NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
45 reportsClear category filter91,750 miles · Jul 17, 2014
EnginePower TrainVehicle Speed Control
I JUST PURCHASED THIS VEHICLE ON 7/15/14, DROVE IT HOME AND IT WOULD NOT START 7/16/14. I WAS ABLE TO GET THE VEHICLE STARTED, BUT THE SERVICE ENGINE SOON LIGHT CAME ON AND IT SHUT OFF 2 MORE TIMES WHILE PARKED. I WAS FINALLY ABLE TO GET IT STARTED AND RUNNING TO GO ABOUT MY ERRANDS. I STOPPED TO PICK SOMEONE UP FROM THE HOSP…
Read full complaint
I JUST PURCHASED THIS VEHICLE ON 7/15/14, DROVE IT HOME AND IT WOULD NOT START 7/16/14. I WAS ABLE TO GET THE VEHICLE STARTED, BUT THE SERVICE ENGINE SOON LIGHT CAME ON AND IT SHUT OFF 2 MORE TIMES WHILE PARKED. I WAS FINALLY ABLE TO GET IT STARTED AND RUNNING TO GO ABOUT MY ERRANDS. I STOPPED TO PICK SOMEONE UP FROM THE HOSPITAL AND IT STARTED UP, BUT IMMEDIATELY SHUT OFF AGAIN. EVENTUALLY, IT STARTED BUCKING AND SHUDDERING WHILE I WAS DRIVING AND SEEMED AS IF IT WAS GOING TO SHUT OFF. I WAS ABLE TO GET IT TO THE DEALER I PURCHASED IT FROM AND HE IS TAKING RESPONSIBILITY OF GETTING IT SERVICED. THE DIAGNOSIS WAS THE REAR CAM POSITION SENSOR WENT BAD. I CALLED HALDEMANN NISSAN IN HAMILTON, NJ TO INQUIRE ABOUT RECALLS, AS I KNEW THIS WAS A RECALL ISSUE AND WAS TOLD THAT MY VIN NUMBER HAD NO RECALLS. *TR
NHTSA ODI #10611281
123,000 miles · Jun 25, 2014
Engine
TL* THE CONTACT OWNS A 2003 NISSAN MURANO. THE CONTACT STATED WHILE DRIVING 40 MPH, THE VEHICLE JERKED AND THE ENGINE STALLED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE HOWEVER, THERE WAS A CLANKING NOISE COMING FROM THE ENGINE COMPARTMENT. THE VEHICLE WAS TOWED TO THE DEALER. THE TECHNICIAN DIAGNOSE THAT THE TRANSFER CASE AND…
Read full complaint
TL* THE CONTACT OWNS A 2003 NISSAN MURANO. THE CONTACT STATED WHILE DRIVING 40 MPH, THE VEHICLE JERKED AND THE ENGINE STALLED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE HOWEVER, THERE WAS A CLANKING NOISE COMING FROM THE ENGINE COMPARTMENT. THE VEHICLE WAS TOWED TO THE DEALER. THE TECHNICIAN DIAGNOSE THAT THE TRANSFER CASE AND THE CRANK CAM SENSOR WERE DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 123,000.
NHTSA ODI #10606003
90,000 miles · Aug 16, 2013
EngineEngine And Engine Cooling
TL* THE CONTACT OWNS A 2003 NISSAN MURANO. THE CONTACT STATED THAT WHILE DRIVING 25 MPH, THE VEHICLE STALLED WITH THE ILLUMINATION OF THE CHECK ENGINE LIGHT. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS WHERE IT WAS STATED THAT THE CAM SHAFT POSITION SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED AND THE MANUFAC…
Read full complaint
TL* THE CONTACT OWNS A 2003 NISSAN MURANO. THE CONTACT STATED THAT WHILE DRIVING 25 MPH, THE VEHICLE STALLED WITH THE ILLUMINATION OF THE CHECK ENGINE LIGHT. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS WHERE IT WAS STATED THAT THE CAM SHAFT POSITION SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 90,000. UPDATED 10/23/13*LJ THE CONSUMER WAS INFORMED HIS VIN WAS NOT INCLUDED IN THE RECALL.
NHTSA ODI #10535805
100,033 miles · Aug 8, 2013
Electrical SystemEngine
I WAS DRIVING MY VEHICLE AND THE ENGINE STALLED. ONCE IT HAPPENED WHEN I WAS DRIVING AT ABOUT 25MPH AND THE VEHICLE JUST SHUT OFF AND TWICE WHEN I WAS AT A RED LIGHT WHILE THE VEHICLE WAS IDLING. ALSO I WAS DRIVING IN THE HWY LAST WEEK AND THE ENGINE LST POWER FOR ABOUT 3 SECOND, PUTTING AT A GREAT RISK FOR A CRASH. THE OTHER PR…
Read full complaint
I WAS DRIVING MY VEHICLE AND THE ENGINE STALLED. ONCE IT HAPPENED WHEN I WAS DRIVING AT ABOUT 25MPH AND THE VEHICLE JUST SHUT OFF AND TWICE WHEN I WAS AT A RED LIGHT WHILE THE VEHICLE WAS IDLING. ALSO I WAS DRIVING IN THE HWY LAST WEEK AND THE ENGINE LST POWER FOR ABOUT 3 SECOND, PUTTING AT A GREAT RISK FOR A CRASH. THE OTHER PROBLEM I AM HAVING IS THE PASSENGER DOOR ACTUATOR THAT STOPPED WORKING SO WHEN I LOCK MY CAR THAT WON'T LOCK PUTTING MY VEHICLE AT A RISK FOR BEING STOLEN. I CALLED NISSAN CORP BECAUSE I KNEW THAT WAS A RECALL ID # 78963 - ENGINE AND ENGINE NISSAN IS RECALLING 362,891 MY 2003-2007 MURANO VEHICLES. THE INTAKE AIR DUCTS, WHICH ARE CONNECTED TO THE INTERMEDIATE RESONATOR IN THE AIR INTAKE SYSTEM OF THE ENGINE, MAY SEPARATE FROM THE RESONATOR WITH ENGINE MOVEMENT. THIS SEPARATION OCCURS DUE TO THE PREMATURE AGING OF THE MATERIAL USED IN THE INTAKE AIR DUCTS WHICH CAUSES EXCESSIVE SHRINKING, AND BECAUSE OF THAT ENGINE MAY STALL INCREASING THE RISK OF A CRASH. HOWEVER THE REPRESENTATIVE SAID THAT THERE IS NOTHING TO WORRY ABOUT AND MY VEHICLE WAS NOT INCLUDED IN THE RECALL EVEN THOUGH IT IS THE SAME MODEL AND YEAR OF THE VEHICLE RECALLED. *TR
NHTSA ODI #10534200
124,000 miles · Jul 5, 2013
EngineEngine And Engine Cooling
TL* THE CONTACT OWNS A 2003 NISSAN MURANO. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 70 MPH THE VEHICLE STALLED. THE VEHICLE WAS TOWED TO DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN REPLACED THE AIR INTAKE MANIFOLD. AFTER THE VEHICLE WAS REPAIRED THE FAILURE RECURRED. NHTSA RECALL CAMPAIGN NUMBER: 03V455000 (ENGINE A…
Read full complaint
TL* THE CONTACT OWNS A 2003 NISSAN MURANO. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 70 MPH THE VEHICLE STALLED. THE VEHICLE WAS TOWED TO DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN REPLACED THE AIR INTAKE MANIFOLD. AFTER THE VEHICLE WAS REPAIRED THE FAILURE RECURRED. NHTSA RECALL CAMPAIGN NUMBER: 03V455000 (ENGINE AND ENGINE COOLING) COULD BE RELATED TO THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THE VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 124,000. *TR
NHTSA ODI #10523230
115,245 miles · Apr 20, 2013
EnginePower Train
VEHICLE HESITATES AND DOES A BUNNY HOP RANDOMLY DURING STOP AND GO TRAFFIC. VEHICLE WON'T MOVE AT ALL YOU CAN HAVE IT FLOORED, THAN ALL OF A SUDDEN IT TAKES OFF. TOOK IT TO NISSAN, THEY KEEP TELLING ME ITS THE TRANSMISSION, WHICH MAKES NO SENSE SINCE IT ONLY DOES IT ONCE IN AWHILE. I FINALLY DECIDED TO FILE A COMPLAINT BECAUSE …
Read full complaint
VEHICLE HESITATES AND DOES A BUNNY HOP RANDOMLY DURING STOP AND GO TRAFFIC. VEHICLE WON'T MOVE AT ALL YOU CAN HAVE IT FLOORED, THAN ALL OF A SUDDEN IT TAKES OFF. TOOK IT TO NISSAN, THEY KEEP TELLING ME ITS THE TRANSMISSION, WHICH MAKES NO SENSE SINCE IT ONLY DOES IT ONCE IN AWHILE. I FINALLY DECIDED TO FILE A COMPLAINT BECAUSE I WAS DRIVING HOME THE OTHER DAY SLOWED DOWN TO GET ON INTERSTATE AND CAR WOULDN'T GO... ALMOST GOT SIDE SWIPED BY A TRACTOR TRAILER AND REAR ENDED BY THE GUY BEHIND ME WHO ASSUMED I WAS GOING. I HAVE DONE SOME RESEARCH, IT DOES NOT SEEM LIKE ANYONE REALLY KNOWS THE CAUSE AND I AM VERY PERPLEXED AS TO THE NUMBER OF PEOPLE HAVING THIS ISSUE YET NO RECALL... I GUESS SOMEONE WILL HAVE TO DIE FOR THIS ISSUE TO BE TAKEN SERIOUSLY, USUALLY HOW THINGS GET DONE IN THE US. *TR
NHTSA ODI #10508949
107,000 miles · Mar 4, 2013
EngineEngine And Engine Cooling
TL* THE CONTACT OWNS A 2003 NISSAN MURANO. THE CONTACT STATED THAT THE VEHICLE STALLED WITHOUT WARNING. THE CHECK ENGINE WARNING LIGHT WOULD SPORADICALLY FLASH. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE CONTACT WAS ADVISED THAT THE CRANKSHAFT POSITION SENSOR FAILED. THE MANUFACTURER ALSO ADVISED THE CONTACT THAT THE VEHICLE …
Read full complaint
TL* THE CONTACT OWNS A 2003 NISSAN MURANO. THE CONTACT STATED THAT THE VEHICLE STALLED WITHOUT WARNING. THE CHECK ENGINE WARNING LIGHT WOULD SPORADICALLY FLASH. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE CONTACT WAS ADVISED THAT THE CRANKSHAFT POSITION SENSOR FAILED. THE MANUFACTURER ALSO ADVISED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 03V455000 (ENGINE AND ENGINE COOLING). THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 107,000 AND THE CURRENT MILEAGE WAS 113,000. *TR
NHTSA ODI #10501252
105,000 miles · Dec 14, 2012
EnginePower Train
WHILE DRIVING THE TRANSMISSION IN THE CAR SPONTANEOUSLY DOWNSHIFTED. AS A RESULT OF THE TRANSMISSION FAILURE, THE ENGINE HAS HAD A ROD FAILURE. NISSAN WILL NOT FIX THE CAR. *TR
NHTSA ODI #10488771
15 miles · Oct 19, 2012
EnginePower Train
DRIVING AND ENGINE SHUTOFF!!!!!!! COULD NOT BRAKE OR ACCELERATE !!!! WAS TERRIFIED AS I WAS IN MIDDLE OF INTERSECTION MAKING A LEFT WITH TWO CHILDREN IN THE BACK! TUNED KEY TO OFF AND RESTARTED . NISSAN SAYS THERE IS A RECALL FOR THIS ISSUE BUT MY VIN DOES NOT FALL UNDER IT PLEASE HELP. *TR
NHTSA ODI #10481192
72,000 miles · Oct 5, 2012
EngineEngine And Engine Cooling
THE "SERVICE ENGINE SOON" WARNING LIGHT HAS COME ON SEVERAL TIMES SINCE I PURCHASED MY 2003 NISSAN MURANO. WHEN IN SLOW TRAFFIC OR THE ENGINE HAS WARMED UP, WHEN I PRESS ON THE ACCELERATOR THE CAR WILL NOT PICK UP SPEED, UNLESS I DEPRESS IT TO THE FLOOR BOARD. I'M TERRIFIED THAT I WILL BE HIT FROM THE REAR WHILE WAITING FOR MY …
Read full complaint
THE "SERVICE ENGINE SOON" WARNING LIGHT HAS COME ON SEVERAL TIMES SINCE I PURCHASED MY 2003 NISSAN MURANO. WHEN IN SLOW TRAFFIC OR THE ENGINE HAS WARMED UP, WHEN I PRESS ON THE ACCELERATOR THE CAR WILL NOT PICK UP SPEED, UNLESS I DEPRESS IT TO THE FLOOR BOARD. I'M TERRIFIED THAT I WILL BE HIT FROM THE REAR WHILE WAITING FOR MY TO GET ENGINE POWER. DOING MY RESEARCH ONLINE I NOTICED THERE WAS A RECALL NHTSA CAMPAIGN ID # 03V455000) FOR THIS EXACT PROBLEM ON THIS YEAR, MAKE AND MODEL. I CALLED NISSAN WITH MY VIN # AND WAS TOLD THAT MY VIN# WAS NOT INCLUDED IN THIS RECALL. I'M VERY FRUSTRATED WITH NISSAN AT THIS POINT. I DON'T UNDERSTAND HOW IF MY CAR IS DOING THE EXACT SAME THING AS DESCRIBED IN THE RECALL, SAME YEAR, MAKE & MODEL, WHY THEY WOULD TAKE A CHANCE IN THE SAFETY OF ME AS WELL AS MY FAMILY. IS THERE ANYONE OR ANYTHING ELSE THAT I CAN DO IN ORDER FOR NISSAN TO HONOR THIS RECALL SINCE IT WAS HAVE A DIRECT EFFECT ON THE SAFETY OF MY FAMILY, MYSELF AND OTHER DRIVERS IF IT WAS TO CAUSE A CRASH AS THEY DESCRIBE IN THEIR RECALL. *TR
NHTSA ODI #10478700
Official recalls
6May 19, 2009
NISSAN IS RECALLING 362,891 MY 2003-2007 MURANO VEHICLES. THE INTAKE AIR DUCTS, WHICH ARE CONNECTED TO THE INTERMEDIATE RESONATOR IN THE AIR INTAKE SYSTEM OF THE ENGINE, MAY SEPARATE FROM THE RESONATOR WITH ENGINE MOVEMENT. THIS SEPARATION OCCURS DUE TO THE PREMATURE AGING OF THE MATERIAL USED IN THE INTAKE AIR DUCTS WHICH CAUSES EXCESSIVE SHRINKING.
Consequence & remedy
Consequence: ENGINE MAY STALL INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT AND REPLACE/REPAIR THE APPROPRIATE COMPONENTS FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 24, 2009. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Feb 13, 2006
ON SOME SPORT UTILITY VEHICLES, IN CERTAIN HIGH SPEED FRONTAL CRASHES, THE WEBBING OF A REAR OUTBOARD SEAT BELT MAY CONTACT THE REAR SEAT BACK HINGE WHERE IT CAN BE CUT BY THE SHARP EDGE OF THE METAL PORTION OF THE HINGE.
Consequence & remedy
Consequence: IF THE WEBBING IS COMPLETELY SEPARATED, IT CAN INCREASE THE RISK OF INJURY TO AN OCCUPANT IN A CRASH.
Remedy: DEALERS WILL INSTALL PROTECTORS OVER THE WEBBING OF THE REAR SEAT BELTS. THE RECALL BEGAN ON MARCH 20, 2006. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Jan 10, 2006
ON CERTAIN SPORT UTILITY VEHICLES, DUE TO THE LOCATION OF THE FORWARD EDGE OF THE FUEL TANK, IN THE EVENT THAT A VEHICLE FRONT TIRE RUNS OVER A SMALL, SHARP OBJECT IN THE ROAD, CATCHES IT AND PROPELS IT TOWARDS THE REAR OF THE VEHICLE, IT MAY STRIKE AND PUNCTURE THE FUEL TANK.
Consequence & remedy
Consequence: A PUNCTURED TANK COULD INCREASE THE RISK OF A FIRE.
Remedy: DEALERS WILL INSTALL PROTECTORS IN FRONT OF THE TANK FREE OF CHARGE. THE RECALL BEGAN ON MARCH 20, 2006. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Jul 14, 2005
ON CERTAIN SPORT UTILITY VEHICLES, THERE IS A POSSIBILITY THAT A WIRE BREAKING INSIDE THE ALTERNATOR COULD STOP THE BATTERY FROM CHARGING.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE CHARGER WARNING AND BRAKE WARNING LAMPS WILL IMMEDIATELY COME ON AND THE BATTERY WILL BEGIN TO DISCHARGE. AFTER A SHORT TIME, THE ENGINE WILL GO INTO A "FALL SAFE" CONDITION WHICH WILL LIMIT VEHICLE SPEED. THE ENGINE WILL STOP RUNNING WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSPECT AND REPLACE THE ALTERNATOR WITH A NEW VERSION WHICH HAS BEEN MODIFIED TO PREVENT MOVEMENT OF THE COIL. THE RECALL BEGAN ON AUGUST 1, 2005. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Nov 17, 2003
ON CERTAIN PASSENGER VEHICLES, THE CIRCUIT BOARD FOR THE CRANK POSITION SENSOR OR CAM POSITION SENSOR MAY HAVE AN IMPROPER SOLDER JOINT DUE TO SOLDER DEFORMATION CAUSED BY HEAT STRESS ACCELERATED BY THE EXISTENCE OF FLUX RESIDUE DURING THE SOLDERING PROCESS.
Consequence & remedy
Consequence: THIS COULD CAUSE THE "SERVICE ENGINE SOON" WARNING LIGHT TO COME ON, CREATE A NO START CONDITION, CAUSE REDUCED ENGINE POWER, OR CAUSE THE ENGINE TO STOP RUNNING WITHOUT WARNING DURING VEHICLE OPERATION, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE CRANK POSITION SENSORS. CAMSHAFT POSITION SENSOR(S), AND IN SOME CASES, THE VARIABLE TIMING CONTROL SENSOR(S). VEHICLES INVOLVED IN A PREVIOUS RECALL CAMPAIGN, 01V357, ARE ALSO INCLUDED IN THIS NEW CAMPAIGN. THE REPLACEMENT SENSORS USED IN THAT CAMPAIGN ARE ALSO AFFECTED. OWNER NOTIFICATION BEGAN ON DECEMBER 22, 2003. OWNERS SHOULD CONTACT NISSAN AT 1-800-647-7261 OR INFINITI AT 1-800-662-6200.
Mar 31, 2003
ON CERTAIN SPORT UTILITY VEHICLES, THE NUT THAT ATTACHES THE TRANSMISSION GEAR SELECTOR SHAFT TO THE CONTROL VALVE LEVER IN THE TRANSMISSION MAY NOT BE ADEQUATELY TIGHTENED. THIS COULD RESULT IN THE TRANSMISSION NOT ACTUALLY BEING IN THE GEAR INDICATED BY THE GEAR SELECTOR LEVER. IN ADDITION, THE TRANSMISSION POSITION DISPLAY IN THE INSTRUMENT PANEL MAY NOT BE ON OR MAY BE INCORRECT.
Consequence & remedy
Consequence: IF THE GEAR DISPLAYED IS DIFFERENT FROM THE GEAR ENGAGED, THIS COULD RESULT IN UNEXPECTED VEHICLE MOVEMENT AND A CRASH.
Remedy: DEALERS WILL CHECK THE AFFECTED NUT IN THE TRANSMISSION SHIFT LEVER LINKAGE, AND TIGHTEN IT IF NECESSARY. OWNER NOTIFICATION BEGAN APRIL 15, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NISSAN AT 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4PE08065 · Driver Seat Anchor Failure
Opened Nov 18, 2008 · Closed Jul 2, 2009
Status: closed (inferred from source dates) · Seats
THIS INVESTIGATION CONCERNS STRUCTURAL FAILURE OF THE ANCHOR/BRACKET ON THE LEFT REAR SIDE OF THE DRIVER'S SEAT.THE CONCERN IS THAT SUCH FAILURES MAY ALTER THE DRIVER'S SEATED POSITION SO AS TO REDUCE EFFECTIVENESS OF THE OCCUPANT PROTECTION SYSTEM OR POTENTIALLY COMPROMISE VEHICLE CONTROL.FAILURE OF THE SUBJECT ANCHOR BRACKET RESULTS FROM METAL FATIGUE AND CAUSES REARWARD TILTING OF THE DRIVER'S SEAT.THESE FAILURES USUALLY OCCUR DURING DRIVER INGRESS BUT MAY ALSO OCCUR WHILE THE VEHICLE IS BEING OPERATED.THE SAFETY RELATED CONCERNS DURING ACTUAL VEHICLE USE WERE NOT VALIDATED BY THIS INVESTIGATION.WHILE THE NUMBER OF COMPLAINTS OF THIS PROBLEM IS RELATIVELY HIGH, ONLY THREE VERY MINOR, UNDOCUMENTED INJURIES WERE REPORTED.THE REPORTED INJURIES OCCURRED DURING DRIVER INGRESS, NOT WHILE THE VEHICLE WAS IN MOTION.INVESTIGATION DISCLOSED THAT THE APPARENT RISK OF COMPROMISE TO VEHICLE CONTROL HAS NOT BEEN DEMONSTRATED.INVESTIGATION ALSO DISCLOSED THAT THE APPARENT RISK OF COLLAPSE OF THE DRIVER'S SEAT BACK HAS NOT BEEN DEMONSTRATEDA SAFETY RELATED DEFECT TREND WAS NOT IDENTIFIED AND THIS INVESTIGATION HAS BEEN CLOSED.
PE05050 · Fuel Tank Punctures From Road Debris
Opened Sep 13, 2005 · Closed Jan 31, 2006
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly; Fuel System, Other:storage:tank Assembly
ODI OPENED A PRELIMINARY EVALUATION BASED ON FOUR VEHICLE OWNER QUESTIONNAIRES (VOQ'S) INDICATING THAT THE FUEL TANKS WEREPUNCTURED BY ROAD DEBRIS UNDER NORMAL, NON OFF-ROAD DRIVING CONDITIONS.AS OF NOVEMBER 30, 2005, THE COMPLAINT TOTAL INCREASED TO 12.NISSAN SUPPLIED ODI WITH 31 COMPLAINTS OF FUEL TANK PUNCTURES, INCLUDING 26 NOT PREVIOUSLY KNOWN TO ODI FROM THE VOQ RECORDS. IN A LETTER DATED JANUARY 9, 2006, NISSAN NORTH AMERICA, INC. NOTIFIED ODI OF ITS PLAN TO RECALL APPROXIMATELY 209,000 MODEL YEAR 2003 - 2006 NISSAN MURANO VEHICLES BUILT FROM APRIL 24, 2002 (START OF PRODUCTION OF MY 2003) THROUGH NOVEMBER 24, 2005 (INCLUDING A PORTION OF MY 2006 VEHICLES) TO CORRECT A DEFICIENCY IN FUEL TANK SHIELDING FROM ROAD DEBRIS.THIS RECALL HAS BEEN DESIGNATED NHTSA NO. 06V-003.RECALLED VEHICLES WILL BE FITTED WITH PROTECTIVE SHIELDING FOR THE FRONTAL PORTION OF THE FUEL TANK TO REDUCE THE POSSIBILITY OF PUNCTURE BY PROJECTILES FROM THE FRONT WHEELS.ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED.
Additional source detail variants (2)
Fuel System, Gasoline:storage:tank Assembly
ODI OPENED A PRELIMINARY EVALUATION BASED ON FOUR VEHICLE OWNER QUESTIONNAIRES (VOQ'S) INDICATING THAT THE FUEL TANKS WEREPUNCTURED BY ROAD DEBRIS UNDER NORMAL, NON OFF-ROAD DRIVING CONDITIONS.AS OF NOVEMBER 30, 2005, THE COMPLAINT TOTAL INCREASED TO 12.NISSAN SUPPLIED ODI WITH 31 COMPLAINTS OF FUEL TANK PUNCTURES, INCLUDING 26 NOT PREVIOUSLY KNOWN TO ODI FROM THE VOQ RECORDS. IN A LETTER DATED JANUARY 9, 2006, NISSAN NORTH AMERICA, INC. NOTIFIED ODI OF ITS PLAN TO RECALL APPROXIMATELY 209,000 MODEL YEAR 2003 - 2006 NISSAN MURANO VEHICLES BUILT FROM APRIL 24, 2002 (START OF PRODUCTION OF MY 2003) THROUGH NOVEMBER 24, 2005 (INCLUDING A PORTION OF MY 2006 VEHICLES) TO CORRECT A DEFICIENCY IN FUEL TANK SHIELDING FROM ROAD DEBRIS.THIS RECALL HAS BEEN DESIGNATED NHTSA NO. 06V-003.RECALLED VEHICLES WILL BE FITTED WITH PROTECTIVE SHIELDING FOR THE FRONTAL PORTION OF THE FUEL TANK TO REDUCE THE POSSIBILITY OF PUNCTURE BY PROJECTILES FROM THE FRONT WHEELS.ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED.
Fuel System, Other:storage:tank Assembly
ODI OPENED A PRELIMINARY EVALUATION BASED ON FOUR VEHICLE OWNER QUESTIONNAIRES (VOQ'S) INDICATING THAT THE FUEL TANKS WEREPUNCTURED BY ROAD DEBRIS UNDER NORMAL, NON OFF-ROAD DRIVING CONDITIONS.AS OF NOVEMBER 30, 2005, THE COMPLAINT TOTAL INCREASED TO 12.NISSAN SUPPLIED ODI WITH 31 COMPLAINTS OF FUEL TANK PUNCTURES, INCLUDING 26 NOT PREVIOUSLY KNOWN TO ODI FROM THE VOQ RECORDS. IN A LETTER DATED JANUARY 9, 2006, NISSAN NORTH AMERICA, INC. NOTIFIED ODI OF ITS PLAN TO RECALL APPROXIMATELY 209,000 MODEL YEAR 2003 - 2006 NISSAN MURANO VEHICLES BUILT FROM APRIL 24, 2002 (START OF PRODUCTION OF MY 2003) THROUGH NOVEMBER 24, 2005 (INCLUDING A PORTION OF MY 2006 VEHICLES) TO CORRECT A DEFICIENCY IN FUEL TANK SHIELDING FROM ROAD DEBRIS.THIS RECALL HAS BEEN DESIGNATED NHTSA NO. 06V-003.RECALLED VEHICLES WILL BE FITTED WITH PROTECTIVE SHIELDING FOR THE FRONTAL PORTION OF THE FUEL TANK TO REDUCE THE POSSIBILITY OF PUNCTURE BY PROJECTILES FROM THE FRONT WHEELS.ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED.
EA05006 · Alternator Failure / Engine Stalling
Opened Mar 25, 2005 · Closed Aug 17, 2005
Status: closed (inferred from source dates) · Electrical System; Electrical System:alternator/generator/regulator
ODI RECEIVED 14 REPORTS OF ALLEGED ENGINE STALLING DUE TO ALTERNATOR FAILURE ON MY 2003-2004 MURANO (SUBJECT) VEHICLES.ALL OF THE COMPLAINTS REPORTED THAT THE VEHICLE COULD NOT BE RESTARTED AFTER THE STALL OCCURRED.BASED ON THESE COMPLAINTS, ODI OPENED PE04-077 AND LATER UPGRADED TO EA05-006 FOR THE SUBJECT VEHICLES.DURING EA05-006, ADDITIONAL FAILURE DATA WERE IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE.ON JULY 12, 2005, NISSAN NOTIFIED NHTSA OF A SAFETY DEFECT ON MY 2003-2005 MURANO VEHICLES PRODUCED FROM APRIL 8, 2002 AND SEPTEMBER 24, 2004 (RECALL 05V-319).THE NOTIFICATION STATED THAT AN OPEN CIRCUIT IN THE ALTERNATOR CAN OCCUR DUE TO WIRE FATIGUE CAUSED BY MOVEMENT OF THE ROTOR COIL DURING RAPID CHANGES IN ENGINE SPEED IN VEHICLES EQUIPPED WITH A CONTINUOUSLY VARIABLE TRANSMISSION (CVT).HIGHER ENGINE COMPARTMENT TEMPERATURE IN THE MURANO COMPARED TO OTHER NISSAN MODELS MAY ALSO BE A CONTRIBUTING FACTOR TO THE WIRE FATIGUE.NISSAN ALSO REPORTED THAT WHEN THIS HAPPENS, THE CHARGE WARNING AND BRAKE WARNING LAMPS WILL ILLUMINATE AND THE BATTERY WILL BEGIN TO DISCHARGE.AFTER A SHORT TIME, THE ENGINE WILL THEN ENTER A FAIL SAFE MODE THAT LIMITS VEHICLE SPEED.VERY SHORTLY AFTER REACHING THIS CONDITION, THE ENGINE WILL STOP.NHTSA'S TESTING, HOWEVER, SHOWED THAT ALTHOUGH THE WARNING LAMPS ILLUMINATE, THE VEHICLE SPEED IS LIMITED TO ONLY 4-7 MPH RATHER THAN WHAT NHTSA CONSIDERS A FAIL SAFE MODE. NISSAN WILL INSTRUCT OWNERS TO RETURN THEIR VEHICLES TO ANY NISSAN DEALER FOR AN ALTERNATOR INSPECTION AND REPLACEMENT, IF REQUIRED.NOTE:SOME VEHICLES MAY HAVE HAD THE NEWLY DESIGNED ALTERNATOR PREVIOUSLY INSTALLED UNDER WARRANTY.CONSEQUENTLY, THIS INVESTIGATION IS CLOSED.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY AND TAKE FURTHER ACTION IF WARRANTED.
Additional source detail variants (2)
Electrical System:alternator/generator/regulator
ODI RECEIVED 14 REPORTS OF ALLEGED ENGINE STALLING DUE TO ALTERNATOR FAILURE ON MY 2003-2004 MURANO (SUBJECT) VEHICLES.ALL OF THE COMPLAINTS REPORTED THAT THE VEHICLE COULD NOT BE RESTARTED AFTER THE STALL OCCURRED.BASED ON THESE COMPLAINTS, ODI OPENED PE04-077 AND LATER UPGRADED TO EA05-006 FOR THE SUBJECT VEHICLES.DURING EA05-006, ADDITIONAL FAILURE DATA WERE IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE.ON JULY 12, 2005, NISSAN NOTIFIED NHTSA OF A SAFETY DEFECT ON MY 2003-2005 MURANO VEHICLES PRODUCED FROM APRIL 8, 2002 AND SEPTEMBER 24, 2004 (RECALL 05V-319).THE NOTIFICATION STATED THAT AN OPEN CIRCUIT IN THE ALTERNATOR CAN OCCUR DUE TO WIRE FATIGUE CAUSED BY MOVEMENT OF THE ROTOR COIL DURING RAPID CHANGES IN ENGINE SPEED IN VEHICLES EQUIPPED WITH A CONTINUOUSLY VARIABLE TRANSMISSION (CVT).HIGHER ENGINE COMPARTMENT TEMPERATURE IN THE MURANO COMPARED TO OTHER NISSAN MODELS MAY ALSO BE A CONTRIBUTING FACTOR TO THE WIRE FATIGUE.NISSAN ALSO REPORTED THAT WHEN THIS HAPPENS, THE CHARGE WARNING AND BRAKE WARNING LAMPS WILL ILLUMINATE AND THE BATTERY WILL BEGIN TO DISCHARGE.AFTER A SHORT TIME, THE ENGINE WILL THEN ENTER A FAIL SAFE MODE THAT LIMITS VEHICLE SPEED.VERY SHORTLY AFTER REACHING THIS CONDITION, THE ENGINE WILL STOP.NHTSA'S TESTING, HOWEVER, SHOWED THAT ALTHOUGH THE WARNING LAMPS ILLUMINATE, THE VEHICLE SPEED IS LIMITED TO ONLY 4-7 MPH RATHER THAN WHAT NHTSA CONSIDERS A FAIL SAFE MODE. NISSAN WILL INSTRUCT OWNERS TO RETURN THEIR VEHICLES TO ANY NISSAN DEALER FOR AN ALTERNATOR INSPECTION AND REPLACEMENT, IF REQUIRED.NOTE:SOME VEHICLES MAY HAVE HAD THE NEWLY DESIGNED ALTERNATOR PREVIOUSLY INSTALLED UNDER WARRANTY.CONSEQUENTLY, THIS INVESTIGATION IS CLOSED.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY AND TAKE FURTHER ACTION IF WARRANTED.
Electrical System
ODI RECEIVED 14 REPORTS OF ALLEGED ENGINE STALLING DUE TO ALTERNATOR FAILURE ON MY 2003-2004 MURANO (SUBJECT) VEHICLES.ALL OF THE COMPLAINTS REPORTED THAT THE VEHICLE COULD NOT BE RESTARTED AFTER THE STALL OCCURRED.BASED ON THESE COMPLAINTS, ODI OPENED PE04-077 AND LATER UPGRADED TO EA05-006 FOR THE SUBJECT VEHICLES.DURING EA05-006, ADDITIONAL FAILURE DATA WERE IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE.ON JULY 12, 2005, NISSAN NOTIFIED NHTSA OF A SAFETY DEFECT ON MY 2003-2005 MURANO VEHICLES PRODUCED FROM APRIL 8, 2002 AND SEPTEMBER 24, 2004 (RECALL 05V-319).THE NOTIFICATION STATED THAT AN OPEN CIRCUIT IN THE ALTERNATOR CAN OCCUR DUE TO WIRE FATIGUE CAUSED BY MOVEMENT OF THE ROTOR COIL DURING RAPID CHANGES IN ENGINE SPEED IN VEHICLES EQUIPPED WITH A CONTINUOUSLY VARIABLE TRANSMISSION (CVT).HIGHER ENGINE COMPARTMENT TEMPERATURE IN THE MURANO COMPARED TO OTHER NISSAN MODELS MAY ALSO BE A CONTRIBUTING FACTOR TO THE WIRE FATIGUE.NISSAN ALSO REPORTED THAT WHEN THIS HAPPENS, THE CHARGE WARNING AND BRAKE WARNING LAMPS WILL ILLUMINATE AND THE BATTERY WILL BEGIN TO DISCHARGE.AFTER A SHORT TIME, THE ENGINE WILL THEN ENTER A FAIL SAFE MODE THAT LIMITS VEHICLE SPEED.VERY SHORTLY AFTER REACHING THIS CONDITION, THE ENGINE WILL STOP.NHTSA'S TESTING, HOWEVER, SHOWED THAT ALTHOUGH THE WARNING LAMPS ILLUMINATE, THE VEHICLE SPEED IS LIMITED TO ONLY 4-7 MPH RATHER THAN WHAT NHTSA CONSIDERS A FAIL SAFE MODE. NISSAN WILL INSTRUCT OWNERS TO RETURN THEIR VEHICLES TO ANY NISSAN DEALER FOR AN ALTERNATOR INSPECTION AND REPLACEMENT, IF REQUIRED.NOTE:SOME VEHICLES MAY HAVE HAD THE NEWLY DESIGNED ALTERNATOR PREVIOUSLY INSTALLED UNDER WARRANTY.CONSEQUENTLY, THIS INVESTIGATION IS CLOSED.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY AND TAKE FURTHER ACTION IF WARRANTED.
PE04077 · Alternator Failure/ Engine Stalling
Opened Nov 19, 2004 · Closed Mar 25, 2005
Status: closed (inferred from source dates) · Electrical System; Electrical System:alternator/generator/regulator
ODI OPENED PE04-077 BASED ON 14 REPORTS OF ALLEGED ENGINE STALLING DUE TO ALTERNATOR FAILURE.ALL OF THE COMPLAINTS REPORTED THAT THE VEHICLE COULD NOT BE RESTARTED AFTER THE STALL OCCURRED.DURING PE04-077, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE . DURING THE INVESTIGATION, NISSAN IDENTIFIED THAT THERE HAD BEEN ALTERNATOR WARRANTY REPLACEMENTS DUE TO AN OPEN CIRCUIT IN THE ROTOR COIL CAUSED BY WIRE FATIGUE. ODI?S ANALYSIS SHOWS FAILURE RATES THAT ARE OF CONCERN TO ODI AND INDICATES THAT THE ALLEGED DEFECT IS CONTINUING TO OCCUR IN THE SUBJECT VEHICLES.ODI'S ANALYSIS ALSO SHOWS THAT NEARLY ALL OF THE ALTERNATOR WARRANTY CLAIMS SUBMITTED RESULTED IN ENGINE STALLS AND AT LEAST 25% OF THE ENGINE STALLS RESULTED IN A NO RESTART CONDITION.HOWEVER, IN 71% OF THE WARRANTY DATA SUBMITTED, ODI HAS NOT BEEN ABLE TO DETERMINE IF THE CONSUMER COULD RESTART THE VEHICLE.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER INVESTIGATE THIS CONCERN, TO ASSESS THE POTENTIAL SAFETY-RELATED CONSEQUENCES, AND TO DETERMINE THE SCOPE OF THE AFFECTED POPULATION.
Additional source detail variants (2)
Electrical System:alternator/generator/regulator
ODI OPENED PE04-077 BASED ON 14 REPORTS OF ALLEGED ENGINE STALLING DUE TO ALTERNATOR FAILURE.ALL OF THE COMPLAINTS REPORTED THAT THE VEHICLE COULD NOT BE RESTARTED AFTER THE STALL OCCURRED.DURING PE04-077, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE . DURING THE INVESTIGATION, NISSAN IDENTIFIED THAT THERE HAD BEEN ALTERNATOR WARRANTY REPLACEMENTS DUE TO AN OPEN CIRCUIT IN THE ROTOR COIL CAUSED BY WIRE FATIGUE. ODI?S ANALYSIS SHOWS FAILURE RATES THAT ARE OF CONCERN TO ODI AND INDICATES THAT THE ALLEGED DEFECT IS CONTINUING TO OCCUR IN THE SUBJECT VEHICLES.ODI'S ANALYSIS ALSO SHOWS THAT NEARLY ALL OF THE ALTERNATOR WARRANTY CLAIMS SUBMITTED RESULTED IN ENGINE STALLS AND AT LEAST 25% OF THE ENGINE STALLS RESULTED IN A NO RESTART CONDITION.HOWEVER, IN 71% OF THE WARRANTY DATA SUBMITTED, ODI HAS NOT BEEN ABLE TO DETERMINE IF THE CONSUMER COULD RESTART THE VEHICLE.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER INVESTIGATE THIS CONCERN, TO ASSESS THE POTENTIAL SAFETY-RELATED CONSEQUENCES, AND TO DETERMINE THE SCOPE OF THE AFFECTED POPULATION.
Electrical System
ODI OPENED PE04-077 BASED ON 14 REPORTS OF ALLEGED ENGINE STALLING DUE TO ALTERNATOR FAILURE.ALL OF THE COMPLAINTS REPORTED THAT THE VEHICLE COULD NOT BE RESTARTED AFTER THE STALL OCCURRED.DURING PE04-077, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE . DURING THE INVESTIGATION, NISSAN IDENTIFIED THAT THERE HAD BEEN ALTERNATOR WARRANTY REPLACEMENTS DUE TO AN OPEN CIRCUIT IN THE ROTOR COIL CAUSED BY WIRE FATIGUE. ODI?S ANALYSIS SHOWS FAILURE RATES THAT ARE OF CONCERN TO ODI AND INDICATES THAT THE ALLEGED DEFECT IS CONTINUING TO OCCUR IN THE SUBJECT VEHICLES.ODI'S ANALYSIS ALSO SHOWS THAT NEARLY ALL OF THE ALTERNATOR WARRANTY CLAIMS SUBMITTED RESULTED IN ENGINE STALLS AND AT LEAST 25% OF THE ENGINE STALLS RESULTED IN A NO RESTART CONDITION.HOWEVER, IN 71% OF THE WARRANTY DATA SUBMITTED, ODI HAS NOT BEEN ABLE TO DETERMINE IF THE CONSUMER COULD RESTART THE VEHICLE.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER INVESTIGATE THIS CONCERN, TO ASSESS THE POTENTIAL SAFETY-RELATED CONSEQUENCES, AND TO DETERMINE THE SCOPE OF THE AFFECTED POPULATION.
Illustration