AXLE SEAL LEAK. RIGHT REAR SEAL. FLUID CAUSED PARKING BRAKE TO SLIP SLIGHTLY. OCCURRED AT 37,000 MILES ON 2004 NISSAN TITAN 4X4. DEALER REPAIRED AND REPLACED UNDER NISSAN 60,000 MILE POWER-TRAIN WARRANTY. [FORUM MEMBERS GENERALLY BELIEVE THE REAR AXLE BREATHER ELEMENT, (A ONE WAY CHECK VALVE), CREATES A VACUUM THAT SUCKS THE SE…
Read full complaint
AXLE SEAL LEAK. RIGHT REAR SEAL. FLUID CAUSED PARKING BRAKE TO SLIP SLIGHTLY. OCCURRED AT 37,000 MILES ON 2004 NISSAN TITAN 4X4. DEALER REPAIRED AND REPLACED UNDER NISSAN 60,000 MILE POWER-TRAIN WARRANTY. [FORUM MEMBERS GENERALLY BELIEVE THE REAR AXLE BREATHER ELEMENT, (A ONE WAY CHECK VALVE), CREATES A VACUUM THAT SUCKS THE SEALS, THEREBY CREATING THE LEAK. SOME EVEN REMOVE THE ELEMENT AND INSTALL TUBING INTO THEIR TAIL LIGHT TO ALLEVIATE THE CHECK VALVE AND STILL PREVENT WATER INTRUSION INTO THE DIFFERENTIAL/AXLE]. *JB
NHTSA ODI #10166059
21,000 miles · Aug 17, 2006
Power Train
REAR SEALS LEAKING ON NISSAN TITAN, FLUID GETTING ON BRAKES. *NM
NHTSA ODI #10165891
3,200 miles · Aug 16, 2006
Power Train
MULTIPLE LEAKS WITH REAR AXLE SEALS PUTTING DIFFERENT FLUID ON REAR BRAKES. *NM
NHTSA ODI #10165690
Mileage unknown · Aug 16, 2006
Power Train
REAR AXLE SEAL LEAKING. DEALER REPLACED UNDER "GOOD WILL". *NM
NHTSA ODI #10165663
19,000 miles · Aug 11, 2006
Power Train
REAR AXLE SEALS LEAKING, WITH THE POSSIBILITY OF THE DIFFERENTIAL OIL GETTING ONTO THE REAR BRAKES CAUSING BRAKE FAILURE. *NM
NHTSA ODI #10165216
65,000 miles · Aug 3, 2006
Power TrainCrashInjury
DT*: THE CONTACT STATED THE VEHICLE'S TRANSMISSION CAME OUT OF THE PARK POSITION AND BEGAN ROLLING WHILE AT THE TOP OF A DRIVEWAY. A CHILD IN THE FRONT PASSENGER SEAT ATTEMPTED TO EXIT THE VEHICLE DURING THE INCIDENT WHICH RESULTED IN THE VEHICLE RUNNING OVER THE CHILD. THE CHILD WAS TAKEN TO THE HOSPITAL AND SUFFERED CONTUSIO…
Read full complaint
DT*: THE CONTACT STATED THE VEHICLE'S TRANSMISSION CAME OUT OF THE PARK POSITION AND BEGAN ROLLING WHILE AT THE TOP OF A DRIVEWAY. A CHILD IN THE FRONT PASSENGER SEAT ATTEMPTED TO EXIT THE VEHICLE DURING THE INCIDENT WHICH RESULTED IN THE VEHICLE RUNNING OVER THE CHILD. THE CHILD WAS TAKEN TO THE HOSPITAL AND SUFFERED CONTUSIONS. THE VEHICLE HIT A TREE AND THE INCIDENT WAS REPORTED TO THE CONTACT'S INSURANCE COMPANY WHO ADVISED THE CONTACT THERE WAS A RECALL, NHTSA CAMPAIGN ID # 04V408000 REGARDING THE POWER TRAIN:MANUAL TRANSMISSION:COLUMN SHIFT ASSEMBLY. THE VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO THE VIN.
NHTSA ODI #10164380
20,141 miles · Jul 28, 2006
Power Train
REAR AXLE REPLACED DUE TO FAILED REAR DIFFERENTIAL. JUST OVER 20K MILES. *JB
NHTSA ODI #10163852
20,100 miles · Jul 8, 2006
Power Train
DIFFERENTIAL WENT OUT ON MY 2004 NISSAN TITAN. THE DEALERSHIP REPLACED THE ENTIRE AXLE. *NM
NHTSA ODI #10161891
33,000 miles · Jul 8, 2006
Power Train
REAR AXLE LEAKS AND DIFFERENTIAL PINION SEAL LEAKING. TOOK TO DEALER AND THEY SAID I NEEDED A COMPLETELY NEW REAR AXLE ASSEMBLY INCLUDING DIFFERENTIAL. *JB
NHTSA ODI #10161866
41,100 miles · Jun 27, 2006
Power Train
REAR END FAILURE ON A 2004 NISSAN TITAN. TURNING A CORNER WHILE UNDER POWER. DEALER STATED THEY ORDERED A NEW REAR END AND IT IS ON ITS WAY TO THEM, DO NOT KNOW IF IT COVERED UNDER WARRANTY YET. *JB
NISSAN IS RECALLING CERTAIN MODEL YEAR 2004-2006 ARMADA, TITAN, INFINITI QX56 AND MODEL YEAR 2005-2006 FRONTIER, PATHFINDER AND XTERRA VEHICLES. THE INTELLIGENT POWER DISTRIBUTION MODULE (IPDM) ASSEMBLY CONTAINS AN ENGINE CONTROL MODULE (ECM) RELAY THAT HAS A DIODE FOR ELECTRICAL CURRENT NOISE REDUCTION. THE ECM RELAY MAY ALLOW SILICON VAPOR TO FORM AND, OVER TIME, THE SILICON EVAPORATES FROM THE DIODE MOLDING WHICH CAUSES SILICON OXIDE TO DEVELOP ON THE ECM RELAY CONTACT DUE TO ARCING.
Consequence & remedy
Consequence: THIS COULD CAUSE ENGINE STALLING INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ECM RELAY INSIDE THE IPDM ASSEMBLY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 6, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
ON CERTAIN CREW CAB MODEL TRUCKS, THE SEAT BACK SHAPE MAY BE SUCH THAT THERE MAY NOT BE SUFFICIENT WEBBING ON THE RETRACTOR SPOOL FOR THE REAR CENTER SEAT BELT TO RELEASE FROM THE AUTOMATIC LOCKING MODE (ALR) AFTER IT IS ENGAGED AND THE SEAT BELT IS RETRACTED. IF THIS OCCURS, THERE MAY BE DIFFICULTY IN PULLING THE SEAT BELT OUT OF THE RETRACTOR THUS PREVENTING ITS USAGE.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, A SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE REAR CENTER SEAT BELT WITH A NEW ONE FREE OF CHARGE. THE RECALL BEGAN ON JUNE 11, 2007. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
ON CERTAIN KING CAB TRUCKS, THE WIRES IN THE HARNESS WERE ROUTED THROUGH THE REAR DOORS AND INTO THE BODY. THESE WIRES MAY BREAK DUE TO OVER BENDING OF THE HARNESS AS THE DOOR IS OPENED AND CLOSED. THE HARNESS CONTAINS WIRES FOR THE DRIVER SEAT BELT PRETENSIONER AND FOR THE FRONT PASSENGER SEAT BELT WHICH IS PART OF THE OCCUPANT CLASSIFICATION SYSTEM. WIRES FOR THE REAR AUDIO SPEAKERS ARE ALSO CONTAINED N THE HARNESS.
Consequence & remedy
Consequence: IF THE WIRES FOR THE SEAT BELTS AND SPEAKER WIRES BREAK AND MAKE CONTACT, THERE IS A POSSIBILITY THAT THE PRETENSIONER MAY DEPLOY. IF THIS HAPPENS WHEN THE SEAT BELT IS RETRACTED, IT WILL NOT BE POSSIBLE TO USE THE SEAT BELT. IF ONE OF THE WIRES ON THE RIGHT SIDE HARNESS FOR THE SEAT BELT TENSION SENSOR BREAKS, THE PASSENGER SIDE FRONT AIR BAG WILL NOT DEPLOY AS DESIGNED IN A FRONTAL COLLISION INCREASING THE RISK OF A CRASH AND PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE WIRE HARNESS COVER WITH A DIFFERENT TYPE THAT PREVENTS OVER BENDING OF THE HARNESS AND THE HARNESS WILL BE REROUTED FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 19, 2007. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
ON CERTAIN PICKUP TRUCKS EQUIPPED WITH A COLUMN SHIFTER, THE SHIFT LEVER ASSEMBLY FOR THE COLUMN SHIFTER MAY HAVE BEEN DAMAGED DURING ASSEMBLY.
Consequence & remedy
Consequence: DURING ITS USE THIS COULD EVENTUALLY RESULT IN FAILURE OF THE PORTION OF THE ASSEMBLY THAT HOLDS THE LEVER IN THE PARK POSITION. THIS COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSPECT AND REPLACE THE SHIFTER. THE RECALL BEGAN ON SEPTEMBER 27, 2004. OWNERS SHOULD CONTACT NISSAN AT 1-800-647-7261.
CERTAIN PICKUP TRUCKS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." AN AREA ON THE REAR PILLAR WHERE THE REAR SEAT BELT UPPER ANCHOR IS ATTACHED MAY NOT BE SUFFICIENTLY ENERGY ABSORBENT.
Consequence & remedy
Consequence: THIS COULD RESULT IN AN INCREASED RISK OF INJURY IF THE AREA IS STRUCK IN A CRASH.
Remedy: DEALERS WILL REPLACE THE OUTBOARD REAR SEAT BELT ASSEMBLIES WITH NEW ONES. THE RECALL BEGAN ON SEPTEMBER 27, 2004. OWNERS SHOULD CONTACT NISSAN AT 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2004 Nissan Titan Problems, Complaints & Recalls | Skip That Year
Illustration