inflators containing phase stabilized ammonium nitrate (PSAN) propellant that were used as interim remedy parts for previous Takata recalls. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

Consequence & remedy

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy: Nissan will notify owners, and dealers will replace the front passenger air bag inflators with alternate desiccated inflators, free of charge. The recall began February 12, 2020. Owners may contact Nissan customer service at 888-737-9511 or Infiniti customer service at 888-810-3715.

18V452000 · Air Bags:frontal:passenger Side:inflator Module

Jul 6, 2018

Nissan North America, Inc. (Nissan) is recalling certain 2007-2008 Nissan Versa sedan and Versa hatchback vehicles originally sold, or ever registered, in Alabama, Arizona, Arkansas, California, Delaware, District of Columbia, Florida, Georgia, Hawaii, Illinois, Indiana, Kansas, Kentucky, Louisiana, Maryland, Mississippi, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, South Carolina, Tennessee, Texas, Virginia, West Virginia, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands. The passenger air bag inflators may explode due to propellant degradation due to exposure to humidity and temperature cycling.

Consequence & remedy

Consequence: If an inflator were to explode it may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

Remedy: Nissan will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. The recall began July 25, 2018. Owners may contact Nissan customer service at 1-800-867-7669. Note: The vehicles covered by this recall are in addition to those covered by recall 16V-349.

17V449000 · Air Bags:frontal:driver Side:inflator Module

Jul 17, 2017

Nissan North America, Inc. (Nissan) is recalling certain 2007-2011 Versa Sedan and 2007-2012 Versa Hatchback vehicles. The affected vehicles have a driver frontal air bag inflator that may rupture due to propellant degradation occurring after long-term exposure to moderate absolute humidity, temperatures, and temperature cycling.

Consequence & remedy

Consequence: An inflator rupture may result in metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy: Nissan will notify owners, and dealers will replace the subject inflator with a new one manufactured by a different supplier, free of charge. The recall began on March 9, 2018. Owners may contact Nissan customer service at 1-800-647-7261.

17V028000 · Air Bags:frontal:passenger Side:inflator Module

Jan 10, 2017

Nissan North America, Inc. (Nissan) is recalling certain 2012 Nissan Versa hatchbacks originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan) and the U.S. Virgin Islands, or "Zone A". Additionally, if not included in "Zone A" above, Nissan is recalling certain 2009-2010 Infiniti M35 and M45 and 2009 Nissan Versa sedans and hatchbacks originally sold, or ever registered, in Arizona, Arkansas, Delaware, the District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B". Additionally, if not included in "Zone A" or "Zone B" above, Nissan is recalling certain 2005-2008 Infiniti FX35 and FX45, 2006-2010 Infiniti M35 and M45, and 2007-2008 Nissan Versa vehicles originally sold, or ever registered, in Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Consequence & remedy

Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

Remedy: Nissan will notify owners, and dealers will replace the front passenger air bag inflators, free of charge. The recall began on June 8, 2017. Owners will receive a second notice when remedy parts become available. Owners may contact Nissan customer service at 1-800-647-7261.

16V349000 · Air Bags:frontal:passenger Side:inflator Module

May 24, 2016

Nissan North America, Inc. (Nissan) is recalling certain model year 2003-2008 Infiniti FX35 and FX45, 2003-2004 Infiniti I35, 2006-2010 Infiniti M35 and M45, and 2007-2011 Nissan Versa vehicles, originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Nissan is recalling certain model year 2005-2008 Infiniti FX35 and FX45, 2003-2004 Infiniti I35, 2006-2008 Infiniti M35 and M45, and 2007-2008 Nissan Versa vehicles, originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Lastly, unless included in "Zone A" or "Zone B" above, Nissan is recalling certain model year 2003-2004 Infiniti I35 vehicles originally sold, or registered, in Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. These inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Consequence & remedy

Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

Remedy: Nissan will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. The recall began December 21, 2017. All owners should receive a second notice by May 15, 2017. Owners may contact Nissan customer service at 1-800-647-7261.

15V573000 · Suspension:front:springs:coil Springs

Sep 14, 2015

Nissan (Nissan North America, Inc.) is recalling certain model year 2007-2012 Nissan Versa vehicles manufactured May 8, 2006, to November 12, 2012, that were sold or ever registered in the District of Columbia, Connecticut, Delaware, Iowa, Illinois, Indiana, Kentucky, Massachusetts, Maine, Maryland, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia and Wisconsin. Road salt may corrode the front coil springs, possibly resulting in the coil springs fracturing.

Consequence & remedy

Consequence: If a front coil spring fractures, it may contact the tire, possibly puncturing it, increasing the risk of a crash.

Remedy: Nissan will notify owners, and dealers will replace both front coil springs, free of charge. The recall began on February 2, 2016. Owners may contact Nissan customer service at 1-800-647-7261.

10V401000 · Equipment:electrical:navigational System(global Positioning System)

Sep 10, 2010

NISSAN IS RECALLING CERTAIN VEHICLES THAT WERE EQUIPPED WITH A GARMIN NUVI MODEL 750 NAVIGATION SYSTEM. THE BATTERIES CONTAINED IN THE AFFECTED GPS UNITS CAN OVERHEAT.

Consequence & remedy

Consequence: OVERHEATED BATTERIES COULD RESULT IN A FIRE.

Remedy: NISSAN WILL NOTIFY OWNERS AND THE REPAIRS WILL BE PERFORMED BY GARMIN TECHNICIANS BY REPLACING THE BATTERY AND INSERTING A SPACER ON TOP OF THE BATTERY FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2010. OWNERS MAY CONTACT GARMIN DIRECTLY AT 1-866-957-1981 OR NISSAN AT 1-800-647-7261.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

2

EA21002 · Desiccated Air Bag Inflator Rupture

Opened Sep 17, 2021 · No close date supplied

Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

Additional source detail variants (2)

Air Bags:frontal:driver Side:inflator Module

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

Air Bags:frontal:passenger Side:inflator Module

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

PE15019 · Front Coil Spring Fracture

Opened May 13, 2015 · Closed Oct 2, 2015

Status: closed (inferred from source dates) · Suspension:front:springs:coil Springs

In a letter dated September 10,2015, Nissan North America,Inc. (Nissan) notified the National Highway Traffic Safety Administration (NHTSA) of a safety defect that may result in coil spring fracture in approximately 218,019 model year (MY) 2007 through 2012 Nissan Versa vehiclesproduced from May 8, 2006 through November12, 2012 and originally sold or ever registered in the following 22 states and the District of Columbia: Connecticut, Delaware, Iowa, Illinois, Indiana, Kentucky Massachusetts, Maine, Maryland, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, Washington D.C., West Virginia and Wisconsin (NHTSA Recall 15V-573).Nissan indicated that the recalled vehicles may contain front coil springs that received inadequate phosphorous coating, have low residual stress, or a combination of both.Surface imperfections resulting from coil-to-coil contact when the spring is compressed may lead to crack initiation.Exposure of the surface imperfections to road salts, in regions with heavy use of road salts for snow and ice control, may promote crack propagation in the spring that could result in spring fracture.If the coil spring fractures it may puncture the front tire and possibly the brake line while driving, which may increase the risk of a vehicle crash.ODI's analysis of complaints it has received from the public (VOQ's) and Nissan complaint data submitted in response to the information request letter for PE15-019 identified a total of 468 non-duplicative reports alleging coil spring fractures in the subject vehicles, including 142 VOQ's and 367 Nissan complaints (41 of the incidents reported to ODI were also reported to Nissan).While the recall region accounts for approximately 43 percent of vehicle sales, the analysis found that 94 percent of the complaints involved vehicles sold or operated in those states.Approximately 27 percent of the VOQ's reporting coil spring failures in the recalled states indicated that the failure resulted in a punctured tire.ODI also identified one complaint that alleged brake line damage from a failed spring.Nissan's recall will replace both coil springs free of charge.Based on Nissan's safety recall, this investigation is closed.The 142 VOQ's referenced in this resume are: 10236143, 10405369, 10443746, 10452956, 10491553, 10497737, 10503060, 10504557, 10512390, 10512975, 10514582, 10516024, 10516085, 10521216, 10522261, 10526334, 10533856, 10537404, 10537407, 10548678, 10552124, 10559853, 10562485, 10565283, 10572591, 10578519, 10583059, 10583154, 10583496, 10583673, 10584979, 10585327, 10585377, 10585751, 10586397, 10586444, 10587798, 10588347, 10588427, 10592366, 10592498, 10592780, 10593373, 10593621, 10595215, 10596802, 10598404, 10598877, 10606859, 10606998, 10610082, 10618059, 10640845, 10644269, 10645075, 10649515, 10653189, 10659632, 10662158, 10663102, 10667071, 10667845, 10669949, 10670829, 10671894, 10676522, 10680544, 10680740, 10682397, 10691419, 10692629, 10693347, 10694156, 10694420, 10701250, 10702765, 10703126, 10704658, 10705882, 10706351, 10711805, 10712045, 10712922, 10714243, 10715041, 10715175, 10716106, 10717254, 10717320, 10717403, 10717412, 10717489, 10717563, 10720958, 10721782, 10721824, 10722113, 10722459, 10722915, 10723873, 10723972, 10723973, 10724158, 10724899, 10725002, 10725328, 10725377, 10725542, 10726251, 10726736, 10726741, 10730138, 10730154, 10730342, 10731050, 10731692, 10731799, 10731901, 10732054, 10732062, 10733059, 10733144, 10733309, 10733349, 10733607, 10733781, 10733854, 10735347, 10735353, 10735606, 10736199, 10736227, 10743474, 10743634, 10743790, 10744