2022 Nissan Leaf

My car all of a sudden lost drive power while I was driving up Parleys Canyon on I-80. My car started slowing down in traffic rapidly and I had to make emergency maneuvers to get to the side of the road. After the incident the car had trouble accelerating and couldn't keep up with traffic to get it to the shop. This is an active recall and Nissan refuses to fix the battery.

The high-voltage battery on my 2022 Nissan Leaf is subject to Recall 25V655. The recall notice states that the battery cells can develop excessive lithium deposits, which increases electrical resistance and can cause rapid battery heating during Level 3 fast charging. Nissan instructs owners not to use Level 3 charging at all until a “remedy” is available. The issue is that the remedy described by Nissan is not an actual repair of the battery defect. Nissan states it will install software that monitors for “state-of-charge fluctuation” and, if detected, will prevent the vehicle from restarting or recharging in order to avoid a thermal incident. This means the defect inside the battery cells is still present, and the car may disable itself if the defect begins to appear. The recall materials also state there is no warning before overheating occurs. This creates multiple safety concerns: • The underlying battery defect remains uncorrected. • The vehicle can become immobilized (unable to restart or recharge) if the software detects the condition. • Loss of Level 3 charging capability affects the ability to travel safely or plan charging when needed. • A battery fire risk exists during Level 3 charging if the defect is not detected in time. Nissan’s documents state that the software is meant only to prevent the “progression” of a thermal incident, not to repair the defective battery. I am concerned that my vehicle contains a known hazardous defect that has not been physically repaired and that the software-only response is inadequate to ensure safety. I am filing this complaint so NHTSA is aware that the remedy being offered does not address the internal battery defect itself and may leave owners exposed to continued safety and reliability risks.

I am reporting a critical safety hazard involving my 2021 Nissan Leaf S Plus (approx. 117,000 miles). Since January 2025, the vehicle has exhibited dangerous battery degradation and voltage sag during operation. On my 30-mile highway commute, while driving at normal highway speeds—especially on inclines—the vehicle would suddenly display a low-power warning, and the remaining battery percentage would instantly crash. This caused a sudden, dangerous loss of propulsion in high-speed traffic, creating severe crash risks. I primarily charged at home and rarely used DC fast charging. On May 22, 2026, while actively driving, the dashboard flashed: "Service EV system unable to restart after power off." I pulled over, and upon turning the car off, it completely bricked. The auxiliary electronics power up, but the vehicle permanently refuses to enter "READY" (Drive) mode due to a high-voltage safety lock. The vehicle was towed to an authorized Nissan dealer. The certified technician's diagnostic report confirmed that the high-voltage traction battery has completely failed and is internally damaged. Crucially, this vehicle is currently under an active, unremedied safety recall (NHTSA Recall 25V655 / Nissan R25C8) due to excessive lithium deposits that cause severe battery degradation, sudden power loss, and fire risks. The physical failure of my battery is a direct manifestation of this exact manufacturing defect. Nissan’s software-only "interim remedy" did not fix the hardware defect; it simply bricked my car after exposing my family to highway propulsion loss. Nissan must be held legally responsible for replacing these defective, recalled battery packs regardless of mileage, as they present a severe, systemic risk of catastrophic failure and traffic accidents.

Nissan Recall R25C8 (NHTSA ID: 25V655), Incomplete, remedy not available Primary Issue: High-voltage battery fire risk during Level 3 (DCFC) charging due to excessive lithium deposits. I have been told by Nissan not to use Level 3 fast charging. This has significantly impaired the utility of my vehicle due to: - Limited Range/Utility: Without fast charging, I can't use the car for trips beyond its immediate single-charge radius, basically turning a long-range EV into a local-only car. The proposed software may limit charging or prevent the vehicle from restarting if it detects a dangerous condition, rather than permanently fixing the defect. - Time Loss: I can't charge at home unless (only overnight & if weather permits) I run a cable out of my apartment window, across the grass & sidewalk for a trickle charge (Level 1). Otherwise I have to drive to a Level 2 charger & wait many hours to charge up. This is significantly longer, makes it impossible to quickly 'top off' as advertised. For comparison: L3 (DCFC) gets me at least 15% in about 15 minutes (60% per/hour); L2 only gets 11% per/hour. L1 only gets 2% per/hour. Without DCFC this car is almost useless. - Diminished Value: Nissan sold me a $38,000 car & I'm concerned that a software-only 'fix' that may throttle charging speeds or simply disable the car if it detects heat will permanently reduce the vehicle's market value. I actually expected to keep this car for the rest of my life, but the CHAdeMO system (which appears is becoming un-supported) that also lacks a cooling system, makes that very unlikely. - Impact to income due to part-time employment that requires travel, which the LEAF was capable of doing with DCFC stops. Now, I need to rent a vehicle for these events. Purchased Cherry Hill Nissan March 11, 2022 2/3/2026: Nissan Service appointment. They are still unable to fix the recall issue, whether via software or hardware. 3/18/2026: I received another safety recall notice. Still no solution.

I bought my vehicle used, in May 2025. Then, in October (if not earlier), a safety recall was issued relating to the fast charging of the EV battery. This recall tells me that I’m not to use the CHAdeMO charging port due to battery fire risk. Now, almost 6 months later, there still isn’t a remedy available. Not being able to fast charge puts a huge restriction on where I’m able to go in my car. NO ONE wants to sit around for hours waiting for their car battery to recharge in order to get to their destination. I have contacted Nissan’s corporate office to ask if they would offer me a loaner vehicle for my longer distance drives, but they said no and didn’t have any other assistance to offer until the remedy is available. I would like to know, are they given any sort of deadline to remedy such a HUGE safety recall, or what most people would consider a DEFECT? If so, what kind of penalty do they face if this deadline isn’t met? If not, is there anything I can do to hold them accountable for selling me a defective Electric Vehicle? Thank you for your time

My Nissan Leaf 2022 Electric Vehicle(VIN: [XXX] ) is subject to Safety Recall 25V-655 (Manufacturer Recall Number R25C8) dated September 30, 2025. As per the recall notice, the vehicle suffers from 'excessive lithium deposits within battery cells' which can cause 'rapid heating of the battery' and result in a battery fire. The manufacturer has officially instructed me NOT to use Level 3 Quick Charging (CHAdeMO) until a remedy is completed. This restriction substantially impairs the use and value of the vehicle, as it eliminates the ability to use the car for long-distance travel, which is its primary intended purpose. It has been over 3 months since this recall was issued, and the status remains 'Remedy not yet available.' The manufacturer has failed to provide a timely repair for this fire risk. I am currently driving a vehicle that is a known fire hazard and has restricted utility. I request an immediate resolution. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

This is related to NHTSA recall 25V-655: I am no longer able to DC fast charge my vehicle due to the recall related to charging and battery instability. This prevents me from using the car in the way that it was intended. I cannot drive more than 80 miles from my home in any direction. Less if I drive on the highway. This is not an acceptable situation for a vehicle. If a gas vehicle could not be refueled as it was designed, the vehicle would be replaced by the manufacturer. I have filed a request for buy back but the manufacturer has stated that there were not enough recalls built up on my vehicle to warrant a replacement or any compensation.

Nissan has informed Leaf owners that we cannot use DCFC to charge the car, there is a danger of fire from an overheating battery. This poorly designed battery management system severely limits the distance one can travel in the car. It has become an expensive short commute vehicle! Nissan offered to "repurchase" my car. The offer had over $27K deductions for milage and repayment of my $10k lien I would have to pay Nissan $2,800 for them to take the car back! Nissan should take full responsibility for the known recall and poor engineering.

The high-voltage battery on my 2022 Nissan Leaf is subject to Recall 25V655. The recall notice states that the battery cells can develop excessive lithium deposits, which increases electrical resistance and can cause rapid battery heating during Level 3 fast charging. Nissan instructs owners not to use Level 3 charging at all until a “remedy” is available. The issue is that the remedy described by Nissan is not an actual repair of the battery defect. Nissan states it will install software that monitors for “state-of-charge fluctuation” and, if detected, will prevent the vehicle from restarting or recharging in order to avoid a thermal incident. This means the defect inside the battery cells is still present, and the car may disable itself if the defect begins to appear. The recall materials also state there is no warning before overheating occurs. This creates multiple safety concerns: • The underlying battery defect remains uncorrected. • The vehicle can become immobilized (unable to restart or recharge) if the software detects the condition. • Loss of Level 3 charging capability affects the ability to travel safely or plan charging when needed. • A battery fire risk exists during Level 3 charging if the defect is not detected in time. Nissan’s documents state that the software is meant only to prevent the “progression” of a thermal incident, not to repair the defective battery. I am concerned that my vehicle contains a known hazardous defect that has not been physically repaired and that the software-only response is inadequate to ensure safety. I am filing this complaint so NHTSA is aware that the remedy being offered does not address the internal battery defect itself and may leave owners exposed to continued safety and reliability risks. I also want to note that EVgo, one of the largest fast charging networks, is refusing to initiate fast charging sessions for Nissan Leafs because of this defect.