2004 Nissan Titan

TL* THE CONTACT OWNS A 2004 NISSAN TITAN. WHILE DRIVING APPROXIMATELY 30 MPH, THE CONTACT HEARD A CLICKING NOISE AND SMELLED EXHAUST FUMES INSIDE OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THEY INFORMED THE CONTACT THAT THE EXHAUST MANIFOLD WAS CRACKED. THE VEHICLE WAS NOT REPAIRED. THE EXHAUST FUMES PROGRESSIVELY BECAME WORSE OVER A PERIOD OF TIME. THE MANUFACTURER WAS NOT MADE AWARE OF THE PROBLEM. THE FAILURE MILEAGE WAS APPROXIMATELY 50,000. THE VIN WAS UNAVAILABLE.

2004 TITAN. CONNECTION FAILED AT THE FLANGES WELDED TO THE EXHAUST PIPE AND THE MUFFLER EXTENSION AT THE RIGHT REAR WHEEL AREA. THE EXHAUST PIPE AND THE MUFFLER EXTENSION ARE IN GOOD CONDITION. THE FAILURE WAS CONFINED TO THE FLANGE ATTACHMENTS. FAILURE RESULTED IN HOT AIR/GASES MELTING A CRITICAL WIRE HARNESS THAT IS ATTACHED ALONG THE FRAME BEAM TO CARRY ELECTRICS TO THE REAR OF VEHICLE. THE RIGHT REAR WHEEL SPEED SENSOR WAS DAMAGED. THE WIRES SHORTED, CAUSING THE FAILURE OF UNDERHOOD ELECTRICAL COMPONENTS. IMMEDIATE CONSEQUENCE WAS THE ENGINE SHUT DOWN WITH LOSS OF POWER STEERING AND POWER BRAKES AND ALL OTHER COMPONENTS RELYING ON POWER FROM THE ALTERNATOR. THE EXPERIENCED DRIVER WAS ABLE TO COAST THE VEHICLE TO A STOP ALONG A BUSY INTERSTATE HIGHWAY. LONG RANGE CONSEQUENCES WERE THE REPLACEMENT OF THE TITAN'S WIRE BUNDLES AND ELECTRONIC COMPONENTS AT CONSIDERABLE COST. NISSAN HAS NOT, TO DATE, EXPLAINED WHY THIS SIMPLE CONNECTION FAILED, WHY A WIRE HARNESS WAS LOCATED CLOSE TO THIS HEAT SOURCE, WHY THE WIRE HARNESS WAS NOT PROTECTED AGAINST HEAT DAMAGE, WHY THE ELECTRICAL DAMAGE WAS NOT LIMITED BY A FUSE, WHY TITAN OWNERS WERE NOT NOTIFIED OF THIS POTENTIAL CATASTROPHIC PROBLEM AND WHY NISSAN DEALERS DID NOT INSPECT AND NOTIFY TITAN OWNERS OF THIS ISSUE DURING OTHER ROUTINE MAINTENANCE AT THEIR FACILITIES. *TR

TL*THE CONTACT OWNS A 2004 NISSAN TITAN. THE CONTACT STATED THAT THERE WAS A TICKING NOISE FROM THE HEADER AND ENGINE AREA. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER SEVERAL TIMES WHILE UNDER WARRANTY AND THE CONTACT WAS TOLD THAT THERE WAS NOTHING WRONG. THE CONTACT STATED THAT NOW THE DEALER WAS STATING THAT THE HEADERS AND MANIFOLD WERE DEFECTIVE. THE FAILURE CAUSED THE VEHICLE TO LOSE OIL PRESSURE AND THE HEADERS ON BOTH SIDES NEEDED TO BE REPLACED. THE FAILURE MILEAGE WAS 30,000 AND THE CURRENT MILEAGE WAS 100,000.

2004 NISSAN TITAN CREW CAB XE 4X4. RADIATOR HAS FAILED, REAR DIFFERENTIAL LEAKED, REAR DIFFERENTIAL AXLE SEALS FAILED, FRONT DIFFERENTIAL FAILED TWICE"C-CLIP", TRANSMISSION LEAKED THREE TIMES, FRONT BRAKE ROTORS REPLACED, DRIVER SIDE POWER WINDOW FAILED, SOMETHING TO DO WITH THE SHIFTER FELL OUT FROM UNDERNEATH THE DASH, REAR SHACKLES FOR LEAF SPRINGS ARE FAILING, NUMEROUS SAFETY RECALLS AND EVEN MORE INFORMATION BULLETINS THAT NISSAN WILL NOT REPAIR. *TR

TL* THE CONTACT OWNS A 2004 NISSAN TITAN. THE CONTACT STATED THAT THE CATALYTIC CONVERTER CAME APART AND WAS SUCKED UP IN THE INTAKE OF THE ENGINE WHILE DRIVING 5 MPH. THE VEHICLE WAS TAKEN TO THE DEALER WHO INFORMED HIM THAT THE ENGINE WOULD NEED REPLACING. THE VEHICLE WAS REPAIRED BY AN INDEPENDENT MECHANIC. THE MANUFACTURER WAS CONTACTED WHO OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 175,000.

2004 NISSAN TITAN - KNOW ISSUE WITH EXHAUST MANIFOLDS THAT LEAK. THIS LEAK OR CRACK IN THE EXHAUST MANIFOLD CAUSES THE ENGINE COMPUTER TO RUN FULL RICH ALL THE TIME. THIS CREATES AN UNSAFE CONDITION INSIDE THE CAB OF THE VEHICLE WITH NOXIOUS EXHAUST FUMES AND HEALTH CONCERNS. NOT TO MENTION THE FUEL MILEAGE IS ALMOST CUT IN HALF AS I HAVE CALCULATED. MY TRUCK WILL BE ON IT'S THIRD SET OF MANIFOLDS. THE FIRST TWO SETS OF REPLACEMENTS WERE COVERED UNDER THE FEDERAL EMISSIONS WARRANT UP TO 80K MILES BUT THAT HAS EXPIRED AT THIS POINT. NISSAN IS AWARE OF THIS ISSUE AND FROM INFORMATION I HAVE GATHERED THE HAVE UPDATED THE DESIGN OF THE MANIFOLDS. I MIGHT ADD THAT THE CATALYTIC CONVERTERS ARE DIRECTLY CONNECTED TO THESE MANIFOLDS. I CANNOT STRESS ENOUGH THE SAFETY CONCERNS WITH EXHAUST FUMES CONSTANTLY ENTERING INSIDE THIS CAB - I DRIVE TO WORK WITH HEADACHES AND NAUSEA AND BURNING EYES EVERY DAY! *TR

TL*THE CONTACT OWNS A 2004 NISSAN TITAN. WHILE TEST DRIVING THE VEHICLE, DRIVING APPROXIMATELY 25 MPH HE HEARD A TICKING SOUND IN THE ENGINE COMPARTMENT. THE DEALER ADVISED HIM THAT THE FAILURE WAS NORMAL. THE CONTACT STATED THAT HE PURCHASED THE VEHICLE USED IN AUGUST OF 2010 AND THAT THE FAILURE HAD OCCURRED SINCE THE PURCHASE DATE. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 87,000 AND THE CURRENT MILEAGE WAS 94,888.

TL*THE CONTACT OWNS A 2004 NISSAN TITAN. WHILE THE VEHICLE WAS BEING INSPECTED BY THE DEALER HE WAS INFORMED THAT THE VEHICLE HAD A CRACKED EXHAUST MANIFOLD. THE CONTACT CALLED THE MANUFACTURER AND WAS ADVISED THAT THE REPAIR WAS NOT UNDER WARRANTY AND THERE WERE NO RECALLS. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 69,000 AND THE CURRENT MILEAGE WAS 69,323.

TL*THE CONTACT OWNS A 2004 NISSAN TITAN. THE CONTACT STARTED THE IGNITION AND HEARD A LOUD TICKING NOISE ON THE OUTSIDE OF THE VEHICLE. THE FAILURE WOULD OCCUR WHEN THE VEHICLE WAS IN MOTION AND DURING THE ENGINE INITIAL START-UP. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSIS AND THEY INFORMED THAT THE EXHAUST MANIFOLD EXHIBITED A SEVERE CRACK. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 66,000. THE VIN WAS UNAVAILABLE.