I HAVE A 2004 NISSAN MURANO SE. AT APPROXIMATELY 50,000 MILES, THE DRIVERS' SIDE SUN VISOR HAD SOME SORT OF INTERNAL MECHANICAL FAILURE WHICH MAKES IT FALL DOWN IN FRONT OF MY FACE WHILE DRIVING. MY EXTENDED WARRANTY COMPANY REFUSES TO FIX IT, CLAIMING IT IS A "TRIM" ITEM, AND THE DEALERSHIP CLAIMS IT IS NO LONGER THEIR PROBLE…
Read full complaint
I HAVE A 2004 NISSAN MURANO SE. AT APPROXIMATELY 50,000 MILES, THE DRIVERS' SIDE SUN VISOR HAD SOME SORT OF INTERNAL MECHANICAL FAILURE WHICH MAKES IT FALL DOWN IN FRONT OF MY FACE WHILE DRIVING. MY EXTENDED WARRANTY COMPANY REFUSES TO FIX IT, CLAIMING IT IS A "TRIM" ITEM, AND THE DEALERSHIP CLAIMS IT IS NO LONGER THEIR PROBLEM AS THE CAR ISN'T UNDER WARRANTY. HOWEVER, IT SEEMS TO ME THAT THIS IS A SAFETY ITEM, SINCE EVERY TIME IT FALLS DOWN, IT OBSCURES MY VIEW OF THE ROADWAY. WHEN I SEARCHED ONLINE, I FOUND MANY OTHER NISSAN MURANO OWNERS ON ONLINE FORUMS COMPLAINING OF THE SAME ISSUE WITH THEIR 2003 THROUGH 2006 MURANOS WITH RELATIVELY LOW MILEAGE FAILURES OF THIS PARTICULAR PART. *TR
NHTSA ODI #10233555
30,000 miles · May 13, 2008
StructureVisibility
FAILURE OF DRIVER SIDE SUN VISOR. SUDDENLY FALLS CAUSING A SAFETY ISSUE. DEALER REPLACED ONCE AND SECOND VISOR ALSO FAILED. *TR
NHTSA ODI #10227651
33,000 miles · May 3, 2008
Air BagsFuel System, GasolineSeat BeltsCrashInjury
I RAN OFF THE LEFT SIDE OF A MOUNTAIN ROAD HITTING A LARGE TREE WITH THE DRIVER'S DOOR, THEN CONTINUED DOWN THE HILL ANOTHER ~20 FEET SLAMMING INTO A BOULDER. WHEN I HIT THE TREE, THE DRIVER'S DOOR WINDOW BROKE AS WELL AS THE DRIVER'S SIDE REAR DOOR. THE DOOR WAS JAMMED SHUT. THE NISSAN WAS EQUIPPED WITH FRONT SIDE IMPACT AIR…
Read full complaint
I RAN OFF THE LEFT SIDE OF A MOUNTAIN ROAD HITTING A LARGE TREE WITH THE DRIVER'S DOOR, THEN CONTINUED DOWN THE HILL ANOTHER ~20 FEET SLAMMING INTO A BOULDER. WHEN I HIT THE TREE, THE DRIVER'S DOOR WINDOW BROKE AS WELL AS THE DRIVER'S SIDE REAR DOOR. THE DOOR WAS JAMMED SHUT. THE NISSAN WAS EQUIPPED WITH FRONT SIDE IMPACT AIRBAGS AND BOTH FRONT AND REAR HEAD PROTECTION AIRBAGS. NONE WERE DEPLOYED. WHEN I HIT THE BOULDER, THE FRONT PASSENGER AIRBAG DEPLOYED, BUT THE DRIVER'S FRONT AIRBAG FAILED TO DEPLOY. THE PRE-TENSIONER ON THE DRIVER'S SEATBELT DID NOT LATCH RESULTING IN ME HITTING MY UPPER CHEST AND LOWER JAW ON THE STEERING WHEEL SINCE THE AIRBAG DID NOT DEPLOY. THE FUEL CUT-OFF DEVICE ALSO FAILED TO ACTIVATE AND SHUT OFF THE ENGINE. AFTER ALMOST A MINUTE, I TURNED OFF THE ENGINE WITH THE KEY. I HAD BEEN KNOCKED UNCONSCIOUS FOR SEVERAL SECONDS. THE 2004 NISSAN MURANO SUSTAINED OVER $25,000 IN DAMAGE WHICH RESULTED IN IT BEING TOTALED BY MY INSURANCE COMPANY. THE AIRBAG LIGHT WOULD ILLUMINATE BRIEFLY WHEN STARTING THE CAR PRIOR TO THE ACCIDENT. SO THERE WAS NO INDICATION OF AN AIRBAG MALFUNCTION. THERE WAS SUBSTANTIAL DAMAGE TO THE DRIVER'S SIDE OF THE VEHICLE AS WELL AS THE FRONT AND UNDERCARRIAGE. MY INJURIES WERE LIMITED TO BRUISES TO MY CHEST AND LOWER JAW. THE ACCIDENT ALSO GREATLY AGGRAVATED A PRIOR INJURY TO MY UPPER BACK. WHEN I WENT TO GO REMOVE MY PERSONAL BELONGINGS FROM THE VEHICLE, I FOUND THAT THE JACK, MOUNTED IN THE REAR FLOOR HAD COME COMPLETELY OUT. *TR
NHTSA ODI #10226557
36,752 miles · Nov 26, 2007
Fuel System, GasolineStructure
I PUT THE BACK TAILGATE UP IN MY 2004 NISSAN MURANO TO PUT MY GRANDDAUGHTERS' BELONGINGS IN TO TAKE THEM HOME. I WALKED TO THE BACK SEAT AREA TO PUT SOMETHING IN THE BACK SEAT, WHEN I HEARD A HUGE WHOOSHING SOUND AND SUDDENLY THE ENTIRE DOOR SLAMMED DOWN. LUCKILY I WASN'T NEAR IT OR I COULD HAVE BEEN KILLED. THE DOOR IS VERY HE…
Read full complaint
I PUT THE BACK TAILGATE UP IN MY 2004 NISSAN MURANO TO PUT MY GRANDDAUGHTERS' BELONGINGS IN TO TAKE THEM HOME. I WALKED TO THE BACK SEAT AREA TO PUT SOMETHING IN THE BACK SEAT, WHEN I HEARD A HUGE WHOOSHING SOUND AND SUDDENLY THE ENTIRE DOOR SLAMMED DOWN. LUCKILY I WASN'T NEAR IT OR I COULD HAVE BEEN KILLED. THE DOOR IS VERY HEAVY AND IT SLAMMED DOWN WITH QUITE A FORCE. THERE WAS A STRONG SMELL OF A VAPORIZED NATURE IN THE CAR. NOW THE DOOR IS VERY DIFFICULT TO OPEN AND REQUIRES BOTH HANDS TO DO SO. EVIDENTLY ONE OF THE HYDRAULIC STRUTS WENT OUT. THIS POSES A SIGNIFICANT DANGER TO ANYONE NEARBY. I HAVE CALLED THE DEALER AND AM TAKING IT IN TODAY. THEY WERE VERY NON-COMMITTAL ABOUT IT BEING SOMETHING THEY WOULD REPAIR WITHOUT COST. THEY DID SAY IT WAS A VERY RARE OCCURRENCE. I AM VERY CONCERNED ABOUT THIS INCIDENT AND WANT TO REPORT IT. IF OTHERS ARE NOT AWARE, THERE COULD BE A VERY SERIOUS ACCIDENT. I AM CONCERNED ABOUT MY OWN SAFETY AS WELL. *TR
NHTSA ODI #10209946
40,000 miles · Sep 13, 2006
Structure
FAILURE OF REAR ENGINE MOUNT ON MY 2004 NISSAN MURANO WITH 40,000 MILES. WITHOUT REPLACING SAID MOUNT SAFETY WOULD COME INTO QUESTION. PARTS ARE ON ORDER IS THIS A COMMON FAILURE. SHOULD NISSAN BE HELD RESPONSIBLE AND MAKE GOOD? *NM
NHTSA ODI #10168164
Mileage unknown · Jun 24, 2006
Structure
EVERY TIME I GET OUT OF MY CAR, PLACE MY FEET ON THE GROUND, AND THEN TOUCH METAL THAT BEING THE CAR FRAME OR CAR DOOR, I GET SHOCKED. THE ONLY WAY I DO NOT GET SHOCKED IS BY TOUCHING THE METAL CONTINUOUSLY AS I PLACE MY FEET ON THE GROUND AND THEN I AM ABLE TO CLOSE THE DOOR WITHOUT GETTING SHOCKED. THE ONLY OTHER TIME I DO N…
Read full complaint
EVERY TIME I GET OUT OF MY CAR, PLACE MY FEET ON THE GROUND, AND THEN TOUCH METAL THAT BEING THE CAR FRAME OR CAR DOOR, I GET SHOCKED. THE ONLY WAY I DO NOT GET SHOCKED IS BY TOUCHING THE METAL CONTINUOUSLY AS I PLACE MY FEET ON THE GROUND AND THEN I AM ABLE TO CLOSE THE DOOR WITHOUT GETTING SHOCKED. THE ONLY OTHER TIME I DO NOT GET SHOCKED IS WHEN IT IS RAINING. THIS DOES NOT HAPPEN WHEN I GET OUT OF ANY OTHER CAR. I AM BEGINNING TO HATE MY CAR BECAUSE OF THIS. WHY IS IT DOING THIS. I HAVE TOLD THE PEOPLE AT THE DEALERSHIP WHEN I GET MY OIL CHANGED AND THEY HAVE NO ANSWERS AND DO NOT SEEM INTERESTED IN CHECKING INTO THIS. *NM
NHTSA ODI #10160678
9,100 miles · May 10, 2005
Structure
MY 2004 NISSAN MURANO BEGAN HAVING A "TINNY" NOISE COMING FROM THE FRONT PASSENGER DOOR. I THOUGHT THAT PERHAPS THE INSULATION HAD FALLEN DOWN, AND TOOK THE CAR IN FOR SERVICING ON 1-13-05 TO FERMAN NISSAN IN TAMPA, FLORIDA. I WAS TOLD THAT THE DEALERSHIP COULD NOT REPAIR THE DOOR, AS THE DOOR BEAM WAS BROKEN, AND THAT THE BOD…
Read full complaint
MY 2004 NISSAN MURANO BEGAN HAVING A "TINNY" NOISE COMING FROM THE FRONT PASSENGER DOOR. I THOUGHT THAT PERHAPS THE INSULATION HAD FALLEN DOWN, AND TOOK THE CAR IN FOR SERVICING ON 1-13-05 TO FERMAN NISSAN IN TAMPA, FLORIDA. I WAS TOLD THAT THE DEALERSHIP COULD NOT REPAIR THE DOOR, AS THE DOOR BEAM WAS BROKEN, AND THAT THE BODY SHOP WOULD HAVE TO REPLACE A DOOR BEAM. IN DECEMBER 2004, THE CAR HAD BEEN INVOLVED IN MINOR VANDALISM. A BRICK HAD BEEN THROWN AT THE REAR OF THE CAR, AND THERE WAS SAND ON THE PASSENGER DOOR. THERE WAS BARELY A DIMPLE ON THE EXTERIOR OF THE DOOR, BUT THE SERVICE DEPARTMENT SURMISED THAT SOMEONE KICKED THE DOOR, WHICH WAS WHY THERE WAS SAND, AND THAT THE DOOR BEAM WAS BROKEN IN THE PROCESS. I TOOK THE CAR TO A BODY SHOP FOR AN ESTIMATE IN APRIL 2004, AND THEY WERE SURPRISED THAT THE DOOR BEAM COULD HAVE BEEN SO EASILY BROKEN, AS THIS WAS SUPPOSED TO BE A SAFETY FEATURE OF THE CAR. I WAS TOLD THAT BECAUSE IT WAS A SAFETY FEATURE, A DOOR BEAM CANNOT BE REPAIRED, AND THAT THE DOOR WOULD HAVE TO BE REPLACED. I CONTACTED NISSAN USA IN ON APRIL 7, 2005, AND EXPLAINED MY CONCERNS THAT THE DOOR BEAM COULD BE SO EASILY BROKEN, WITH BARELY A MARK ON THE EXTERIOR, AND THIS WOULD NOT PROTECT PASSENGERS IN A CRASH SITUATION. I OFFERED THEM THE OPPORTUNITY TO INSPECT THE DOOR, AS A POSSIBLE MANUFACTURING DEFECT, AND POSSIBLY PAY TO REPLACE IT, BUT, PER COLLETTE, THEY WERE NOT INTERESTED IN INSPECTING THE DOOR. NEITHER WAS THE LOCAL DEALERSHIP, FERMAN NISSAN IN TAMPA, FLORIDA. HOWEVER, I WANTED TO BE SURE THAT THIS INCIDENT WAS RECORDED SOMEWHERE, AS I AM STILL CONCERNED THAT THE DOOR BEAM COULD BE SO EASILY BROKEN, CAUSING A POTENTIAL SAFETY HAZARD. I HAVE SINCE HAD THE DOOR REPLACED, AND THE EXPENSE WAS COVERED BY MY INSURANCE COMPANY.
NHTSA ODI #10120608
Mileage unknown · Mar 7, 2005
Exterior LightingStructure
THE LEFT XENON HEADLIGHT IN THE CONSUMER'S 2004 NISSAN MURANO WAS STOLEN. *NAR** *NM *JB A THIEF ENTERED THE CONSUMERS VEHICLE VIA KEYHOLE, POPPED THE KEYHOLE AND STOLE THE LEFT LIGHT. THE CONSUMER FELT THAT THE EASY ENTRANCE WAS A DEFECT. *SC *JB
NHTSA ODI #10115537
500 miles · Feb 15, 2004
Structure
I HAVE A NOISE/SQUEAK/RATTLE BEHIND MY GLOVE BOX. MY CAR HAS BEEN TO THE DEALER OVER 10 TIMES FOR THIS ISSUE AND IT HASN'T BEEN REPAIRED. IT IS NOT MAKING THE VEHICLE UN-DRIVABLE, BUT A BRAND NEW VEHICLE SHOULD NOT BE DOING THAT.*AK
NISSAN IS RECALLING 362,891 MY 2003-2007 MURANO VEHICLES. THE INTAKE AIR DUCTS, WHICH ARE CONNECTED TO THE INTERMEDIATE RESONATOR IN THE AIR INTAKE SYSTEM OF THE ENGINE, MAY SEPARATE FROM THE RESONATOR WITH ENGINE MOVEMENT. THIS SEPARATION OCCURS DUE TO THE PREMATURE AGING OF THE MATERIAL USED IN THE INTAKE AIR DUCTS WHICH CAUSES EXCESSIVE SHRINKING.
Consequence & remedy
Consequence: ENGINE MAY STALL INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT AND REPLACE/REPAIR THE APPROPRIATE COMPONENTS FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 24, 2009. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
ON SOME SPORT UTILITY VEHICLES, IN CERTAIN HIGH SPEED FRONTAL CRASHES, THE WEBBING OF A REAR OUTBOARD SEAT BELT MAY CONTACT THE REAR SEAT BACK HINGE WHERE IT CAN BE CUT BY THE SHARP EDGE OF THE METAL PORTION OF THE HINGE.
Consequence & remedy
Consequence: IF THE WEBBING IS COMPLETELY SEPARATED, IT CAN INCREASE THE RISK OF INJURY TO AN OCCUPANT IN A CRASH.
Remedy: DEALERS WILL INSTALL PROTECTORS OVER THE WEBBING OF THE REAR SEAT BELTS. THE RECALL BEGAN ON MARCH 20, 2006. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
ON CERTAIN SPORT UTILITY VEHICLES, DUE TO THE LOCATION OF THE FORWARD EDGE OF THE FUEL TANK, IN THE EVENT THAT A VEHICLE FRONT TIRE RUNS OVER A SMALL, SHARP OBJECT IN THE ROAD, CATCHES IT AND PROPELS IT TOWARDS THE REAR OF THE VEHICLE, IT MAY STRIKE AND PUNCTURE THE FUEL TANK.
Consequence & remedy
Consequence: A PUNCTURED TANK COULD INCREASE THE RISK OF A FIRE.
Remedy: DEALERS WILL INSTALL PROTECTORS IN FRONT OF THE TANK FREE OF CHARGE. THE RECALL BEGAN ON MARCH 20, 2006. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
ON CERTAIN SPORT UTILITY VEHICLES, THERE IS A POSSIBILITY THAT A WIRE BREAKING INSIDE THE ALTERNATOR COULD STOP THE BATTERY FROM CHARGING.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE CHARGER WARNING AND BRAKE WARNING LAMPS WILL IMMEDIATELY COME ON AND THE BATTERY WILL BEGIN TO DISCHARGE. AFTER A SHORT TIME, THE ENGINE WILL GO INTO A "FALL SAFE" CONDITION WHICH WILL LIMIT VEHICLE SPEED. THE ENGINE WILL STOP RUNNING WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSPECT AND REPLACE THE ALTERNATOR WITH A NEW VERSION WHICH HAS BEEN MODIFIED TO PREVENT MOVEMENT OF THE COIL. THE RECALL BEGAN ON AUGUST 1, 2005. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4
PE08065 · Driver Seat Anchor Failure
Opened Nov 18, 2008 · Closed Jul 2, 2009
Status: closed (inferred from source dates) · Seats
THIS INVESTIGATION CONCERNS STRUCTURAL FAILURE OF THE ANCHOR/BRACKET ON THE LEFT REAR SIDE OF THE DRIVER'S SEAT.THE CONCERN IS THAT SUCH FAILURES MAY ALTER THE DRIVER'S SEATED POSITION SO AS TO REDUCE EFFECTIVENESS OF THE OCCUPANT PROTECTION SYSTEM OR POTENTIALLY COMPROMISE VEHICLE CONTROL.FAILURE OF THE SUBJECT ANCHOR BRACKET RESULTS FROM METAL FATIGUE AND CAUSES REARWARD TILTING OF THE DRIVER'S SEAT.THESE FAILURES USUALLY OCCUR DURING DRIVER INGRESS BUT MAY ALSO OCCUR WHILE THE VEHICLE IS BEING OPERATED.THE SAFETY RELATED CONCERNS DURING ACTUAL VEHICLE USE WERE NOT VALIDATED BY THIS INVESTIGATION.WHILE THE NUMBER OF COMPLAINTS OF THIS PROBLEM IS RELATIVELY HIGH, ONLY THREE VERY MINOR, UNDOCUMENTED INJURIES WERE REPORTED.THE REPORTED INJURIES OCCURRED DURING DRIVER INGRESS, NOT WHILE THE VEHICLE WAS IN MOTION.INVESTIGATION DISCLOSED THAT THE APPARENT RISK OF COMPROMISE TO VEHICLE CONTROL HAS NOT BEEN DEMONSTRATED.INVESTIGATION ALSO DISCLOSED THAT THE APPARENT RISK OF COLLAPSE OF THE DRIVER'S SEAT BACK HAS NOT BEEN DEMONSTRATEDA SAFETY RELATED DEFECT TREND WAS NOT IDENTIFIED AND THIS INVESTIGATION HAS BEEN CLOSED.
ODI OPENED A PRELIMINARY EVALUATION BASED ON FOUR VEHICLE OWNER QUESTIONNAIRES (VOQ'S) INDICATING THAT THE FUEL TANKS WEREPUNCTURED BY ROAD DEBRIS UNDER NORMAL, NON OFF-ROAD DRIVING CONDITIONS.AS OF NOVEMBER 30, 2005, THE COMPLAINT TOTAL INCREASED TO 12.NISSAN SUPPLIED ODI WITH 31 COMPLAINTS OF FUEL TANK PUNCTURES, INCLUDING 26 NOT PREVIOUSLY KNOWN TO ODI FROM THE VOQ RECORDS. IN A LETTER DATED JANUARY 9, 2006, NISSAN NORTH AMERICA, INC. NOTIFIED ODI OF ITS PLAN TO RECALL APPROXIMATELY 209,000 MODEL YEAR 2003 - 2006 NISSAN MURANO VEHICLES BUILT FROM APRIL 24, 2002 (START OF PRODUCTION OF MY 2003) THROUGH NOVEMBER 24, 2005 (INCLUDING A PORTION OF MY 2006 VEHICLES) TO CORRECT A DEFICIENCY IN FUEL TANK SHIELDING FROM ROAD DEBRIS.THIS RECALL HAS BEEN DESIGNATED NHTSA NO. 06V-003.RECALLED VEHICLES WILL BE FITTED WITH PROTECTIVE SHIELDING FOR THE FRONTAL PORTION OF THE FUEL TANK TO REDUCE THE POSSIBILITY OF PUNCTURE BY PROJECTILES FROM THE FRONT WHEELS.ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED.
Additional source detail variants (2)
Fuel System, Gasoline:storage:tank Assembly
ODI OPENED A PRELIMINARY EVALUATION BASED ON FOUR VEHICLE OWNER QUESTIONNAIRES (VOQ'S) INDICATING THAT THE FUEL TANKS WEREPUNCTURED BY ROAD DEBRIS UNDER NORMAL, NON OFF-ROAD DRIVING CONDITIONS.AS OF NOVEMBER 30, 2005, THE COMPLAINT TOTAL INCREASED TO 12.NISSAN SUPPLIED ODI WITH 31 COMPLAINTS OF FUEL TANK PUNCTURES, INCLUDING 26 NOT PREVIOUSLY KNOWN TO ODI FROM THE VOQ RECORDS. IN A LETTER DATED JANUARY 9, 2006, NISSAN NORTH AMERICA, INC. NOTIFIED ODI OF ITS PLAN TO RECALL APPROXIMATELY 209,000 MODEL YEAR 2003 - 2006 NISSAN MURANO VEHICLES BUILT FROM APRIL 24, 2002 (START OF PRODUCTION OF MY 2003) THROUGH NOVEMBER 24, 2005 (INCLUDING A PORTION OF MY 2006 VEHICLES) TO CORRECT A DEFICIENCY IN FUEL TANK SHIELDING FROM ROAD DEBRIS.THIS RECALL HAS BEEN DESIGNATED NHTSA NO. 06V-003.RECALLED VEHICLES WILL BE FITTED WITH PROTECTIVE SHIELDING FOR THE FRONTAL PORTION OF THE FUEL TANK TO REDUCE THE POSSIBILITY OF PUNCTURE BY PROJECTILES FROM THE FRONT WHEELS.ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED.
Fuel System, Other:storage:tank Assembly
ODI OPENED A PRELIMINARY EVALUATION BASED ON FOUR VEHICLE OWNER QUESTIONNAIRES (VOQ'S) INDICATING THAT THE FUEL TANKS WEREPUNCTURED BY ROAD DEBRIS UNDER NORMAL, NON OFF-ROAD DRIVING CONDITIONS.AS OF NOVEMBER 30, 2005, THE COMPLAINT TOTAL INCREASED TO 12.NISSAN SUPPLIED ODI WITH 31 COMPLAINTS OF FUEL TANK PUNCTURES, INCLUDING 26 NOT PREVIOUSLY KNOWN TO ODI FROM THE VOQ RECORDS. IN A LETTER DATED JANUARY 9, 2006, NISSAN NORTH AMERICA, INC. NOTIFIED ODI OF ITS PLAN TO RECALL APPROXIMATELY 209,000 MODEL YEAR 2003 - 2006 NISSAN MURANO VEHICLES BUILT FROM APRIL 24, 2002 (START OF PRODUCTION OF MY 2003) THROUGH NOVEMBER 24, 2005 (INCLUDING A PORTION OF MY 2006 VEHICLES) TO CORRECT A DEFICIENCY IN FUEL TANK SHIELDING FROM ROAD DEBRIS.THIS RECALL HAS BEEN DESIGNATED NHTSA NO. 06V-003.RECALLED VEHICLES WILL BE FITTED WITH PROTECTIVE SHIELDING FOR THE FRONTAL PORTION OF THE FUEL TANK TO REDUCE THE POSSIBILITY OF PUNCTURE BY PROJECTILES FROM THE FRONT WHEELS.ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED.
ODI RECEIVED 14 REPORTS OF ALLEGED ENGINE STALLING DUE TO ALTERNATOR FAILURE ON MY 2003-2004 MURANO (SUBJECT) VEHICLES.ALL OF THE COMPLAINTS REPORTED THAT THE VEHICLE COULD NOT BE RESTARTED AFTER THE STALL OCCURRED.BASED ON THESE COMPLAINTS, ODI OPENED PE04-077 AND LATER UPGRADED TO EA05-006 FOR THE SUBJECT VEHICLES.DURING EA05-006, ADDITIONAL FAILURE DATA WERE IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE.ON JULY 12, 2005, NISSAN NOTIFIED NHTSA OF A SAFETY DEFECT ON MY 2003-2005 MURANO VEHICLES PRODUCED FROM APRIL 8, 2002 AND SEPTEMBER 24, 2004 (RECALL 05V-319).THE NOTIFICATION STATED THAT AN OPEN CIRCUIT IN THE ALTERNATOR CAN OCCUR DUE TO WIRE FATIGUE CAUSED BY MOVEMENT OF THE ROTOR COIL DURING RAPID CHANGES IN ENGINE SPEED IN VEHICLES EQUIPPED WITH A CONTINUOUSLY VARIABLE TRANSMISSION (CVT).HIGHER ENGINE COMPARTMENT TEMPERATURE IN THE MURANO COMPARED TO OTHER NISSAN MODELS MAY ALSO BE A CONTRIBUTING FACTOR TO THE WIRE FATIGUE.NISSAN ALSO REPORTED THAT WHEN THIS HAPPENS, THE CHARGE WARNING AND BRAKE WARNING LAMPS WILL ILLUMINATE AND THE BATTERY WILL BEGIN TO DISCHARGE.AFTER A SHORT TIME, THE ENGINE WILL THEN ENTER A FAIL SAFE MODE THAT LIMITS VEHICLE SPEED.VERY SHORTLY AFTER REACHING THIS CONDITION, THE ENGINE WILL STOP.NHTSA'S TESTING, HOWEVER, SHOWED THAT ALTHOUGH THE WARNING LAMPS ILLUMINATE, THE VEHICLE SPEED IS LIMITED TO ONLY 4-7 MPH RATHER THAN WHAT NHTSA CONSIDERS A FAIL SAFE MODE. NISSAN WILL INSTRUCT OWNERS TO RETURN THEIR VEHICLES TO ANY NISSAN DEALER FOR AN ALTERNATOR INSPECTION AND REPLACEMENT, IF REQUIRED.NOTE:SOME VEHICLES MAY HAVE HAD THE NEWLY DESIGNED ALTERNATOR PREVIOUSLY INSTALLED UNDER WARRANTY.CONSEQUENTLY, THIS INVESTIGATION IS CLOSED.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY AND TAKE FURTHER ACTION IF WARRANTED.
Additional source detail variants (2)
Electrical System:alternator/generator/regulator
ODI RECEIVED 14 REPORTS OF ALLEGED ENGINE STALLING DUE TO ALTERNATOR FAILURE ON MY 2003-2004 MURANO (SUBJECT) VEHICLES.ALL OF THE COMPLAINTS REPORTED THAT THE VEHICLE COULD NOT BE RESTARTED AFTER THE STALL OCCURRED.BASED ON THESE COMPLAINTS, ODI OPENED PE04-077 AND LATER UPGRADED TO EA05-006 FOR THE SUBJECT VEHICLES.DURING EA05-006, ADDITIONAL FAILURE DATA WERE IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE.ON JULY 12, 2005, NISSAN NOTIFIED NHTSA OF A SAFETY DEFECT ON MY 2003-2005 MURANO VEHICLES PRODUCED FROM APRIL 8, 2002 AND SEPTEMBER 24, 2004 (RECALL 05V-319).THE NOTIFICATION STATED THAT AN OPEN CIRCUIT IN THE ALTERNATOR CAN OCCUR DUE TO WIRE FATIGUE CAUSED BY MOVEMENT OF THE ROTOR COIL DURING RAPID CHANGES IN ENGINE SPEED IN VEHICLES EQUIPPED WITH A CONTINUOUSLY VARIABLE TRANSMISSION (CVT).HIGHER ENGINE COMPARTMENT TEMPERATURE IN THE MURANO COMPARED TO OTHER NISSAN MODELS MAY ALSO BE A CONTRIBUTING FACTOR TO THE WIRE FATIGUE.NISSAN ALSO REPORTED THAT WHEN THIS HAPPENS, THE CHARGE WARNING AND BRAKE WARNING LAMPS WILL ILLUMINATE AND THE BATTERY WILL BEGIN TO DISCHARGE.AFTER A SHORT TIME, THE ENGINE WILL THEN ENTER A FAIL SAFE MODE THAT LIMITS VEHICLE SPEED.VERY SHORTLY AFTER REACHING THIS CONDITION, THE ENGINE WILL STOP.NHTSA'S TESTING, HOWEVER, SHOWED THAT ALTHOUGH THE WARNING LAMPS ILLUMINATE, THE VEHICLE SPEED IS LIMITED TO ONLY 4-7 MPH RATHER THAN WHAT NHTSA CONSIDERS A FAIL SAFE MODE. NISSAN WILL INSTRUCT OWNERS TO RETURN THEIR VEHICLES TO ANY NISSAN DEALER FOR AN ALTERNATOR INSPECTION AND REPLACEMENT, IF REQUIRED.NOTE:SOME VEHICLES MAY HAVE HAD THE NEWLY DESIGNED ALTERNATOR PREVIOUSLY INSTALLED UNDER WARRANTY.CONSEQUENTLY, THIS INVESTIGATION IS CLOSED.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY AND TAKE FURTHER ACTION IF WARRANTED.
Electrical System
ODI RECEIVED 14 REPORTS OF ALLEGED ENGINE STALLING DUE TO ALTERNATOR FAILURE ON MY 2003-2004 MURANO (SUBJECT) VEHICLES.ALL OF THE COMPLAINTS REPORTED THAT THE VEHICLE COULD NOT BE RESTARTED AFTER THE STALL OCCURRED.BASED ON THESE COMPLAINTS, ODI OPENED PE04-077 AND LATER UPGRADED TO EA05-006 FOR THE SUBJECT VEHICLES.DURING EA05-006, ADDITIONAL FAILURE DATA WERE IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE.ON JULY 12, 2005, NISSAN NOTIFIED NHTSA OF A SAFETY DEFECT ON MY 2003-2005 MURANO VEHICLES PRODUCED FROM APRIL 8, 2002 AND SEPTEMBER 24, 2004 (RECALL 05V-319).THE NOTIFICATION STATED THAT AN OPEN CIRCUIT IN THE ALTERNATOR CAN OCCUR DUE TO WIRE FATIGUE CAUSED BY MOVEMENT OF THE ROTOR COIL DURING RAPID CHANGES IN ENGINE SPEED IN VEHICLES EQUIPPED WITH A CONTINUOUSLY VARIABLE TRANSMISSION (CVT).HIGHER ENGINE COMPARTMENT TEMPERATURE IN THE MURANO COMPARED TO OTHER NISSAN MODELS MAY ALSO BE A CONTRIBUTING FACTOR TO THE WIRE FATIGUE.NISSAN ALSO REPORTED THAT WHEN THIS HAPPENS, THE CHARGE WARNING AND BRAKE WARNING LAMPS WILL ILLUMINATE AND THE BATTERY WILL BEGIN TO DISCHARGE.AFTER A SHORT TIME, THE ENGINE WILL THEN ENTER A FAIL SAFE MODE THAT LIMITS VEHICLE SPEED.VERY SHORTLY AFTER REACHING THIS CONDITION, THE ENGINE WILL STOP.NHTSA'S TESTING, HOWEVER, SHOWED THAT ALTHOUGH THE WARNING LAMPS ILLUMINATE, THE VEHICLE SPEED IS LIMITED TO ONLY 4-7 MPH RATHER THAN WHAT NHTSA CONSIDERS A FAIL SAFE MODE. NISSAN WILL INSTRUCT OWNERS TO RETURN THEIR VEHICLES TO ANY NISSAN DEALER FOR AN ALTERNATOR INSPECTION AND REPLACEMENT, IF REQUIRED.NOTE:SOME VEHICLES MAY HAVE HAD THE NEWLY DESIGNED ALTERNATOR PREVIOUSLY INSTALLED UNDER WARRANTY.CONSEQUENTLY, THIS INVESTIGATION IS CLOSED.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY AND TAKE FURTHER ACTION IF WARRANTED.
ODI OPENED PE04-077 BASED ON 14 REPORTS OF ALLEGED ENGINE STALLING DUE TO ALTERNATOR FAILURE.ALL OF THE COMPLAINTS REPORTED THAT THE VEHICLE COULD NOT BE RESTARTED AFTER THE STALL OCCURRED.DURING PE04-077, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE . DURING THE INVESTIGATION, NISSAN IDENTIFIED THAT THERE HAD BEEN ALTERNATOR WARRANTY REPLACEMENTS DUE TO AN OPEN CIRCUIT IN THE ROTOR COIL CAUSED BY WIRE FATIGUE. ODI?S ANALYSIS SHOWS FAILURE RATES THAT ARE OF CONCERN TO ODI AND INDICATES THAT THE ALLEGED DEFECT IS CONTINUING TO OCCUR IN THE SUBJECT VEHICLES.ODI'S ANALYSIS ALSO SHOWS THAT NEARLY ALL OF THE ALTERNATOR WARRANTY CLAIMS SUBMITTED RESULTED IN ENGINE STALLS AND AT LEAST 25% OF THE ENGINE STALLS RESULTED IN A NO RESTART CONDITION.HOWEVER, IN 71% OF THE WARRANTY DATA SUBMITTED, ODI HAS NOT BEEN ABLE TO DETERMINE IF THE CONSUMER COULD RESTART THE VEHICLE.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER INVESTIGATE THIS CONCERN, TO ASSESS THE POTENTIAL SAFETY-RELATED CONSEQUENCES, AND TO DETERMINE THE SCOPE OF THE AFFECTED POPULATION.
Additional source detail variants (2)
Electrical System:alternator/generator/regulator
ODI OPENED PE04-077 BASED ON 14 REPORTS OF ALLEGED ENGINE STALLING DUE TO ALTERNATOR FAILURE.ALL OF THE COMPLAINTS REPORTED THAT THE VEHICLE COULD NOT BE RESTARTED AFTER THE STALL OCCURRED.DURING PE04-077, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE . DURING THE INVESTIGATION, NISSAN IDENTIFIED THAT THERE HAD BEEN ALTERNATOR WARRANTY REPLACEMENTS DUE TO AN OPEN CIRCUIT IN THE ROTOR COIL CAUSED BY WIRE FATIGUE. ODI?S ANALYSIS SHOWS FAILURE RATES THAT ARE OF CONCERN TO ODI AND INDICATES THAT THE ALLEGED DEFECT IS CONTINUING TO OCCUR IN THE SUBJECT VEHICLES.ODI'S ANALYSIS ALSO SHOWS THAT NEARLY ALL OF THE ALTERNATOR WARRANTY CLAIMS SUBMITTED RESULTED IN ENGINE STALLS AND AT LEAST 25% OF THE ENGINE STALLS RESULTED IN A NO RESTART CONDITION.HOWEVER, IN 71% OF THE WARRANTY DATA SUBMITTED, ODI HAS NOT BEEN ABLE TO DETERMINE IF THE CONSUMER COULD RESTART THE VEHICLE.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER INVESTIGATE THIS CONCERN, TO ASSESS THE POTENTIAL SAFETY-RELATED CONSEQUENCES, AND TO DETERMINE THE SCOPE OF THE AFFECTED POPULATION.
Electrical System
ODI OPENED PE04-077 BASED ON 14 REPORTS OF ALLEGED ENGINE STALLING DUE TO ALTERNATOR FAILURE.ALL OF THE COMPLAINTS REPORTED THAT THE VEHICLE COULD NOT BE RESTARTED AFTER THE STALL OCCURRED.DURING PE04-077, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE . DURING THE INVESTIGATION, NISSAN IDENTIFIED THAT THERE HAD BEEN ALTERNATOR WARRANTY REPLACEMENTS DUE TO AN OPEN CIRCUIT IN THE ROTOR COIL CAUSED BY WIRE FATIGUE. ODI?S ANALYSIS SHOWS FAILURE RATES THAT ARE OF CONCERN TO ODI AND INDICATES THAT THE ALLEGED DEFECT IS CONTINUING TO OCCUR IN THE SUBJECT VEHICLES.ODI'S ANALYSIS ALSO SHOWS THAT NEARLY ALL OF THE ALTERNATOR WARRANTY CLAIMS SUBMITTED RESULTED IN ENGINE STALLS AND AT LEAST 25% OF THE ENGINE STALLS RESULTED IN A NO RESTART CONDITION.HOWEVER, IN 71% OF THE WARRANTY DATA SUBMITTED, ODI HAS NOT BEEN ABLE TO DETERMINE IF THE CONSUMER COULD RESTART THE VEHICLE.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER INVESTIGATE THIS CONCERN, TO ASSESS THE POTENTIAL SAFETY-RELATED CONSEQUENCES, AND TO DETERMINE THE SCOPE OF THE AFFECTED POPULATION.
2004 Nissan Murano Problems, Complaints & Recalls | Skip That Year
Illustration