NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
373 reports114,000 miles · Feb 13, 2012
Fuel System, Gasoline
TL* THE CONTACT OWNS A 2005 NISSAN ARMADA. THE CONTACT STATED THAT WHILE REFUELING, FUEL WOULD SPILL OUT FROM THE FILLER NECK AND THE FUEL GAUGE WOULD DISPLAY READINGS OF BEING HALF FULL. AN AUTHORIZED DEALER WAS NOTIFIED AND THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN …
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN ARMADA. THE CONTACT STATED THAT WHILE REFUELING, FUEL WOULD SPILL OUT FROM THE FILLER NECK AND THE FUEL GAUGE WOULD DISPLAY READINGS OF BEING HALF FULL. AN AUTHORIZED DEALER WAS NOTIFIED AND THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 10V074000 (FUEL SYSTEM, OTHER:STORAGE:FUEL GAUGE SYSTEM). THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 114,000 AND THE CURRENT MILEAGE WAS 156,000.
NHTSA ODI #10447822
10,000 miles · Jan 26, 2012
Service Brakes, Hydraulic
TL* THE CONTACT OWNS A 2005 NISSAN ARMADA. THE CONTACT STATED THAT WHILE DRIVING 40 MPH, HE APPLIED THE BRAKES AND THE BRAKE PEDAL VIBRATED. A SLIPPAGE LIGHT ALSO ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT STATED THAT THE FAILURE OCCURRED WHILE DRIVING ON A DRY ROAD SURFACE. AN AUTHORIZED DEALER WAS NOTIFIED AND STATED THA…
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN ARMADA. THE CONTACT STATED THAT WHILE DRIVING 40 MPH, HE APPLIED THE BRAKES AND THE BRAKE PEDAL VIBRATED. A SLIPPAGE LIGHT ALSO ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT STATED THAT THE FAILURE OCCURRED WHILE DRIVING ON A DRY ROAD SURFACE. AN AUTHORIZED DEALER WAS NOTIFIED AND STATED THAT THE ROTORS WOULD HAVE TO BE TURNED, BUT THEY DID NOT DIAGNOSE THE ACTUAL FAILURE. THE FAILURE OCCURRED A TOTAL OF THREE TIMES AND WAS NEVER REPAIRED. THE FAILURE MILEAGE WAS 10,000 AND THE CURRENT MILEAGE WAS 140,000.
NHTSA ODI #10445491
83,000 miles · Nov 28, 2011
Engine And Engine CoolingPower Train
TL* THE CONTACT OWNS A 2005 NISSAN ARMADA. WHILE PARKED THE CONTACT ATTEMPTED TO PLACE THE VEHICLE INTO DRIVE BUT THE GEAR SHIFTER WOULD NOT MOVE. THE VEHICLE WAS TOWED TO A TRANSMISSION SHOP. THE TECHNICIAN STATED THERE WERE PIECES OF METAL IN THE TRANSMISSION LINE. THE TECHNICIAN ATTEMPTED TO UN-CLOG THE TRANSMISSION LINE BUT …
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN ARMADA. WHILE PARKED THE CONTACT ATTEMPTED TO PLACE THE VEHICLE INTO DRIVE BUT THE GEAR SHIFTER WOULD NOT MOVE. THE VEHICLE WAS TOWED TO A TRANSMISSION SHOP. THE TECHNICIAN STATED THERE WERE PIECES OF METAL IN THE TRANSMISSION LINE. THE TECHNICIAN ATTEMPTED TO UN-CLOG THE TRANSMISSION LINE BUT WAS UNABLE TO DO SO. THE TECHNICIAN STATED THE TRANSMISSION WOULD HAVE TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 83,000. ....UPDATED 12/03/12 *BF THE CONSUME STATED WHEN SHE MADE A TURN, THE VEHICLE FELT AS THOUGH IT WAS GOING TO STOP. WHEN SHE STOPPED AND LOOKED UNDER THE VEHICLE, SHE SAW A REDDISH COLOR FLUID LEAKING FROM THE VEHICLE, THE CONSUMER WENT TO THE NEAREST REPAIR SHOP WHERE SHE WAS INFORMED THREE WAS A TRANSMISSION PROBLEM. THE VEHICLE WAS THEN TOWED TO A TRANSMISSION SHOP WHERE THEY REPLACED THE RADIATOR LINE WHICH WAS LEAKING. WHEN THEY ATTEMPTED TO REPLACE THE TRANSMISSION FLUID, THEY NOTICED SEVERAL HOLES BETWEEN THE RADIATOR AND TRANSMISSION WERE CLOGGED. UPDATED 01/10/12
NHTSA ODI #10437516
65,000 miles · Oct 20, 2011
Power TrainService Brakes, Hydraulic
WHEN CRUISING AT LOW SPEED WHEN I RELEASE THE GAS PEDAL TO LET THE TRUCK COAST, IT FEELS LIKE THE BRAKES GET APPLIED SLIGHTLY AND THE TRUCK STARTS TO LOOSE SPEED. IN MY EXPERIENCE WITH ALL MY AUTOMATIC TRANSMISSION CARS IS THAT WHEN YOU RELEASE THE GAS PEDAL THE CAR WOULD COAST AND LOOSE SPEED GRADUALLY. BUT IN MY ARMADA IT ALMO…
Read full complaint
WHEN CRUISING AT LOW SPEED WHEN I RELEASE THE GAS PEDAL TO LET THE TRUCK COAST, IT FEELS LIKE THE BRAKES GET APPLIED SLIGHTLY AND THE TRUCK STARTS TO LOOSE SPEED. IN MY EXPERIENCE WITH ALL MY AUTOMATIC TRANSMISSION CARS IS THAT WHEN YOU RELEASE THE GAS PEDAL THE CAR WOULD COAST AND LOOSE SPEED GRADUALLY. BUT IN MY ARMADA IT ALMOST FEELS LIKE THE BRAKES ARE BEING APPLIED VERY SLIGHTLY. *TR
NHTSA ODI #10432287
75,000 miles · Oct 17, 2011
Engine And Engine Cooling
TL* THE CONTACT OWNS A 2005 NISSAN ARMADA. THE CONTACT STATED WHILE DRIVING 60 MPH UP HILL, THE VEHICLE STOPPED ACCELERATING. THE CONTACT RELEASED PRESSURE FROM THE ACCELERATOR PEDAL AND WHEN PRESSURE WAS REAPPLIED, THE VEHICLE RESPONDED AS NORMAL. THE FAILURE RECURRED VERY FREQUENTLY AND THE VEHICLE STALLED ON ONE OCCASION. THE…
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN ARMADA. THE CONTACT STATED WHILE DRIVING 60 MPH UP HILL, THE VEHICLE STOPPED ACCELERATING. THE CONTACT RELEASED PRESSURE FROM THE ACCELERATOR PEDAL AND WHEN PRESSURE WAS REAPPLIED, THE VEHICLE RESPONDED AS NORMAL. THE FAILURE RECURRED VERY FREQUENTLY AND THE VEHICLE STALLED ON ONE OCCASION. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO STATED THE ENGINE CONTROL MODULE FAILED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 75,000. UPDATED 11/04/11*LJ THE CONSUMER STATED THE VEHICLE CONTINUES TO STALL ON THE SLIGHTEST INCLINE. UPDATD 11/14/11
NHTSA ODI #10430482
60,000 miles · Oct 12, 2011
Service Brakes, Hydraulic
SAME ISSUE EVERYONE ELSE IS HAVING SPONGY BRAKES WHEN PRESSED NOT STOPPING, LOUD GRINDING NOISE, MAJOR SAFETY ISSUE. CAN NHTSA HELP OUT THE LITTLE GUY FOR A CHANGE AND ORDER A RECALL FOR THIS SAFETY ISSUE AT HAND WITH ALL NISSAN ARMADAS BREAKING SYSTEMS. NISSAN IS AWARE OF THE ISSUES BUT DOES NOT WANT TO FIX ITS PROBLEM. I GU…
Read full complaint
SAME ISSUE EVERYONE ELSE IS HAVING SPONGY BRAKES WHEN PRESSED NOT STOPPING, LOUD GRINDING NOISE, MAJOR SAFETY ISSUE. CAN NHTSA HELP OUT THE LITTLE GUY FOR A CHANGE AND ORDER A RECALL FOR THIS SAFETY ISSUE AT HAND WITH ALL NISSAN ARMADAS BREAKING SYSTEMS. NISSAN IS AWARE OF THE ISSUES BUT DOES NOT WANT TO FIX ITS PROBLEM. I GUESS IT TAKES A DEATH TO HAVE THEM LISTEN. IN ALL REALITY ITS NOT THE DEATH THAT WILL CAUSE THEM TO LISTEN OR FIX THE ISSUE AT HAND IT WILL BE THE LAW SUIT AGAINST NISSAN FOR THEIR UNSAFE PRACTICES. *KB
NHTSA ODI #10429921
Mileage unknown · Oct 3, 2011
Latches/locks/linkagesService Brakes, Hydraulic
WHEN DRIVING AND WHEN THE BRAKE IS APPLIED TO STOP THE BRAKE LIGHT COMES ON AND THE BRAKES SOUND LIKE THEY ARE SCRUBBING AND THE BRAKE PETAL GOES TO THE FLOOR THE VEHICLE SLOWS A LITTLE BUT IT IS STILL ROLLING. THE VEHICLE THEN HAS TO BE PUT IN PARK, THE ENGINE THEN HAS TO BE TURNED OFF. YOU THEN HAVE TO WAIT A FEW SECONDS AND …
Read full complaint
WHEN DRIVING AND WHEN THE BRAKE IS APPLIED TO STOP THE BRAKE LIGHT COMES ON AND THE BRAKES SOUND LIKE THEY ARE SCRUBBING AND THE BRAKE PETAL GOES TO THE FLOOR THE VEHICLE SLOWS A LITTLE BUT IT IS STILL ROLLING. THE VEHICLE THEN HAS TO BE PUT IN PARK, THE ENGINE THEN HAS TO BE TURNED OFF. YOU THEN HAVE TO WAIT A FEW SECONDS AND RESTART VEHICLE. IF THIS IS NOT DONE THE LIGHT DOESNT GO OFF AND THE BRAKING IS THE SAME. ALSO THE FRONT PASSENGER DOOR LOCK WORKS RANDOMLY. I HAVE THIS PROBLEM ALSO WITH MY INFINITI G35 WHICH IS ALSO MADE BY NISSAN, I HAVE TWO FRIENDS THAT OWN NISSAN VEHICLES THAT EXPERIENCE THE SAME PROBLEM WITH THEIR DOOR LOCK ON THE FRONT PASSENGER SIDE. *TR
NHTSA ODI #10428241
45,000 miles · Sep 20, 2011
Service Brakes, Hydraulic
TL* THE CONTACT OWNS A 2005 NISSAN ARMADA. WHILE DRIVING APPROXIMATELY 35 MPH, THE CONTACT ENGAGED THE BRAKE PEDAL AND AN ABNORMAL GRINDING AND PULSATION WAS EXHIBITED BY THE VEHICLE. THE VEHICLE FAILED TO PROPERLY DECELERATE. THE CONTACT DROVE TO THE SIDE OF THE ROAD AND THE ENGINE WAS TURNED OFF. UPON RESTARTING, THE VEHICLE R…
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN ARMADA. WHILE DRIVING APPROXIMATELY 35 MPH, THE CONTACT ENGAGED THE BRAKE PEDAL AND AN ABNORMAL GRINDING AND PULSATION WAS EXHIBITED BY THE VEHICLE. THE VEHICLE FAILED TO PROPERLY DECELERATE. THE CONTACT DROVE TO THE SIDE OF THE ROAD AND THE ENGINE WAS TURNED OFF. UPON RESTARTING, THE VEHICLE RESUMED NORMALLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSIS AND THEY WERE UNABLE TO LOCATE THE PROBLEM. THE MANUFACTURER WAS NOTIFIED OF THE CONSTANT FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 45,000.
NHTSA ODI #10426502
133,862 miles · Sep 18, 2011
Engine And Engine CoolingPower TrainService Brakes, Hydraulic
DRIVING FINE THEN AFTER STOPPING AT A STOP SIGN, CAR WOULD NOT ACCELERATE, LIKE IT IS IN A HIGHER GEAR. AFTER REACHING 10MPH IT DRIVES PERFECTLY FINE. IF AFTER STOPPING YOU CUT THE ENGINE AND RESTART, IT IS FINE. REVERSE WORKS FINE. CODE P1757 COMES UP ON TEST. A BAD VALVE BODY. I'VE SEEN THIS ALL OVER THE INTERNET MOSTLY ON NIS…
Read full complaint
DRIVING FINE THEN AFTER STOPPING AT A STOP SIGN, CAR WOULD NOT ACCELERATE, LIKE IT IS IN A HIGHER GEAR. AFTER REACHING 10MPH IT DRIVES PERFECTLY FINE. IF AFTER STOPPING YOU CUT THE ENGINE AND RESTART, IT IS FINE. REVERSE WORKS FINE. CODE P1757 COMES UP ON TEST. A BAD VALVE BODY. I'VE SEEN THIS ALL OVER THE INTERNET MOSTLY ON NISSAN '05 MODELS, MAYBE SOME '06. VERY FRUSTRATING, NISSAN SAYS I NEED A WHOLE NEW TRANSMISSION. I'M THINKING A RECALL SHOULD BE LOOKED INTO. IT DOESN'T SEEM TO HAPPEN ON OTHER YEAR MODELS AS MUCH. *TT
NHTSA ODI #10425943
105,000 miles · Sep 11, 2011
Service Brakes, Hydraulic
AT SLOW SPEED, BRAKES APPEAR TO FAIL. GRINDING NOISE WITH VERY MINIMAL BRAKING AS A RESULT. TURNING OFF VEHICLE AND RESTARTING SEEMS TO CLEAR THE "TROUBLE". WOULD BE DANGEROUS IN TRAFFIC SITUATION. RECURRING YET VERY OCCASIONAL PROBLEM. *TR
NHTSA ODI #10424639
Official recalls
3Oct 28, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2004-2006 ARMADA, TITAN, INFINITI QX56 AND MODEL YEAR 2005-2006 FRONTIER, PATHFINDER AND XTERRA VEHICLES. THE INTELLIGENT POWER DISTRIBUTION MODULE (IPDM) ASSEMBLY CONTAINS AN ENGINE CONTROL MODULE (ECM) RELAY THAT HAS A DIODE FOR ELECTRICAL CURRENT NOISE REDUCTION. THE ECM RELAY MAY ALLOW SILICON VAPOR TO FORM AND, OVER TIME, THE SILICON EVAPORATES FROM THE DIODE MOLDING WHICH CAUSES SILICON OXIDE TO DEVELOP ON THE ECM RELAY CONTACT DUE TO ARCING.
Consequence & remedy
Consequence: THIS COULD CAUSE ENGINE STALLING INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ECM RELAY INSIDE THE IPDM ASSEMBLY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 6, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Mar 3, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2005-2009 TITAN, ARMADA, AND INFINITI QX56 VEHICLES. THE INSTRUMENT PANEL FUEL GAUGE MAY INACCURATELY DISPLAY THAT THE VEHICLE STILL HAS SOME FUEL, TYPICALLY ABOUT ONE QUARTER TANK, WHEN THE FUEL TANK IS EMPTY.
Consequence & remedy
Consequence: THIS COULD CAUSE THE VEHICLE TO RUN OUT OF GAS AND STALL ON THE HIGHWAY, WHICH COULD CAUSE A CRASH.
Remedy: DEALERS WILL REPLACE THE FUEL SENDER UNIT INSIDE THE FUEL TANK WITH A NEW IMPROVED SENDER CARD. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 22, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Jun 27, 2008
NISSAN IS RECALLING 180,664 MY 2005-2006 TITAN, ARMADA AND INFINITY QX56 VEHICLES MANUFACTURED AFTER MARCH 17, 2005, THAT ARE EQUIPPED WITH A VISTEON AIR CONDITIONING CONDENSER FAN MOTOR. THE FAN MOTOR MAY NOT BE PROPERLY SEALED ALLOWING EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE.
Consequence & remedy
Consequence: THIS COULD CAUSE CORROSION IN THE MOTOR LEADING POSSIBLY TO OVERHEATING AND A FIRE.
Remedy: DEALERS WILL INSTALL A 'THERMAL PROTECTOR KIT' AND TEST THE AIR CONDITIONING CONDENSER FAN MOTOR AND REPLACE IT IF NECESSARY. THE RECALL BEGAN ON AUGUST 2, 2008. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE08037 · Engine Compartment Fire
Opened May 30, 2008 · Closed Aug 25, 2008
Status: closed (inferred from source dates) · Electrical System:wiring; Electrical System:wiring:front Underhood; Engine And Engine Cooling; Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Electrical System:wiring:front Underhood
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Electrical System:wiring
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
PE08004 · Side Air Bag NON-DEPLOYMENT
Opened Jan 25, 2008 · Closed May 30, 2008
Status: closed (inferred from source dates) · Air Bags:side/window
THE SUBJECT VEHICLES ARE EQUIPPED WITH OPTIONAL SEAT-MOUNTED SIDE AIR BAGS.ALL VEHICLES ARE EQUIPPED WITH STANDARD FRONTAL AIR BAGS AND SIDE AIR CURTAINS.INSTALLATION OF THE INCORRECT SRS DIAGNOSIS SENSOR UNIT DOES NOT IMPAIR DEPLOYMENT OF THE FRONTAL AIR BAG AND SIDE AIR CURTAIN IN THE EVENT OF A CRASH.NO REPORTS OF NON-DEPLOYMENT OF THE SUBJECT SEAT-MOUNTED SIDE AIR BAGS HAVE BEEN RECEIVED BY THE MANUFACTURER OR BY NHTSA.THE WARRANTY REPORTS CITED ABOVE REPRESENT VEHICLE INSPECTIONS CONDUCTED UNDER THE SERVICE CAMPAIGN AND SENSOR REPLACEMENT WAS REQUIRED IN 32 OF THESE CASES.THE MANUFACTURER REPORTS A TOTAL OF 151 SENSOR UNITS SOLD AS REPLACEMENT PARTS FOR ALL PURPOSES.INVESTIGATION DISCLOSED A LOW INCIDENCE OF SENSOR REPLACEMENT REQUIRED UNDER THE SERVICE CAMPAIGN TO DATE.NO INCIDENTS OF REAL WORLD NON-DEPLOYMENT OF THE SUBJECT AIR BAGS WERE IDENTIFIED.THIS PRELIMINARY EVALUATION IS CLOSED.
Illustration