NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
373 reports27,000 miles · Jul 20, 2012
Service Brakes
MY 05 ARMADA HAS PROBLEMS WITH THE BRAKE SENOR LIGHT COMING ON AND THE ABS SYSTEM START ACTING ERRATIC, VIBRATION UNDER DASH AND PEDAL MOVING BACK AND FORTH THE BRAKES LOCK UP AND START MAKING GRINDING SOUND AND IS HARD TO CONTROL. WHEN THE CAR IS STOPPED AND RESTARTED ALL PROBLEMS VANISH. SOMETIMES IT DOES IT WHEN THE CAR IS …
Read full complaint
MY 05 ARMADA HAS PROBLEMS WITH THE BRAKE SENOR LIGHT COMING ON AND THE ABS SYSTEM START ACTING ERRATIC, VIBRATION UNDER DASH AND PEDAL MOVING BACK AND FORTH THE BRAKES LOCK UP AND START MAKING GRINDING SOUND AND IS HARD TO CONTROL. WHEN THE CAR IS STOPPED AND RESTARTED ALL PROBLEMS VANISH. SOMETIMES IT DOES IT WHEN THE CAR IS PARKED LIKE WHEN I WENT TO THE STORE CAME OUT AND TRY TO DRIVE IT BUT IT WAS LOCKED. WHEN IM DRIVING THE CAR AND IT WITH JUST A TOUCH TO THE PEDAL THE BRAKES WOULD JUST LOCK UP. ITS UNSAFE BECAUSE THERE IS NO WARNING WHEN IT HAPPENS. I CALLED THE DEALER AND TOLD THE PERSON IN CHARGE WHAT WAS HAPPENING SHE SAID IT MIGHT BE THE BRAKE BOOSTER. I THINK ITS A COMPUTER HARD WARE OR SOFTWARE ISSUE BECAUSE ONCE ITS RE-STARTED IT GOES BACK TO NORMAL. SINCE MY INSURANCE HAS ALREADY EXPIRED AND THE LADY SAID IT WILL COST ME ABOUT 1,000 DLLS WHICH I DON'T HAVE RIGHT KNOW IT WILL BE DIFFICULT FOR ME TO FIX IT RIGHT AWAY. IF IT IS THE BRAKE BOOSTER.I HOPE IN THE MEANTIME IM LUCKY ENOUGH TO NOT BE IN A CAR ACCIDENT BECAUSE OF THIS PROBLEM THANK YOU. HELP. *TR
NHTSA ODI #10466769
77,042 miles · Jul 10, 2012
Service Brakes
WHILE TRAVELING DOWN THE ROAD, THE BRAKELIGHT COMES ON. WHEN PRESSING THE BRAKE PEDAL THERE IS NOT THE SAME AMOUNT OF BRAKING PRESSURE AND THE ABS STARTS SOUNDING OFF, CREATING A LOT OF NOISE. THE BRAKE FEEL BECOMES OVERLY GRABBY AND INCONSISTENT. THIS HAS HAPPENED AT LEAST A DOZEN TIMES TO ME PERSONALLY AS WELL AS MY WIFE. WH…
Read full complaint
WHILE TRAVELING DOWN THE ROAD, THE BRAKELIGHT COMES ON. WHEN PRESSING THE BRAKE PEDAL THERE IS NOT THE SAME AMOUNT OF BRAKING PRESSURE AND THE ABS STARTS SOUNDING OFF, CREATING A LOT OF NOISE. THE BRAKE FEEL BECOMES OVERLY GRABBY AND INCONSISTENT. THIS HAS HAPPENED AT LEAST A DOZEN TIMES TO ME PERSONALLY AS WELL AS MY WIFE. WHEN THE VEHICLE IS SHUT OFF AND THEN TURNED BACK ON IT SEEMS TO RESET AND WORK AS NORMAL, UNTIL IT DOES IT AGAIN. PLEASE HELP! THIS HAD RECENTLY HAPPENED 4 TIMES IN THE LAST 1 WEEK. THIS HAS OCCURRED 2 YEARS AGO. I WENT TO THE DEALER. THEY REPROGRAMMED SOMETHING AND HAS BEEN GOOD FOR A WHILE, BUT NOW IT IS BACK. I TOOK VEHICLE IN TO SERVICE ON JULY 9TH 2012 IS PART OF A TSB TO HAVE THE COMPUTER FLASHED OR UPDATED. DID NOT SOLVE PROBLEM, IT HAPPENED AGAIN TODAY. THIS IS BECOMING A SERIOUS AND LIFE THREATENING ISSUE WITH BRAKE FAILURE ON THIS NISSAN ARMADA. *TR
NHTSA ODI #10465107
60,000 miles · Jun 27, 2012
Service Brakes
WHILE DRIVING IN THE NEIGHBORHOOD AROUND 20 MPH, I NEEDED TO BRAKE AND NOTICE AN UNUSUAL NOISE. THIS NOISE SEEMS TO BE COMING FROM THE BRAKE BOOSTER. IN ADDITION, IT SOUNDED LIKE THE BRAKES WERE GRINDING. I NOTICE THAT THE BRAKE LAMP FROM THE INSTRUMENT CLUSTER WAS ON. DRIVING SLOWLY, I REPEATED THE BRAKING AND IT WOULD DO T…
Read full complaint
WHILE DRIVING IN THE NEIGHBORHOOD AROUND 20 MPH, I NEEDED TO BRAKE AND NOTICE AN UNUSUAL NOISE. THIS NOISE SEEMS TO BE COMING FROM THE BRAKE BOOSTER. IN ADDITION, IT SOUNDED LIKE THE BRAKES WERE GRINDING. I NOTICE THAT THE BRAKE LAMP FROM THE INSTRUMENT CLUSTER WAS ON. DRIVING SLOWLY, I REPEATED THE BRAKING AND IT WOULD DO THE SAME. SO I PULLED OVER TO THE SIDE OF THE ROAD AND TURN OFF THE TRUCK. I TURNED THE TRUCK BACK ON AND THE BRAKE LAMP IS NOW GONE. I WAS ABLE TO DRIVE HOME WITH NO PROBLEM. THIS HAS OCCURRED TO ME AT LEAST 5 TIMES. I HAVE BROUGHT IT TO THE DEALERSHIP AND THEY DID NOT SEE ANY FAULT CODE. DID A SEARCH ON THE WEB AND MANY PEOPLE HAVE HAD THE SAME ISSUE. THIS SHOULD BE A SAFETY RECALL SINCE IT PERTAINS TO THE BRAKE SYSTEM OF THE VEHICLE. *TR
NHTSA ODI #10463306
80,000 miles · Jun 20, 2012
Service Brakes
WHEN I WAS DRIVING TODAY, THE BRAKE LIGHT CAME ON AND IT WAS VERY HARD TO STOP. THIS HAS HAPPENED SEVERAL TIMES IN THE LAST SEVERAL YEARS. IT'S SCARY BECAUSE YOU CAN'T STOP LIKE NORMAL. WHEN THIS HAPPENS, I PULL OVER, TURN MY CAR OFF AND THEN ON AGAIN AND IT CLEARS IT. THIS SEEMS TO BE AN ONGOING PROBLEM FROM ONLINE COMPLA…
Read full complaint
WHEN I WAS DRIVING TODAY, THE BRAKE LIGHT CAME ON AND IT WAS VERY HARD TO STOP. THIS HAS HAPPENED SEVERAL TIMES IN THE LAST SEVERAL YEARS. IT'S SCARY BECAUSE YOU CAN'T STOP LIKE NORMAL. WHEN THIS HAPPENS, I PULL OVER, TURN MY CAR OFF AND THEN ON AGAIN AND IT CLEARS IT. THIS SEEMS TO BE AN ONGOING PROBLEM FROM ONLINE COMPLAINTS I HAVE READ AND NISSAN IS AWARE OF THIS. THIS IS A HUGE SAFETY CONCERN. PLEASE DO SOMETHING ABOUT THIS. THIS SHOULD BE WITHOUT A QUESTION, RECALLED. THANK YOU ! *JS
NHTSA ODI #10462471
50,550 miles · May 30, 2012
Service Brakes
THE BRAKE LIGHT CAME ON AND THE PEDAL WENT TO THE FLOOR ALSO A GRINDING BANGING NOISE. I SHUT THE TRUCK OFF AND STARTED IT UP AND IT WAS FINE. THIS HAS HAPPENED 4 TIMES IN THE LAST YEAR, THE LAST 2 TIMES WITHIN THE LAST WEEK. *TR
NHTSA ODI #10460016
117,690 miles · May 21, 2012
Service BrakesUnknown Or Other
I NEEDED TO STOP AND MY BRAKES WOULDN'T WORK COMPLETELY. THEY SLOWED ME DOWN A LITTLE BUT DID NOT FUNCTION COMPLETELY. THE PEDAL PUMPED UP AND DOWN MADE A WEIRD NOISE AND THE BRAKE LIGHT CAME ON. IF I HAD BEEN TRAVELING AT A FASTER SPEED AND BEEN FOLLOWING CLOSER, I WOULD HAVE WRECKED. *TT
NHTSA ODI #10459202
Mileage unknown · Apr 20, 2012
Service Brakes, Hydraulic
DRIVING HOME ABOUT 45 MPH, THE BRAKE LIGHT CAME ON. I SLOWED DOWN FOR THE UPCOMING RED LIGHT BUT THE BRAKES DID NOT WORK, THEY WENT INTO ABS MODE SO I REMOVED MY FOOT FROM THE PEDAL, RE-APPLIED PRESSURE TO THE BRAKE PEDAL AND THE BRAKES STARTED PULSING AND GRINDING VIOLENTLY. I COULD NOT STOP FOR THE RED LIGHT SO I DROPPED IT DO…
Read full complaint
DRIVING HOME ABOUT 45 MPH, THE BRAKE LIGHT CAME ON. I SLOWED DOWN FOR THE UPCOMING RED LIGHT BUT THE BRAKES DID NOT WORK, THEY WENT INTO ABS MODE SO I REMOVED MY FOOT FROM THE PEDAL, RE-APPLIED PRESSURE TO THE BRAKE PEDAL AND THE BRAKES STARTED PULSING AND GRINDING VIOLENTLY. I COULD NOT STOP FOR THE RED LIGHT SO I DROPPED IT DOWN INTO 4TH GEAR AND MADE A HARD RIGHT TURN ABOUT 25 MPH. THANKFULLY THERE WAS LITTLE TRAFFIC SO NO ACCIDENT AND NO ONE WAS HURT. I DROVE THE REMAINING TWO MILES HOMES AT 25 MPH AND WITHOUT USING THE BRAKES UNTIL I GOT TO MY DRIVEWAY. I APPLIED VERY LIGHT PRESSURE ON THE BRAKE PEDAL AND LITTLE NOISE BUT NOT MUCH STOPPING POWER, THANKFULLY MY DRIVEWAY IS UPHILL. WHEN I GOT HOME I LOOKED UP ARMADA BRAKE FAILURE AND REALIZED THAT THERE WERE HUNDREDS OF POSTS DATING BACK TO 2004, SO THIS APPEARS TO BE A COMMON ISSUE WITH THE BRAKE BOOSTER AND COMPUTER. *JS
NHTSA ODI #10455903
110,000 miles · Mar 27, 2012
Fuel System, GasolineFuel System, Other
MY 2005 NISSAN ARMADA HAS THE PROBLEM DESCRIBED IN NHTSA #10V-074. NISSAN CLAIMS MY VEHICLE IS NOT PART OF THE RECALL EVEN THOUGHT THE RECALL IS FOR 2005 - 2009 NISSAN ARMADAS. IT IS VERY FRUSTRATING TO HAVE A SAFETY PROBLEM, LEARN THAT THE MANUFACTURER IS AWARE OF IT AND HAS A RECALL, BUT TO BE TOLD THAT IT DOESN'T APPLY TO Y…
Read full complaint
MY 2005 NISSAN ARMADA HAS THE PROBLEM DESCRIBED IN NHTSA #10V-074. NISSAN CLAIMS MY VEHICLE IS NOT PART OF THE RECALL EVEN THOUGHT THE RECALL IS FOR 2005 - 2009 NISSAN ARMADAS. IT IS VERY FRUSTRATING TO HAVE A SAFETY PROBLEM, LEARN THAT THE MANUFACTURER IS AWARE OF IT AND HAS A RECALL, BUT TO BE TOLD THAT IT DOESN'T APPLY TO YOUR VEHICLE. CLEARLY IT DOES, BECAUSE I HAVE THE EXACT PROBLEM DESCRIBED, "ISSUE CAN CAUSE THE FUEL GAUGE TO SHOW THAT THE VEHICLE STILL HAS SOME FUEL, TYPICALLY ABOUT ONE QUARTER TANK, WHEN FUEL TANK IS EMPTY." *TR
NHTSA ODI #10453237
103,125 miles · Mar 22, 2012
Fuel System, Gasoline
DRIVING ALONG AND VEHICLE SPUTTERS AND SHUTS DOWN, COASTING TO A STOP. UNABLE TO RESTART. GAS GAUGE SHOWS APPROXIMATELY 1/4 TANK OF GAS REMAINING YET IT WILL NOT START. UPON GETTING SOME GAS AND PUTTING IT IN TANK, VEHICLE STARTS AGAIN AND CONTINUES TO RUN AND IS DRIVEN TO GAS STATION FOR ADDITIONAL GAS. THIS HAS HAPPENED ON APP…
Read full complaint
DRIVING ALONG AND VEHICLE SPUTTERS AND SHUTS DOWN, COASTING TO A STOP. UNABLE TO RESTART. GAS GAUGE SHOWS APPROXIMATELY 1/4 TANK OF GAS REMAINING YET IT WILL NOT START. UPON GETTING SOME GAS AND PUTTING IT IN TANK, VEHICLE STARTS AGAIN AND CONTINUES TO RUN AND IS DRIVEN TO GAS STATION FOR ADDITIONAL GAS. THIS HAS HAPPENED ON APPROXIMATELY 10 OCCASIONS. CALLED THE NISSAN CUSTOMER SERVICE LINE AND WAS TOLD THAT THEIR RECALL ON FUEL SENDING UNITS FOR NISSAN ARMADAS DID NOT INCLUDE MY VEHICLE. WAS INSTRUCTED TO SEEK FURTHER ASSISTANCE AND DIAGNOSIS FROM DEALER OR REPAIR SHOP OF MY CHOICE. DECLINED TO REPAIR & SERVICE MY VEHICLE REGARDING MY COMPLAINT. FURTHER RESEARCH ON MY PART HAS FOUND THAT THIS IS AN ISSUE WITH MANY NISSAN ARMADA VEHICLES THAT DO NOT FALL UNDER THE NISSAN RECALL UMBRELLA, WITH NISSAN DECLINING TO ADDRESS OR REPAIR THOSE VEHICLES AS WELL. NISSAN REFUSES TO RESEARCH INTO THESE COMPLAINTS WITH A BLANKET DENIAL THAT THESE VEHICLES DO NOT FALL INTO THEIR 'DETERMINED' LIST OF VEHICLE AFFECTED WITH THIS ISSUE. I WOULD MERELY LIKE MY COMPLAINT TO BE ADDRESSED AND REPAIRED ACCORDINGLY. I PURCHASED MY VEHICLE BRAND NEW IN JULY 2005. *TR
NHTSA ODI #10452628
70,000 miles · Feb 18, 2012
Service Brakes, Hydraulic
I WAS DRIVING IN A RESIDENTIAL AREA AND ATTEMPTED TO STOP AND I COULDN'T. THE BRAKES STARTED MAKING A GRINDING NOISE AND THE E-BRAKE LIGHT CAME ON. IT SLOWED DOWN ENOUGH FOR ME TO PULL TO THE SIDE AND FINALLY ABLE TO MAKE A COMPLETE STOP. I PUT IT IN PARK CHECKED THE E-BRAKE AND IT WASN'T ON AND PUT BACK INTO DRIVE WHEN THE VEHI…
Read full complaint
I WAS DRIVING IN A RESIDENTIAL AREA AND ATTEMPTED TO STOP AND I COULDN'T. THE BRAKES STARTED MAKING A GRINDING NOISE AND THE E-BRAKE LIGHT CAME ON. IT SLOWED DOWN ENOUGH FOR ME TO PULL TO THE SIDE AND FINALLY ABLE TO MAKE A COMPLETE STOP. I PUT IT IN PARK CHECKED THE E-BRAKE AND IT WASN'T ON AND PUT BACK INTO DRIVE WHEN THE VEHICLE WAS IN A SLOW ROLL I CHECKED THE BRAKES AND IT DID THE SAME THING. I PUT IT IN PARK TURNED IT OFF AND CALLED MT HUSBAND. WHEN TURNED HE TURNED IT BACK ON THE E-BRAKE LIGHT WAS OFF AND THE BRAKES WORKED. *TR
NHTSA ODI #10448432
Official recalls
3Oct 28, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2004-2006 ARMADA, TITAN, INFINITI QX56 AND MODEL YEAR 2005-2006 FRONTIER, PATHFINDER AND XTERRA VEHICLES. THE INTELLIGENT POWER DISTRIBUTION MODULE (IPDM) ASSEMBLY CONTAINS AN ENGINE CONTROL MODULE (ECM) RELAY THAT HAS A DIODE FOR ELECTRICAL CURRENT NOISE REDUCTION. THE ECM RELAY MAY ALLOW SILICON VAPOR TO FORM AND, OVER TIME, THE SILICON EVAPORATES FROM THE DIODE MOLDING WHICH CAUSES SILICON OXIDE TO DEVELOP ON THE ECM RELAY CONTACT DUE TO ARCING.
Consequence & remedy
Consequence: THIS COULD CAUSE ENGINE STALLING INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ECM RELAY INSIDE THE IPDM ASSEMBLY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 6, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Mar 3, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2005-2009 TITAN, ARMADA, AND INFINITI QX56 VEHICLES. THE INSTRUMENT PANEL FUEL GAUGE MAY INACCURATELY DISPLAY THAT THE VEHICLE STILL HAS SOME FUEL, TYPICALLY ABOUT ONE QUARTER TANK, WHEN THE FUEL TANK IS EMPTY.
Consequence & remedy
Consequence: THIS COULD CAUSE THE VEHICLE TO RUN OUT OF GAS AND STALL ON THE HIGHWAY, WHICH COULD CAUSE A CRASH.
Remedy: DEALERS WILL REPLACE THE FUEL SENDER UNIT INSIDE THE FUEL TANK WITH A NEW IMPROVED SENDER CARD. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 22, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Jun 27, 2008
NISSAN IS RECALLING 180,664 MY 2005-2006 TITAN, ARMADA AND INFINITY QX56 VEHICLES MANUFACTURED AFTER MARCH 17, 2005, THAT ARE EQUIPPED WITH A VISTEON AIR CONDITIONING CONDENSER FAN MOTOR. THE FAN MOTOR MAY NOT BE PROPERLY SEALED ALLOWING EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE.
Consequence & remedy
Consequence: THIS COULD CAUSE CORROSION IN THE MOTOR LEADING POSSIBLY TO OVERHEATING AND A FIRE.
Remedy: DEALERS WILL INSTALL A 'THERMAL PROTECTOR KIT' AND TEST THE AIR CONDITIONING CONDENSER FAN MOTOR AND REPLACE IT IF NECESSARY. THE RECALL BEGAN ON AUGUST 2, 2008. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE08037 · Engine Compartment Fire
Opened May 30, 2008 · Closed Aug 25, 2008
Status: closed (inferred from source dates) · Electrical System:wiring; Electrical System:wiring:front Underhood; Engine And Engine Cooling; Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Electrical System:wiring:front Underhood
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Electrical System:wiring
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
PE08004 · Side Air Bag NON-DEPLOYMENT
Opened Jan 25, 2008 · Closed May 30, 2008
Status: closed (inferred from source dates) · Air Bags:side/window
THE SUBJECT VEHICLES ARE EQUIPPED WITH OPTIONAL SEAT-MOUNTED SIDE AIR BAGS.ALL VEHICLES ARE EQUIPPED WITH STANDARD FRONTAL AIR BAGS AND SIDE AIR CURTAINS.INSTALLATION OF THE INCORRECT SRS DIAGNOSIS SENSOR UNIT DOES NOT IMPAIR DEPLOYMENT OF THE FRONTAL AIR BAG AND SIDE AIR CURTAIN IN THE EVENT OF A CRASH.NO REPORTS OF NON-DEPLOYMENT OF THE SUBJECT SEAT-MOUNTED SIDE AIR BAGS HAVE BEEN RECEIVED BY THE MANUFACTURER OR BY NHTSA.THE WARRANTY REPORTS CITED ABOVE REPRESENT VEHICLE INSPECTIONS CONDUCTED UNDER THE SERVICE CAMPAIGN AND SENSOR REPLACEMENT WAS REQUIRED IN 32 OF THESE CASES.THE MANUFACTURER REPORTS A TOTAL OF 151 SENSOR UNITS SOLD AS REPLACEMENT PARTS FOR ALL PURPOSES.INVESTIGATION DISCLOSED A LOW INCIDENCE OF SENSOR REPLACEMENT REQUIRED UNDER THE SERVICE CAMPAIGN TO DATE.NO INCIDENTS OF REAL WORLD NON-DEPLOYMENT OF THE SUBJECT AIR BAGS WERE IDENTIFIED.THIS PRELIMINARY EVALUATION IS CLOSED.
Illustration