IllustrationMY BRAKES ARE GOING OUT FAST. MY HEATER TAKES FOREVER TO HEAT UP. MY FUSES KEEP BURNING OUT,CAR LIGHTER DON'T WORK. IT RUNS ROUGH. I THINK IT HAS A SHORT ON SOME WIRES.
2002 Nissan Altima
Owner reports · Recalls · Investigations
More warning signs than most Altima years
Owner complaints for the 2002 Nissan Altima are substantially higher than the model-year median of 231.
About this comparison →How this year compares
Owner complaints by model year
Compare all Altima years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
720–25K
7425–50K
12150–75K
23575–100K
239100–150K
60150K+
801 reports with mileage · 246 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 594 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 128 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 92 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
29 crash reports28 fire reports23 injury reports
Exterior Lighting complaints
41 reportsHEADLIGHTS WAS SO FOGGED UP COULDNT SEE 25 FEET IN FRONT OF YOU WITH THEM ON BRIGHT BAD SAFTY HAZZARD.
" TAKATA RECALL " . THE CAR HAS BEEN GIVING ENGINE PROBLEMS BUT I DID NOT KNOW WHAT IT WAS UNTIL I SEARCHED IT ONLINE AND I AM HAVING THE SAME PROBLEM AS MANY COMPLAINT ON THE RECALL WEBSITE. THE ENGINE WHILE ON SLOW DRIVE OR WHEN ON A FULL STOP IT SHUTS DOWN WITHOUT ANY WARNING. IT HAS HAPPENED TO ME A COUPLE OF TIMES ONCE I WA…
Read full complaint
" TAKATA RECALL " . THE CAR HAS BEEN GIVING ENGINE PROBLEMS BUT I DID NOT KNOW WHAT IT WAS UNTIL I SEARCHED IT ONLINE AND I AM HAVING THE SAME PROBLEM AS MANY COMPLAINT ON THE RECALL WEBSITE. THE ENGINE WHILE ON SLOW DRIVE OR WHEN ON A FULL STOP IT SHUTS DOWN WITHOUT ANY WARNING. IT HAS HAPPENED TO ME A COUPLE OF TIMES ONCE I WAS ON A HIGHWAY BUT THERE WAS TRAFFIC AND MY CAR SHUT DOWN. ANOTHER TIME I WAS AT A REGULAR CITY ROAD AND I WAS DRIVING SLOW LOOKING FOR PARKING AND THE CAR SHUT DOWN BUT THANKFULLY THE CAR BEHIND ME WAS FAR AND I TURNED MY BLINKERS ON, BUT THANKFULLY NO CRASHES AS OF YET. MANY OTHER TIMES IT HAS SHUT DOWN ON RED LIGHTS, STOP SIGNS ANYWHERE THAT IT HAS BEEN SLOW MOTION. RECENTLY AFTER SO LONG OF HAVING THESE TROUBLES, MY CAR WILL TAKE FOREVER TO TURN ON. IT STARTS BUT IT MAKES A WEIRD NOISE FROM THE ENGINE AND IT SHUTS DOWN. I AM A FULL TIME STUDENT AND IT WOULD BE GREAT TO FIX MY CAR AND ACTUALLY DRIVE TO SCHOOL WITH LESS WORRIES THAT MY CAR WILL SHUT DOWN IN THE MIDDLE OF THE HIGHWAY OR REGULAR ROAD AND BE IN A FATAL CRASH. I HAVE ALSO TRIED MALECHANICS OR CHECK THE ENGINE WITH THE MACHINES AND EVERYONE IS SAYING THAT THE PROBLEM IS IN THE ENGINE AND I HAVE CHECKED THE ENGINE MYSELF, THE ENGINE IS HOT, SHAKES, MAKES NOISES.
TL* THE CONTACT OWNS A 2002 NISSAN ALTIMA. THE CONTACT STATED THAT THERE WAS A HAZE COVERING THE HEADLIGHTS ON THE VEHICLE. AN INDEPENDENT MECHANIC CLEANED THE HEADLIGHTS, BUT THE FAILURE RECURRED MULTIPLE TIMES. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 60,000.
TL*THE CONTACT OWNS A 2002 NISSAN ALTIMA. INITIALLY, THE REAR SEAT BELTS ON BOTH SIDES OF THE VEHICLE WOULD NOT RELEASE ON AN INTERMITTENT BASIS. CURRENTLY, THEY DO NOT WORK AT ALL. THE DEALER HAS NOT YET BEEN NOTIFIED. THE FRONT DRIVER AND PASSENGER SIDE HEADLAMPS DIM ON THEIR OWN; HOWEVER, THE INSTRUMENT CONTROL PANEL SHOW…
Read full complaint
TL*THE CONTACT OWNS A 2002 NISSAN ALTIMA. INITIALLY, THE REAR SEAT BELTS ON BOTH SIDES OF THE VEHICLE WOULD NOT RELEASE ON AN INTERMITTENT BASIS. CURRENTLY, THEY DO NOT WORK AT ALL. THE DEALER HAS NOT YET BEEN NOTIFIED. THE FRONT DRIVER AND PASSENGER SIDE HEADLAMPS DIM ON THEIR OWN; HOWEVER, THE INSTRUMENT CONTROL PANEL SHOW THEM AS BEING ACTIVATED. NHTSA CAMPAIGN ID NUMBER 073054000 (EXTERIOR LIGHTING:HEADLIGHTS) WAS REFERENCED. THE CONTACT RECEIVED A TICKET DUE TO THE HEADLAMP FAILURE. THE CURRENT MILEAGE WAS 96,791 AND FAILURE MILEAGE WAS 95,000.
MY 2002 NISSAN ALTIMA VEHICLE WAS TAKEN IN FOR SERVICE AT BOB BELL CHEVROLET NISSAN, 7900 EASTERN AVENUE, BALTIMORE, MARYLAND, 21224, ON THURSDAY, AUGUST 2, 2007. IT WAS BROUGHT IN FOR SERVICING OF ALL THE VEHICLES' RECALLS, A SOFT GRINDING NOISE THAT COULD BE HEARD WHEN TURNING THE STEERING WHEEL AND LOW FREON LEVELS FOR AIR CO…
Read full complaint
MY 2002 NISSAN ALTIMA VEHICLE WAS TAKEN IN FOR SERVICE AT BOB BELL CHEVROLET NISSAN, 7900 EASTERN AVENUE, BALTIMORE, MARYLAND, 21224, ON THURSDAY, AUGUST 2, 2007. IT WAS BROUGHT IN FOR SERVICING OF ALL THE VEHICLES' RECALLS, A SOFT GRINDING NOISE THAT COULD BE HEARD WHEN TURNING THE STEERING WHEEL AND LOW FREON LEVELS FOR AIR CONDITIONING. ON FRIDAY AFTERNOON, AUGUST 3, 2007 AROUND 5PM, I WAS CONTACTED BY THE SERVICE DEPARTMENT AND STRONGLY ADVISED TO PICK UP THE VEHICLE BEFORE THE SERVICE DIVISION CLOSED AT 6PM. THE DEALERSHIP STATED THAT ALL RECALLS AND ISSUES HAD BEEN RESOLVED AND COMPLETED. I PICKED THE VEHICLE UP AROUND 5:45PM AND PROCEEDED TO TRAVEL HOME. AFTER ONLY FIFTEEN MINUTES, THE VEHICLE ENGINE STARTED TO SMOKE PROFUSELY. THE ENGINE STARTED SHAKING HARDER AND HARDER AND A LOUD RATTLING NOISE COULD BE HEARD FROM WITHIN THE ENGINE. THE TEENAGE PASSENGER IN THE VEHICLE BEGAN TO VOMIT AND HER EYES STARTED SWELLING DUE TO THE VOLUME OF FUMES EXPELLED FROM THE CARS ENGINE THROUGH THE VENTILATION AND INTO THE CAR. I IMMEDIATELY PULLED OVER (3700 EASTERN BLVD.) AND RUSHED TO GET HER OUT OF THE SEAT WHERE SHE CONTINUED TO VOMIT ONCE OUTSIDE THE VEHICLE. THE DEALERSHIP NOW DENIES EVER SEEING SMOKE FROM THE ENGINE (SEE ATTACH.), AS WELL AS, DENIED CAUSING DAMAGE TO MY CAR THAT POTENTIALLY RESULTED IN THE ENGINE SMOKING. THE VEHICLE WAS PICKED UP ON WEDNESDAY, AUGUST 8, 2007 WITH THE ENGINE RATTLING UNCONTROLLABLY EVEN AFTER BEING RETURNED A SECOND TIME TO THE DEALERSHIP. THE VEHICLE CUT OFF WHILE ATTEMPTING TO DE-ACCELERATE AT A RED LIGHT THE FOLLOWING DAY. UNCERTAINTY SURROUNDS WHETHER THE VEHICLE WILL CUT OFF AGAIN WHILE DE-ACCELERATING PROVING IT HAZARDOUS TO DRIVE, WHETHER THE VEHICLES FIVE RECALLS WHERE ALL PROPERLY ADDRESSED, AND IF THE ENGINE WILL START SMOKING AGAIN. *TR
DEFECTIVE HEADLAMPS. CLIP MELTS FROM HIGH HEAT, BULB LOSES CONTACT. REQUIRES REPLACEMENT OF ENTIRE ASSEMBLY, OR IF NOT, REMOVAL OF FRONT BUMPER JUST TO REPLACE BULB. FIRST TIME OCCURRED AT NIGHT ON A HIGHWAY -- WENT TO AUTO PARTS STORE BUT COULD NOT ACCESS TO CHANGE THE BULB. DEALER CHARGED TWO HOURS TO PULL FRONT BUMPER -- …
Read full complaint
DEFECTIVE HEADLAMPS. CLIP MELTS FROM HIGH HEAT, BULB LOSES CONTACT. REQUIRES REPLACEMENT OF ENTIRE ASSEMBLY, OR IF NOT, REMOVAL OF FRONT BUMPER JUST TO REPLACE BULB. FIRST TIME OCCURRED AT NIGHT ON A HIGHWAY -- WENT TO AUTO PARTS STORE BUT COULD NOT ACCESS TO CHANGE THE BULB. DEALER CHARGED TWO HOURS TO PULL FRONT BUMPER -- ONLY TOOK ONE HOUR. COST OF REPLACING BULB ABOUT $260. BULB BY ITSELF IS LESS THAN $30. *JB
CONTINUAL FAILURE OF LOW BEAM HEADLAMPS ON 2002 NISSAN ALTIMA SE. HAVE REPLACED LAMP NUMEROUS TIMES. BAD GROUND CONTACT. DUE TO FAILURE OF LAMP, HAVE HAD TO DRIVE AT NIGHT EITHER WITH ONE HEADLAMP, OR WITH HIGH BEAMS ON. *JB
2002 NISSAN ATLIMA CUSTOMER STATES SINCE 30,000 MILES THE CHECK ENGINE LIGHT HAS BEEN ON**CC THE CONSUMER WAS UNABLE TO DEFROST THE WINDOWS, DUE TO THE DEFROSTER BEING INOPERATIVE. THE CONSUMER STATED THE VEHICLE WOULD LOSE POWER, SO HE WOULD HAVE TO TAKE HIS FOOT OFF THE GAS AND EVENTUALLY IT WOULD GAIN SPEED. THE CONSUMER HA…
Read full complaint
2002 NISSAN ATLIMA CUSTOMER STATES SINCE 30,000 MILES THE CHECK ENGINE LIGHT HAS BEEN ON**CC THE CONSUMER WAS UNABLE TO DEFROST THE WINDOWS, DUE TO THE DEFROSTER BEING INOPERATIVE. THE CONSUMER STATED THE VEHICLE WOULD LOSE POWER, SO HE WOULD HAVE TO TAKE HIS FOOT OFF THE GAS AND EVENTUALLY IT WOULD GAIN SPEED. THE CONSUMER HAD VARIOUS REPAIRS MADE ON THE VEHICLE. THE CATALYTIC CONVERTER WAS DETERIORATING, THE VALVE COVER GASKET WAS REPLACED, THE HEADLIGHT WAS REPLACED 3 TIMES, THE TAIL LIGHT ASSEMBLY NEEDED TO REPLACED THE CONSUMER WAS TOLD THE VEHICLE NEEDED A NEW ENGINE AFTER EXPERIENCING THE STALLING AND NO START PROBLEMS. *JB
DT*: THE CONTACT STATED THE AIR BAG LIGHT ON THE DASH FLASHED CONSTANTLY. THERE IS A SAFETY IMPROVEMENT CAMPAIGN, # 02I001000, REGARDING THE AIR BAG. THE VEHICLE HAS THE SAME PROBLEMS AS INDICATED IN THE SAFETY IMPROVEMENT CAMPAIGN; HOWEVER IT IS NOT INCLUDED IN THE SAFETY IMPROVEMENT CAMPAIGN DUE TO THE VIN. UPDATED 4/17/20…
Read full complaint
DT*: THE CONTACT STATED THE AIR BAG LIGHT ON THE DASH FLASHED CONSTANTLY. THERE IS A SAFETY IMPROVEMENT CAMPAIGN, # 02I001000, REGARDING THE AIR BAG. THE VEHICLE HAS THE SAME PROBLEMS AS INDICATED IN THE SAFETY IMPROVEMENT CAMPAIGN; HOWEVER IT IS NOT INCLUDED IN THE SAFETY IMPROVEMENT CAMPAIGN DUE TO THE VIN. UPDATED 4/17/2006 - THE VEHICLE WAS TAKEN TO A DEALER WHO INDICATED THAT EH AIR BAG WAS DEFECTIVE. THE DEALER REFUSED ANY ASSISTANCE BECAUSE THE VEHICLE WAS 2000 MILE OUT OF WARRANTY. THE CHECK ENGINE LIGHT ILLUMINATED. THE DEALER FOUND ANTIFREEZE LEAKING INTO THE CYLINDERS. THE DRIVER'S SIDE LOW BEAM HEADLAMP WAS INOP. THE TECH REPLACED THE RIGHT SIDE HEADLIGHT BULB. RADIATOR LEAKED COOLANT. THE HEATER BLEW OUT COOL AIR WHEN THE VEHICLE WAS STOPPED. THE TECH FOUND AN AIR POCKET IN THE COOLANT SYSTEM. REPLACED CLUTCH ASSEMBLY. CYLINDER HEAD GASKET WAS REPLACED. *NM
Official recalls
507V527000 · Engine And Engine Cooling
Nov 14, 2007
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH A 2.5L ENGINE, THE CRANKSHAFT POSITION SENSOR CAN OVERHEAT CAUSING A BRIEF INTERRUPTION IN THE SIGNAL OUTPUT FROM THE SENSOR.
Consequence & remedy
Consequence: IF THE INTERRUPTION IN THE SIGNAL FROM THE CRANKSHAFT POSITION SENSOR IS SO BRIEF THAT THE ELECTRONIC CONTROL MODULE (ECM) LOGIC DOES NOT HAVE TIME TO DIAGNOSE THE CONDITION, THE ENGINE MAY STOP RUNNING WITHOUT WARNING WHILE THE VEHICLE IS DRIVEN AT A LOW SPEED INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPROGRAM THE ECM FREE OF CHARGE. CERTAIN MY 2006 ALTIMAS WHICH HAVE BEEN PREVIOUSLY REMEDIED UNDER RECALL CAMPAIGN 06V223 (NISSAN R0606) ARE NOT INCLUDED IN THIS RECALL SINCE THE REPROGRAMMING FOR 06V223 ALSO INCLUDED THIS REPROGRAMMING. THE RECALL BEGAN ON DECEMBER 31, 2007. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
03V455000 · Engine And Engine Cooling
Nov 17, 2003
ON CERTAIN PASSENGER VEHICLES, THE CIRCUIT BOARD FOR THE CRANK POSITION SENSOR OR CAM POSITION SENSOR MAY HAVE AN IMPROPER SOLDER JOINT DUE TO SOLDER DEFORMATION CAUSED BY HEAT STRESS ACCELERATED BY THE EXISTENCE OF FLUX RESIDUE DURING THE SOLDERING PROCESS.
Consequence & remedy
Consequence: THIS COULD CAUSE THE "SERVICE ENGINE SOON" WARNING LIGHT TO COME ON, CREATE A NO START CONDITION, CAUSE REDUCED ENGINE POWER, OR CAUSE THE ENGINE TO STOP RUNNING WITHOUT WARNING DURING VEHICLE OPERATION, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE CRANK POSITION SENSORS. CAMSHAFT POSITION SENSOR(S), AND IN SOME CASES, THE VARIABLE TIMING CONTROL SENSOR(S). VEHICLES INVOLVED IN A PREVIOUS RECALL CAMPAIGN, 01V357, ARE ALSO INCLUDED IN THIS NEW CAMPAIGN. THE REPLACEMENT SENSORS USED IN THAT CAMPAIGN ARE ALSO AFFECTED. OWNER NOTIFICATION BEGAN ON DECEMBER 22, 2003. OWNERS SHOULD CONTACT NISSAN AT 1-800-647-7261 OR INFINITI AT 1-800-662-6200.
03V251000 · Fuel System, Gasoline:storage:tank Assembly
Jul 14, 2003
ON CERTAIN PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ALASKA, COLORADO, CONNECTICUT, IOWA, IDAHO, ILLINOIS, INDIANA, KANSAS, MASSACHUSETTS, MAINE, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NORTH DAKOTA, NEBRASKA, NEW HAMPSHIRE, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WISCONSIN, AND WYOMING. AT EXTREMELY COLD TEMPERATURES, MOISTURE IN THE FUEL TANK COULD FREEZE AND FORM ICE CRYSTALS. THESE ICE CRYSTALS MAY OBSTRUCT THE SUCTION OPENING OF THE FUEL PUMP.
Consequence & remedy
Consequence: THIS CAN PREVENT THE SUPPLY OF FUEL TO THE ENGINE AND CAUSE THE ENGINE TO STOP, WHICH COULD RESULT IN A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL A SCREEN AT THE SUCTION OPENING OF THE FUEL PUMP TO PREVENT ICE CRYSTALS FROM BLOCKING THE OPENING. OWNER NOTIFICATION BEGAN ON AUGUST 18, 2003. OWNERS SHOULD CONTACT NISSAN AT 1-800-333-0829.
03V084000 · Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
Mar 11, 2003
ON CERTAIN VEHICLES EQUIPPED WITH THE 2.5 LITER ENGINE, THE EXHAUST PIPE HANGER PIN MAY CATCH DEBRIS FROM THE ROAD THAT COULD BE IGNITED BY CONTACT WITH THE MAIN CATALYST. ALSO ON 2002 ALTIMA AND SENTRA VEHICLES, CERTAIN ENGINE OPERATING CONDITIONS MAY CAUSE THE PRE-CATALYST TO OVERHEAT AND DAMAGE THE CATALYST SUBSTRATE.
Consequence & remedy
Consequence: EITHER OF THESE TWO CONDITIONS COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REMOVE THE PROTRUDING PORTION OF THE EXHAUST PIPE HANGER PIN. IN ADDITION TO THE CORRECTIVE ACTION, IN ORDER TO REDUCE THE RISK OF FIRE IN THE EVENT OF POOR OR IMPROPER MAINTENANCE THAT COULD RESULT IN OIL SPILLAGE, HEAT SHIELD(S) WILL BE INSTALLED ON THE PRE-CATALYST AND EXHAUST TUBE. OWNER NOTIFICATION BEGAN ON JULY 28, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NISSAN AT 1-800-647-7261. NISSAN RECALL NOS. R3007, R3014, R3015, R3016, R3017. ALSO ON 2002 ALTIMA AND SENTRA VEHICLES, CERTAIN ENGINE OPERATING CONDITIONS MAY CAUSE THE PRE-CATALYST TO OVERHEAT AND DAMAGE THE CATALYST SUBSTRATE. IF SUBSTRATE PARTICLES ENTER THE COMBUSTION CHAMBER, THEY COULD SCORE THE CYLINDER WALLS, RESULTING IN INCREASED OIL CONSUMPTION. IF THE ENGINE OIL LEVEL IS NOT CHECKED ON A PERIODIC BASIS AND DROPS BELOW THE LOW LEVEL, AND THE DRIVER CONTINUES TO OPERATE THE VEHICLE IGNORING NOTICEABLE ENGINE NOISE, ENGINE DAMAGE MAY OCCUR WHICH COULD RESULT IN A FIRE. THE PRE-CATALYST WILL BE TESTED TO ENSURE IT IS WORKING PROPERLY AND REPLACED IF NECESSARY. IF DAMAGE IS FOUND INSIDE THE PRE-CATALYST, IT WILL BE NECESSARY TO REPLACE THE ENGINE.
03V061000 · Air Bags:frontal:driver Side:inflator Module
Feb 27, 2003
ON CERTAIN VEHICLES, THE ELECTRICAL CONNECTOR FOR THE DRIVER AIR BAG MAY COME LOOSE. IF THE CONNECTOR COMES LOOSE, THE SUPPLEMENTAL AIR BAG WARNING LIGHT FLASHES INTERMITTENTLY.
Consequence & remedy
Consequence: THE DRIVER SIDE AIR BAG WILL NOT DEPLOY IN THE EVENT OF A CRASH, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL INSTALL A RETAINING CLIP ON THE CLOCK SPRING ELECTRICAL CONNECTOR. OWNER NOTIFICATION BEGAN APRIL 21, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NISSAN AT 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE02078 · Engine Compartment Fires
Opened Oct 18, 2002 · Closed Mar 25, 2003
Status: closed (inferred from source dates) · Engine And Engine Cooling:exhaust System; Engine And Engine Cooling:exhaust System:emission Control:catalytic Convertor
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION ON OCTOBER 18, 2002 BASED ON THREE REPORTS INDICATING THAT THE ENGINE COMPARTMENT IN MODEL YEAR (MY) 2002 NISSAN ALTIMA VEHICLES EQUIPPED WITH THE 2.5 LITER ENGINE CAUGHT ON FIRE WITHOUT ANY WARNING TO THE DRIVER WHILE THE VEHICLE WAS DRIVEN AT HIGHWAY SPEEDS.ONE NON-BURN RELATED INJURY WAS REPORTED AS A RESULT OF THE COMPLAINANT EXITING THE VEHICLE IN HASTE AFTER IT HAD CAUGHT ON FIRE.NISSAN DISCOVERED THAT ONE OF THE HANGER PINS WHICH HOLDS EXHAUST PIPE IN PLACE MAY CATCH DEBRIS FROM THE ROAD.IF THE DEBRIS WERE TO COME IN CONTACT WITH THE MAIN CATALYST, A FIRE COULD RESULT.THIS CONDITION IS ALSO PRESENT IN MY 2003 NISSAN ALTIMA VEHICLES BUILT THRU FEBRUARY 18, 2003.NISSAN ALSO STATED IN ITS DEFECT INFORMATION REPORT THAT ON MY 2002 ALTIMAS AND SENTRAS (EQUIPPED WITH THE 2.5-LITER ENGINE) THAT CERTAIN OPERATING CONDITIONS MAY CAUSE THE PRE-CATALYST TO OVERHEAT, WHICH WOULD CAUSE CATALYST SUBSTRATE PARTICLES TO FLOW INTO THE ENGINE.THESE PARTICLES CAN SCORE THE CYLINDER WALLS WHICH RESULTS IN INCREASE OIL CONSUMPTION.IF THE ENGINE OIL LEVEL IS LOW, ENGINE NOISE AND DAMAGE CAN OCCUR WHICH COULD RESULT IN A FIRE.THE RECALL INCLUDES 268,000 MY 2002-2003 ALTIMAS AND 2002 SENTRAS EQUIPPED WITH THE 2.5-LITER ENGINE.TO CORRECT THE CONDITION NISSAN WILL REMOVE THE PROTRUDING PORTION OF THE EXHAUST PIN ON THE ALTIMAS.NISSAN IS DEVELOPING A CORRECTIVE ACTION TO ADDRESS THE PRE-CATALYST.IN ADDITION TO THE CORRECTIVE ACTION, NISSAN WILL INSTALL HEAT SHIELDS ON THE PRE-CATALYST AND THE SURROUNDING EXHAUST TUBING.NISSAN WILL BEGIN OWNER NOTIFICATION IN MAY OF 2003.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:emission Control:catalytic Convertor
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION ON OCTOBER 18, 2002 BASED ON THREE REPORTS INDICATING THAT THE ENGINE COMPARTMENT IN MODEL YEAR (MY) 2002 NISSAN ALTIMA VEHICLES EQUIPPED WITH THE 2.5 LITER ENGINE CAUGHT ON FIRE WITHOUT ANY WARNING TO THE DRIVER WHILE THE VEHICLE WAS DRIVEN AT HIGHWAY SPEEDS.ONE NON-BURN RELATED INJURY WAS REPORTED AS A RESULT OF THE COMPLAINANT EXITING THE VEHICLE IN HASTE AFTER IT HAD CAUGHT ON FIRE.NISSAN DISCOVERED THAT ONE OF THE HANGER PINS WHICH HOLDS EXHAUST PIPE IN PLACE MAY CATCH DEBRIS FROM THE ROAD.IF THE DEBRIS WERE TO COME IN CONTACT WITH THE MAIN CATALYST, A FIRE COULD RESULT.THIS CONDITION IS ALSO PRESENT IN MY 2003 NISSAN ALTIMA VEHICLES BUILT THRU FEBRUARY 18, 2003.NISSAN ALSO STATED IN ITS DEFECT INFORMATION REPORT THAT ON MY 2002 ALTIMAS AND SENTRAS (EQUIPPED WITH THE 2.5-LITER ENGINE) THAT CERTAIN OPERATING CONDITIONS MAY CAUSE THE PRE-CATALYST TO OVERHEAT, WHICH WOULD CAUSE CATALYST SUBSTRATE PARTICLES TO FLOW INTO THE ENGINE.THESE PARTICLES CAN SCORE THE CYLINDER WALLS WHICH RESULTS IN INCREASE OIL CONSUMPTION.IF THE ENGINE OIL LEVEL IS LOW, ENGINE NOISE AND DAMAGE CAN OCCUR WHICH COULD RESULT IN A FIRE.THE RECALL INCLUDES 268,000 MY 2002-2003 ALTIMAS AND 2002 SENTRAS EQUIPPED WITH THE 2.5-LITER ENGINE.TO CORRECT THE CONDITION NISSAN WILL REMOVE THE PROTRUDING PORTION OF THE EXHAUST PIN ON THE ALTIMAS.NISSAN IS DEVELOPING A CORRECTIVE ACTION TO ADDRESS THE PRE-CATALYST.IN ADDITION TO THE CORRECTIVE ACTION, NISSAN WILL INSTALL HEAT SHIELDS ON THE PRE-CATALYST AND THE SURROUNDING EXHAUST TUBING.NISSAN WILL BEGIN OWNER NOTIFICATION IN MAY OF 2003.
Engine And Engine Cooling:exhaust System
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION ON OCTOBER 18, 2002 BASED ON THREE REPORTS INDICATING THAT THE ENGINE COMPARTMENT IN MODEL YEAR (MY) 2002 NISSAN ALTIMA VEHICLES EQUIPPED WITH THE 2.5 LITER ENGINE CAUGHT ON FIRE WITHOUT ANY WARNING TO THE DRIVER WHILE THE VEHICLE WAS DRIVEN AT HIGHWAY SPEEDS.ONE NON-BURN RELATED INJURY WAS REPORTED AS A RESULT OF THE COMPLAINANT EXITING THE VEHICLE IN HASTE AFTER IT HAD CAUGHT ON FIRE.NISSAN DISCOVERED THAT ONE OF THE HANGER PINS WHICH HOLDS EXHAUST PIPE IN PLACE MAY CATCH DEBRIS FROM THE ROAD.IF THE DEBRIS WERE TO COME IN CONTACT WITH THE MAIN CATALYST, A FIRE COULD RESULT.THIS CONDITION IS ALSO PRESENT IN MY 2003 NISSAN ALTIMA VEHICLES BUILT THRU FEBRUARY 18, 2003.NISSAN ALSO STATED IN ITS DEFECT INFORMATION REPORT THAT ON MY 2002 ALTIMAS AND SENTRAS (EQUIPPED WITH THE 2.5-LITER ENGINE) THAT CERTAIN OPERATING CONDITIONS MAY CAUSE THE PRE-CATALYST TO OVERHEAT, WHICH WOULD CAUSE CATALYST SUBSTRATE PARTICLES TO FLOW INTO THE ENGINE.THESE PARTICLES CAN SCORE THE CYLINDER WALLS WHICH RESULTS IN INCREASE OIL CONSUMPTION.IF THE ENGINE OIL LEVEL IS LOW, ENGINE NOISE AND DAMAGE CAN OCCUR WHICH COULD RESULT IN A FIRE.THE RECALL INCLUDES 268,000 MY 2002-2003 ALTIMAS AND 2002 SENTRAS EQUIPPED WITH THE 2.5-LITER ENGINE.TO CORRECT THE CONDITION NISSAN WILL REMOVE THE PROTRUDING PORTION OF THE EXHAUST PIN ON THE ALTIMAS.NISSAN IS DEVELOPING A CORRECTIVE ACTION TO ADDRESS THE PRE-CATALYST.IN ADDITION TO THE CORRECTIVE ACTION, NISSAN WILL INSTALL HEAT SHIELDS ON THE PRE-CATALYST AND THE SURROUNDING EXHAUST TUBING.NISSAN WILL BEGIN OWNER NOTIFICATION IN MAY OF 2003.