NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
60 reportsClear category filterMileage unknown · Jan 28, 2026
Electrical SystemForward Collision Avoidance
Vehicle Safety Defect Report I am submitting this vehicle safety defect report regarding a serious and dangerous failure in a 2021 Nissan Rogue. The vehicle experienced complete electronic shutdowns while driving on the highway. During the most severe incidents, on December 19, 2025 and again on January 14, 2026, the vehicle act…
Read full complaint
Vehicle Safety Defect Report I am submitting this vehicle safety defect report regarding a serious and dangerous failure in a 2021 Nissan Rogue. The vehicle experienced complete electronic shutdowns while driving on the highway. During the most severe incidents, on December 19, 2025 and again on January 14, 2026, the vehicle activated the automatic emergency braking system without external cause, shifted into PARK, and shut down completely, leaving the vehicle immobilized in live interstate traffic during heavy rain. The dashboard displayed multiple simultaneous warnings (engine, battery, collision sensors). A repair facility later diagnosed corrosion in the Transmission Control Module (TCM). The module was not replaced, only cleaned, and the failure recurred. This defect presents an extreme risk of collision, serious injury, or death. A vehicle that shuts down and electronically locks while in motion is unsafe to operate. I respectfully request that NHTSA investigate this electronic defect affecting critical safety and control systems. Videos, dashboard images, repair records, and documented evidence are attached. While driving on an interstate highway during heavy rain, my 2021 Nissan Rogue experienced a complete electronic shutdown. Multiple warning lights appeared simultaneously, the automatic emergency braking system activated without cause, and the vehicle suddenly shifted into PARK and shut off, leaving me immobilized in live traffic. This occurred on December 19, 2025, and the same failure happened again on January 14, 2026. The vehicle could not be moved and required towing. A repair facility diagnosed corrosion in the Transmission Control Module (TCM). The module was only cleaned, not replaced, and the failure recurred. This defect creates a severe risk of collision, serious injury, or death. I narrowly avoided being struck by a truck. I am no longer able to safely operate this vehicle.
NHTSA ODI #11714061
41,000 miles · Dec 9, 2025
Back Over PreventionElectrical SystemLatches/locks/linkages
The contact owns a 2021 Nissan Rogue. The contact stated that after starting the vehicle and then turning off the vehicle and entering the residence, the contact then attempted to restart the vehicle, and the vehicle failed to restart. Several unknown warning lights were illuminated. The contact was unable to roll down the windo…
Read full complaint
The contact owns a 2021 Nissan Rogue. The contact stated that after starting the vehicle and then turning off the vehicle and entering the residence, the contact then attempted to restart the vehicle, and the vehicle failed to restart. Several unknown warning lights were illuminated. The contact was unable to roll down the windows. The contact was assisted with jumpstarting the vehicle. The vehicle was taken to the dealer, and the contact was informed that the battery needed to be replaced. The battery was replaced. The contact stated that on a separate occasion, while the vehicle was stopped at a stop sign, the vehicle made an abnormal sound and then stalled. The vehicle failed to restart, with several unknown warning lights illuminated. The contact was unable to move over to the side of the road. The contact called a family member for a jumpstart. The vehicle was then taken to the dealer; however, the vehicle was not inspected or diagnosed. The contact stated that the failure persisted. Upon further investigation, the contact related the failure to a manufacturer’s campaign related to the Body Control Module (BCM). Most recently, the contact stated that the rearview camera displayed a distorted image or a black screen while the vehicle was in reverse(R). The contact stated that the failure obstructed the driver's visibility, which prevented the driver from safely operating the vehicle. The contact turned off the vehicle and waited for several minutes before restarting the vehicle. The contact stated that the rear camera would then reboot. The contact stated that while using the key fob, the doors or liftgate failed to lock securely. The manufacturer was not notified of the failure. The failure mileage was approximately 41,000.
NHTSA ODI #11704093
Mileage unknown · Nov 23, 2025
Electrical SystemUnknown Or Other
Nissan chime speaker unbelievably loud at car start up. The seat belt chimes and any chime that comes from the dash speaker is louder than normal. The speaker is “ inst panel speaker 24832-6ra0a. “ I have only had this car for one year this November. It happened for a few days during the first month or two having the car then it…
Read full complaint
Nissan chime speaker unbelievably loud at car start up. The seat belt chimes and any chime that comes from the dash speaker is louder than normal. The speaker is “ inst panel speaker 24832-6ra0a. “ I have only had this car for one year this November. It happened for a few days during the first month or two having the car then it went back to normal, now it is doing it again and has lasted a month. Seems to happen only when it’s cold outside. Sometimes chime will start normal then grow increasingly loud.
NHTSA ODI #11701123
Mileage unknown · Aug 26, 2025
Electrical SystemForward Collision AvoidanceStructure
2021 NISSAN ROGUE SV FWD 5N1AT3BAXMC6*****. Water leaking inside interior During rain storm in upper left drivers side corner of vehicle. Shifter delayed when shifting into PARK, NEUTRAL, REVERSE, or DRIVE and shifter assembly indicator lights are out. Reference NTB21-069A. This is a known issue. A corrupted Shifter Assembly …
Read full complaint
2021 NISSAN ROGUE SV FWD 5N1AT3BAXMC6*****. Water leaking inside interior During rain storm in upper left drivers side corner of vehicle. Shifter delayed when shifting into PARK, NEUTRAL, REVERSE, or DRIVE and shifter assembly indicator lights are out. Reference NTB21-069A. This is a known issue. A corrupted Shifter Assembly has caused this vehicle to display multiple warnings such as CVT warnings , shifter position warnings, front and rear crash sensors unavailable, and a multitude of other electrical system warnings. Communications with Nissan consumer affairs and Nissan service departments both of which state the vehicle is out of warranty and repairs for this known issue will be charged to customer despite evidence this is a manufacturing defect known to exist within this year make and model.
NHTSA ODI #11683144
69,000 miles · Aug 5, 2025
Electrical SystemEquipmentForward Collision Avoidance
The contact owns a 2021 Nissan Rogue. The contact stated that while driving at various speeds, the infotainment system would turn off or reboot independently. Additionally, the contact stated that while driving at various speeds under rainy weather conditions, the forward collision avoidance system would independently disengage.…
Read full complaint
The contact owns a 2021 Nissan Rogue. The contact stated that while driving at various speeds, the infotainment system would turn off or reboot independently. Additionally, the contact stated that while driving at various speeds under rainy weather conditions, the forward collision avoidance system would independently disengage. There was no warning light illuminated. The vehicle was taken to the local dealer, where it was diagnosed, but the diagnosis information was unavailable. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 69,000.
NHTSA ODI #11678439
Mileage unknown · Jul 29, 2025
Electrical SystemSteering
Buttons to scroll through dash menu sticking and not working due to spring issue. I noticed this was a common problem and make it difficult to go through the menu to check my tire pressure, manage my driver assistance such as emergency braking and blind spot, and any other systems related to setting up my driving experience.
NHTSA ODI #11677053
Mileage unknown · Jul 22, 2025
Electrical System
The battery was drained on several occasions starting just shy of a year of owning the vehicle, after recharging it would be fine and showed no signs that it needed replacing, until it was finally completely drained and wouldn’t start without being jumped in June 2025. The USM Configuration for the EEM recall was completed at th…
Read full complaint
The battery was drained on several occasions starting just shy of a year of owning the vehicle, after recharging it would be fine and showed no signs that it needed replacing, until it was finally completely drained and wouldn’t start without being jumped in June 2025. The USM Configuration for the EEM recall was completed at this time along with a battery replacement. However, research suggests that issue could lead to draining of the battery, which the dealer denies was a possibility. These issues combined lead to all warning lights/lamps being produced on the display panel intermittently with a different message as to what the problem was each time. Turns out the only issue was the battery, according to the dealer. There have been several other issues I believe may be electrical related but unsure and when the taken to the dealership to have inspected was told the system just needed to be updated, however it has never fixed these issues, such as rearview backup camera screen black and not working intermittently and sometimes staying on while driving at higher speeds, screen in middle dash not responding to touch or buttons at random, doors automatically and unintentionally unlocked, doors not opening from the inside or outside on rare occasion, system in dash completely shutting down as if the vehicle was turned off and flashing before coming back up, vehicle not starting here and there while inside the vehicle or with key fob or app for remote start. All the random issues have been ongoing since the purchase of the vehicle, but told due to the dealer unable to recreate each problem, they are unable to actually identify what it is.
NHTSA ODI #11675249
Mileage unknown · Jul 15, 2025
Electrical System
Turned car on and it said engine malfunction reduced power. Turned car back off and on again, and the same message appeared. I drove the car home and let it sit. Turned it on later and message was gone.
NHTSA ODI #11673733
Mileage unknown · Jul 8, 2025
Electrical SystemForward Collision Avoidance
While driving one day in November 2024, the master warning light and the automatic emergency braking system off warning light came on. With 2 malfunction warnings: “Not available system malfunction with the Lane Departure warning symbol” and “AEB malfunction”. If you try to use cruise control a loud siren is alerted since these …
Read full complaint
While driving one day in November 2024, the master warning light and the automatic emergency braking system off warning light came on. With 2 malfunction warnings: “Not available system malfunction with the Lane Departure warning symbol” and “AEB malfunction”. If you try to use cruise control a loud siren is alerted since these 2 malfunctions are happening. Took it to the Nissan dealership where I bought it and was told there was a lane camera with an open circuit and to replace it when my windshield crack since it was close to $2,000.
NHTSA ODI #11672108
Mileage unknown · Jul 5, 2025
Electrical SystemEngineUnknown Or Other
We have had a problem where our battery had died on us out of nowhere. We took it to autozone to check out or battery and they said it was low and we just had to drive it around so we can charge it. We did that didn’t work so we changed the battery. Well two months later our car won’t start anymore and our battery drained again.…
Read full complaint
We have had a problem where our battery had died on us out of nowhere. We took it to autozone to check out or battery and they said it was low and we just had to drive it around so we can charge it. We did that didn’t work so we changed the battery. Well two months later our car won’t start anymore and our battery drained again. Now our car won’t start we had to jump start it again and even with that the battery wont hold its charge. We had a good friend who is a mechanic come in and help us and he did what he could to inspect the car and he was at a lost couldn’t tell us why the car won’t start.
NHTSA ODI #11671344
Official recalls
10Jun 27, 2025
Nissan North America, Inc. (Nissan) is recalling certain 2021-2024 Rogue, 2019-2020 Altima, 2019-2022 Infiniti QX50, and 2022 Infiniti QX55 vehicles equipped with 3-cylinder 1.5L or 4-cylinder 2.0L variable compression turbo (VC-Turbo) engines. The engine bearings may have manufacturing defects that can lead to engine failure.
Consequence & remedy
Consequence: Engine failure increases the risk of a crash. A bearing failure may cause a breach in the engine block, allowing hot oil to be discharged, increasing the risk of an engine fire.
Remedy: Dealers will reprogram the engine control module (ECM) software, free of charge. Owner letters were mailed April 8, 2026. Owners may contact Nissan's customer service at 800-647-7261 or Infiniti's customer service at 1-800-662-6200. Nissan's numbers for this recall are R25A8/A9 and R25B1/B2.
Nov 22, 2023
Nissan North America, Inc. (Nissan) is recalling certain 2021 Rogue vehicles. The left and/or right rear brake caliper assemblies may be missing an internal bushing, allowing the O-ring seal to move and brake fluid to leak.
Consequence & remedy
Consequence: A loss of brake fluid may reduce braking performance, increasing the risk of crash.
Remedy: Dealers will replace the left and right rear brake calipers, free of charge. Owner notification letters were mailed January 12, 2024. Owners may contact Nissan customer service at 1-800-867-7669. Nissan's number for this recall is PC933. The two vehicles that were previously inspected under recall 21V-286 and did not receive a brake caliper replacement will need to have the new remedy completed.
Oct 13, 2022
Nissan North America, Inc. (Nissan) is recalling certain 2022 Titan, Titan XD, Frontier, and 2021-2022 Rogue vehicles. The in-vehicle infotainment (IVI) system may continuously reboot when the vehicle is restarted, which can result in an inoperative rearview display. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: An inoperative rearview camera display reduces the driver's rear visibility, increasing the risk of a crash.
Remedy: The IVI software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters are expected to be mailed November 18, 2022. Owners may contact Nissan's customer service at 1-800-867-7669. Nissan's numbers for this recall are R22B8, R22C1, and PC923/25.
Sep 1, 2022
Nissan North America, Inc. (Nissan) is recalling certain 2021-2022 Rogue vehicles. The rear seat belts for the left-hand and right-hand rear seats may not retract properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 208, "Occupant Crash Protection," and 209, "Seatbelt Assemblies."
Consequence & remedy
Consequence: Seat belts that do not retract properly may be difficult to operate, preventing their usage, which can increase the risk of injury in a crash.
Remedy: Dealers will inspect and replace the rear seat belts, as necessary, free of charge. Owner notification letters are expected to be mailed October 27, 2023. Owners may contact Nissan's customer service at 1-800-867-7669. Nissan's number for this recall is PC915.
Jul 21, 2022
Nissan North America, Inc. (Nissan) is recalling certain 2021-2022 Rogue, 2022 Frontier, Pathfinder, and Titan rental vehicles. When the Sirius XM subscription is set to "Not Subscribed," it may cause the infotainment head unit to reboot, resulting in an inoperative rearview camera. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: An inoperative rearview camera display reduces the driver's rear visibility, increasing the risk of a crash.
Remedy: The Infotainment system software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters are expected to be mailed July 29, 2022. Owners may contact Nissan's customer service at 1-800-867-7669. Nissan's number for this recall is R22A5 PC901 PC902.
Additional source detail variants (2)
Equipment:electrical:infotainment:software
Nissan North America, Inc. (Nissan) is recalling certain 2021-2022 Rogue, 2022 Frontier, Pathfinder, and Titan rental vehicles. When the Sirius XM subscription is set to "Not Subscribed," it may cause the infotainment head unit to reboot, resulting in an inoperative rearview camera. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence: An inoperative rearview camera display reduces the driver's rear visibility, increasing the risk of a crash.
Remedy: The Infotainment system software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters are expected to be mailed July 29, 2022. Owners may contact Nissan's customer service at 1-800-867-7669. Nissan's number for this recall is R22A5 PC901 PC902.
Back Over Prevention: Sensing System: Camera
Nissan North America, Inc. (Nissan) is recalling certain 2021-2022 Rogue, 2022 Frontier, Pathfinder, and Titan rental vehicles. When the Sirius XM subscription is set to "Not Subscribed," it may cause the infotainment head unit to reboot, resulting in an inoperative rearview camera. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence: An inoperative rearview camera display reduces the driver's rear visibility, increasing the risk of a crash.
Remedy: The Infotainment system software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters are expected to be mailed July 29, 2022. Owners may contact Nissan's customer service at 1-800-867-7669. Nissan's number for this recall is R22A5 PC901 PC902.
Dec 9, 2021
Nissan North America, Inc. (Nissan) is recalling certain 2021 Rogue vehicles. Abnormal wear inside the fuel pump may cause it to overheat and fail.
Consequence & remedy
Consequence: Fuel pump failure may cause an engine stall, increasing the risk of a crash.
Remedy: Dealers will replace the fuel pump assembly, free of charge. Owner notification letters were mailed January 27, 2022. Owners may contact Nissan customer service at 1-800-867-7669. Nissan's number for this recall is R21B8.
Jun 24, 2021
Nissan North America, Inc. (Nissan) is recalling certain 2021 Rogue vehicles. The second-row upper tether wires may have been improperly welded to the seatback frame, preventing a child seat from being securely anchored. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 225, "Child Restraint Anchorage Systems."
Consequence & remedy
Consequence: An insecurely anchored child seat can move during a sudden stop or crash, increasing the risk of injury.
Remedy: Dealers will inspect and replace the rear seatbacks as necessary, free of charge. Owner notification letters were mailed July 30, 2021. Owners may contact Nissan customer service at 1-800-867-7669. Nissan's number for this recall is PC812.
Additional source detail variants (2)
Seats:mid/rear Assembly
Nissan North America, Inc. (Nissan) is recalling certain 2021 Rogue vehicles. The second-row upper tether wires may have been improperly welded to the seatback frame, preventing a child seat from being securely anchored. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 225, "Child Restraint Anchorage Systems."
Consequence: An insecurely anchored child seat can move during a sudden stop or crash, increasing the risk of injury.
Remedy: Dealers will inspect and replace the rear seatbacks as necessary, free of charge. Owner notification letters were mailed July 30, 2021. Owners may contact Nissan customer service at 1-800-867-7669. Nissan's number for this recall is PC812.
Child Seat:vehicle Tether Anchor
Nissan North America, Inc. (Nissan) is recalling certain 2021 Rogue vehicles. The second-row upper tether wires may have been improperly welded to the seatback frame, preventing a child seat from being securely anchored. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 225, "Child Restraint Anchorage Systems."
Consequence: An insecurely anchored child seat can move during a sudden stop or crash, increasing the risk of injury.
Remedy: Dealers will inspect and replace the rear seatbacks as necessary, free of charge. Owner notification letters were mailed July 30, 2021. Owners may contact Nissan customer service at 1-800-867-7669. Nissan's number for this recall is PC812.
Apr 22, 2021
Nissan North America, Inc. (Nissan) is recalling certain 2021 Rogue vehicles. The rear left and/or right brake caliper assemblies may be missing an internal bushing, allowing the O-ring seal to move and brake fluid to leak.
Consequence & remedy
Consequence: A loss of brake fluid may reduce braking performance, increasing the risk of crash.
Remedy: Dealers will inspect and replace the left and/or right rear brake calipers, as necessary, free of charge. Owner notification letters were mailed June 10, 2021. Owners may contact Nissan customer service at 1-800-867-7669. Nissan's number for this recall is PC804.
Mar 17, 2021
Nissan North America, Inc. (Nissan) is recalling certain 2021 Nissan Rogue vehicles. The incorrect wheel nuts may have been installed, and may loosen causing wheel vibration.
Consequence & remedy
Consequence: The wheel vibration may break the wheel studs and cause the wheel assembly to separate from the vehicle, increasing the risk of a crash.
Remedy: Nissan will notify owners, and dealers will inspect the wheel nuts and replace any incorrect ones, free of charge. The recall began May 4, 2021. Owners may contact Nissan customer service at 1-800-867-7669. Nissan's number for this recall is PC799.
Feb 11, 2021
Nissan North America, Inc. (Nissan) is recalling certain 2021 Nissan Rogue vehicles. The fuel hose may not be secured in the proper position and the fuel tank lock ring may not be fully seated.
Consequence & remedy
Consequence: An improperly secured fuel hose may leak, increasing the risk of a fire. The fuel hose may also disconnect completely, causing the engine to stall and increasing the risk of a crash.
Remedy: Nissan will notify owners, and dealers will inspect and, as necessary, reposition and secure the fuel hose and lock ring, free of charge. The recall began March 16, 2021. Owners may contact Nissan customer service at 1-800-867-7669. Nissan's number for this recall is PC791.
Additional source detail variants (2)
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
Nissan North America, Inc. (Nissan) is recalling certain 2021 Nissan Rogue vehicles. The fuel hose may not be secured in the proper position and the fuel tank lock ring may not be fully seated.
Consequence: An improperly secured fuel hose may leak, increasing the risk of a fire. The fuel hose may also disconnect completely, causing the engine to stall and increasing the risk of a crash.
Remedy: Nissan will notify owners, and dealers will inspect and, as necessary, reposition and secure the fuel hose and lock ring, free of charge. The recall began March 16, 2021. Owners may contact Nissan customer service at 1-800-867-7669. Nissan's number for this recall is PC791.
Fuel System, Gasoline:storage:tank Assembly
Nissan North America, Inc. (Nissan) is recalling certain 2021 Nissan Rogue vehicles. The fuel hose may not be secured in the proper position and the fuel tank lock ring may not be fully seated.
Consequence: An improperly secured fuel hose may leak, increasing the risk of a fire. The fuel hose may also disconnect completely, causing the engine to stall and increasing the risk of a crash.
Remedy: Nissan will notify owners, and dealers will inspect and, as necessary, reposition and secure the fuel hose and lock ring, free of charge. The recall began March 16, 2021. Owners may contact Nissan customer service at 1-800-867-7669. Nissan's number for this recall is PC791.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE24020 · 2021 Nissan Rogue Inner Tie Rod Failures
Opened Aug 5, 2024 · Closed Aug 24, 2026
Status: closed (inferred from source dates) · Steering:linkages:tie Rod Assembly
The Office of Defects Investigation (ODI) opened this investigation to assess allegations of tie rod bending, deformation, or related steering linkage damage in certain 2021 Nissan Rogue vehicles. A bent tie rod can affect wheel alignment and steering geometry, and in some circumstances may result in steering pull, abnormal tire wear, reduced steering precision, difficulty maintaining directional control, or loss of vehicle steering control, increasing the risk of a crash. ODI reviewed Vehicle Owner Questionnaires (VOQs), Early Warning Reporting data, manufacturer field reports, warranty claims, consumer complaints submitted to the manufacturer, and other information provided by Nissan in response to ODI’s information request. ODI also evaluated the reported failure circumstances, vehicle age and mileage, incident severity, and whether the available evidence indicated a defect trend occurring in the absence of external impact or other non-defect causes. Based on the information reviewed, ODI identified a low number of tie rod bending or deformation allegations relative to the subject vehicle population and exposure. The available reports did not indicate a consistent failure pattern, common production period, common mileage, or repeatable failure mode suggestive of a safety-related defect. Many of the reviewed incidents involved circumstances consistent with external loading or impact-related damage, including pothole strikes, curb contact, road debris impacts, prior collision damage, or other abnormal steering/suspension loads. ODI’s analysis did not identify a trend of tie rod bending occurring during normal vehicle operation without evidence of external influence. The complaint and warranty rates were low, and ODI did not identify a pattern of crashes, injuries, or loss-of-control events attributable to a tie rod defect in the subject vehicles. Accordingly, this investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by new circumstances or additional information. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
PE23023 · Complete Loss Of Motive Power Due To Engine Failure
Opened Dec 13, 2023 · Closed Jul 18, 2025
Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On December 13, 2023, the Office of Defects Investigation (ODI) opened PE23-023 to investigate allegations of engine failures leading to loss of motive power in model year (MY) 2021-2023 Nissan Rogue; MY 2019-2021 Nissan Altima; and MY 2019-2021 Infiniti QX50 vehicles. At that time, ODI had received 6 Vehicle Owner Questionnaires (VOQ) and multiple early warning reports, with consumers reporting engine knocking noises accompanied by a loss of engine power while driving. The investigation identified bearing failures in certain vehicles equipped with the subject 3-cylinder 1.5L or 4-cylinder 2.0L variable compression turbo (VC-Turbo) engines. ODI also identified early warning reports describing thermal incidents that occurred immediately after the vehicle suffered a catastrophic engine failure. The failures were the result of a manufacturing defect in specific engine bearings (main, A-, C-, and L-link) or other engine components that may cause engine damage and potentially lead to engine failure. Engine failure can result in a loss of motive power event that can increase the risk of a crash. Engine failure might also result in a fire if internal components detach and impact the engine block creating a hole that allows engine oil to reach hot surfaces. In its April 2024, May 2024, and June 2025 responses to ODI’s information requests, Nissan provided 998 customer reports (including complaints, field reports, and legal claims) and 1,107 warranty claims related to the alleged defect. When combining ODI and manufacturer report data, there are 1,878 unique VINs that have experienced failures across all subject vehicles. In one of the early warning reports, ODI identified an incident involving a 2022 Infiniti QX55 that resulted in an engine fire following an alleged engine failure. The 2022 Infiniti QX55 was not included in the scope of this investigation but the vehicle model shares the same 4-cylinder 2.0L variable compression turbo engine. Based on the information included with the early warning report, the fire can be directly related to the alleged defect. A further review of ODI and manufacturer data, identified 12 allegations of engine compartment fires in subject vehicles; three were confirmed as directly related to the engine failure, and nine reports described an under-hood fire that occurred following a loss of power event. Additionally, ODI identified multiple reports describing an engine block crack or hole surrounded by oil residue following an engine failure. On June 27, 2025, Nissan submitted recall 25V-437 involving 443,899 MY 2021-2023 Nissan Rogue, MY 2019-2021 Nissan Altima; MY 2019-2021 Infiniti QX50; and 2022 Infiniti QX55 vehicles. The recall remedy provides the dealer instructions to inspect the engine oil pan for the presence of specific metal debris. For customers with the 3-cylinder 1.5L VC-Turbo engine, if no debris is detected during the inspection, dealers will replace the oil pan gasket, engine oil, and reprogram the vehicle’s Engine Control Module (ECM). For customers with the 4-cylinder 2.0L VC-Turbo engine, if no debris is detected, dealers will replace the engine oil. In the case where specific debris is detected and confirmed by Nissan Powertrain Call Center, dealers will be instructed to replace the engine. In addition, Nissan will extend the vehicle warranty to 10 years and 120,000 miles for the recall subject vehicle population after the dealer performs the inspection. Nissan has implemented multiple corrective actions to address the identified manufacturing defects of certain engine block internal components. In view of the recall action (25V437) taken by Nissan, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On December 13, 2023, the Office of Defects Investigation (ODI) opened PE23-023 to investigate allegations of engine failures leading to loss of motive power in model year (MY) 2021-2023 Nissan Rogue; MY 2019-2021 Nissan Altima; and MY 2019-2021 Infiniti QX50 vehicles. At that time, ODI had received 6 Vehicle Owner Questionnaires (VOQ) and multiple early warning reports, with consumers reporting engine knocking noises accompanied by a loss of engine power while driving. The investigation identified bearing failures in certain vehicles equipped with the subject 3-cylinder 1.5L or 4-cylinder 2.0L variable compression turbo (VC-Turbo) engines. ODI also identified early warning reports describing thermal incidents that occurred immediately after the vehicle suffered a catastrophic engine failure. The failures were the result of a manufacturing defect in specific engine bearings (main, A-, C-, and L-link) or other engine components that may cause engine damage and potentially lead to engine failure. Engine failure can result in a loss of motive power event that can increase the risk of a crash. Engine failure might also result in a fire if internal components detach and impact the engine block creating a hole that allows engine oil to reach hot surfaces. In its April 2024, May 2024, and June 2025 responses to ODI’s information requests, Nissan provided 998 customer reports (including complaints, field reports, and legal claims) and 1,107 warranty claims related to the alleged defect. When combining ODI and manufacturer report data, there are 1,878 unique VINs that have experienced failures across all subject vehicles. In one of the early warning reports, ODI identified an incident involving a 2022 Infiniti QX55 that resulted in an engine fire following an alleged engine failure. The 2022 Infiniti QX55 was not included in the scope of this investigation but the vehicle model shares the same 4-cylinder 2.0L variable compression turbo engine. Based on the information included with the early warning report, the fire can be directly related to the alleged defect. A further review of ODI and manufacturer data, identified 12 allegations of engine compartment fires in subject vehicles; three were confirmed as directly related to the engine failure, and nine reports described an under-hood fire that occurred following a loss of power event. Additionally, ODI identified multiple reports describing an engine block crack or hole surrounded by oil residue following an engine failure. On June 27, 2025, Nissan submitted recall 25V-437 involving 443,899 MY 2021-2023 Nissan Rogue, MY 2019-2021 Nissan Altima; MY 2019-2021 Infiniti QX50; and 2022 Infiniti QX55 vehicles. The recall remedy provides the dealer instructions to inspect the engine oil pan for the presence of specific metal debris. For customers with the 3-cylinder 1.5L VC-Turbo engine, if no debris is detected during the inspection, dealers will replace the oil pan gasket, engine oil, and reprogram the vehicle’s Engine Control Module (ECM). For customers with the 4-cylinder 2.0L VC-Turbo engine, if no debris is detected, dealers will replace the engine oil. In the case where specific debris is detected and confirmed by Nissan Powertrain Call Center, dealers will be instructed to replace the engine. In addition, Nissan will extend the vehicle warranty to 10 years and 120,000 miles for the recall subject vehicle population after the dealer performs the inspection. Nissan has implemented multiple corrective actions to address the identified manufacturing defects of certain engine block internal components. In view of the recall action (25V437) taken by Nissan, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling
On December 13, 2023, the Office of Defects Investigation (ODI) opened PE23-023 to investigate allegations of engine failures leading to loss of motive power in model year (MY) 2021-2023 Nissan Rogue; MY 2019-2021 Nissan Altima; and MY 2019-2021 Infiniti QX50 vehicles. At that time, ODI had received 6 Vehicle Owner Questionnaires (VOQ) and multiple early warning reports, with consumers reporting engine knocking noises accompanied by a loss of engine power while driving. The investigation identified bearing failures in certain vehicles equipped with the subject 3-cylinder 1.5L or 4-cylinder 2.0L variable compression turbo (VC-Turbo) engines. ODI also identified early warning reports describing thermal incidents that occurred immediately after the vehicle suffered a catastrophic engine failure. The failures were the result of a manufacturing defect in specific engine bearings (main, A-, C-, and L-link) or other engine components that may cause engine damage and potentially lead to engine failure. Engine failure can result in a loss of motive power event that can increase the risk of a crash. Engine failure might also result in a fire if internal components detach and impact the engine block creating a hole that allows engine oil to reach hot surfaces. In its April 2024, May 2024, and June 2025 responses to ODI’s information requests, Nissan provided 998 customer reports (including complaints, field reports, and legal claims) and 1,107 warranty claims related to the alleged defect. When combining ODI and manufacturer report data, there are 1,878 unique VINs that have experienced failures across all subject vehicles. In one of the early warning reports, ODI identified an incident involving a 2022 Infiniti QX55 that resulted in an engine fire following an alleged engine failure. The 2022 Infiniti QX55 was not included in the scope of this investigation but the vehicle model shares the same 4-cylinder 2.0L variable compression turbo engine. Based on the information included with the early warning report, the fire can be directly related to the alleged defect. A further review of ODI and manufacturer data, identified 12 allegations of engine compartment fires in subject vehicles; three were confirmed as directly related to the engine failure, and nine reports described an under-hood fire that occurred following a loss of power event. Additionally, ODI identified multiple reports describing an engine block crack or hole surrounded by oil residue following an engine failure. On June 27, 2025, Nissan submitted recall 25V-437 involving 443,899 MY 2021-2023 Nissan Rogue, MY 2019-2021 Nissan Altima; MY 2019-2021 Infiniti QX50; and 2022 Infiniti QX55 vehicles. The recall remedy provides the dealer instructions to inspect the engine oil pan for the presence of specific metal debris. For customers with the 3-cylinder 1.5L VC-Turbo engine, if no debris is detected during the inspection, dealers will replace the oil pan gasket, engine oil, and reprogram the vehicle’s Engine Control Module (ECM). For customers with the 4-cylinder 2.0L VC-Turbo engine, if no debris is detected, dealers will replace the engine oil. In the case where specific debris is detected and confirmed by Nissan Powertrain Call Center, dealers will be instructed to replace the engine. In addition, Nissan will extend the vehicle warranty to 10 years and 120,000 miles for the recall subject vehicle population after the dealer performs the inspection. Nissan has implemented multiple corrective actions to address the identified manufacturing defects of certain engine block internal components. In view of the recall action (25V437) taken by Nissan, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
On December 13, 2023, the Office of Defects Investigation (ODI) opened PE23-023 to investigate allegations of engine failures leading to loss of motive power in model year (MY) 2021-2023 Nissan Rogue; MY 2019-2021 Nissan Altima; and MY 2019-2021 Infiniti QX50 vehicles. At that time, ODI had received 6 Vehicle Owner Questionnaires (VOQ) and multiple early warning reports, with consumers reporting engine knocking noises accompanied by a loss of engine power while driving. The investigation identified bearing failures in certain vehicles equipped with the subject 3-cylinder 1.5L or 4-cylinder 2.0L variable compression turbo (VC-Turbo) engines. ODI also identified early warning reports describing thermal incidents that occurred immediately after the vehicle suffered a catastrophic engine failure. The failures were the result of a manufacturing defect in specific engine bearings (main, A-, C-, and L-link) or other engine components that may cause engine damage and potentially lead to engine failure. Engine failure can result in a loss of motive power event that can increase the risk of a crash. Engine failure might also result in a fire if internal components detach and impact the engine block creating a hole that allows engine oil to reach hot surfaces. In its April 2024, May 2024, and June 2025 responses to ODI’s information requests, Nissan provided 998 customer reports (including complaints, field reports, and legal claims) and 1,107 warranty claims related to the alleged defect. When combining ODI and manufacturer report data, there are 1,878 unique VINs that have experienced failures across all subject vehicles. In one of the early warning reports, ODI identified an incident involving a 2022 Infiniti QX55 that resulted in an engine fire following an alleged engine failure. The 2022 Infiniti QX55 was not included in the scope of this investigation but the vehicle model shares the same 4-cylinder 2.0L variable compression turbo engine. Based on the information included with the early warning report, the fire can be directly related to the alleged defect. A further review of ODI and manufacturer data, identified 12 allegations of engine compartment fires in subject vehicles; three were confirmed as directly related to the engine failure, and nine reports described an under-hood fire that occurred following a loss of power event. Additionally, ODI identified multiple reports describing an engine block crack or hole surrounded by oil residue following an engine failure. On June 27, 2025, Nissan submitted recall 25V-437 involving 443,899 MY 2021-2023 Nissan Rogue, MY 2019-2021 Nissan Altima; MY 2019-2021 Infiniti QX50; and 2022 Infiniti QX55 vehicles. The recall remedy provides the dealer instructions to inspect the engine oil pan for the presence of specific metal debris. For customers with the 3-cylinder 1.5L VC-Turbo engine, if no debris is detected during the inspection, dealers will replace the oil pan gasket, engine oil, and reprogram the vehicle’s Engine Control Module (ECM). For customers with the 4-cylinder 2.0L VC-Turbo engine, if no debris is detected, dealers will replace the engine oil. In the case where specific debris is detected and confirmed by Nissan Powertrain Call Center, dealers will be instructed to replace the engine. In addition, Nissan will extend the vehicle warranty to 10 years and 120,000 miles for the recall subject vehicle population after the dealer performs the inspection. Nissan has implemented multiple corrective actions to address the identified manufacturing defects of certain engine block internal components. In view of the recall action (25V437) taken by Nissan, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration