2003 NISSAN ALTIMA. WIFE HIT A SMALL PIECE OF ROADWAY DEBRIS, THOUGHT TO BE A PIECE OF TIRE DEBRIS, WHICH CAUSED THE FUEL TANK TO CRACK AND LEAK FUEL FROM TANK. DAMAGE WAS NOT DISCOVERED FOR SEVERAL DAYS. RUPTURE POSED A SERIOUS FIRE HAZARD IF THERE HAD BEEN AN IGNITION SOURCE. GIVEN THE DAMAGE CAUSED BY A SMALL PIECE OF ROAD D…
Read full complaint
2003 NISSAN ALTIMA. WIFE HIT A SMALL PIECE OF ROADWAY DEBRIS, THOUGHT TO BE A PIECE OF TIRE DEBRIS, WHICH CAUSED THE FUEL TANK TO CRACK AND LEAK FUEL FROM TANK. DAMAGE WAS NOT DISCOVERED FOR SEVERAL DAYS. RUPTURE POSED A SERIOUS FIRE HAZARD IF THERE HAD BEEN AN IGNITION SOURCE. GIVEN THE DAMAGE CAUSED BY A SMALL PIECE OF ROAD DEBRIS, THE TANK, MADE OF FIBERGLASS/COMPOSITE MATERIAL, DOES NOT SEEM AS SUITABLE AS A STEEL TANK IN A MAJOR COLLISION. DEALER (NORTH TEXAS NISSAN) WOULD NOT ASSUME RESPONSIBILITY OR PASS COMPLAINT TO MANUFACTURER, SO I HAD TO PAY OVER $700 IN REPLACEMENT COSTS. DATE OF INCIDENT IS APPROXIMATE.
NHTSA ODI #10128132
60,850 miles · May 11, 2005
Engine And Engine CoolingFuel System, Gasoline
AT ABOUT 60,850 MILEAGE - 850 MILES AFTER THE WARRANTY EXPIRED, MY CAR STARTED TO STALL WHILE IN MOTION AND THE ENGINE LIGHT CAME ON. AFTER DOING A LOT OF RESEARCH AND AN ENGINE DIAGNOSTIC TEST, IT WAS FOUND THAT THE CRANK POSITION SENSOR WAS FAULTY. I WENT ON THE INTERNET AND FOUND THAT NISSAN HAD RECALLED 2002-2003 NISSAN ALTI…
Read full complaint
AT ABOUT 60,850 MILEAGE - 850 MILES AFTER THE WARRANTY EXPIRED, MY CAR STARTED TO STALL WHILE IN MOTION AND THE ENGINE LIGHT CAME ON. AFTER DOING A LOT OF RESEARCH AND AN ENGINE DIAGNOSTIC TEST, IT WAS FOUND THAT THE CRANK POSITION SENSOR WAS FAULTY. I WENT ON THE INTERNET AND FOUND THAT NISSAN HAD RECALLED 2002-2003 NISSAN ALTIMAS (ALOMST 75,000 OF THEM) BUT ONLY IN CANADA. I NEED TO KNOW WHY THEY HAVE NOT RECALLED THESE PARTS IN AMERICA. THIS IS A VERY SERIOUS SITUATION. THE CAR TENDS TO SHUT OFF AND LOSE ALL POWER WHILE IN MOTION. MYSELF BEING A COMMUTER TO AND FROM WORK ON HIGHWAYS, THIS IS VERY DANGEROUS. AFTER SPEAKING TO THE DEALERSHIP, THEY STATED THAT NISSAN HAD PUT A BULLETAN OUT ON THIS PART STATING THAT IT WAS A COMMON PROBLEM. AGAIN, PLEASE ADVISE ME WHY THIS SERIOUS SITUATION HAS NOT BEEN CORRECTED IN AMERICA.
NHTSA ODI #10120678
Mileage unknown · Sep 28, 2004
Fuel System, Gasoline
THE DEALER REFUSES TO PERFORM RECALL REPAIRS BECAUSE THE CONSUMER'S VEHICLE IS NOT IN THE REGION SPECIFIED FOR REPAIRS. *NM RECALL# 03V251000. *SC
NHTSA ODI #10095183
Mileage unknown · Aug 20, 2004
Fuel System, Gasoline
2003 NISSAN ALTIMA SAFETY RECALL REGARDING FUEL PUMP.*MR THE CONSUMER CONTACTED THE DEALER TO HAVE THE RECALL DONE AND WAS TOLD THAT THE MANUFACTURER WAS NO LONGER CORRECTING THE DEFECT IN SOUTHERN STATES. *NM
NHTSA ODI #10089545
Mileage unknown · Jun 8, 2004
Fuel System, Gasoline
2003 NISSAN ALTIMA SAFETY RECALL REGARDING DEFECT IN FUEL PUMP. *MR RECALL#03V251000. *SC THE CONSUMER WAS TOLD BY THE DEALER THAT THEY WERE NO LONGER CORRECTING THE DEFECT IN SOUTHERN STATES. *JB
NHTSA ODI #10076030
Mileage unknown · Feb 23, 2004
Electrical SystemFuel System, Gasoline
CONSUMER MADE AN APPOINTMENT WITH THE DEALER FOR A RECALL REPAIR, AND ASKED IF VEHICLE IS SAFE TO DRIVE BEFORE REPAIR DATE, DEALER SAID YES. 2 DAYS BEFORE REPAIR DATE, VEHICLE STOPPED RUNNING WHILE TRAVELING AT 65 MPH. *LA VEHICLE HAS MORE THAN A QUARTER OF GAS ON IT. CONSUMER TOOK VEHICLE TO THE DEALER, AND IT WAS LATER FOU…
Read full complaint
CONSUMER MADE AN APPOINTMENT WITH THE DEALER FOR A RECALL REPAIR, AND ASKED IF VEHICLE IS SAFE TO DRIVE BEFORE REPAIR DATE, DEALER SAID YES. 2 DAYS BEFORE REPAIR DATE, VEHICLE STOPPED RUNNING WHILE TRAVELING AT 65 MPH. *LA VEHICLE HAS MORE THAN A QUARTER OF GAS ON IT. CONSUMER TOOK VEHICLE TO THE DEALER, AND IT WAS LATER FOUND OUT THAT ICE BUILD-UP ON THE FUEL LINE WHICH CAUSED THE STALLING. PROBLEM WAS FIXED AND DEALER ASSURED CONSUMER THAT IT WAS SAFE TO DRIVE. ANOTHER RECALL THAT NEEDED REPAIR ON VEHICLE'S PRE-CATALYST. CONSUMER WAS INFORMED BY DEALER THAT REPAIR COULDN'T BE DONE IN A MONTH AND A HALF DUE TO PARTS RESTRICTION. *LA
NHTSA ODI #10060983
Mileage unknown · Feb 19, 2004
Fuel System, Gasoline
THE CONSUMER RECEIVED A RECALL NOTICE FROM THE MANUFACTURER WHICH STATED THAT CERTAIN ENGINE OPERATING CONDITIONS MAY CAUSE DAMAGE TO THE PRE-CATALYST. THE CONSUMER SCHEDULED AN APPOINTMENT WITH THE DEALER BUT, THE APPOINTMENT WAS CANCELLED DUE TO THE PARTS NOT BEING AVAILABLE. *LA *JB
NHTSA ODI #10059484
Mileage unknown · Dec 24, 2003
Fuel System, Gasoline
GASOLINE SMELL AROUND VEHICLE DUE TO LEAK ON EXHAUST PIPES. *LA THE DEALER SUGGESTED THAT THE LEAKING WAS DUE TO FAULTY FUEL TANK GAS VALVES. *SC *JB
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH A 2.5L ENGINE, THE CRANK ANGLE SENSOR IS AFFECTED BY TEMPERATURE VARIATIONS. UNDER CERTAIN DRIVING CONDITIONS, THESE VARIATIONS IN TEMPERATURE CAN BE LARGE ENOUGH TO CAUSE A BRIEF INTERRUPTION IN THE SIGNAL OUTPUT FROM THE SENSOR.
Consequence & remedy
Consequence: IF THE INTERRUPTION IN THE SIGNAL FROM THE SENSOR IS SO BRIEF THAT THE ELECTRONIC CONTROL MODULE (ECM) LOGIC DOES NOT HAVE TIME TO DIAGNOSE THE CONDITION, THE ENGINE MAY STOP RUNNING WITHOUT WARNING WHILE THE VEHICLE IS DRIVEN AT A LOW SPEED INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPROGRAM THE ECM FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 21, 2006. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
ON CERTAIN PASSENGER VEHICLES, THE CIRCUIT BOARD FOR THE CRANK POSITION SENSOR OR CAM POSITION SENSOR MAY HAVE AN IMPROPER SOLDER JOINT DUE TO SOLDER DEFORMATION CAUSED BY HEAT STRESS ACCELERATED BY THE EXISTENCE OF FLUX RESIDUE DURING THE SOLDERING PROCESS.
Consequence & remedy
Consequence: THIS COULD CAUSE THE "SERVICE ENGINE SOON" WARNING LIGHT TO COME ON, CREATE A NO START CONDITION, CAUSE REDUCED ENGINE POWER, OR CAUSE THE ENGINE TO STOP RUNNING WITHOUT WARNING DURING VEHICLE OPERATION, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE CRANK POSITION SENSORS. CAMSHAFT POSITION SENSOR(S), AND IN SOME CASES, THE VARIABLE TIMING CONTROL SENSOR(S). VEHICLES INVOLVED IN A PREVIOUS RECALL CAMPAIGN, 01V357, ARE ALSO INCLUDED IN THIS NEW CAMPAIGN. THE REPLACEMENT SENSORS USED IN THAT CAMPAIGN ARE ALSO AFFECTED. OWNER NOTIFICATION BEGAN ON DECEMBER 22, 2003. OWNERS SHOULD CONTACT NISSAN AT 1-800-647-7261 OR INFINITI AT 1-800-662-6200.
ON CERTAIN PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ALASKA, COLORADO, CONNECTICUT, IOWA, IDAHO, ILLINOIS, INDIANA, KANSAS, MASSACHUSETTS, MAINE, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NORTH DAKOTA, NEBRASKA, NEW HAMPSHIRE, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WISCONSIN, AND WYOMING. AT EXTREMELY COLD TEMPERATURES, MOISTURE IN THE FUEL TANK COULD FREEZE AND FORM ICE CRYSTALS. THESE ICE CRYSTALS MAY OBSTRUCT THE SUCTION OPENING OF THE FUEL PUMP.
Consequence & remedy
Consequence: THIS CAN PREVENT THE SUPPLY OF FUEL TO THE ENGINE AND CAUSE THE ENGINE TO STOP, WHICH COULD RESULT IN A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL A SCREEN AT THE SUCTION OPENING OF THE FUEL PUMP TO PREVENT ICE CRYSTALS FROM BLOCKING THE OPENING. OWNER NOTIFICATION BEGAN ON AUGUST 18, 2003. OWNERS SHOULD CONTACT NISSAN AT 1-800-333-0829.
ON CERTAIN VEHICLES EQUIPPED WITH THE 2.5 LITER ENGINE, THE EXHAUST PIPE HANGER PIN MAY CATCH DEBRIS FROM THE ROAD THAT COULD BE IGNITED BY CONTACT WITH THE MAIN CATALYST. ALSO ON 2002 ALTIMA AND SENTRA VEHICLES, CERTAIN ENGINE OPERATING CONDITIONS MAY CAUSE THE PRE-CATALYST TO OVERHEAT AND DAMAGE THE CATALYST SUBSTRATE.
Consequence & remedy
Consequence: EITHER OF THESE TWO CONDITIONS COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REMOVE THE PROTRUDING PORTION OF THE EXHAUST PIPE HANGER PIN. IN ADDITION TO THE CORRECTIVE ACTION, IN ORDER TO REDUCE THE RISK OF FIRE IN THE EVENT OF POOR OR IMPROPER MAINTENANCE THAT COULD RESULT IN OIL SPILLAGE, HEAT SHIELD(S) WILL BE INSTALLED ON THE PRE-CATALYST AND EXHAUST TUBE. OWNER NOTIFICATION BEGAN ON JULY 28, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NISSAN AT 1-800-647-7261. NISSAN RECALL NOS. R3007, R3014, R3015, R3016, R3017. ALSO ON 2002 ALTIMA AND SENTRA VEHICLES, CERTAIN ENGINE OPERATING CONDITIONS MAY CAUSE THE PRE-CATALYST TO OVERHEAT AND DAMAGE THE CATALYST SUBSTRATE. IF SUBSTRATE PARTICLES ENTER THE COMBUSTION CHAMBER, THEY COULD SCORE THE CYLINDER WALLS, RESULTING IN INCREASED OIL CONSUMPTION. IF THE ENGINE OIL LEVEL IS NOT CHECKED ON A PERIODIC BASIS AND DROPS BELOW THE LOW LEVEL, AND THE DRIVER CONTINUES TO OPERATE THE VEHICLE IGNORING NOTICEABLE ENGINE NOISE, ENGINE DAMAGE MAY OCCUR WHICH COULD RESULT IN A FIRE. THE PRE-CATALYST WILL BE TESTED TO ENSURE IT IS WORKING PROPERLY AND REPLACED IF NECESSARY. IF DAMAGE IS FOUND INSIDE THE PRE-CATALYST, IT WILL BE NECESSARY TO REPLACE THE ENGINE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
RQ06001 · Engine Stall - Crank Position Sensor
Opened Feb 22, 2006 · Closed Jul 18, 2006
Status: closed (inferred from source dates) · Engine And Engine Cooling
ON JUNE 28, 2006 NISSAN SUBMITTED TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) A PART 573 REPORT ADVISING THAT CERTAIN MODEL YEAR 2003 NISSAN SENTRA AND NISSAN ALTIMA SEDANS EQUIPPED WITH 2.5L ENGINES WOULD BE RECALLED TO REPROGRAM THE ELECTRONIC CONTROL MODULE (ECM). THE RECALL IS IDENTIFIED BY NHTSA RECALL NO. 06V242. THE SUBJECT POPULATIONS OF THE RECALL ARE 14,587 NISSAN SENTRA VEHICLES AND 186,279 NISSAN ALTIMA VEHICLES.NISSAN DETERMINED THAT THE OPERATION OF THE CRANK ANGLE SENSOR IN ALTIMA AND SENTRA SEDANS EQUIPPED WITH A 2.5L ENGINE WAS SIGNIFICANTLY AFFECTED BY TEMPERATURE VARIATIONS DUE TO THE UNIQUE LOCATION OF THE SENSOR. UNDER CERTAIN DRIVING CONDITIONS THE TEMPERATURE VARIATIONS MAY CAUSE A BRIEF INTERRUPTION IN THE SIGNAL OUTPUT FROM THE SENSOR.IF THE INTERRUPTION IS BRIEF ENOUGH, SUCH THAT THE ELECTRONIC CONTROL MODULE (ECM) LOGIC DOES NOT HAVE TIME TO DIAGNOSE THE CONDITION, THE ENGINE MAY STOP RUNNING WHILE THE VEHICLE IS DRIVEN AT A LOW SPEED. AS A REMEDY, NISSAN WILL REPROGRAM THE ECM TO PREVENT THE STALLING INCIDENTS DUE TO SIGNAL INTERRUPTIONS FROM THE CRANK ANGLE SENSOR.ADDITIONALLY, AS PART OF THE RECALL QUERY, NISSAN WAS REQUESTED TO PROVIDE COMPLAINT INFORMATION FOR MY 2004 ALTIMA FOR COMPARATIVE PURPOSES.NISSAN HAS INDICATED TO ODI THAT THE SCOPE OF THE RECALL IS LIMITED TO THE MY 2003 AS COMPARATIVELY, THE MY 2004 COMPLAINT RATE IS SUBSTANTIALLY LOWER. ODI WILL CONTINUE TO MONITOR THE COMPLAINT RATE OF THE MY 2004 ALTIMA. ACCORDINGLY THE RECALL QUERY IS CLOSED.
Additional source detail variants (2)
Engine And Engine Cooling
ON JUNE 28, 2006 NISSAN SUBMITTED TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) A PART 573 REPORT ADVISING THAT CERTAIN MODEL YEAR 2003 NISSAN SENTRA AND NISSAN ALTIMA SEDANS EQUIPPED WITH 2.5L ENGINES WOULD BE RECALLED TO REPROGRAM THE ELECTRONIC CONTROL MODULE (ECM). THE RECALL IS IDENTIFIED BY NHTSA RECALL NO. 06V242. THE SUBJECT POPULATIONS OF THE RECALL ARE 14,587 NISSAN SENTRA VEHICLES AND 186,279 NISSAN ALTIMA VEHICLES.NISSAN DETERMINED THAT THE OPERATION OF THE CRANK ANGLE SENSOR IN ALTIMA AND SENTRA SEDANS EQUIPPED WITH A 2.5L ENGINE WAS SIGNIFICANTLY AFFECTED BY TEMPERATURE VARIATIONS DUE TO THE UNIQUE LOCATION OF THE SENSOR. UNDER CERTAIN DRIVING CONDITIONS THE TEMPERATURE VARIATIONS MAY CAUSE A BRIEF INTERRUPTION IN THE SIGNAL OUTPUT FROM THE SENSOR.IF THE INTERRUPTION IS BRIEF ENOUGH, SUCH THAT THE ELECTRONIC CONTROL MODULE (ECM) LOGIC DOES NOT HAVE TIME TO DIAGNOSE THE CONDITION, THE ENGINE MAY STOP RUNNING WHILE THE VEHICLE IS DRIVEN AT A LOW SPEED. AS A REMEDY, NISSAN WILL REPROGRAM THE ECM TO PREVENT THE STALLING INCIDENTS DUE TO SIGNAL INTERRUPTIONS FROM THE CRANK ANGLE SENSOR.ADDITIONALLY, AS PART OF THE RECALL QUERY, NISSAN WAS REQUESTED TO PROVIDE COMPLAINT INFORMATION FOR MY 2004 ALTIMA FOR COMPARATIVE PURPOSES.NISSAN HAS INDICATED TO ODI THAT THE SCOPE OF THE RECALL IS LIMITED TO THE MY 2003 AS COMPARATIVELY, THE MY 2004 COMPLAINT RATE IS SUBSTANTIALLY LOWER. ODI WILL CONTINUE TO MONITOR THE COMPLAINT RATE OF THE MY 2004 ALTIMA. ACCORDINGLY THE RECALL QUERY IS CLOSED.
Engine And Engine Cooling
ON JUNE 28, 2006 NISSAN SUBMITTED TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) A PART 573 REPORT ADVISING THAT CERTAIN MODEL YEAR 2003 NISSAN SENTRA AND NISSAN ALTIMA SEDANS EQUIPPED WITH 2.5L ENGINES WOULD BE RECALLED TO REPROGRAM THE ELECTRONIC CONTROL MODULE (ECM). THE RECALL IS IDENTIFIED BY NHTSA RECALL NO. 06V242. THE SUBJECT POPULATIONS OF THE RECALL ARE 14,587 NISSAN SENTRA VEHICLES AND 186,279 NISSAN ALTIMA VEHICLES.NISSAN DETERMINED THAT THE OPERATION OF THE CRANK ANGLE SENSOR IN ALTIMA AND SENTRA SEDANS EQUIPPED WITH A 2.5L ENGINE WAS SIGNIFICANTLY AFFECTED BY TEMPERATURE VARIATIONS DUE TO THE UNIQUE LOCATION OF THE SENSOR. UNDER CERTAIN DRIVING CONDITIONS THE TEMPERATURE VARIATIONS MAY CAUSE A BRIEF INTERRUPTION IN THE SIGNAL OUTPUT FROM THE SENSOR.IF THE INTERRUPTION IS BRIEF ENOUGH, SUCH THAT THE ELECTRONIC CONTROL MODULE (ECM) LOGIC DOES NOT HAVE TIME TO DIAGNOSE THE CONDITION, THE ENGINE MAY STOP RUNNING WHILE THE VEHICLE IS DRIVEN AT A LOW SPEED. AS A REMEDY, NISSAN WILL REPROGRAM THE ECM TO PREVENT THE STALLING INCIDENTS DUE TO SIGNAL INTERRUPTIONS FROM THE CRANK ANGLE SENSOR.ADDITIONALLY, AS PART OF THE RECALL QUERY, NISSAN WAS REQUESTED TO PROVIDE COMPLAINT INFORMATION FOR MY 2004 ALTIMA FOR COMPARATIVE PURPOSES.NISSAN HAS INDICATED TO ODI THAT THE SCOPE OF THE RECALL IS LIMITED TO THE MY 2003 AS COMPARATIVELY, THE MY 2004 COMPLAINT RATE IS SUBSTANTIALLY LOWER. ODI WILL CONTINUE TO MONITOR THE COMPLAINT RATE OF THE MY 2004 ALTIMA. ACCORDINGLY THE RECALL QUERY IS CLOSED.
Illustration