2022 Nissan Leaf

Nissan Recall R25C8 (NHTSA ID: 25V655), Incomplete, remedy not available Primary Issue: High-voltage battery fire risk during Level 3 (DCFC) charging due to excessive lithium deposits. I have been told by Nissan not to use Level 3 fast charging. This has significantly impaired the utility of my vehicle due to: - Limited Range/Utility: Without fast charging, I can't use the car for trips beyond its immediate single-charge radius, basically turning a long-range EV into a local-only car. The proposed software may limit charging or prevent the vehicle from restarting if it detects a dangerous condition, rather than permanently fixing the defect. - Time Loss: I can't charge at home unless (only overnight & if weather permits) I run a cable out of my apartment window, across the grass & sidewalk for a trickle charge (Level 1). Otherwise I have to drive to a Level 2 charger & wait many hours to charge up. This is significantly longer, makes it impossible to quickly 'top off' as advertised. For comparison: L3 (DCFC) gets me at least 15% in about 15 minutes (60% per/hour); L2 only gets 11% per/hour. L1 only gets 2% per/hour. Without DCFC this car is almost useless. - Diminished Value: Nissan sold me a $38,000 car & I'm concerned that a software-only 'fix' that may throttle charging speeds or simply disable the car if it detects heat will permanently reduce the vehicle's market value. I actually expected to keep this car for the rest of my life, but the CHAdeMO system (which appears is becoming un-supported) that also lacks a cooling system, makes that very unlikely. - Impact to income due to part-time employment that requires travel, which the LEAF was capable of doing with DCFC stops. Now, I need to rent a vehicle for these events. Purchased Cherry Hill Nissan March 11, 2022 2/3/2026: Nissan Service appointment. They are still unable to fix the recall issue, whether via software or hardware. 3/18/2026: I received another safety recall notice. Still no solution.

My Nissan Leaf is currently under NHTSA Recall Number 25V-655 since Oct 2025 and I cannot charge the car on a Level 3 fast charger. This has made the car unusable for my current needs. I have been forced to rent and borrow cars for necessary long distance trips. Nissan continues to delay their planned resolution for this problem and this situation is completely unacceptable.

Due to Recall 25V-655, I am unable to safely use level 3 charging. The first notice I received of this issue (in October, 2025), stated that a remedy would be available by December, 2025. I just received a second interim owner notification that states a remedy will be available within the 2026 calendar year. This is not a timely remedy, as I have already waited 5 months for this fix to an important safety problem, and am now being told I may have to wait another 9 months.

The high-voltage battery on my 2022 Nissan Leaf SL+ is subject to Recall NHTSA ID: 25V-655. The recall notice states that the battery cells can develop excessive lithium deposits, which increases electrical resistance and can cause rapid battery heating during Level 3 fast charging. Nissan instructs owners not to use Level 3 charging at all until a “remedy” is available. The issue is that the remedy described by Nissan is not an actual repair of the battery defect and has been significantly delayed, with no remedy provided for the loss of use of my vehicle, due to the dangers of the battery, which is still covered by warranty. Nissan states it will install software that monitors for “state-of-charge fluctuation” and, if detected, will prevent the vehicle from restarting or recharging in order to avoid a thermal incident. This means the defect inside the battery cells is still present, and the car may disable itself if the defect begins to appear. The recall materials also state there is no warning before overheating occurs. This creates multiple safety concerns: • The underlying battery defect remains uncorrected. • The vehicle can become immobilized (unable to restart or recharge) if the software detects the condition. • Loss of Level 3 charging capability affects the ability to travel safely or plan charging when needed. • A battery fire risk exists during Level 3 charging if the defect is not detected in time. Nissan’s documents state that the software is meant only to prevent the “progression” of a thermal incident, not to repair the defective battery. I am concerned that my vehicle contains a known hazardous defect that has not been physically repaired and that the software-only response is inadequate to ensure safety. I am filing this complaint so NHTSA is aware that the remedy being offered does not address the internal battery defect itself and may leave owners exposed to continued safety and reliability risks.

The contact owns a 2022 Nissan Leaf. The contact stated that while attempting to charge the vehicle, the vehicle failed to charge using the fast-charging mode. The vehicle was charged in the slow-charging mode, which took 8 hours to charge the vehicle. No warning lights were illuminated. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and confirmed that the VIN was included in NHTSA Campaign Number: 25V655000 (Electrical System). The approximate failure mileage was 18,000.

The contact owns a 2022 Nissan Leaf. The contact received notification of NHTSA Campaign Number: 25V655000 (Electrical System); however, the part to do the recall repair was not yet available. The contact stated that due to the recall, she was forced to rent vehicles to avoid experiencing the failure stated in the recall. The local dealer was contacted and confirmed that parts were not yet available. The dealer referred the contact to the NHTSA Hotline to report the failure. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

My 2022 Nissan LEAF (VIN: [XXX] , approximately 24,000 miles) is subject to an active safety recall involving the high‑voltage battery and risk of fire during DC fast charging. This includes NHTSA Recall Campaign No. 25V‑655 (Nissan Recall No. R25C8), which relates to battery overheating during Level 3 (DC fast) charging. Related prior campaigns include 24V‑700 affecting similar Nissan LEAF battery systems. Nissan has instructed owners not to use Level 3 fast charging but has failed to provide a timely repair or firm remedy date. I have been waiting [X months] with no confirmed resolution. The restriction significantly limits vehicle range and usability, increases charging time, and creates ongoing inconvenience and safety concerns. Despite the seriousness of the defect, Nissan has not offered a loaner vehicle, compensation, or alternative remedy. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My 2022 Nissan Leaf (VIN ending 558192) is affected by recall R25C8 (Lithium-ion Battery Expansion / Fire Risk from Quick Charging). The recall, announced September 30, 2025, requires a software update to the battery management system. Nissan has advised not to use the CHAdeMO DC fast charging port until remedied. No remedy is currently available, and the software update has not been deployed. This defect substantially impairs the vehicle's use, value, and safety for its intended purpose (long-distance travel), restricting it to local driving only. The delay has caused significant loss of use. We previously contacted Nissan on October 7, 2025 (Case #55896895) with no resolution. Contacted them again February 18 2026 (Case #56332493), with no resolution. This is ongoing as of February 2026.

Received recall notice in September/October 2025 that the lithium battery of my 2022 Nissan Leaf SV Plus could catch on fire if fast charged, creating a serious safety hazard. This prevents use of car on out of town trips, or fast charging in town when needed. This puts myself and others at risk of injury by fire and limits my ability to fully use my car to the extent that I was able when I purchased it from the dealership. I continue to be informed by the dealer that a software repair is being worked on, but no date for repair availability, nor confirmation that a software repair will allow me to take the car out of town for fast charging without slowing or shutting down of the system. No warning lamps have appeared, and the dealer has not examined my car.