TAKATA INFLATORS: UNDERSTANDING THAT IT IS A SUPERCHARGER AND IT WILL NOT GET THE FUEL MILEAGE AS A FOUR-CYLINDER VEHICLE I SHOULD NOT BE GOING THROUGH THIS MUCH GAS AND I DO NOT HAVE MY FOOT IN IT ALL THE TIME ALSO MY FRONT DRIVER SEAT IS ABOUT TO DISMANTLE FROM THE FLOOR THERE IS A LOT OF ELECTRICAL ISSUES WHICH I'M NOT SUR…
Read full complaint
TAKATA INFLATORS: UNDERSTANDING THAT IT IS A SUPERCHARGER AND IT WILL NOT GET THE FUEL MILEAGE AS A FOUR-CYLINDER VEHICLE I SHOULD NOT BE GOING THROUGH THIS MUCH GAS AND I DO NOT HAVE MY FOOT IN IT ALL THE TIME ALSO MY FRONT DRIVER SEAT IS ABOUT TO DISMANTLE FROM THE FLOOR THERE IS A LOT OF ELECTRICAL ISSUES WHICH I'M NOT SURE IF THAT IS WHAT IS CAUSING SENSOR PROBLEMS THE CHECK ENGINE LIGHT IS NOW ON AGAIN. I HAVE HAD OVER $3000 OF MY OWN MONEY PUT INTO THIS TRUCK ALONG WITH ANOTHER USED MOTOR AND SUPERCHARGER PUT IN RIGHT AFTER PURCHASING THIS TRUCK USED I WOULD NOT HAVE PREFERRED THEM BUYING USED I WANTED REMANUFACTURED BUT IT WAS NOT MY CHOICE THEY SAID. THE BED OF THE TRUCK IS ALSO RIDING OUT THE BRAKE SYSTEM I ALSO HAVE TO REDO AGAIN WHICH I SHOULD NOT HAVE ANY ISSUES. AND FOR A SUPERCHARGER IT SHOULD HAVE A LOT MORE POWER THAN IT DOES. I HAVE DOCUMENTATION TO PROVE THAT I HAVE SPENT SO FAR RECEIPTS AND I DO NOT EVEN LIKE TAKING THE HIGHWAY AT TIMES BECAUSE I JUST DON'T FEEL LIKE IT SAFE ENOUGH TO BE HONEST WITH YOU AND I SHOULD NOT FEEL THAT WAY WHEN I JUST PURCHASED THIS TRUCK NOT EVEN A YEAR AGO. THIS IS THE FIRST USED TRUCK I HAVE EVER PURCHASED WHERE I HAVE HAD SO MANY ISSUES WITH IT I DON'T KNOW WHETHER NOT TO BLAME MYSELF TO USE DEALERSHIP OR THE TRUCK ITSELF I FELL IN LOVE WITH THE TRUCK AT FIRST SIGHT BUT I WILL NEVER DO THAT AGAIN. WHEN IT RAINS AND I'M ON THE HIGHWAY I WILL LOSE POWER ALMOST TO THE POINT WHERE I THINK THE ENGINE AND THE ENGINE WELL ALMOST SHUT OFF I WILL HAVE TO GET OFF THE HIGHWAY SHUT THE TRUCK DOWN LET IT SIT FOR ABOUT A MINUTE OR TWO TURN IT BACK ON AND THEN PROCEED IF I STILL IN LOSING POWER I WILL HAVE TO SHUT IT OFF AGAIN AND THEN WAIT UNTIL THE TRUCK IS READY IN ORDER FOR IT TO HAVE ITS POWER BACK I DO NOT KNOW WHAT THE PROBLEM IS I'M NOT SURE IF TOO MUCH RAIN IS GETTING INTO THE ENGINE AND I'M NOT SURE WHY
NHTSA ODI #11006306
93,898 miles · Jun 21, 2011
SteeringSuspension
TL* THE CONTACT OWNS A 2002 NISSAN FRONTIER. THE CONTACT STATED THE VEHICLE WAS REPAIRED FOR THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER: 10V554000 (STEERING:COLUMN). AFTER RECEIVING THE VEHICLE FROM THE AUTHORIZED DEALER, THE CONTACT NOTICED THAT THE STEERING WHEEL WAS POSITIONED OUT OF ALIGNMENT. WHENEVER THE STEERING …
Read full complaint
TL* THE CONTACT OWNS A 2002 NISSAN FRONTIER. THE CONTACT STATED THE VEHICLE WAS REPAIRED FOR THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER: 10V554000 (STEERING:COLUMN). AFTER RECEIVING THE VEHICLE FROM THE AUTHORIZED DEALER, THE CONTACT NOTICED THAT THE STEERING WHEEL WAS POSITIONED OUT OF ALIGNMENT. WHENEVER THE STEERING WHEEL WAS POSITIONED TO DRIVE STRAIGHT, THE VEHICLE WOULD STEER TOWARDS THE RIGHT. THE MANUFACTURER AND AUTHORIZED DEALER WERE NOTIFIED, BUT OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 93,898. UPDATED 8/29/11 *CN THE DEALER INFORMED THE CONSUMER THE ALIGNMENT WAS PROBABLY OFF. UPDATED 10/03/11
NHTSA ODI #10407676
15,000 miles · Oct 4, 2010
Suspension
TL* THE CONTACT OWNS A 2002 NISSAN FRONTIER. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO THE DEALER FOR REPAIRS TO THE REAR SEALS UNDER NHTSA CAMPAIGN ID NUMBER: 02V299000 (SUSPENSION:REAR) IN 2003. ONE YEAR LATER, THE LEFT REAR SEAL BEGAN LEAKING ON THE AXLE. THEN, IN 2005 THE WHEEL ASSEMBLY FRACTURED FROM THE AXLE BECAUSE…
Read full complaint
TL* THE CONTACT OWNS A 2002 NISSAN FRONTIER. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO THE DEALER FOR REPAIRS TO THE REAR SEALS UNDER NHTSA CAMPAIGN ID NUMBER: 02V299000 (SUSPENSION:REAR) IN 2003. ONE YEAR LATER, THE LEFT REAR SEAL BEGAN LEAKING ON THE AXLE. THEN, IN 2005 THE WHEEL ASSEMBLY FRACTURED FROM THE AXLE BECAUSE THE SEAL FAILED A SECOND TIME. IN TOTAL, THE CONTACT HAS HAD THE SEALS REPLACED SEVEN TIMES AND MOST RECENTLY, THE CONTACT WAS ADVISED BY THE DEALER THAT THE REAR HOUSING WAS DEFECTIVE. THE FAILURE MILEAGE WAS 15,000 AND THE CURRENT MILEAGE WAS 21,000.
NHTSA ODI #10359034
70,000 miles · Nov 25, 2009
Suspension
NO FOLLOW UP FROM DEALER ABOUT NHTSA CAMPAIGN NUMBER 02V299000. I CALLED NISSAN TO GET MORE INFORMATION BECAUSE MY ABS SENSOR LIGHTS TEND TO TURN ON DURING RAINY DAYS. RESEARCHED ONLINE AND FOUND THIS RECALL, ASKED TO SCHEDULE MY TRUCK FOR SERVICING WITH NO RESULTS, NOT EVEN A CALL BACK. *TR
NHTSA ODI #10293602
78,000 miles · Apr 20, 2007
Suspension
TL* THE CONTACT OWNS A 2002 NISSAN FRONTIER. WHILE DRIVING 70 MPH HE HEARD A LOUD BANG AND THE VEHICLE SWERVED TO THE LEFT. THE CONTACT NOTICED THE DRIVER'S SIDE OF THE VEHICLE WAS LOWER THAN THE OTHER. HE INSPECTED THE VEHICLE AND NOTICED THE TORSION BAR FAILED. THE DEALER HAS NOT INSPECTED THE VEHICLE. THE CURRENT AND FAI…
Read full complaint
TL* THE CONTACT OWNS A 2002 NISSAN FRONTIER. WHILE DRIVING 70 MPH HE HEARD A LOUD BANG AND THE VEHICLE SWERVED TO THE LEFT. THE CONTACT NOTICED THE DRIVER'S SIDE OF THE VEHICLE WAS LOWER THAN THE OTHER. HE INSPECTED THE VEHICLE AND NOTICED THE TORSION BAR FAILED. THE DEALER HAS NOT INSPECTED THE VEHICLE. THE CURRENT AND FAILURE MILEAGES WERE 78,000. *AK
NHTSA ODI #10188418
15,000 miles · Nov 1, 2006
Suspension
DT*: THE CONTACT STATED SINCE THE VEHICLE WAS PURCHASED THERE WAS A KNOCKING SOUND UNDER THE REAR OF THE VEHICLE WHEN THE BRAKE PEDAL WAS DEPRESSED OR WHEN REVERSING AT 3 MPH. THE VEHICLE WAS TAKEN TO AN INDEPENDENT SERVICE DEALER WHO REPLACED THE REAR SHOCKS, BUT THE NOISE CONTINUED. THE SERVICE DEALER INSPECTED THE VEHICLE …
Read full complaint
DT*: THE CONTACT STATED SINCE THE VEHICLE WAS PURCHASED THERE WAS A KNOCKING SOUND UNDER THE REAR OF THE VEHICLE WHEN THE BRAKE PEDAL WAS DEPRESSED OR WHEN REVERSING AT 3 MPH. THE VEHICLE WAS TAKEN TO AN INDEPENDENT SERVICE DEALER WHO REPLACED THE REAR SHOCKS, BUT THE NOISE CONTINUED. THE SERVICE DEALER INSPECTED THE VEHICLE 5 TIMES AND COULD NOT IDENTIFY THE PROBLEM. THE MANUFACTURER WAS NOT NOTIFIED.
NHTSA ODI #10172341
35,000 miles · Jul 10, 2004
Suspension
VEHICLE BECAME HARD TO CONTROL, REGARDING STEERING AND JUST TRYING TO KEEP THE TRUCK FROM DRIFTING. DISCOVERED THAT THE RETAINING NUT HAD WORKED LOOSE AND SWAY BAR WAS NOT SECURED TO THE RIGHT SIDE OF CAR. WAS REPAIRED AT THE DEALERSHIP.*AK
NHTSA ODI #10080755
Mileage unknown · Sep 26, 2002
Suspension
CONSUMER STATES THAT WHILE DRIVING "PARTS" FELL OUT OF PASSENGER SIDE OF SUSPENSION SYSTEM. VEHICLE WAS REPAIRED BY DLR WHO ALSO STATED THEY PERFORMED A FULL INSPECTION OF SUSPENSION SYSTEM. 1 WEEK LATER "PARTS" FELL OUT OF DRIVER'S SIDE SUSPENSION. *MR
NHTSA ODI #8019624
Mileage unknown · Jan 29, 2002
Engine And Engine CoolingSuspension
WHILE DRIVING VEHICLE SUDDENLY STARTED TO SHAKE AND VIBRATE ERRATICALLY, AND THEN VEHICLE COMPLETELY SHUTDOWN. PLEASE PROVIDE ANY FURTHER INFORMATION*AK.
NISSAN IS RECALLING CERTAIN MODEL YEAR 2002-2004 FRONTIER VEHICLES MANUFACTURED FROM JULY 9, 2001 THROUGH OCTOBER 20, 2004, AND MODEL YEAR 2002-2004, XTERRA VEHICLES MANUFACTURED FROM JULY 9, 2001, THROUGH JANUARY 6, 2005. OVER TIME CORROSION MAY FORM IN THE LOWER STEERING COLUMN JOINT AND LIMIT MOVEMENT OF THE JOINT. THE LIMITED MOVEMENT OF THIS JOINT MAY CREATE EXCESSIVE LOAD ON THE LOWER STEERING COLUMN SHAFT. IF THE VEHICLE CONTINUES TO BE DRIVEN IN THIS CONDITION, IT MAY LEAD TO CRACKING OF THE SHAFT DURING LOW SPEED MANEUVERS THAT REQUIRE LARGE STEERING INPUTS.
Consequence & remedy
Consequence: THE SHAFT MAY BREAK WHICH COULD RESULT IN LOSS OF STEERING CONTROL DURING THESE LOW SPEED MANEUVERS INCREASING THE RISK OF A CRASH.
Remedy: THE STEERING COLUMN SHAFT AND JOINT WILL BE REPLACED WITH A SHAFT OF A DIFFERENT DESIGN. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 13, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
ON CERTAIN PICKUP TRUCKS EQUIPPED WITH SIX CYLINDER ENGINES AND SPORT UTILITY VEHICLES EQUIPPED WITH FOUR OR SIX CYLINDER ENGINES, THE FUEL PUMP TERMINAL ON THE FUEL-SENDING UNIT CAN DEVELOP A CRACK IN THE PLASTIC MOLDING. THIS CAN CAUSE THE TERMINAL STRIP TO CORRODE UNDER SOME ENVIRONMENTAL CONDITIONS.
Consequence & remedy
Consequence: IF CORROSION OCCURS, THE TERMINAL STRIP COULD EVENTUALLY BREAK CAUSING THE FUEL PUMP TO STOP OPERATION. THIS WILL RESULT IN NOT BEING ABLE TO START THE ENGINE OR CAUSE THE ENGINE TO STOP RUNNING WITHOUT WARNING, WHICH CAN RESULT IN A CRASH.
Remedy: IN THE FOLLOWING STATES, DEALERS WILL REPLACE THE FUEL-SENDING UNIT. THESE STATES ARE CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, TENNESSEE, VERMONT, VIRGINIA, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. IN THE OTHER STATES, THE DEALER WILL INSPECT THE FUEL PUMP TERMINAL ON THE SENDING UNIT FOR CORROSION. IF CORROSION IS PRESENT, THE DEALER WILL REPLACE THE UNIT. IF THERE IS NOT CORROSION, THE DEALER WILL APPLY SEALANT TO THE TERMINAL HOUSING TO HELP PREVENT CORROSION IN THE FUTURE. OWNER NOTIFICATION BEGAN ON JUNE 28, 2004. OWNERS SHOULD CONTACT NISSAN AT 1-800-647-7261.
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH A SUPERCHARGER, UNDER CERTAIN CONDITIONS, SUCH AS FULL THROTTLE IN LOW GEAR WHEN THE ENGINE IS NOT FULLY WARMED UP AND AT COLD AMBIENT TEMPERATURE, THE AMOUNT OF INTAKE AIR FLOW THROUGH THE AIR FLOW METER MAY EXCEED THE MAXIMUM PRESET DIAGNOSIS LIMIT VALUE.
Consequence & remedy
Consequence: THIS WILL CAUSE THE ENGINE CONTROL SYSTEM TO GO INTO THE FAILSAFE MODE. UNDER THIS CONDITION, THE MALFUNCTION INDICATOR LAMP WILL ILLUMINATE AND ENGINE SPEED WILL NOT EXCEED 2400 RPM REGARDLESS OF THE THROTTLE POSITION, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPROGRAM THE ELECTRONIC CONTROL MODULE. OWNER NOTIFICATION BEGAN JANUARY 15, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NISSAN AT 1-800-647-7261.
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, WATER MAY ENTER THE REAR AXLE HOUSING DUE TO INADEQUATE SEALING OF THE ANTI-LOCK BRAKING SYSTEM (ABS) SENSOR.
Consequence & remedy
Consequence: THIS CAN RESULT IN CORROSION AND EVENTUAL FAILURE OF THE WHEEL BEARING. IF THIS OCCURS, THE WHEEL ASSEMBLY COULD SEPARATE FROM THE VEHICLE INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE REAR AXLE FOR WATER INTRUSION AND ANY AFFECTED COMPONENTS WILL BE REPLACED. THE ABS SENSOR WILL BE RESEALED TO PREVENT WATER INTRUSION. OWNER NOTIFICATION BEGAN DECEMBER 10, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NISSAN AT 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2002 Nissan Frontier Problems, Complaints & Recalls | Skip That Year
Illustration