NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
265 reportsClear category filter22,000 miles · Jul 6, 2005
Power Train
I HAVE HAD MY MURANO 1 YEAR AND HAD NO PROBLEMS UNTIL NOW. IT IS A 2003 AND HAS 22,000 MILES ON IT. WE WERE ON VACATION ABOUT 350 MILES FROM HOME AND I NOTICED WHAT I THOUGHT WAS THE TRANSMISSION ACTING UP. IT JUST CONTINUED TO GET WORSE. I WOULD STOP AT A RED LIGHT AND DEPRESS THE ACCELATOR AND NOTHING WOULD HAPPEN UNTIL ABOUT …
Read full complaint
I HAVE HAD MY MURANO 1 YEAR AND HAD NO PROBLEMS UNTIL NOW. IT IS A 2003 AND HAS 22,000 MILES ON IT. WE WERE ON VACATION ABOUT 350 MILES FROM HOME AND I NOTICED WHAT I THOUGHT WAS THE TRANSMISSION ACTING UP. IT JUST CONTINUED TO GET WORSE. I WOULD STOP AT A RED LIGHT AND DEPRESS THE ACCELATOR AND NOTHING WOULD HAPPEN UNTIL ABOUT 1 MINUTE LATER. LUCKILY WE MADE IT IN TO A NISSAN DEALER AND THEY CHECKED IT OUT AND GOT WITH NISSAN TECH SUPPORT. THEY VERIFIED IT WAS THE TRANSMISSION. THEY ARE GOING TO REPLACE THE ENTIRE TRANSMISSION WITH A NEW ONE. THANK GOODNESS IT IS UNDER WARRANTY! THE NISSAN DEALERSHIP RENTED ME A CAR TO GET BACK HOME FROM VACATION AND WE WILL HAVE TO DRIVE 350 MILES BACK TO PICK UP MY MURANO IN ABOUT 3 TO 4 DAYS.
NHTSA ODI #10127592
19,000 miles · Jun 29, 2005
Power Train
DT: THE CONTACT OWNS A 2003 NISSAN MORANO. THE VEHICLE INTERMEDIATLEY WILL NOT ACCELERATE. ITS LIKE YOU HAVE TO PUMP THE GAS PEDAL TO GET IT TO GO. TOOK TO DEALER 5 OR 6 TIMES. THEY RESET THE COMPUTER AND MOVED TIME TO THE TRANSMISSION. AFTER THAT THEY KEEP SAYING IT WAS FIXED.
NHTSA ODI #10127075
85,500 miles · Jun 8, 2005
Power Train
WITH NO WARNING ON A CROWDED INTERSTATE THE VEHICLE LOST ALL POWER TO THE DRIVETRAIN. VEHICLE WOULD REV IN PARK BUT WOULD DO NOTHING IN DRIVE OR REVERSE. VERY BUSY INTERESTATE AND ALMOST HIT IN REAR AS CAR COULD NOT MOE OUT OF TRAFFIC. DEALER SAYS CVT TRANSMISSION FAILED. DEALER CAN NOT TELL ME WHAT WAS WRONG WITH THE CVT AN…
Read full complaint
WITH NO WARNING ON A CROWDED INTERSTATE THE VEHICLE LOST ALL POWER TO THE DRIVETRAIN. VEHICLE WOULD REV IN PARK BUT WOULD DO NOTHING IN DRIVE OR REVERSE. VERY BUSY INTERESTATE AND ALMOST HIT IN REAR AS CAR COULD NOT MOE OUT OF TRAFFIC. DEALER SAYS CVT TRANSMISSION FAILED. DEALER CAN NOT TELL ME WHAT WAS WRONG WITH THE CVT AND JUST SAYS IT NEEDS REPLACED.
NHTSA ODI #10124621
66,000 miles · May 31, 2005
Power Train
TRANSFER CASE FOR AWD FAILURE AT 66,000 MILES (AWD FUNCTION USED LESS THAN 10 TIMES IN VEHICLES HISTORY). OBSERVERED GRINGING POPING NIOSE AND LOCKED UP VIECHELE. THE TRANSFER CASE HAS BEEN BACK-ORDERED FOR SEVEN WEEKS. THERE WAS NO INDICATION OF A PROBLEM PRIOR TO FAILURE. CONCERNED REGARDING FAILURE IN HIGHWAY DRIVING*LSJ
NHTSA ODI #10122522
66,000 miles · May 31, 2005
Power Train
TRANSFER CASE FOR AWD FAILURE AT 66,000 MILES (AWD OPTION USED LESS THAN APPROXIMATELY 12 TIMES IN VEHICLE'S HISTORY). GRINGING POPING NIOSE AND LOCKED UP VIECHELE. TRANSFER CASE HAS BEEN BACK-ORDERED FOR SEVEN WEEKS! THERE WAS NO INDICATION OF A PROBLEM PRIOR TO FAILURE. *LSJ
NHTSA ODI #10122518
30,000 miles · May 13, 2005
Electrical SystemEquipmentFuel System, Other
IN FEBRUARY 2005 THE ALTERNATOR FAILED TO CHARGE THE BATTERY AND THE CAR SLOWED TO A COMPLETE STOP AND THE BATTERY DIED IN THE MIDDLE OF A BUSY INTERSECTION. I HAD TO TOW THE CAR TO THE NEAREST DEALERSHIP AND THE CAR WAS REPAIRED 48 HOURS LATER. IN MARCH 2005 THE GAS TANK LID WOULDN'T OPEN AND THE CAR WAS RUNNING OUT OF GAS. …
Read full complaint
IN FEBRUARY 2005 THE ALTERNATOR FAILED TO CHARGE THE BATTERY AND THE CAR SLOWED TO A COMPLETE STOP AND THE BATTERY DIED IN THE MIDDLE OF A BUSY INTERSECTION. I HAD TO TOW THE CAR TO THE NEAREST DEALERSHIP AND THE CAR WAS REPAIRED 48 HOURS LATER. IN MARCH 2005 THE GAS TANK LID WOULDN'T OPEN AND THE CAR WAS RUNNING OUT OF GAS. I DROVE THE CAR TO THE DEALERSHIP AND IT TOOK 48 HOURS TO REPAIR. HOWEVER, THE "REPAIR" WAS DONE BY PRYING THE LID OPEN AND I STILL HAVE NOT RECIEVED THE NEW PART. IN MAY 2005 THE TRANSMISSION FAILED IN THE MIDDLE OF A BUSY INTERSECTION AND I HAD TO TOW THE CAR TO THE DEALERSHIP. THEY STILL HAVE THE CAR AND EXPECT TO HAVE IT FOR TWO WEEKS AT LEAST. THEY CANNOT GUARENTEE THAT THEY WILL PAY FOR THE RENTAL CAR COSTS WHICH WILL AMOUNT TO AT LEAST $350 AT $25 A DAY. THIS CAR ONLY HAS 35,000 MILES ON IT.
NHTSA ODI #10120902
Mileage unknown · Apr 11, 2005
Electrical SystemExterior LightingPower Train
BATTERY AND BRAKE INDICATOR LIGHTS ON DASHBOARD CAME ON. NEXT EVENING (APPROXIMATELY 10 MILES LATER), THE LIGHTS DIMMED AND ELECTRICAL ACCESSORIES FAILED WHILE DRIVING DOWN A 4 LANE ROAD. MOMENTS LATER THE CAR WENT INTO "LIMP MODE" (LESS THAN 5 MPH). I WAS ABLE TO NAVIGATE OFF THE ROAD, BUT COULDN'T MOVE VERY FAR. THE ENG…
Read full complaint
BATTERY AND BRAKE INDICATOR LIGHTS ON DASHBOARD CAME ON. NEXT EVENING (APPROXIMATELY 10 MILES LATER), THE LIGHTS DIMMED AND ELECTRICAL ACCESSORIES FAILED WHILE DRIVING DOWN A 4 LANE ROAD. MOMENTS LATER THE CAR WENT INTO "LIMP MODE" (LESS THAN 5 MPH). I WAS ABLE TO NAVIGATE OFF THE ROAD, BUT COULDN'T MOVE VERY FAR. THE ENGINE WOULD RUN FINE (WHILE THE CAR WAS IN PARK OR NEUTRAL), BUT WOULD IMMEDIATELY GO INTO LIMP MODE WHEN SHIFTED INTO GEAR. FOLLOWING A COUPLE OF RESTARTS ... THE BATTERY FINALLY WENT COMPLETELY DEAD AND COULDN'T RESTART ENGINE. TOWED TO NISSAN ... REPLACED ALTERNATOR.*AK
NHTSA ODI #10116763
23,459 miles · Nov 24, 2004
Power Train
2003 NISSAN MURANO TRANSMISSION FAILURE WITH LESS THAN 24,000 MILES. TRANSMISSION FAILED, WHEELS LOCKED, UNABLE TO MOVE OR PUSH THE VEHICLE. THANKFULLY, IT HAPPENED APPROACHING A RED LIGHT, NO ACCIDENT INVOLVED. *NM
NHTSA ODI #10100473
26,000 miles · Oct 21, 2004
Power Train
TRANSFER CASE FOR AWD FAILURE 2ND TIME IN 26,000 MILES (1ST 8,000 MILES, 2ND 26,000 MILES). IN BOTH CASES GRINGING POPING NIOSE AND LOCKED UP VIECHELE HAD TO BE TOWED IN TO DEALERSHIP. THERE WAS NO INDICATION OF A PROBLEM PRIOR TO FAILURE.
NHTSA ODI #10096149
36,852 miles · Sep 21, 2004
Power Train
CRACKED TRANSFER CASE OCCURRED TWICE ON 2003 NISSAN MURANO; AUG 27, 2004 & SEP 24 2003. CONCERN IS FUTURE INCIDENTS MAY OCCUR WHILE DRIVING ON INTERSTATE HIGHWAYS CAUSING ACCIDENTS. OTHER INTERNET SITE FORUMS INDICATED FAILURES BUT DID NOT SUBMIT COMPLAINTS TO NHTSA.*AK
NHTSA ODI #10092984
Official recalls
6May 19, 2009
NISSAN IS RECALLING 362,891 MY 2003-2007 MURANO VEHICLES. THE INTAKE AIR DUCTS, WHICH ARE CONNECTED TO THE INTERMEDIATE RESONATOR IN THE AIR INTAKE SYSTEM OF THE ENGINE, MAY SEPARATE FROM THE RESONATOR WITH ENGINE MOVEMENT. THIS SEPARATION OCCURS DUE TO THE PREMATURE AGING OF THE MATERIAL USED IN THE INTAKE AIR DUCTS WHICH CAUSES EXCESSIVE SHRINKING.
Consequence & remedy
Consequence: ENGINE MAY STALL INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT AND REPLACE/REPAIR THE APPROPRIATE COMPONENTS FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 24, 2009. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Feb 13, 2006
ON SOME SPORT UTILITY VEHICLES, IN CERTAIN HIGH SPEED FRONTAL CRASHES, THE WEBBING OF A REAR OUTBOARD SEAT BELT MAY CONTACT THE REAR SEAT BACK HINGE WHERE IT CAN BE CUT BY THE SHARP EDGE OF THE METAL PORTION OF THE HINGE.
Consequence & remedy
Consequence: IF THE WEBBING IS COMPLETELY SEPARATED, IT CAN INCREASE THE RISK OF INJURY TO AN OCCUPANT IN A CRASH.
Remedy: DEALERS WILL INSTALL PROTECTORS OVER THE WEBBING OF THE REAR SEAT BELTS. THE RECALL BEGAN ON MARCH 20, 2006. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Jan 10, 2006
ON CERTAIN SPORT UTILITY VEHICLES, DUE TO THE LOCATION OF THE FORWARD EDGE OF THE FUEL TANK, IN THE EVENT THAT A VEHICLE FRONT TIRE RUNS OVER A SMALL, SHARP OBJECT IN THE ROAD, CATCHES IT AND PROPELS IT TOWARDS THE REAR OF THE VEHICLE, IT MAY STRIKE AND PUNCTURE THE FUEL TANK.
Consequence & remedy
Consequence: A PUNCTURED TANK COULD INCREASE THE RISK OF A FIRE.
Remedy: DEALERS WILL INSTALL PROTECTORS IN FRONT OF THE TANK FREE OF CHARGE. THE RECALL BEGAN ON MARCH 20, 2006. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Jul 14, 2005
ON CERTAIN SPORT UTILITY VEHICLES, THERE IS A POSSIBILITY THAT A WIRE BREAKING INSIDE THE ALTERNATOR COULD STOP THE BATTERY FROM CHARGING.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE CHARGER WARNING AND BRAKE WARNING LAMPS WILL IMMEDIATELY COME ON AND THE BATTERY WILL BEGIN TO DISCHARGE. AFTER A SHORT TIME, THE ENGINE WILL GO INTO A "FALL SAFE" CONDITION WHICH WILL LIMIT VEHICLE SPEED. THE ENGINE WILL STOP RUNNING WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSPECT AND REPLACE THE ALTERNATOR WITH A NEW VERSION WHICH HAS BEEN MODIFIED TO PREVENT MOVEMENT OF THE COIL. THE RECALL BEGAN ON AUGUST 1, 2005. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Nov 17, 2003
ON CERTAIN PASSENGER VEHICLES, THE CIRCUIT BOARD FOR THE CRANK POSITION SENSOR OR CAM POSITION SENSOR MAY HAVE AN IMPROPER SOLDER JOINT DUE TO SOLDER DEFORMATION CAUSED BY HEAT STRESS ACCELERATED BY THE EXISTENCE OF FLUX RESIDUE DURING THE SOLDERING PROCESS.
Consequence & remedy
Consequence: THIS COULD CAUSE THE "SERVICE ENGINE SOON" WARNING LIGHT TO COME ON, CREATE A NO START CONDITION, CAUSE REDUCED ENGINE POWER, OR CAUSE THE ENGINE TO STOP RUNNING WITHOUT WARNING DURING VEHICLE OPERATION, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE CRANK POSITION SENSORS. CAMSHAFT POSITION SENSOR(S), AND IN SOME CASES, THE VARIABLE TIMING CONTROL SENSOR(S). VEHICLES INVOLVED IN A PREVIOUS RECALL CAMPAIGN, 01V357, ARE ALSO INCLUDED IN THIS NEW CAMPAIGN. THE REPLACEMENT SENSORS USED IN THAT CAMPAIGN ARE ALSO AFFECTED. OWNER NOTIFICATION BEGAN ON DECEMBER 22, 2003. OWNERS SHOULD CONTACT NISSAN AT 1-800-647-7261 OR INFINITI AT 1-800-662-6200.
Mar 31, 2003
ON CERTAIN SPORT UTILITY VEHICLES, THE NUT THAT ATTACHES THE TRANSMISSION GEAR SELECTOR SHAFT TO THE CONTROL VALVE LEVER IN THE TRANSMISSION MAY NOT BE ADEQUATELY TIGHTENED. THIS COULD RESULT IN THE TRANSMISSION NOT ACTUALLY BEING IN THE GEAR INDICATED BY THE GEAR SELECTOR LEVER. IN ADDITION, THE TRANSMISSION POSITION DISPLAY IN THE INSTRUMENT PANEL MAY NOT BE ON OR MAY BE INCORRECT.
Consequence & remedy
Consequence: IF THE GEAR DISPLAYED IS DIFFERENT FROM THE GEAR ENGAGED, THIS COULD RESULT IN UNEXPECTED VEHICLE MOVEMENT AND A CRASH.
Remedy: DEALERS WILL CHECK THE AFFECTED NUT IN THE TRANSMISSION SHIFT LEVER LINKAGE, AND TIGHTEN IT IF NECESSARY. OWNER NOTIFICATION BEGAN APRIL 15, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NISSAN AT 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4PE08065 · Driver Seat Anchor Failure
Opened Nov 18, 2008 · Closed Jul 2, 2009
Status: closed (inferred from source dates) · Seats
THIS INVESTIGATION CONCERNS STRUCTURAL FAILURE OF THE ANCHOR/BRACKET ON THE LEFT REAR SIDE OF THE DRIVER'S SEAT.THE CONCERN IS THAT SUCH FAILURES MAY ALTER THE DRIVER'S SEATED POSITION SO AS TO REDUCE EFFECTIVENESS OF THE OCCUPANT PROTECTION SYSTEM OR POTENTIALLY COMPROMISE VEHICLE CONTROL.FAILURE OF THE SUBJECT ANCHOR BRACKET RESULTS FROM METAL FATIGUE AND CAUSES REARWARD TILTING OF THE DRIVER'S SEAT.THESE FAILURES USUALLY OCCUR DURING DRIVER INGRESS BUT MAY ALSO OCCUR WHILE THE VEHICLE IS BEING OPERATED.THE SAFETY RELATED CONCERNS DURING ACTUAL VEHICLE USE WERE NOT VALIDATED BY THIS INVESTIGATION.WHILE THE NUMBER OF COMPLAINTS OF THIS PROBLEM IS RELATIVELY HIGH, ONLY THREE VERY MINOR, UNDOCUMENTED INJURIES WERE REPORTED.THE REPORTED INJURIES OCCURRED DURING DRIVER INGRESS, NOT WHILE THE VEHICLE WAS IN MOTION.INVESTIGATION DISCLOSED THAT THE APPARENT RISK OF COMPROMISE TO VEHICLE CONTROL HAS NOT BEEN DEMONSTRATED.INVESTIGATION ALSO DISCLOSED THAT THE APPARENT RISK OF COLLAPSE OF THE DRIVER'S SEAT BACK HAS NOT BEEN DEMONSTRATEDA SAFETY RELATED DEFECT TREND WAS NOT IDENTIFIED AND THIS INVESTIGATION HAS BEEN CLOSED.
PE05050 · Fuel Tank Punctures From Road Debris
Opened Sep 13, 2005 · Closed Jan 31, 2006
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly; Fuel System, Other:storage:tank Assembly
ODI OPENED A PRELIMINARY EVALUATION BASED ON FOUR VEHICLE OWNER QUESTIONNAIRES (VOQ'S) INDICATING THAT THE FUEL TANKS WEREPUNCTURED BY ROAD DEBRIS UNDER NORMAL, NON OFF-ROAD DRIVING CONDITIONS.AS OF NOVEMBER 30, 2005, THE COMPLAINT TOTAL INCREASED TO 12.NISSAN SUPPLIED ODI WITH 31 COMPLAINTS OF FUEL TANK PUNCTURES, INCLUDING 26 NOT PREVIOUSLY KNOWN TO ODI FROM THE VOQ RECORDS. IN A LETTER DATED JANUARY 9, 2006, NISSAN NORTH AMERICA, INC. NOTIFIED ODI OF ITS PLAN TO RECALL APPROXIMATELY 209,000 MODEL YEAR 2003 - 2006 NISSAN MURANO VEHICLES BUILT FROM APRIL 24, 2002 (START OF PRODUCTION OF MY 2003) THROUGH NOVEMBER 24, 2005 (INCLUDING A PORTION OF MY 2006 VEHICLES) TO CORRECT A DEFICIENCY IN FUEL TANK SHIELDING FROM ROAD DEBRIS.THIS RECALL HAS BEEN DESIGNATED NHTSA NO. 06V-003.RECALLED VEHICLES WILL BE FITTED WITH PROTECTIVE SHIELDING FOR THE FRONTAL PORTION OF THE FUEL TANK TO REDUCE THE POSSIBILITY OF PUNCTURE BY PROJECTILES FROM THE FRONT WHEELS.ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED.
Additional source detail variants (2)
Fuel System, Gasoline:storage:tank Assembly
ODI OPENED A PRELIMINARY EVALUATION BASED ON FOUR VEHICLE OWNER QUESTIONNAIRES (VOQ'S) INDICATING THAT THE FUEL TANKS WEREPUNCTURED BY ROAD DEBRIS UNDER NORMAL, NON OFF-ROAD DRIVING CONDITIONS.AS OF NOVEMBER 30, 2005, THE COMPLAINT TOTAL INCREASED TO 12.NISSAN SUPPLIED ODI WITH 31 COMPLAINTS OF FUEL TANK PUNCTURES, INCLUDING 26 NOT PREVIOUSLY KNOWN TO ODI FROM THE VOQ RECORDS. IN A LETTER DATED JANUARY 9, 2006, NISSAN NORTH AMERICA, INC. NOTIFIED ODI OF ITS PLAN TO RECALL APPROXIMATELY 209,000 MODEL YEAR 2003 - 2006 NISSAN MURANO VEHICLES BUILT FROM APRIL 24, 2002 (START OF PRODUCTION OF MY 2003) THROUGH NOVEMBER 24, 2005 (INCLUDING A PORTION OF MY 2006 VEHICLES) TO CORRECT A DEFICIENCY IN FUEL TANK SHIELDING FROM ROAD DEBRIS.THIS RECALL HAS BEEN DESIGNATED NHTSA NO. 06V-003.RECALLED VEHICLES WILL BE FITTED WITH PROTECTIVE SHIELDING FOR THE FRONTAL PORTION OF THE FUEL TANK TO REDUCE THE POSSIBILITY OF PUNCTURE BY PROJECTILES FROM THE FRONT WHEELS.ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED.
Fuel System, Other:storage:tank Assembly
ODI OPENED A PRELIMINARY EVALUATION BASED ON FOUR VEHICLE OWNER QUESTIONNAIRES (VOQ'S) INDICATING THAT THE FUEL TANKS WEREPUNCTURED BY ROAD DEBRIS UNDER NORMAL, NON OFF-ROAD DRIVING CONDITIONS.AS OF NOVEMBER 30, 2005, THE COMPLAINT TOTAL INCREASED TO 12.NISSAN SUPPLIED ODI WITH 31 COMPLAINTS OF FUEL TANK PUNCTURES, INCLUDING 26 NOT PREVIOUSLY KNOWN TO ODI FROM THE VOQ RECORDS. IN A LETTER DATED JANUARY 9, 2006, NISSAN NORTH AMERICA, INC. NOTIFIED ODI OF ITS PLAN TO RECALL APPROXIMATELY 209,000 MODEL YEAR 2003 - 2006 NISSAN MURANO VEHICLES BUILT FROM APRIL 24, 2002 (START OF PRODUCTION OF MY 2003) THROUGH NOVEMBER 24, 2005 (INCLUDING A PORTION OF MY 2006 VEHICLES) TO CORRECT A DEFICIENCY IN FUEL TANK SHIELDING FROM ROAD DEBRIS.THIS RECALL HAS BEEN DESIGNATED NHTSA NO. 06V-003.RECALLED VEHICLES WILL BE FITTED WITH PROTECTIVE SHIELDING FOR THE FRONTAL PORTION OF THE FUEL TANK TO REDUCE THE POSSIBILITY OF PUNCTURE BY PROJECTILES FROM THE FRONT WHEELS.ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED.
EA05006 · Alternator Failure / Engine Stalling
Opened Mar 25, 2005 · Closed Aug 17, 2005
Status: closed (inferred from source dates) · Electrical System; Electrical System:alternator/generator/regulator
ODI RECEIVED 14 REPORTS OF ALLEGED ENGINE STALLING DUE TO ALTERNATOR FAILURE ON MY 2003-2004 MURANO (SUBJECT) VEHICLES.ALL OF THE COMPLAINTS REPORTED THAT THE VEHICLE COULD NOT BE RESTARTED AFTER THE STALL OCCURRED.BASED ON THESE COMPLAINTS, ODI OPENED PE04-077 AND LATER UPGRADED TO EA05-006 FOR THE SUBJECT VEHICLES.DURING EA05-006, ADDITIONAL FAILURE DATA WERE IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE.ON JULY 12, 2005, NISSAN NOTIFIED NHTSA OF A SAFETY DEFECT ON MY 2003-2005 MURANO VEHICLES PRODUCED FROM APRIL 8, 2002 AND SEPTEMBER 24, 2004 (RECALL 05V-319).THE NOTIFICATION STATED THAT AN OPEN CIRCUIT IN THE ALTERNATOR CAN OCCUR DUE TO WIRE FATIGUE CAUSED BY MOVEMENT OF THE ROTOR COIL DURING RAPID CHANGES IN ENGINE SPEED IN VEHICLES EQUIPPED WITH A CONTINUOUSLY VARIABLE TRANSMISSION (CVT).HIGHER ENGINE COMPARTMENT TEMPERATURE IN THE MURANO COMPARED TO OTHER NISSAN MODELS MAY ALSO BE A CONTRIBUTING FACTOR TO THE WIRE FATIGUE.NISSAN ALSO REPORTED THAT WHEN THIS HAPPENS, THE CHARGE WARNING AND BRAKE WARNING LAMPS WILL ILLUMINATE AND THE BATTERY WILL BEGIN TO DISCHARGE.AFTER A SHORT TIME, THE ENGINE WILL THEN ENTER A FAIL SAFE MODE THAT LIMITS VEHICLE SPEED.VERY SHORTLY AFTER REACHING THIS CONDITION, THE ENGINE WILL STOP.NHTSA'S TESTING, HOWEVER, SHOWED THAT ALTHOUGH THE WARNING LAMPS ILLUMINATE, THE VEHICLE SPEED IS LIMITED TO ONLY 4-7 MPH RATHER THAN WHAT NHTSA CONSIDERS A FAIL SAFE MODE. NISSAN WILL INSTRUCT OWNERS TO RETURN THEIR VEHICLES TO ANY NISSAN DEALER FOR AN ALTERNATOR INSPECTION AND REPLACEMENT, IF REQUIRED.NOTE:SOME VEHICLES MAY HAVE HAD THE NEWLY DESIGNED ALTERNATOR PREVIOUSLY INSTALLED UNDER WARRANTY.CONSEQUENTLY, THIS INVESTIGATION IS CLOSED.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY AND TAKE FURTHER ACTION IF WARRANTED.
Additional source detail variants (2)
Electrical System:alternator/generator/regulator
ODI RECEIVED 14 REPORTS OF ALLEGED ENGINE STALLING DUE TO ALTERNATOR FAILURE ON MY 2003-2004 MURANO (SUBJECT) VEHICLES.ALL OF THE COMPLAINTS REPORTED THAT THE VEHICLE COULD NOT BE RESTARTED AFTER THE STALL OCCURRED.BASED ON THESE COMPLAINTS, ODI OPENED PE04-077 AND LATER UPGRADED TO EA05-006 FOR THE SUBJECT VEHICLES.DURING EA05-006, ADDITIONAL FAILURE DATA WERE IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE.ON JULY 12, 2005, NISSAN NOTIFIED NHTSA OF A SAFETY DEFECT ON MY 2003-2005 MURANO VEHICLES PRODUCED FROM APRIL 8, 2002 AND SEPTEMBER 24, 2004 (RECALL 05V-319).THE NOTIFICATION STATED THAT AN OPEN CIRCUIT IN THE ALTERNATOR CAN OCCUR DUE TO WIRE FATIGUE CAUSED BY MOVEMENT OF THE ROTOR COIL DURING RAPID CHANGES IN ENGINE SPEED IN VEHICLES EQUIPPED WITH A CONTINUOUSLY VARIABLE TRANSMISSION (CVT).HIGHER ENGINE COMPARTMENT TEMPERATURE IN THE MURANO COMPARED TO OTHER NISSAN MODELS MAY ALSO BE A CONTRIBUTING FACTOR TO THE WIRE FATIGUE.NISSAN ALSO REPORTED THAT WHEN THIS HAPPENS, THE CHARGE WARNING AND BRAKE WARNING LAMPS WILL ILLUMINATE AND THE BATTERY WILL BEGIN TO DISCHARGE.AFTER A SHORT TIME, THE ENGINE WILL THEN ENTER A FAIL SAFE MODE THAT LIMITS VEHICLE SPEED.VERY SHORTLY AFTER REACHING THIS CONDITION, THE ENGINE WILL STOP.NHTSA'S TESTING, HOWEVER, SHOWED THAT ALTHOUGH THE WARNING LAMPS ILLUMINATE, THE VEHICLE SPEED IS LIMITED TO ONLY 4-7 MPH RATHER THAN WHAT NHTSA CONSIDERS A FAIL SAFE MODE. NISSAN WILL INSTRUCT OWNERS TO RETURN THEIR VEHICLES TO ANY NISSAN DEALER FOR AN ALTERNATOR INSPECTION AND REPLACEMENT, IF REQUIRED.NOTE:SOME VEHICLES MAY HAVE HAD THE NEWLY DESIGNED ALTERNATOR PREVIOUSLY INSTALLED UNDER WARRANTY.CONSEQUENTLY, THIS INVESTIGATION IS CLOSED.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY AND TAKE FURTHER ACTION IF WARRANTED.
Electrical System
ODI RECEIVED 14 REPORTS OF ALLEGED ENGINE STALLING DUE TO ALTERNATOR FAILURE ON MY 2003-2004 MURANO (SUBJECT) VEHICLES.ALL OF THE COMPLAINTS REPORTED THAT THE VEHICLE COULD NOT BE RESTARTED AFTER THE STALL OCCURRED.BASED ON THESE COMPLAINTS, ODI OPENED PE04-077 AND LATER UPGRADED TO EA05-006 FOR THE SUBJECT VEHICLES.DURING EA05-006, ADDITIONAL FAILURE DATA WERE IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE.ON JULY 12, 2005, NISSAN NOTIFIED NHTSA OF A SAFETY DEFECT ON MY 2003-2005 MURANO VEHICLES PRODUCED FROM APRIL 8, 2002 AND SEPTEMBER 24, 2004 (RECALL 05V-319).THE NOTIFICATION STATED THAT AN OPEN CIRCUIT IN THE ALTERNATOR CAN OCCUR DUE TO WIRE FATIGUE CAUSED BY MOVEMENT OF THE ROTOR COIL DURING RAPID CHANGES IN ENGINE SPEED IN VEHICLES EQUIPPED WITH A CONTINUOUSLY VARIABLE TRANSMISSION (CVT).HIGHER ENGINE COMPARTMENT TEMPERATURE IN THE MURANO COMPARED TO OTHER NISSAN MODELS MAY ALSO BE A CONTRIBUTING FACTOR TO THE WIRE FATIGUE.NISSAN ALSO REPORTED THAT WHEN THIS HAPPENS, THE CHARGE WARNING AND BRAKE WARNING LAMPS WILL ILLUMINATE AND THE BATTERY WILL BEGIN TO DISCHARGE.AFTER A SHORT TIME, THE ENGINE WILL THEN ENTER A FAIL SAFE MODE THAT LIMITS VEHICLE SPEED.VERY SHORTLY AFTER REACHING THIS CONDITION, THE ENGINE WILL STOP.NHTSA'S TESTING, HOWEVER, SHOWED THAT ALTHOUGH THE WARNING LAMPS ILLUMINATE, THE VEHICLE SPEED IS LIMITED TO ONLY 4-7 MPH RATHER THAN WHAT NHTSA CONSIDERS A FAIL SAFE MODE. NISSAN WILL INSTRUCT OWNERS TO RETURN THEIR VEHICLES TO ANY NISSAN DEALER FOR AN ALTERNATOR INSPECTION AND REPLACEMENT, IF REQUIRED.NOTE:SOME VEHICLES MAY HAVE HAD THE NEWLY DESIGNED ALTERNATOR PREVIOUSLY INSTALLED UNDER WARRANTY.CONSEQUENTLY, THIS INVESTIGATION IS CLOSED.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY AND TAKE FURTHER ACTION IF WARRANTED.
PE04077 · Alternator Failure/ Engine Stalling
Opened Nov 19, 2004 · Closed Mar 25, 2005
Status: closed (inferred from source dates) · Electrical System; Electrical System:alternator/generator/regulator
ODI OPENED PE04-077 BASED ON 14 REPORTS OF ALLEGED ENGINE STALLING DUE TO ALTERNATOR FAILURE.ALL OF THE COMPLAINTS REPORTED THAT THE VEHICLE COULD NOT BE RESTARTED AFTER THE STALL OCCURRED.DURING PE04-077, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE . DURING THE INVESTIGATION, NISSAN IDENTIFIED THAT THERE HAD BEEN ALTERNATOR WARRANTY REPLACEMENTS DUE TO AN OPEN CIRCUIT IN THE ROTOR COIL CAUSED BY WIRE FATIGUE. ODI?S ANALYSIS SHOWS FAILURE RATES THAT ARE OF CONCERN TO ODI AND INDICATES THAT THE ALLEGED DEFECT IS CONTINUING TO OCCUR IN THE SUBJECT VEHICLES.ODI'S ANALYSIS ALSO SHOWS THAT NEARLY ALL OF THE ALTERNATOR WARRANTY CLAIMS SUBMITTED RESULTED IN ENGINE STALLS AND AT LEAST 25% OF THE ENGINE STALLS RESULTED IN A NO RESTART CONDITION.HOWEVER, IN 71% OF THE WARRANTY DATA SUBMITTED, ODI HAS NOT BEEN ABLE TO DETERMINE IF THE CONSUMER COULD RESTART THE VEHICLE.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER INVESTIGATE THIS CONCERN, TO ASSESS THE POTENTIAL SAFETY-RELATED CONSEQUENCES, AND TO DETERMINE THE SCOPE OF THE AFFECTED POPULATION.
Additional source detail variants (2)
Electrical System:alternator/generator/regulator
ODI OPENED PE04-077 BASED ON 14 REPORTS OF ALLEGED ENGINE STALLING DUE TO ALTERNATOR FAILURE.ALL OF THE COMPLAINTS REPORTED THAT THE VEHICLE COULD NOT BE RESTARTED AFTER THE STALL OCCURRED.DURING PE04-077, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE . DURING THE INVESTIGATION, NISSAN IDENTIFIED THAT THERE HAD BEEN ALTERNATOR WARRANTY REPLACEMENTS DUE TO AN OPEN CIRCUIT IN THE ROTOR COIL CAUSED BY WIRE FATIGUE. ODI?S ANALYSIS SHOWS FAILURE RATES THAT ARE OF CONCERN TO ODI AND INDICATES THAT THE ALLEGED DEFECT IS CONTINUING TO OCCUR IN THE SUBJECT VEHICLES.ODI'S ANALYSIS ALSO SHOWS THAT NEARLY ALL OF THE ALTERNATOR WARRANTY CLAIMS SUBMITTED RESULTED IN ENGINE STALLS AND AT LEAST 25% OF THE ENGINE STALLS RESULTED IN A NO RESTART CONDITION.HOWEVER, IN 71% OF THE WARRANTY DATA SUBMITTED, ODI HAS NOT BEEN ABLE TO DETERMINE IF THE CONSUMER COULD RESTART THE VEHICLE.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER INVESTIGATE THIS CONCERN, TO ASSESS THE POTENTIAL SAFETY-RELATED CONSEQUENCES, AND TO DETERMINE THE SCOPE OF THE AFFECTED POPULATION.
Electrical System
ODI OPENED PE04-077 BASED ON 14 REPORTS OF ALLEGED ENGINE STALLING DUE TO ALTERNATOR FAILURE.ALL OF THE COMPLAINTS REPORTED THAT THE VEHICLE COULD NOT BE RESTARTED AFTER THE STALL OCCURRED.DURING PE04-077, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE . DURING THE INVESTIGATION, NISSAN IDENTIFIED THAT THERE HAD BEEN ALTERNATOR WARRANTY REPLACEMENTS DUE TO AN OPEN CIRCUIT IN THE ROTOR COIL CAUSED BY WIRE FATIGUE. ODI?S ANALYSIS SHOWS FAILURE RATES THAT ARE OF CONCERN TO ODI AND INDICATES THAT THE ALLEGED DEFECT IS CONTINUING TO OCCUR IN THE SUBJECT VEHICLES.ODI'S ANALYSIS ALSO SHOWS THAT NEARLY ALL OF THE ALTERNATOR WARRANTY CLAIMS SUBMITTED RESULTED IN ENGINE STALLS AND AT LEAST 25% OF THE ENGINE STALLS RESULTED IN A NO RESTART CONDITION.HOWEVER, IN 71% OF THE WARRANTY DATA SUBMITTED, ODI HAS NOT BEEN ABLE TO DETERMINE IF THE CONSUMER COULD RESTART THE VEHICLE.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER INVESTIGATE THIS CONCERN, TO ASSESS THE POTENTIAL SAFETY-RELATED CONSEQUENCES, AND TO DETERMINE THE SCOPE OF THE AFFECTED POPULATION.
Illustration