2021 Nissan Leaf

Incident Summary & Ineffective Recall Remedy: I am reporting an acute high-voltage battery cell collapse on my 2021 Nissan LEAF (VIN: [XXX]). The vehicle previously received the software update for NHTSA Recall #25V655 (Nissan Recall #R25C8) at Kings Nissan. The software patch failed to repair the underlying defective battery hardware. Following a second service visit on XXX where Kings Nissan tested only the auxiliary 12V lead-acid battery to dismiss my complaint, I purchased an independent CAN-bus diagnostic tool. On XXX (63,702 miles), LeafSpy telemetry confirmed Cell #31 is severely degraded, exhibiting a 191–307 mV voltage collapse. This causes sudden dashboard state-of-charge drops from 70%+ down to 42–45% on active highways, forcing emergency power limits ("limp mode"). Refusal of Post-Remedy Service: Despite active Corporate Case #XXX with Nissan Consumer Affairs, authorized dealers (Kings Nissan, Nissan of Queens and Nissan of Staten Island) refuse to intake, scan, or ground the vehicle, leaving a severe hardware hazard active on public roads. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owned a 2021 Nissan Leaf. The contact received notification of NHTSA Campaign Number: 25V655000 (Electrical System). The contact stated that while at a dealer charging the vehicle for approximately 15- 20 minutes, there was a fire coming from the front of the vehicle. The fire was extinguished by the fire department after several hours. A Police report was not filed. No injuries, medical attention, or damages were reported. The vehicle was towed to a tow lot and was deemed a total loss. The manufacturer was not notified of the failure. The failure mileage was 25,000.

A recall fix was done for the back up camera about a year ago. That was a national recall for an issue with the system. My car started the same exact issue about 3 weeks ago. No back up camera, pink or blue screen, glitchy. I contacted Nissan about it and it didn't seem like they wanted to make the repair again or fix the issue at no cost. I was wondering if other owners have had the same issue and if you can intervene. Thank you

Our vehicle was affected by recall 25V655 for defective battery. The vehicle was serviced at the Nissan dealer and the software update to resolve the recall was applied. Yesterday the vehicle spontaneously combusted during DC fast charging despite the software update. It appears that the software update was ineffective at mitigating the fire hazard.

Recall for FAST CHARGE LEVEL 3 CHADEMO has been issued for over 6 months. I am advised not to fast charge due to risk of devastating fire. Very dangerous to continue to use this car in an urban setting. Buyback was denied and told to wait for a fix. No fix yet! I can't get out of Philadelphia in this car. Tesla wouldn't let this happen!

Level 3 quick charging was not working, and only Level 2 charging is working now. That creates a risk of not working if Level 2 charging does not work as well. Nissan issued the letter on 3/18/2026 to recall but not yet provided the detailed repair plan as of today. Please advise. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I own a 2021 Nissan Leaf with an open safety recall (NHTSA Recall 25V-655, Nissan Recall R25C8) issued on September 30, 2025. The recall involves a battery defect that creates a safety risk during DC fast charging (Level 3). As a result, I am unable to use public fast-charging networks such as EVgo. The recall currently has no remedy available and has been unresolved for over 7 months. I do not have access to home charging, and without fast charging, the vehicle cannot be used in a practical or reasonable way for daily transportation. This has resulted in a complete loss of use of my vehicle and has impacted my ability to work. Nissan has not provided a timeline for repair or an alternative solution such as a loaner or rental reimbursement. This delay is not reasonable, and I am requesting investigation into the lack of remedy and the impact on vehicle usability.

The contact owns a 2021 Nissan Leaf. The contact received notification of NHTSA Campaign Number: 25V655000 (Electrical System); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was not made aware of the issue. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

I own a 2021 Nissan Leaf subject to open recall R25C8 (NHTSA Campaign 25V655) for fire risk during Level 3 DC fast charging. The recall was issued October 2025. Nissan’s stated remedy target was late March 2026. As of today, April 6, 2026, no remedy has been provided. The affected component is the lithium-ion battery pack and its charging system. The vehicle is equipped with a CHAdeMO DC fast charging port, which I cannot safely use due to the documented fire risk. I am not avoiding this feature by choice – I am avoiding it because Nissan’s own recall identified it as a safety hazard. On April 6, 2026, I encountered a DC fast charging station and chose not to attempt charging due to the active recall warning, and due to reports that charging networks have begun refusing sessions on recalled vehicles. Diagnostic software shows my battery’s internal resistance index (Hx) at 71%, disproportionately low relative to State of Health at 87.5%. The vehicle is also consuming battery charge at an accelerated rate during highway driving, with approximately 50% of charge depleted over 30 to 40 miles. I am concerned that a software-only remedy will be inadequate for a battery with this level of internal resistance degradation, as software cannot compensate for the absence of active thermal management hardware. No dealer has confirmed the condition. I am filing to document loss of vehicle functionality, Nissan’s missed remedy deadline, and concern about remedy adequacy.

This vehicle is subject to NHTSA Recall 25V-655 involving the high-voltage traction battery. The recall restricts the vehicle from using DC fast charging (Level 3), which significantly limits the safe and practical operation of the vehicle for its intended use. My household must routinely complete 300+ mile one-way trips on a weekly basis. Without DC fast charging capability, the vehicle cannot reliably complete these trips, creating a risk of being stranded or unable to safely reach destinations. Reliance on Level 2 charging requires extended delays of 6+ hours, which makes the vehicle impractical for its intended use and inconsistent with reasonable consumer expectations for normal operation. I contacted Nissan North America Consumer Affairs and was directed to work with the local dealer. I then contacted Dick Hannah Nissan in Gladstone, OR, who redirected me back to Consumer Affairs. As a result, no party is taking responsibility and no remedy or interim solution has been provided. The manufacturer has issued a safety recall but is unable to provide a repair, timeline, or mitigation. The vehicle’s primary propulsion system is effectively restricted, and the vehicle cannot be used as intended for necessary travel. I have requested a loaner or comparable replacement vehicle while awaiting a remedy, but this has not been provided. This unresolved recall creates an ongoing safety and usability issue, and the manufacturer has failed to provide a reasonable interim solution.